Safety flooring the complete system
|
|
- Vivian Craig
- 6 years ago
- Views:
Transcription
1 Technical Information Safety the complete system Safety the complete system Altro safety Altro Everlay Adhesive Screed Concrete sub-floor Preparation of sub-floors Sub-floors must be dry, sound and free from dust and grease. The floor must be smooth. The requirements of BS 8203: A1:2009 and international equivalents apply where relevant. Direct-to-earth sub-floors must incorporate an efficient dampproof membrane. If not, a surface damp-proof membrane must be applied. Underlay Where additional sound absorption is required, an acoustic underlay may be required. Please consult your local Altro representative about Altro Acoustic Underlay Altro Everlay A and B are designed to overcome the problems sometimes encountered in laying sheet s over new or old sub-floors. Altro Everlay can be laid over a variety of surfaces, such as old vinyl tiles, sheet metal, access floors, damp sub-floors or those contaminated with oil or paint. They provide a continuous base over tiles, which is stabilised and resistant to damp. Please consult your local Altro representative about Altro Everlay. If you have any concerns about installation, maintenance, adhesives or possible staining risks, please consult your local Altro distributor. 114
2 Detailing examples Technical Information Safety the complete system Welding All joints should be hot welded, using a hot air welding gun and Altro welding rod. Sealing AltroMastic is a specially formulated sealing compound for use where Altro s abut edges, skirtings, wall surfaces etc or where the is cut around pipes, upstands door frames etc. AltroMastic is not recommended for use in trafficked areas, as a welded joint will give superior performance. Where abuts drainage channels, access covers, quarry tiles etc a clamping or welding system should be used. Clamping drain Installation Altro safety must be installed according to the Altro Safety Flooring Installation guidelines. Please consult your local Altro representative for more information, the relevant product datasheets and installation guides or visit Clamping channel Stair finish Expansion joint 115
3 Technical Information information How Page vinyl Content safety works / Walling accessories How vinyl safety works Wet contaminants on create a film between the shoe and the floor. The most common wet contaminant is water, but it could be virtually anything. The film created by the wet contaminant prevents complete contact between a shoe and the floor and can result in a slip or fall. Safety works by incorporating aggregates into a wear layer, which, providing they are sufficient in number and quality, penetrate the film to provide contact with the shoe. A wet film needs only to be 1-2 μm thick to prevent complete contact between a shoe and the. That s about one tenth the thickness of a human hair. Film of water Solid contaminant Silicon carbide Recycled glass Silicon carbide Recycled glass Aluminium oxide Altro Aluminium oxide Altro Remember It only takes 1-2 μm of wet film to cause a slip or fall The aggregates in safety penetrate the wet film orthe dry contaminants to prevent a slip or fall Wall cladding accessories Altro adhesives AltroFix W139 AltroFix W139 is a two-part adhesive for use with all types of Altro PVCu wall cladding systems. It can be used in hygienic environments and areas subject to wet usage. It has excellent adhesion properties to all sound substrates used for internal wall construction. AltroFix W139 is supplied in 6.5kg and 8kg units. AltroFix W139 is suitable for porous and non-porous substrates or uneven substrate such as fairfaced brick or blockwork. Colour Coverage Average Beige 6.5 kg Unit 1 x 2.5m sheet, 8 kg Unit 1 x 3m sheet 116
4 +44 (0)
5 Safety Self-coved with cove former to semi-rigid PVCu sheet D8/03/05 Silicone sealant Cove former 38R Cove former 20R 38mm 20mm 20mm 38mm Altro safety Self-coved with cove former and captile strip C8 to wall tiles D5/03/05 Masonry nail fixing and tile adhesive, hole drilled in PVC first Glazed wall tile Captile strip C8 20mm 45mm 17mm Cove former 38R Cove former 20R 6.1mm 38mm 20mm 20mm Altro safety 38mm 118
6 Self-coved to architrave D9/03/05 Captile strip C7 Reduced Altro cove former 17mm 42mm 4.5mm Cove former 38R 38mm Cove former 20R 20mm Altro safety 20mm 38mm Self-coved with cove former and capping seal C11 over floor tiles D6/03/05 Coved quarry tiles AltroMastic 100 Captile strip C11 15mm 30mm 6mm Cove former 38R 38mm Cove former 20R 20mm Altro safety 20mm 38mm Latex screed 119
7 Self-coved with cove former and capping seal D4/03/05 CI/SfB reference (43) T (U47) January 2006 Wall finish Captile strip C7 17mm installation techniques and detailing 42mm set-in 4.5mm cove skirting JANUARY 2006 Cove former 38R Cove former 20R Altro safety 38mm 20mm 20mm 38mm Set-in cove skirting D3 Set-in cove skirting PRCS mm 1.95mm 14.5mm radius 2.5mm 4mm 25mm Hot welded joint Altro safety 120
8 121
9 Straight laid D1/03/05 CI/SfB reference (43) T (U47) April 2006 AltroMastic 100 installation techniques and detailing sit-on cove APRIL 2006 Altro sheet Sit-on cove D2 Sit-on cove 100mm 15mm Altro safety 122
10 Transition with clamping drain D13/03/05 Grille Clamping ring CI/SfB re (43) March installation techniques and detailing Altro safety dressed into outlet finished to gully angle Drain outlet Finished to gully angle D10/03/05 Altro sheet Hot welded joint AltroMastic 100 Gully angle GA25/35 25mm Adhesive 3.5mm gully angle for multi purpose use with 2.5 or 3.5 thick floors 2.5mm 123
11 Transition with other floor surfaces D12/08/05 CI/SfB reference (43) T (U47) Ceramic tiles March 2005 Hot welded joint Altro sheet Visedge Series and installation instructions from: Howe Green Limited, +44 (0) info@howegreen.co.uk installation techniques and detailing transition with clamping channel Visedge VR transition strip NOVEMBER mm PVC insert 29.5mm Transition with clamping channel D14/03/05 Altro safety clamped in place Clamping section Drain outlet grating Grating 124
12 Transition with access covers D16/03/05 Welded joints Altro Welded joints Altro sheet Visedge access cover Altro offer many other installation detail drawings to assist specifiers and installers. All our installation detail drawings can be downloaded from within the Technical Information section of the site. Altro can also provide detail and typical specification clauses for virtually any installation of our and wall cladding products. 125
13 The performance of Altro and wall cladding depends on their correct installation, and the care with which jointing detail is finished. For your guidance, the drawings published here demonstrate best practice. A representative selection of commonly encountered installations is shown. For further guidance, typical specification clauses or isometric diagrams please contact us. Resin Altro resin transition detail RF4/11/05 AltroCrete PU Clean cut toe AltroPrime Transition Girth Concrete substrate In-situ cove detail with retaining rebate RF2/07/00 Stable background Angle bead Two coats of primer required: the first is AltroPrime seeded the second is AltroPrime with added TX AltroCove PU Altro resin floor finish Concrete substrate Retaining rebate (where necessary) * Modified products 126
14 Altro resin finish at floor expansion joints RF1/07/00 Altro resin Altro Expand joint sealer Retaining rebate (where necessary) Typical arris damage repair using AltroPatch UFC Backing material Concrete substrate Altro resin finished to stainless steel drainage RF5/11/05 Stainless steel grating Altro Expand joint sealer (AltroPrime contact surfaces) Resin overlay Stainless steel drainage Bedding screed for drainage Concrete slab AltroPrime 127
15 CI/SfB reference (43) T (U47) November 2005 Altro resin finished to poured trench drainage RF6/11/05 Stainless steel grating Stainless steel drainage AltroCrete PU installation techniques and detailing Altro resin with in situ cove and isolated slab to wall NOVEMBER 2005 AltroPrime Altro Expand joint sealer (AltroPrime contact surfaces) Concrete slab Altro resin with in situ cove and isolated slab to wall RF7/11/05 Angle bead Suitable stable background AltroCove PU Bond breaker tape Flexcell filled isolating joint Altro Expand Altro resin floor finish AltroPrime Concrete substrate * Modified products 128
16 Walls to Altro resin detail WF5 AltroFix adhesive 2.5mm thick panel Most sound and dry substrates Altro transition strip incorporating neoprene seal (G832) Clear silicone sealant (A803) Altro resin CI/SfB reference (43) T (U47) July 2011 Square edge profile Altro Whiterock hygienic PVCu wall cladding to Altro resin detail AltroPrime typical specification (Ref: WF6) JULY 2011 to Altro resin detail WF6 Most sound and dry wall substrates resin transition joint strip (G834/25) incorporating neoprene seal Min. 100mm self cove 2.5mm thick Altro resin self coved 129
17 Altro Whiterock hygienic PVCu wall cladding to shower tray with integral upstand detail WS2 Altro Whiterock hygienic PVCu wall cladding 2.5mm thick AltroFix adhesive Silicone sealant Double sided tape and W165 primer 2-3mm gap Small chamfer to sheet Silicone between sheet and upstand Most sound, dry substrates Shower tray with integral upstand to Altro Whiterock FlexiJoint detail W11 W165 primer and double sided tape Double sided tape (A815) positioned 3mm from the edge of the sheet AltroFix adhesive W165 primer and double sided tape 2.5mm thick Most sound, dry substrates Gap between sheets to be 3.4mm produced by using precision space bars Gap 3.4mm AP600 sealant within gap Altro Whiterock FlexiJoint (Ref: FJ01) 130
18 to detail W9 Double sided tape (A915) AltroFix adhesive Most sound, dry and level substrates Contact adhesive or primer (W165) 2.5mm thick For welding over tiled surfaces contact Altro Technical Services. Pre welded gap 1.5mm-2mm max Hot welded PVC joint or Altro Mastic XT to window / door frame detail W1 Silicone sealant (A802/A806) AltroFix adhesive Window frame (Complete with finish coat prior to installation of ) 3mm Most sound, dry substrates 2.5mm thick Thermoformed corner 131
19 Altro Whiterock hygienic PVCu wall cladding to Altro Aquarius safety shower tray detail WF4 2.5mm thick Altro Whiterock hygienic PVCu wall cladding Small arris to bottom of sheet AltroFix adhesive Most sound, dry substrates 50mm silicone seal (A802) applied to back of sheet prior to installation Silicone sealant A802 at junction Clear silicone sealant (A803) Min. 50mm overlap to Altro Aquarius coved skirting Altro Aquarius safety mm Cove former Shower tray or suitable subfloor Shower tray detail for dementia-friendly environments available at to Altro safety overlap detail WF4a 2.5mm thick Altro wall cladding Small arris to bottom of sheet AltroFix adhesive Most sound, dry substrates 50mm silicone seal (A802) applied to back of sheet prior to installation Silicone sealant A802 at junction Clear silicone sealant (A803) or Altro Mastic XT Min. 50mm overlap to Altro safety coved skirting Altro safety mm Cove former Suitable subfloor 132
20 at dado height with Altro FlexiTrim W12 Wall finish 6.4 Altro FlexiTrim Back face to wall Front facing out 1.4 AltroFix adhesive with corner protector fixing detail W8 Most sound, dry substrates 2.5mm thick with thermoformed corner 5mm 5mm Double sided tape (A815) Edges sealed with silicone sealant white (A802) or clear (A803) or Altro Mastic XT Edges sealed with silicone sealant white (A802) or clear (A803) or Altro Mastic XT Double sided tape (A815) 75mm 18swg stainless steel corner protector or Altro Fortis corner protection Void filled with silicone sealant (A802) or clear (A803) 133
21 to boxing inspection cover detail W3 Altro transition strip A832/25 Thermoformed corners 2.5mm thick 9mm WPB plywood / inspection cover fixed by PVCu or stainless steel cap screws fixed to plywood with AltroFix adhesive Altro transition strip A832/25 Tanalised Tanalised timber framework timber 25mm x 75mm framework 25mm x 75mm Most sound and dry substrates Tanalised timber framework 25mm x 50mm 9mm WBP plywood cladding compliant with: EN13986:2004, BSEN636:2003, BSEN315, BSEN314-2 glue bonding quality class 3, 'S' Grade Concealed transition strip WHTT2 AltroFix adhesive Double sided tape REF (A815) Clear silicone seal (REF A803) 38mm radius 38mm cove former bonded to wall and G835/25 transition strip with AP600 Standard 20mm overlap 50mm overlap in showers 100mm visual skirting G835 transition trim Altro safety sheet vinyl 134
22 Concealed transition strip WHTT3 AltroFix adhesive Double sided tape REF (A815) Concealed wall / floor transition strip (REF G835/25) mechanically fixed or bonded to the wall with AP600 adhesive Clear silicone seal (REF A803) Standard 20mm overlap 50mm overlap in showers G835 transition trim Altro resin coved up wall Altro resin Concealed transition strip WHTT4 The hidden transition strip has been designed to maintain the overlap detail when replacing without the need to replace the cladding, for installation guidance contact the Altro technical team on
Detailing guide for senior living facilities
Detailing guide for senior living facilities Creating an integrated system with Altro flooring and wall cladding is an ideal solution for areas in which hygiene and water resistance are a top concern.
More information84 Lapping & Jointing 86 Service Pipe Penetrations 87 Sealing to Cavity Wall Constructions 88 Protecting Membranes System Components.
84 Lapping & Jointing 86 Service Pipe Penetrations 87 Sealing to Cavity Wall Constructions 88 Protecting Membranes 90 System Components installation/ SYSTEM COMPONENTS INSTALLATION ADVICE LAPPING and JOINTING
More informationTILING SPECIFICATIONS
TILING SPECIFICATIONS SPECIFICATION NUMBER: NR204-16 PREPARED BY: Mike Cubley PREPARED FOR: Porcelain Plus ATTENTION: Kirk Pollock INSTALLATION: 712 Turner Floor and Wall Tiling Specification. M40 STONE/
More informationALTRO WHITEROCK CHAMELEON Architectural Guide Specification CSI/CSC SectionFormat [3-part] CSI PageFormat
ALTRO WHITEROCK CHAMELEON Architectural Guide Specification CSI/CSC SectionFormat [3-part] CSI PageFormat Altro 80 Industrial Way, Wilmington, MA 01887 USA Toll Free: 800.377.5597 Fax: 978.694.0433 1731
More informationTILE TILE
09300 - TILE 09300-1 PART ONE: GENERAL 1.1 Description TILE 1.1.1 Work of this Section, as shown or specified, shall be provided by the Interior Contractor and shall be in accordance with the requirements
More informationSECTION RESILIENT SHEET FLOORING
SECTION 09 65 16 RESILIENT SHEET FLOORING SPEC WRITER NOTE: Delete text between // // not applicable to project. Edit remaining text to suit project. PART 1 - GENERAL 1.1 SUMMARY A. Section Includes: 1.
More informationTI-LINE TILUX DURABASE. Borderless Shower Areas
TI-LINE TILUX DURABASE Borderless Shower Areas Borderless Shower Areas TI-LINE The patented linear drainage system that makes a perfect junction with walls. An overview of all the system s components along
More informationRMF Intercell. NBS Specification 2013 K41
RMF Intercell NBS Specification 2013 K41 InterfaceFLOR BV. K41 Specification 40mm, 60mm, 80mm, 90mm and 110mm K41 Raised access floors To be read with Preliminaries/ General conditions. TYPES OF RAISED
More informationThermaSlim Aerogel Magnesium Oxide Board Internal Wall Insulation (IWI) Board
ThermaSlim Aerogel Magnesium Oxide Board Internal Wall Insulation (IWI) Board Installation Guide Unique insulation with the lowest Thermal Conductivity of any insulation product 0.014W/m²K. Hydrophobic,
More informationOutline NBS Specification. Protec System to PVC Single Ply (Waterproofing Only)
Outline NBS Specification Protec System to PVC Single Ply (Waterproofing Only) This document is a guide to assist in the production of tender documents only and is not project specific. A site survey is
More informationOver 20 years experience of high quality commercial hygienic wall and ceiling cladding supplies. Quality you can trust
Over 20 years experience of high quality commercial hygienic wall and ceiling cladding supplies Quality you can trust In association with - the hygienic cladding specialists HPS is proud to announce the
More informationARCHITECTURAL GUIDE SPECIFICATIONS - DESCRIPTIVE
ARCHITECTURAL GUIDE SPECIFICATIONS - DESCRIPTIVE MANNINGTON COLORFIELDS SHEET RUBBER FLOORING Section 09 65 16 Sheet rubber Flooring (Thermoset Rubber) Created May 2012 Mannington Mills, Inc. P. O. Box
More informationChannel Drain Shower Base. Aqua Line pro. Installation Instructions
Channel Drain Shower Base. Aqua Line pro Installation Instructions 02 JACKOBOARD Aqua Line pro System components a JACKOBOARD Aqua Line pro b JACKOBOARD Aqua Line pro - Horizontal Drain (Art. No. 4510370)
More informationAQUABLOK INTERIOR WATERPROOFING MEMBRANES. Product. Scope. Appraisal No. 724 [2017]
WATERPROOFING MEMBRANES This Appraisal replaces BRANZ Appraisal No. 724 (2011) BRANZ Appraisals Technical Assessments of products for building and construction. Sika (NZ) Ltd PO Box 19 192 Avondale Auckland
More informationSIKALASTIC-152 EXTERIOR WATERPROOFING MEMBRANE. Product. Scope. Appraisal No. 811 [2013] Appraisal No. 811 (2013) Amended 28 August 2017
SIKALASTIC-152 EXTERIOR WATERPROOFING MEMBRANE Amended 28 August 2017 BRANZ Appraisals Technical Assessments of products for building and construction. Sika (NZ) Ltd PO Box 19 192 Avondale Auckland 1746
More informationRIW SHEETSEAL GR BENEFITS APPLICATIONS APPLIED TO
CI/SfB TN6 LI4143 August 2017 RIW SHEETSEAL GR is a cold applied, high density polyethylene film bonded to aluminium foil and coated with a bitumen/rubber self adhesive layer with a removable reinforced
More informationFloor Insulation Underlayment Section Sound Control Matting
Floor Insulation Underlayment Section 09618 Sound Control Matting Part I General 1.1 Summary A. Section includes a sound control material for achieving an STC and IIC rating in excess of 50 to meet building
More informationB. Related Sections: 1. Division 07 Section "Joint Sealants" for sealing of expansion, contraction, control, and isolation joints in tile surfaces.
SECTION 093000 - CERAMIC TILE PART 1 - GENERAL 1.1 RELATED DOCUMENTS A. Drawings and general provisions of the Contract, including General and Supplementary Conditions and Division 01 Specification Sections,
More informationViking Enviroclad Waterproofing Membrane. EC01 Enviroclad Drip Edge Specify from the above three options
*lum ngle 50x50x1.6mm min. with 20mm lum fixing bar to mechanically secure membrane Enviroclad Waterproofing Membrane Substrate to comply with current Roofspec Masterspec specification Substrate Checksheet
More informationHOW TO: BOARD BATHROOMS, WET ROOMS & SHOWERS
HOW TO: BOARD BATHROOMS, WET ROOMS & SHOWERS 1 FOCUS ON GETTING IT RIGHT As with any building project the quality of finish is determined by the foundation upon which it is installed. The most important
More informationGRP Flat Roofing Edge Trims
GRP Flat Roofing Edge Trims Compatible with GRP, rigid and flexible polyester, polyurethane, acrylic and alkyd systems. Trim Brochure and Technical Specification Guide General Information The Easy To Use
More informationRESILIENT FLOORING
RESILIENT FLOORING 09650-1 SECTION 09650 RESILIENT FLOORING Part 1 General RELATED DOCUMENTS: Drawings and general provisions of Contract, including General and Supplementary Conditions and Division 1
More informationProduct Data Sheet Waterproofing Membrane for Ponds and Water Features Description Uses Suitable Surfaces Additional Uses Specification
Product Data Sheet Pondseal Waterproofing Membrane for Ponds and Water Features Description Pondseal is a polyurethane / acrylic co-polymer, water based coating which when fully cured, forms an impervious,
More informationStandard specification for the application of Danosa Two-Layer waterproof roofing membrane to plywood & concrete surfaces.
Standard specification for the application of Danosa Two-Layer waterproof roofing membrane to plywood & concrete surfaces. BRANZ Appraised No. 678 Ref: P3200 Rev 1 February 2016 Page 1 of 5 1.0 PREAMBLE:
More informationRoofgard Paving Support System
Roofgard Paving Support System CI/SfB (47) January 2007 Adjustable paving support system for paved and raised deck applications One of a range of Roofgard accessories specially designed to meet the exacting
More information1.3 Work shall include all reinforcement and accessories necessary to complete installation.
CERAMIC TILING GENERAL INFORMATION 1.1 Ceramic mosaic tile floors and bases, glazed wall tile wainscots and walls, and marble thresholds. 1.2 Installation will typically be with latex-portland cement mortar
More informationGround Terraces. bal-adhesives.com. Part B: Installation Guide
Ground Terraces Part B: Installation Guide Enjoy problem-free ground terrace systems with Gutjahr System Technology from BAL market leaders in full tiling solutions. This step-by-step guide explains in
More informationAssembly Instruction. wedi Fundo Primo Shower System
Assembly Instruction wedi Fundo Primo Shower System Assembly Instructions wedi Fundo wedi Fundo Shower System-Primo Overview & General Product Description of the wedi Fundo Shower Systems All wedi Waterproof
More informationFIRE PROTECTION. GTEC Shaftwall systems 244 GTEC Shaftwall Stairwell systems 248 GTEC Horizontal Shaftwall systems 249 GTEC Encasement systems 250
FIRE PROTECTION GTEC Shaftwall range uses a specially designed system to protect voids and shafts in buildings. It resists pressure changes and enables installation from one side of the shaft only. GTEC
More informationENKASONIC FLOOR UNDERLAYMENT 9110
ENKASONIC FLOOR UNDERLAYMENT 9110 GS1197 Section 13080 SECTION 09618 SOUND CONTROL MATTING Part I General 1.1 Summary A. Section includes a sound control material for achieving an STC and IIC rating in
More informationSECTION CERAMIC TILE. B. Ceramic tile wall finishes including standard and custom designs.
SECTION 09 30 13 CERAMIC TILE PART 1 GENERAL 1.1 SECTION INCLUDES A. Ceramic tile floor and base finishes. B. Ceramic tile wall finishes including standard and custom designs. 1.2 REFERENCES A. ANSI/TCNA
More informationInstallation Procedure of Floating floors
SUBFLOOR PREPARATION OF WICANDERS FLOATING FLOORS WITH CORKLOC Wicanders floating floors with Corkloc can be installed in most domestic areas and in almost all commercial areas except in bathrooms, saunas
More informationDesigned for possibilities. Made for people.
Designed for possibilities. Made for people. Welcome to Altro Altro Walls Catalogue 1800 673 441 03 9764 5655 info@asf.com.au www.asf.com.au Contents Types of 4 The superior solution for interior surfaces
More informationPLATON RUGGED, DIMPLED HIGH-DENSITY POLYETHYLENE (HDPE) MEMBRANE THAT KEEPS FOUNDATIONS AND FLOORING DRY ADVANCED TECHNOLOGY EASY INSTALLATION
DRAINAGE SOLUTIONS SINCE 1908 PLATON RUGGED, DIMPLED HIGH-DENSITY POLYETHYLENE (HDPE) MEMBRANE THAT KEEPS FOUNDATIONS AND FLOORING DRY ADVANCED TECHNOLOGY EASY INSTALLATION PROVEN PERFORMANCE ARMTEC.COM
More informationFiber Reinforced Tile and Stone Mortar
, ANSI A 118.4, ANSI A 118.11 ARDEX X 77 MICROTEC Fiber Reinforced Tile and Stone Mortar The most advanced technology ideal for large format porcelain tile installations,exterior or interior, floor or
More informationInstallation Information 2016
Installation Information 2016 DENDRO-SCOTT Root Barrier... why use anything else? DENDRO-SCOTT Root Barrier, recognised by the Environment Agency, is known for its quality and reliability. It is flexible
More informationDURABASE. Systems for decoupling, sealing, drainage, sound and heat insulation. Systematic underlays. WP page 4/5. CI++ page 2/3. DD page 6.
EXP DURABASE Systematic underlays Systems for decoupling, sealing, drainage, sound and heat insulation CI++ page 2/3 WP page 4/5 DD page 6 SW page 7 STONE CONCEPT HOLDINGS P/L 3/179-183 Woodpark Road,
More informationEllure Tile Look Walls
Ellure Tile Look Walls Ellure Tile Look Walls - FITTING INSTRUCTIONS Included in this package: Other equipment that may be required 1 x Corner Flashing Drill 2 x Side finishing trim Adhesive application
More informationWorld of Altro. fax: phone: visit: Altro Whiterock - Hygienic Wall Cladding Product Portfolio 2015
World of Altro - Hygienic Wall Cladding Product Portfolio 2015 phone: fax: email: visit: 1800 673 441 03 9764 5655 info@asf.com.au www.asf.com.au Types of hygienic wall cladding Types of hygienic wall
More informationTechnical Service. INSTALLATION INSTRUCTIONS FOR TARAFLEX SPORT PRODUCTS over Gypsum base Products. This document refers to the following products:
INSTALLATION INSTRUCTIONS FOR TARAFLEX SPORT PRODUCTS over Gypsum base Products This document refers to the following products: Product Width Width Ft. Installation direction Seams treatment Taraflex Surface
More informationConstruction Sealants 101 Making the Connections. Building Enclosure Council Austin October 3, 2012
Construction Sealants 101 Making the Connections Building Enclosure Council Austin October 3, 2012 RPM Incorporated Consumer Consumer Industrial 2 Topics Covered Overview of various types of construction
More informationFlexLok Adhesive Tabs for Carpet Tile
FlexLok Adhesive Tabs for Carpet Tile INSTALLATION EcoFlex ICT EcoFlex NXT 160 South Industrial Blvd. Calhoun, GA. 30701 MohawkGroup.com Technical Services Department 508 East Morris St. Dalton, GA 30721
More informationAltro Contractor Training School
Altro Contractor Training School Course Guide www.altro.com Altro are a leading UK, family-owned manufacturer and supplier of Floor, Resin and Wall coverings, founded in 1919. Our success is due to determined
More informationBUILD A SHOWER CUBICLE
BUILD A SHOWER CUBICLE Building a shower cubicle requires some experience in carpentry and tiling. You also need a degree of expertise in wiring and plumbing in order to install a shower unit. By all means
More informationStaggered stud acoustic partition system
C0 Partitions Staggered stud acoustic partition system All our systems are covered by SpecSure when using genuine Gyproc and Isover products is a non-loadbearing stud partition incorporating a single framework
More informationSECTION LATEX-MODIFIED MEDIUM BED MORTAR
SECTION 09305.24 LATEX-MODIFIED MEDIUM BED MORTAR This product guide specification can be used to specify Hydroment Big Tile & Stone Mortar, a latex-modified, medium bed mortar designed for setting large
More informationSureProtect Pure Wall Cladding System
February 2017 Uniclass Pr_35_90_43_86 CI/SfB (42) X Wall Cladding System Designed for hygiene sensitive applications Healthcare Commercial Kitchens Sport & Leisure For more information visit our website:
More informationLUXURY VINYL GENERAL INSTALLATION INSTRUCTIONS FOR LOCKING FLOORING
LUXURY VINYL GENERAL INSTALLATION INSTRUCTIONS FOR LOCKING FLOORING ACCLIMATION Acclimation is required prior to the installation of Luxury Vinyl Flooring (LVF). Store the UNOPENED BOXES in the room where
More informationENGINEERED WATERPROOF FLOORING GENERAL INSTALLATION INSTRUCTIONS FOR VÄLINGE 2G LOCKING FLOORING
ENGINEERED WATERPROOF FLOORING GENERAL INSTALLATION INSTRUCTIONS FOR VÄLINGE 2G LOCKING FLOORING SITE CONDITIONS Always store the boxes of Engineered Waterproof Flooring (EWF) on a flat and level surface;
More informationSITE VISIT REPORT DATE: JOB: NO. OF VISIT: PAGE OF : PURPOSE OF VISIT: CONTRACTOR: Items to be checked Observations Actions SETTING OUT
SETTING OUT Correct to boundaries Correct to building lines? Diagonals accurate? Levels correct? EXCAVATIONS Adjoining structures OK? Centres of foundations line with walls? Bottoms of trenches uniform,
More informationSTEP UP SHOWER BASE INSTALLATION GUIDE FOR TIMBER AND CONCRETE FLOORS
GUIDE FOR TIMBER AND CONCRETE FLOORS EDITION: APRIL 2016 IMPORTANT: This guide is for the installation of a Step Up shower base on a timber or concrete floor. If you require a walk in (flush with floor)
More informationSpecialists in Acoustic Flooring and House to Flat Conversions
Sound Solution Consultants Ltd Po Box 755 Capel St Mary Ipswich Suffolk IP9 2WF Tel No: 0845 5212096 Fax No: 0845 5212097 Email: mpconsultservice@aol.com Specialists in Acoustic Flooring and House to Flat
More informationUniclass L534. CI/SfB (90.4) Sg2. TredWay. The easy-lay modular paving system
Uniclass CI/SfB L4 (90.4) Sg2 TredWay The easy-lay modular paving system OVERVIEW Unique modular base designed for fast and easy laying TredWay TredWay is a lightweight, low profile weather and frost resistant
More informationalternative» The real alternative to natural stone and tiles! «
alternative» The real alternative to natural stone and tiles! « CERAMIN the new ceramic-like composite The CERAMIN components are bonded together at low temperatures and thus in an energy-saving and low
More informationHYDRATHANE INTERIOR WATERPROOFING MEMBRANE. Product. Scope. Building Regulations. Appraisal No. 959 [2017] Appraisal No. 959 (2017) BRANZ Appraisals
Appraisal No. 959 [2017] HYDRATHANE INTERIOR WATERPROOFING MEMBRANE BRANZ Appraisals Technical Assessments of products for building and construction. Construction Chemicals Pty Ltd 49-57 Davis Street Wingfield
More informationDivision 09 FINISHES TABLE OF CONTENTS
Division 09 FINISHES TABLE OF CONTENTS 09 1000 GENERAL... 3 A. RELATED SECTIONS... 3 B. MAINTENANCE OF FINISHES... 3 C. PUBLIC AREAS... 3 D. CUTTING AND PATCHING... 3 E. CLEANING... 3 F. RECOMMENDED FLOORING
More informationAcceptable Floor Substrates: Concrete, cured mortar bed, plywood, and backer board.
SECTION 093000 - SHEET MEMBRANE WATERPROOFING PART 1 - GENERAL This specification includes the sheet membrane used as waterproofing and vapor retarder, in conjunction with tile and dimension stone installations.
More information1. Division 09 Section "Rough Carpentry."
GREENSPOINT AND LAUDER RD. EC/PRE-KlK PAGE 1 SECTION 096400 - WOOD FLOORING PART 1 - GENERAL 1.1 RELATED DOCUMENTS A. Drawings and general provisions of the Contract, including General and Supplementary
More informationReal Stone Cladding mm sandstone ashlar. Thin Sandstone Ashlar Catalogue
12 15 20 mm sandstone ashlar Thin Sandstone Ashlar Catalogue 12 15 20 mm ashlar 1 SANDSTONE ASHLAR 12 15 20 MM Ashlar sandstone is the most desired and expensive stone finish for any facade. It is now
More informationARDEX X 32 MICROTEC Universal Rapid Setting and Drying Thin-to-Thick Bed Mortar
ANSI A 118.15, ANSI A 118.4, ANSI A 118.11 ARDEX X 32 MICROTEC Universal Rapid Setting and Drying Thin-to-Thick Bed Mortar The fast track, interior or exterior, thin-to-thick bed solution for every natural
More informationCommercial Resilient Sheet Flooring
Commercial Resilient Sheet Flooring INSTALLATION 160 South Industrial Blvd. Calhoun, GA. 30701 MohawkGroup.com Technical Services Department 508 East Morris St. Dalton, GA 30721 800.833.6954 product_tech@mohawkind.com
More informationhow to easy! TILE A BATHROOM DIY made Scan here to watch the video HOW TO TILE A BATHROOM
how to TILE A BATHROOM DIY Scan here to watch the video HOW TO TILE A BATHROOM TILING A BATHROOM: WHAT YOU LL NEED Adhesive 90045 ABA Powerstik Powder 20kg 90578 ABA Mixing Bucket FROM YOUR TOOLBOX Electric
More informationPLATON FOUNDATION WRAP
DRAINAGE SOLUTIONS SINCE 1908 PLATON FOUNDATION WRAP RUGGED, DIMPLED HIGH-DENSITY POLYETHYLENE (HDPE) MEMBRANE THAT KEEPS FOUNDATIONS DRY ADVANCED TECHNOLOGY EASY INSTALLATION PROVEN PERFORMANCE ARMTEC.COM
More informationGLUE-DOWN INSTALLATION VIRTUO 30 / 55
Before laying the flooring, it is a good idea to inspect it and to identify any problems with the appearance. If there are any visible defects, please notify GERFLOR and wait to hear from them before laying
More informationCaparol System PRO Data sheet
System features Expanded polystyrene insulation Cost effective solution Excellent detailing options Proven technology Wide variety of colours Reliable protection and crack resistance Proven track record
More informationREGUPOL ACOUSTIC UNDERLAY COLLECTION IMPACT SOUNDPROOFING FLOORS
REGUPOL ACOUSTIC UNDERLAY COLLECTION IMPACT SOUNDPROOFING FLOORS Regupol it just feels right Regupol Impact Soundproofing Products Regupol it just feels right Regupol Australia have developed twelve individual
More informationCOOK COUNTY ILLINOIS CONTRACT FOR WORK DOCUMENT NO Countywide Warehouse and Records Storage Center Hawthorne Project TKB No.
SECTION 092900 GYPSUM BOARD PART 1 - GENERAL 1.1 RELATED DOCUMENTS A. Drawings and general provisions of the Contract, including General and Supplementary Conditions and Division 01 Specification Sections,
More informationPOROUS (ABSORBENT) SUBFLOORS. (most wood subfloors and some concrete)
Adhesive Recommendations for Altro Flooring PRODUCT Safety Sheet Flooring POROUS (ABSORBENT) SUBFLOORS (most wood subfloors and some concrete) Altrofix 30/31/300 (CANADA) (excessively heavy rolling loads
More informationVINYL TILE, SHEET & LAMINATED FLOORING TRADE SPECIFICATION
VINYL TILE, SHEET & LAMINATED FLOORING TRADE SPECIFICATION GENERAL a) BDW Trading Limited Barratt Homes, David Wilson Homes and Ward Homes are all trading names of BDW Trading Limited the Company. b) Site
More informationFLUID APPLIED WATERPROOFING
SECTION 07120 FLUID APPLIED WATERPROOFING PART 1 GENERAL 1.01 SUMMARY A. Related Sections: 1. 03300 - Cast-In-Place Concrete. 2. 09200 - Metal Studs, Metal Lath, Suspension Ceilings, Plaster, and Stucco.
More informationENGINEERED LUXURY VINYL GENERAL INSTALLATION INSTRUCTIONS FOR ANGLE-TO-ANGLE FLOORING
ENGINEERED LUXURY VINYL GENERAL INSTALLATION INSTRUCTIONS FOR ANGLE-TO-ANGLE FLOORING WARNING Prior to installation, please ensure that the product received is the correct style and color as well as to
More informationBioPrism Solid Surface
Please read all instructions before installing products. STORAGE & HANDLING: Check for damage that may have occurred during transit. Keep receptor flat on pallet, as it was shipped, until ready to install.
More informationBalconies Information. How to waterproof and reduce efflorescence
Balconies Information How to waterproof and reduce efflorescence With existing structures, the balcony may be showing efflorescence as a bi-product of poor waterproofing design. Efflorescence in the construction
More informationExternal Thermal Insulation Composite System Insulation below ground level
Insulation below ground level 1. Concrete wall substrate 2. Aluminium starter base profile 3. Terraco Styrofix (adhesive) 4. Mechanical fastener 5. a. Graphite enhanced polystyrene board b. HD polystyrene
More informationSECTION EPOXY FLOORING SYSTEMS
SECTION 09800 EPOXY FLOORING SYSTEMS PART 1 GENERAL 1.1 RELATED DOCUMENTS A. Drawings and general provisions of the Contract, including General and Supplementary Conditions and Division 1 Specification
More informationHygienic cladding solutions. the complete internal cladding solution
Hygienic cladding solutions the complete internal cladding solution Hygienic cladding range overview Our range of sheets, prof iles and adhesives are made to industry leading standards to meet all customer
More information[404] TARADOUCHE SYSTEM
DO NOT USE SOLVENT BASED NEOPRENE ADHESIVE TO GLUE THE COVING SYSTEM AND EXTERNAL CORNER SECTIONS OR ANY OTHER CORNER. GERFLOR RECOMMENDS A POLYURETHANE RESIN BASED ONE-COMPONENT TRANSPARENT CONTACT ADHESIVE
More informationTiling Tiling Finishes C08
C08 Finishes In rooms subject to high or intermittent moisture conditions, the range of boards available for tiling offers flexibility of design and peace of mind when installed in both wall linings, lightweight
More informationKolorines Glass Mosaic Tiles Project Specification
Kolorines Glass Mosaic Tiles Project Specification SUGGESTED SPECIFICATION Glass Mosaic Tile Installation for Swimming Pools NOTES TO SPECIFIER: 1. Specify PremiumPlus Thin-Set mixed with CustomFlex Additive
More informationLP SmartSide Perfection Shingle
Application Instructions Fiber Substrate Lap Siding A A - Lap Siding ON SITE STORAGE Store off the ground well supported, on a flat well-drained surface. (Diagram 1a) Additional support may be required
More informationSchluter -KERDI-DRAIN
Schluter -RONDEC Finishing and edge-protection profile with a rounded reveal surface. Schluter -RONDEC is a finishing and edge-protection profile for tiled edges and outside corners of tiled surfaces.
More informationWORK BELOW LOWEST FLOOR FINISH 1/7 230, , , FRAME 2/6 96, , ,056.00
Description Page No Summary Amount Summary 1/7 230,694.60 22,019.25 22,642.65 2/6 96,801.30 80,150.60 114,056.00 Total Per Unit (MYR) 327,495.90 102,169.85 136,698.65 Total Unit(s) X 1 2 2 Total Per Type
More informationAssembly Instruction. wedi Fundo Primo Steam Shower System
Assembly Instruction wedi Fundo Primo Steam Shower System Assembly Instructions wedi Fundo wedi Fundo Steam Shower System Residential and Commercial Use Whether installed in a steam room with commercial
More informationTECHNICAL BULLETIN TB147 THE INSTALLATION OF ARDEX DS40 SOUND REDUCTION MATTING IN INTERNAL INSTALLATIONS
TECHNICAL BULLETIN TB147 THE INSTALLATION OF ARDEX DS40 SOUND REDUCTION MATTING IN INTERNAL INSTALLATIONS TB147.004 Ardex Australia 2008-2014 Date, Wednesday, 12 March 2014 INTRODUCTION & SCOPE There is
More information26 Visqueen 100% Recycled Ecomembrane 28 Visqueen DPM To Pifa Standard PROOF. membranes
26 Visqueen 100% Recycled Ecomembrane 28 Visqueen DPM To Pifa Standard DAMP PROOF membranes Visqueen Ecomembrane is a BRE certified DPM manufactured from 100% recycled polythene. This ensures valuable
More informationIssue 8 www.gekko-adhesives.com GEKKO... REVOLUTIONARY TIME AND COST SAVING ADHESIVE SOLUTIONS CONTENTS Gekko Gun Adhesive Systems 04 G1 Gun 06 G2 Gun 08 Woodstikk 10 Wood Floor Adhesive 12 Claddstikk
More informationPlanning and installation instructions
Planning and installation instructions Stofix Oy Ahlmaninkatu 2 E 40100 Jyväskylä Finland stofixgroup@stofix.com www.stofix.com 2 PLANNING AND INSTALLATION INSTRUCTIONS... 1 1 General... 3 2 Project Design...
More informationM40 STONE / CONCRETE / CERAMIC TILING / MOSAIC To be read with preliminaries/general conditions
M40 GUIDE RECOMMENDATION M40 STONE / CONCRETE / CERAMIC TILING / MOSAIC To be read with preliminaries/general conditions Document prepared for: Recommendations for: Armatile Station Road Industrial Estate
More informationThe Ashland Project. Total Area: 1,778 Sq.Ft. 3 Bedroom, 2 Bath, 2 Car Garage
The Ashland Project Total Area: 1,778 Sq.Ft. 3 Bedroom, 2 Bath, 2 Car Garage The garage and bedroom extend from the front of this three bedroom home, drawing you visually into the entryway. Brick and stucco
More informationTECHNICAL INFORMATION SHEET NUMBER 1a
BASIC BUILDING REQUIREMENTS FOR THE CONSTRUCTION OF TRADITIONAL SQUASH COURTS Building Requirements The dimensions of a singles or doubles court is shown on the attached diagram. Width and length of the
More informationFire Door Installation
FA LCON PANEL PRODUCTS LTD 14.1 It is vital that performance doorset are installed by competent tradesmen and It is strongly recommended that the installer is a member of a recognised quality assurance
More informationHYBRID. Pre-Laying Checks
Warning Veles CK has been developed for exceptional stability in low and high temperatures, however, after installation extreme temperatures (under 5 C or over 50 C) should be avoided by use of interior
More informationPella 250 Series. Wood Frame Construction with Vinyl Siding... V250-ID-888 Wood Frame Construction with Brick Veneer...
SECTION DIRECTORY General Information Introduction... V250-ID-886 Installation Accessories and Applications... V250-ID-886 Typical Sealant Placement Details... V250-ID-887 Fin Installation Details Wood
More informationphone web . Pictured on cover: Roman Marble. Search trust IPSL on Google
phone web email 0114 279 9188 www.ipsluk.co.uk info@ipsluk.co.uk Pictured on cover: Roman Marble Search trust IPSL on Google IPSL offer an extensive range of products and designs that are cost Core: Hollow
More informationSURESILL WATER MANAGEMENT GUIDE
THE SURE LEVEL OF PROTECTION SURESILL WATER MANAGEMENT GUIDE FOR WINDOWS AND DOORS *1 SLOPED SILL PAN ASSEMBLY Cut the channel plate ¼ smaller than the rough opening. Check the fit with end caps before
More informationfloors Altro sheet flooring installation guide Updated 12/20/ USA / CAN
Altro sheet flooring installation guide 800 377 5597 USA / 800 565 4658 CAN support@altrofloors.com www.altro.com TECHNICAL>TRAINING ACADEMY>FlOORS INSTALL GUIDE floors Updated 12/20/17 For technical support
More informationTidy tiles Walls, floors, stairs and tiles on tiles Building materials of brand-name quality for your home Nur im
www.probau.eu Building materials of brand-name quality for your home PROBAU offers a wide range of products in many areas of application for home improvement, renovation and construction. In professional
More informationEasy Drain. Modulo. TAF Side outlet INSTALLATION MANUAL FOR WOODEN OR CONCRETE SUBFLOORS
Easy Drain TAF Side outlet INSTALLATION MANUAL FOR WOODEN OR CONCRETE SUBFLOORS Easy Drain CONTENTS Installation options... 3 Frame options... 3 Height adjustable feet... 4 Height adjustable feet Wall
More informationGypLyner UNIVERSAL Metal framed wall lining system
Metal framed wall lining system Pizza Express, York 30 Metal framed wall lining system wall lining system is a cost-effective, virtually independent metal frame drylining. It is a general purpose system
More informationLIQUID RUBBER INDUSTRIES ENGINEERING SPECIFICATIONS FOR ENGINEERS AND ARCHITECTS. Diagram 1: Standard Membrane Continuation 150 mm Overlap
LIQUID RUBBER INDUSTRIES ENGINEERING SPECIFICATIONS FOR ENGINEERS AND ARCHITECTS Diagram 1: Standard Membrane Continuation 150 mm Overlap Ensure Membrane to Membrane Contact Diagram 2: Membrane Continuation
More information