Quad/Graphics 295,000 Square Feet on Acres Dickson, Tennessee

Transcription

1 Quad/Graphics 295,000 Square Feet on Acres Dickson, Tennessee

2 QUAD/GRAPHICS 1665 OLD COLUMBIA ROAD DICKSON, TENNESSEE SIZE: NUMBER OF BUILDINGS: GROUND: Approximately 295,000 square feet Four buildings, broken out as follows: Manufacturing: 258,950 square feet Plant Support: 15,150 square feet CRT Support: 10,900 square feet Office: 10,000 square feet (Guard House and Storage Shed not included) Approximately acres, mostly level except for eastern edge BUILDING DIMENSIONS: Gross dimensions: 380 x 705 for manufacturing area CONSTRUCTION: Floors: Minimum 6 reinforced concrete with heavier floor areas up to 10 for rolled paper storage and press room area Walls: Roof: Prefab concrete Twin T insulated wall panels Metal decking with 6 Styrofoam insulation, 60% rubber stone covered and 40% mechanically fastened EPDM. The mechanically fastened area is approximately 8 years old. Columns: Steel H columns, 14 x 14 DATE OF CONSTRUCTION: 1982 with an addition in 1987 and 1989 CONDITION OF PROPERTY: CEILING HEIGHTS: Excellent 25 clear in plate prep area 27 clear in binding and shipping area 30 clear in press room and paper storage area COLUMN SPACING: Mostly 40 x 65 POWER: Supplied by Dickson Electric Systems: Main Plant: 12,400 volt Primary, (4) four 1,000 KVA, (2) two 2,000 KVA transformers Plant Support Facility: (1) one 2,500 KVA and (2) two 1,500 KVA transformers 480/277, 3 phase, 4 wire. Conduit and electrical tray distribution to sub panels and sub stations. Dual feed capability through manual switch located near Plant Support facility.

3 QUAD/GRAPHICS 1665 Old Columbia Road Dickson, Tennessee Page 2 NATURAL GAS: WATER: SEWER: SPRINKLER SYSTEM: LIGHTING: OFFICE FACILITIES: EMPLOYEE CANTEEN: TOILET FACILITIES: Supplied by Greater Dickson Gas Authority: 6 high pressure main with one 4 lateral servicing the Plant Support facility from the west and one 4 lateral servicing the Production facility from the east. Service pressure is 250 psi, reduced to psi at the building. Supplied by Dickson Water Authority: 12 city main to Fire Pumps and 6 feed into plant. 40 psi boosted to 80 psi from plant support facility. Supplied by Dickson Water Authority: 10 city main with 8 lateral to plant. Additional waste treatment system for process water fully licensed and compliant with TDEC 100% wet sprinklers with back-up water tank and fire pumps Mixture of metal halide, T-8, T-5 and fluorescent fixtures. Approximately 10,000 square feet of main office area featuring tiled and hardwood floor coverings, carpeting, painted walls, recessed fluorescent lighting and fixed exterior windows. Large open areas for support services and meetings. Fluorescent fixtures with 2 x 4 acoustical ceiling tiles, tiled, carpeted and hard wood floor finishes. Complete vending style cafeteria approximately 55 x 70, with outside patio and smoking designated areas Office: Men s: 2 Toilets, 2 Sinks, 1 Urinal Women s: 3 Toilets, 2 Sinks Manufacturing: Men s: Locker Area: 4 Toilets, 5 wash station positions, 4 urinals7 Shower positions, 370 full lockers Women s: Locker Area: 4 Toilets, 4 Sinks, 3 Shower Stalls, 73 full lockers Unisex: 1 Toilet, 1 Sink, 1 Urinal Northeast Area: Men s: 1 Toilet, 1 Sink Women s: 1 Toilet, 1 Sink Press Prep (Second Floor): Men s: 2 Toilets, 1 Sink, 1 Urinal Women s: 2 Toilets, 2 Sinks The information contained herein is from sources deemed reliable but no warranty of representation is made as to the accuracy thereof

4 QUAD/GRAPHICS 1665 Old Columbia Road Dickson, Tennessee Page 3 Plant Support Building: Men s: 2 Toilets, 2 Sinks, 1 Urinal, 2 Showers Women s: 1 Toilet, 2 Sinks, 1 Shower CRT Support Building: Men s: 1 Toilet, 1 Sink, 1 Urinal, 1 Shower PARKING: HEATING: Approximately 215 paved parking spaces, with additional parking of 75 to 100 spaces on graveled area. Three high pressure, dual fired Natural Gas or Fuel Oil, Cleaver Brooks boilers provide process steam and heat for the entire facility. Two (2) 869HP/ 260 psi and one (1) 500HP/150 psi. AIR CONDITIONING: One (1) 850-ton Trane unit, one (1) 500-ton Carrier, one (1) 350- ton Carrier (not operational) TRUCK LOADING: Nine (9) dock high doors with dock seals, levelers and lights service the main facility with several overhead doors for drive-in access. Two (2) truck docks service the CRT building along with two overhead drive-in doors. RAIL: COMPRESSED AIR: TAXES: Provided by South Central Tennessee Railroad (SCTR), provides short line service CSX. Three rail spurs service the site. Two interior rail spurs enter the west end of the paper storage area which can handle 4 rail cars each with side car access for both interior spurs. One exterior rail spur services the CRT facility for liquid transfer. Entire facility is piped for compressed air: One (1) 450 HP Cooper One (1) 300 HP Sullair Two (2) 125 HP Sullair One (1) 125 HP Atlas (not operational) Tax Appraisal: Land: $ 1,029,600 Improvements: $ 3,776,000 Total: $ 4,805,600 40%: $1,922,240 City Tax Rate $ = $18,819/$0.063 per square foot County Tax Rate $2.90 = $55,745/$0.188 per square foot Total $0.25 per square foot based on 295,000 square feet The information contained herein is from sources deemed reliable but no warranty of representation is made as to the accuracy thereof

5 QUAD/GRAPHICS 1665 Old Columbia Road Dickson, Tennessee Page 4 FENCING: FORMER USE: TRANSPORTATION: Immediate shipping and receiving areas are fenced and gated with a guard house This was a Rotogravure printing facility which produced newspaper inserts for the Tri-State Region. Located less than 1 mile from Exit 172 (SR 46) along I-40 which allows for easy access to I-840 to the east, with easy connections to I-65 and I-24 just south of Nashville and all major arteries for the mid-south region. MISCELLANEOUS: Vending style Cafeteria First Aid Station Security Cameras Current facility layout was designed to be doubled in size for future expansion The information contained herein is from sources deemed reliable but no warranty of representation is made as to the accuracy thereof

6

7

8

9