WARMUP TILED SHOWER SOLUTION

Size: px
Start display at page:

Download "WARMUP TILED SHOWER SOLUTION"

Transcription

1 WARMUP TILED SHOWER SOLUTION INSTALLATION INSTRUCTIONS NOTE: this instruction detail is specific to the requirements of the Tiled Shower solution and must be read in conjunction with the ARDEX WPM750 membrane installation requirements, WARMUP Undertile heating requirements, Marmox insulation board requirements and glass glazier requirements. 1. Pre Install site check Check that walls and floors are prepared (in accordance with the attached builders requirements ) in conjunction or exceeding (in the case of additional nogging requirements) the requirements of NZS3604 Timber floor Needs to be clean, stable and sound. For level entry showers the set down for shower base should be smooth and level (maximum 3mm height deflections) and sized in accordance with the quoted detail. Any areas that are out of level or unsound need to be rectified either by us or by others. Concrete floor Needs to be clean and smooth. Make sure the floor is free of any efflorescence, curing compounds, and release agents. For level entry showers the set down for shower base should be smooth and level (maximum 3mm height deflections) and sized in accordance with the quoted detail. Check that all concrete is solid and cured appropriately. Check that the plumbing is positioned correctly for the quoted waste Walls Check that the walls are stable and firm, plumb and straight particularly in the immediate shower area and where glass will be attached to the wall. 2. Position and install the clamp flange waste. Note: for centring purposes, glass is fitted to the inside of a shower threshold. a) Centre waste: 100mm diameter clamp flange (to fit to 100mm riser as prepared by the site plumber) positioned in the centre of the shower. b) Off centre waste: 100mm diameter clamp flange (to fit to 100mm riser as prepared by the site plumber) positioned in the centre of the shower. c) Off Centre Channel: 80mm diameter clamp flange (to fit 80mm riser as prepared by the site plumber) positioned 135mm (to the centre) off the back bottom plate and centred along the shower base. d) Full length Channel: 80mm diameter clamp flange (to fit 80mm riser as prepared by the site plumber) positioned 75mm (to the centre) off the back bottom plate, and along the shower base as centre as possible. Timber substrate: Make sure the perimeter of the flange is supported by at least 10mm of timber substrate around the complete circumference. Enlarge the hole if it is too small. If too large, manufacture a support by strapping underneath and screwing timber to infill. Countersink the flange so it fits flush to the floor, sealing it to the existing riser using approved PVC cement. Affix flange to timber sub floor with CA20P sealant. If required screw with stainless countersunk timber screws. Concrete substrate: Countersink the flange so it is flush with the floor. Seal it to the existing riser using approved PVC cement. Fill any gaps around the flange with the appropriate cement based filler depending upon the depth and breadth of the fill as required. Make sure the flange is completely supported. Install spec July 2012 Page 1

2 3. Install Marmox underlay to floor. a) Timber floor in accordance with Marmox installation instructions, boards should be affixed (Sika Nailbond premium solvent free adhesive) and screwed to the substrate. For Threshold showers, Marmox underlay should be installed over the entire floor area, including the shower base. For level entry showers, do not install in the immediate shower floor area. b) Concrete floor in accordance with Marmox installation instructions, boards should be affixed (suitable quality flexible tile adhesive). 4. Install ARDEX WPM750 Undertile Butynol waterproofing membrane a) Pencil mark vertical (external) line of shower glass channel and mask the wall outside the shower area b) Install the sheet waterproofing from the outermost point of the room towards the shower. c) Install the sheet membrane over the shower base making sure that there are no joins in the immediate base area. Ensure that the sheet membrane extends up the shower wall by a minimum of 150mm from the shower floor, and out side the shower floor limits by 100mm. d) Apply CA20P adhesive to the fixed part of the clamp flange in the shower base so as to seal the underside of the WPM750 to the flange. Clamp the WPM750 into position around the waste e) Install the sheet membrane on the wall up to the point as pencil marked / masked. If the walls are to be tiled outside the shower, the waterproofing may be extended past the shower perimeter. f) Install water stops at all doorways 5. Install the shower tray Threshold a) Trim the shower tray to exact size required. If joining pieces of the tray to extend any sides, apply a full bead of CA20P to both sides to be joined. Push together, smooth out excess adhesive, and tape over the join using 80mm Butyl tape. Lightly heat (with the Leister gun) and roll the tape to get a full bond to either side of the base. b) Using masking tape, outline the profile of shower tray onto the waterproofing. c) Size and cut MARMOX threshold as required, sized as specified. For pre channelling, using 35mm (high) x 50mm (wide) threshold. If not pre channelling, hob size should be 65mm x 65mm. Note, glass will be installed on the inside edge of the threshold. d) Weld an appropriate flap of membrane around the inside of the hob position of the shower base (effectively under the shower base once installed). The flap must be wide enough to achieve a 50mm weld to the existing membrane as well as to have enough un welded width to extend up the inside of the hob. Ie 35mm when pre channelling for glass, and 65mm otherwise. e) Install the trimmed shower tray with ARDEX Optima tile adhesive (as per the manufacturer s instructions) using an 8mm notched trowel to the shower tray floor area ensuring complete floor coverage. Make sure the tray is well bedded into the adhesive. Remove masking tape around the perimeter of the tray, leaving a clean area around the perimeter. f) Apply CA20P to seal between the join between the top of the flange and / or waterproofing to the inside of the shower tray. Install spec July 2012 Page 2

3 g) Install the hob sandwiching the installed WPM750 flap between the shower base and the hob. Glue the hob to the waterproofing with Optima adhesive. Seal between the flap and the shower base using CA20P. Trim the excess flap piece so it is level with the rest of the hob. Level Entry h) Trim the shower tray to exact size required. If joining pieces of the tray to extend any sides, apply a full bead of CA20P to both sides to be joined. Push together, smooth out excess adhesive, and tape over the join using 80mm Butyl tape. Lightly heat (with the Leister gun) and roll the tape to get a full bond to either side of the base. i) Using masking tape, outline the profile of shower tray onto the waterproofing. j) Install the trimmed shower tray with ARDEX Optima tile adhesive (as per the manufacturer s instructions) using an 8mm notched trowel to the shower tray floor area ensuring complete floor coverage. Make sure the tray is well bedded into the adhesive. Remove masking tape around the perimeter of the tray, leaving a clean area around the perimeter. k) Apply CA20P to seal between the join between the top of the flange and / or waterproofing to the inside of the shower tray. l) Apply CA20P sealant around the perimeter of the tray, sealing between the tray and the waterproofing. Remove masking tape. NOTE: If heating inside the shower base this should be done over the threshold and under the glass channel (for both threshold shower and level entry). Over the shower base the elements should be affixed in place with a thin coating of Optima adhesive. The aim being to fix the wires in place, and to absolutely minimise and change to the fall of the shower. 6. Pre channel for glass (or water stop) a) Size and cut glass channel profile to base and wall. Affix using V60 silicone adhesive. Check (appendix 1) that the appropriate profile is used for appropriate shower. Glass profile must be installed plumb and level and be completely sealed to the waterproofing membrane. b) Using V60 glue in corner channel sealants taking care that any silicone that overflows onto the channel is wiped clean. c) Channels MUST be installed level. d) Measure final installed channels to confirm size for glass. e) If there is no glass or glass installed by others then install water stops (7mm x 20mm L ) around the perimeter of the shower both walls and floors. Sealed to the waterproofing with CA20P. Instructions for the Tiler (re sealing the joint) must be left on site. 7. Install heating a) Mark out and install undertile heating as required. b) Screed undertile heating using WARMUP Indoor / outdoor compatible levelling compound. 8. Ready for other trades Tiling or flood testing (if required) can commence the next day. 9. Install glass as specified. 10. Connect and program heating controller Install spec July 2012 Page 3

4

5

adjustable fusion shower pan surface mounted on subfloor installation guide

adjustable fusion shower pan surface mounted on subfloor installation guide a a) Wall b) Tile c) Adjustable Shower Pan d) Liquid Membrane e) Crack Isolation Tape f) Cement Board g) Subfloor h) Joists b d c f h g e adjustable fusion shower pan surface mounted on subfloor www.trendingaccessibility.com

More information

BRANZ Appraisal Certificate # 461 (2010) Internal wet areas.

BRANZ Appraisal Certificate # 461 (2010) Internal wet areas. SPECIFICATION FOR PROTECTO WRAP AFM-WM FOR INTERNAL WET AREAS BRANZ Appraisal Certificate # 461 (2010) Internal wet areas AFM/WM INTERNAL 0104 Page 1 AFM-WM INTERNAL SPECIFICATION PRODUCT DESCRIPTION Anti

More information

adjustable fusion shower pan on wood joists installation guide

adjustable fusion shower pan on wood joists installation guide a a) Wall b) Tile c) Shower Pan d) Liquid Membrane e) Crack Isolation Tape f) Cement Board g) Subfloor h) Joists b d c f h g e adjustable fusion shower pan on wood joists installation guide www.trendingaccessibility.com

More information

30mm Height Linear Drain Shower Trays

30mm Height Linear Drain Shower Trays Installation Instructions 30mm Height Linear Drain Shower Trays 9. Parts Supplied Description Qty Shower Tray Parts Supplied (Fitting Kit) Description Qty Description Qty Shower Drain Base Fix-KST Adhesive

More information

fusion shower pan on wood joists installation guide

fusion shower pan on wood joists installation guide a a) Wall b) Tile c) Shower Pan d) Liquid waterproofing e) Crack Isolation Tape f) Cement Board g) Subfloor h) Joists b c d f h g e fusion shower pan on wood joists installation guide www.trendingaccessibility.com

More information

ProFinish TILE TRAY SYSTEM

ProFinish TILE TRAY SYSTEM Tiles and Adhesive Waterproofing Membrane ProFinish TM Tile Tray Important: Tray must be protected from moisture by an approved waterproofing membrane applied by an approved waterproofing applicator. The

More information

ARDEX UNDERTILE SHEET MEMBRANE (WPM 750 AND WPM 1000) Product. Scope. Building Regulations. Appraisal No. 727 [2017]

ARDEX UNDERTILE SHEET MEMBRANE (WPM 750 AND WPM 1000) Product. Scope. Building Regulations. Appraisal No. 727 [2017] ARDEX UNDERTILE SHEET MEMBRANE (WPM 750 AND WPM 1000) This Appraisal replaces BRANZ Appraisal No. 727 (2011) BRANZ Appraisals Technical Assessments of products for building and construction. ARDEX New

More information

JIGSAW. Jigsaw. DIY Tile Shower Tray Systems. Fast, Efficient, Easy! Advantages. sand and cement screed required!

JIGSAW. Jigsaw. DIY Tile Shower Tray Systems. Fast, Efficient, Easy! Advantages. sand and cement screed required! JIGSAW DIY Tile Shower Tray Systems Fast, Efficient, Easy! Advantages Create tray and waterproof within hours Creates a professional finish every time 20 year guarantee when protected from water by an

More information

1 PVC or ABS drain with strainer

1 PVC or ABS drain with strainer Patents Pending ProBase II Single-Slope Shower Base and Kit CONTENTS 1. General Information...1 2. Materials...1 3. Planning...2 4. Preparation...3 5. Layout...3 6. Install Base and Shims...4 7. Install

More information

PTY LTD. Paskaseal SRB. Screed Replacement Base

PTY LTD. Paskaseal SRB. Screed Replacement Base PTY LTD Paskaseal SRB Screed Replacement Base brochure main 3 - bluegreen.indd 1 About Us Visit us at paskaltileandstone.com.au We encourage you to come in and speak to our highly trained experts. Paskal

More information

Shower Drain Installation Guide

Shower Drain Installation Guide Shower Drain Installation Guide Tools Plus 2x10 Lumber Binding Adhesive Building Paper Cement Board Galvanized Lath Inset Mortar Rags Support Framing Materials(Optional) Sealant Tile and Tile Tools Waterproof

More information

1850 x 40/50mm Raised Shower Tray Kit

1850 x 40/50mm Raised Shower Tray Kit Installation Instructions 850 x 40/50mm Raised Shower Tray Kit Parts Supplied Description Qty Shower Tray Shower Tray Extension Parts Required (Fitting Kit) Materials Required Description Qty Description

More information

BioPrism Solid Surface

BioPrism Solid Surface Please read all instructions before installing products. STORAGE & HANDLING: Check for damage that may have occurred during transit. Keep receptor flat on pallet, as it was shipped, until ready to install.

More information

Technical Data. wedi Prefabricated Elements

Technical Data. wedi Prefabricated Elements Technical Data wedi Prefabricated Elements Technical Data wedi Prefabricated Elements Overview A secret among bath design professionals is to use L- and U-shaped wedi Building Panels to create more tileable

More information

Shower Tray - Timber Floors

Shower Tray - Timber Floors Shower Tray - Timber Floors Assembly information Assembly information The JACKOBOARD shower unit consists of a floor panel and a drainage system. Both components are coordinated with each other and form

More information

how to easy! TILE A BATHROOM DIY made Scan here to watch the video HOW TO TILE A BATHROOM

how to easy! TILE A BATHROOM DIY made Scan here to watch the video HOW TO TILE A BATHROOM how to TILE A BATHROOM DIY Scan here to watch the video HOW TO TILE A BATHROOM TILING A BATHROOM: WHAT YOU LL NEED Adhesive 90045 ABA Powerstik Powder 20kg 90578 ABA Mixing Bucket FROM YOUR TOOLBOX Electric

More information

BioPrism Solid Surface

BioPrism Solid Surface Please read all instructions before installing products. STORAGE & HANDLING: Check for damage that may have occurred during transit. Keep receptor flat on pallet, as it was shipped, until ready to install.

More information

AS Interpretation of External Waterproofing as it applies to Melbourne, Class 1 buildings

AS Interpretation of External Waterproofing as it applies to Melbourne, Class 1 buildings AS4654.2 Interpretation of External Waterproofing as it applies to Melbourne, Class 1 buildings Climate Zone: 6 Wind Class: N1 Membrane Types: Liquid Applied Class II and Class III as defined and tested

More information

USG DUROCK BRAND INFINITY DRAIN SHOWER SYSTEM Shower Floor and Drain Installation Guide

USG DUROCK BRAND INFINITY DRAIN SHOWER SYSTEM Shower Floor and Drain Installation Guide USG DUROCK BRAND INFINITY DRAIN SHOWER SYSTEM Shower Floor and Drain Installation Guide SHOWER AND DRAIN INSTALLATION USG DUROCK BRAND ULTRALIGHT FOAM TILE BACKERBOARD (WALL) USG DUROCK BRAND WATERPROOFING

More information

STEP UP SHOWER BASE INSTALLATION GUIDE FOR TIMBER AND CONCRETE FLOORS

STEP UP SHOWER BASE INSTALLATION GUIDE FOR TIMBER AND CONCRETE FLOORS GUIDE FOR TIMBER AND CONCRETE FLOORS EDITION: APRIL 2016 IMPORTANT: This guide is for the installation of a Step Up shower base on a timber or concrete floor. If you require a walk in (flush with floor)

More information

Impression Graphic panels

Impression Graphic panels Impression Graphic panels Installation Guidelines 6003.I Rev. 02 8/15 Please Read Disclaimers: PLEASE READ ALL INSTRUCTIONS BEFORE BEGINNING INSTALLATION!! These guidelines are provided in good faith to

More information

TECHNICAL BULLETIN TB215 TILING WITH AND WITHOUT WATERPROOFING OVER JAMES HARDIE SCYON SECURA FLOORING SHEETS

TECHNICAL BULLETIN TB215 TILING WITH AND WITHOUT WATERPROOFING OVER JAMES HARDIE SCYON SECURA FLOORING SHEETS TECHNICAL BULLETIN TB215 TILING WITH AND WITHOUT WATERPROOFING OVER JAMES HARDIE SCYON SECURA FLOORING SHEETS TB215-002 ARDEX Australia 2009-2016 Date, Thursday, 22 December 2016 INTRODUCTION & SCOPE The

More information

Tile Safe Shower System

Tile Safe Shower System Tile Safe Shower System Tile Safe Shower System CONTENTS ABOUT SHOWERWELL 2 THE SHOWERWELL TILE SAFE SHOWER SYSTEM 4 SHOWERWELL STERLING 10MM DOOR 6 SHOWERWELL 10MM SLIDING DOOR 9 SHOWERWELL STERLING

More information

For wooden fabricated underlay e.g. plywood, care must be taken to store the material in an area where it will not become damp or contaminated.

For wooden fabricated underlay e.g. plywood, care must be taken to store the material in an area where it will not become damp or contaminated. Page 1 1.30MM VERTICAL AND T The preparation/dryness of the wall / subfloor and installation procedures should all be as BS 476. i.e.: The relative humidity of the wall must be below 75%RH when tested

More information

The professionals choice. Installation instructions Torridon. shower tray

The professionals choice. Installation instructions Torridon. shower tray The professionals choice. Installation instructions Torridon shower tray 1 2Torridon Patent pending Before installation please check: All component parts of your assembly, including fixings, are present

More information

fermacell Powerpanel H 2 O Linear Shower Outlet 2.0

fermacell Powerpanel H 2 O Linear Shower Outlet 2.0 fermacell Product Data Sheet fermacell Powerpanel H 2 O Linear Shower Outlet 2.0 Product The prefabricated is the quick and economic dry solution for flush-to-floor installation of shower trays (included

More information

WET AREA CONSTRUCTION AUSTRALIA SEPTEMBER 2006 DESIGN MANUAL

WET AREA CONSTRUCTION AUSTRALIA SEPTEMBER 2006 DESIGN MANUAL WET AREA CONSTRUCTION AUSTRALIA SEPTEMBER 2006 DESIGN MANUAL 1 INTRODUCTION CONTENTS 1 INTRODUCTION 2 2 SUITABLE WET AREA SUBSTRATES 3 Wall and ceiling linings 3 Structural flooring sheets 3 Tile underlays

More information

Assembly Instruction wedi Fundo Floor element

Assembly Instruction wedi Fundo Floor element Assembly Instruction wedi Fundo Floor element Assembly Instructions wedi Fundo Legend A Caulking nut B Rubber caulking gasket C Drain body D wedi sealant E Rubber gasket F Fiber gasket G Locking nut A

More information

Assembly Instruction. wedi Fundo Primo Steam Shower System

Assembly Instruction. wedi Fundo Primo Steam Shower System Assembly Instruction wedi Fundo Primo Steam Shower System Assembly Instructions wedi Fundo wedi Fundo Steam Shower System Residential and Commercial Use Whether installed in a steam room with commercial

More information

System Recommendation SR0618

System Recommendation SR0618 Ardex Australia Pty Ltd ABN 82 000 550 005 Unit 7, 20 Powers Road, Seven Hills NSW 2147 Australia Telephone + 61 2 9851 9100 Facsimile +61 2 9838 7970 www.ardexaustralia.com System Recommendation SR0618

More information

Shower Kits Installation Manual

Shower Kits Installation Manual Shower Kits Installation Manual CURAVA.COM How To Handle Curava Panels When handling Curava panels it is very important to NEVER carry them flat. ALWAYS carry Curava panels vertically as shown in picture

More information

SlimLine Neo-Angle Base & Q-Wall-2

SlimLine Neo-Angle Base & Q-Wall-2 SlimLine Neo-Angle Base & Q-Wall-2 BASE & BACKWALL INSTALLATION INSTRUCTIONS IMPORTANT DreamLine reserves the right to alter, modify or redesign products at any time without prior notice. For the latest

More information

Watertight & maintenance-free. Schluter -Shower System FOR TILED SHOWERS

Watertight & maintenance-free. Schluter -Shower System FOR TILED SHOWERS Watertight & maintenance-free Schluter -Shower System FOR D SHOWERS ANATOMY OF A SHOWER BEAUTIFUL, DURABLE, MAINTENANCE-FREE T iled showers have always represented a considerable challenge to installers.

More information

Lock Installation Instructions for BT Strand Lock, BT Strand Engineered & BT Bamboo Engineered

Lock Installation Instructions for BT Strand Lock, BT Strand Engineered & BT Bamboo Engineered Lock Installation Instructions for BT Strand Lock, BT Strand Engineered & BT Bamboo Engineered Please read the following instructions before starting the installation Applications... 1 Pre installation...

More information

DeltaTrayTamar PCS. Installation Guide for Centre and Offset Drain. INSTALLING DELTATRAY tamar A PCS GUIDE TO CREATING THE PERFECT WETROOM

DeltaTrayTamar PCS. Installation Guide for Centre and Offset Drain. INSTALLING DELTATRAY tamar A PCS GUIDE TO CREATING THE PERFECT WETROOM INSTALLING DELTATRAY tamar DeltaTrayTamar Installation Guide for Centre and Offset Drain PCS High Performance Construction Products A PCS GUIDE TO CREATING THE PERFECT WETROOM INSTALLING DELTATRAY TAMAR

More information

NoMorePly The first tile backing system with a lifetime guarantee

NoMorePly The first tile backing system with a lifetime guarantee Installation Guide NoMorePly.net The first tile backing system with a lifetime guarantee QUICK & EASY THIN PROFILE STRONGER BUILD WATER RESISTANT LIFETIME GUARANTEE KG KG It s quick and easy, and we re

More information

For wooden fabricated underlay e.g. plywood, care must be taken to store the material in an area where it will not become damp or contaminated.

For wooden fabricated underlay e.g. plywood, care must be taken to store the material in an area where it will not become damp or contaminated. Page 1 The preparation/dryness of the subfloor and installation procedures should all be as BS 8203: 2001. i.e.: The relative humidity of a solid subfloor should be below 75%RH when tested with a Hygrometer

More information

WALK-IN SHOWER BASE INSTALLATION GUIDE FOR CONCRETE FLOORS

WALK-IN SHOWER BASE INSTALLATION GUIDE FOR CONCRETE FLOORS WALK-IN SHOWER BASE INSTALLATION GUIDE FOR CONCRETE FLOORS EDITION: APRIL 2016 IMPORTANT: If you require a Walk In shower base for timber floors, please go to our support page at www.hydroblok.com.au IMPORTANT:

More information

Ubau Flo Shower Element Installation Manual

Ubau Flo Shower Element Installation Manual Ubau Flo Shower Element Installation Manual The information pertained within this guide is for reference only and does not supersede instructions from other product manufacturers or building codes. Always

More information

Wet Areas Using Plasterboard

Wet Areas Using Plasterboard INSTALLATION 168 DEFINITIONS 168 WET AREA REQUIREMENTS 168 WATERPROOFING REQUIREMENTS BY AREA 169 GENERAL REQUIREMENTS 171 FRAMING 171 PLASTERBOARD LAYOUT 171 PLASTERBOARD FIXING 171 CONSTRUCTION DETAILS

More information

Assembly Instruction. wedi Fundo Primo Shower System

Assembly Instruction. wedi Fundo Primo Shower System Assembly Instruction wedi Fundo Primo Shower System Assembly Instructions wedi Fundo wedi Fundo Shower System-Primo Overview & General Product Description of the wedi Fundo Shower Systems All wedi Waterproof

More information

Technical Specification Aug 2012

Technical Specification Aug 2012 Technical Specification Aug 2012 Product Description BGC Compressed Fibre Cement sheeting is a high density fibre cement sheet which is ideally suited as a structural substrate for interior floors in dry

More information

Wall Protection Installation Guidelines

Wall Protection Installation Guidelines SureProtect Pure Hygienic Wall Cladding Data Sheet: Page 1 of 8 August 2016 1. Substrate suitability and recommended preparation All material must be installed in environmentally controlled conditions.

More information

WPM WATERPROOFING MEMBRANE

WPM WATERPROOFING MEMBRANE WPM 300 - WATERPROOFING MEMBRANE Description WPM 300 Waterproofing Membrane is a single-pack, water based polyurethane modified synthetic rubber polymer, liquid membrane developed specifically as a tough,

More information

Premium wall cladding. Complete system. Installation guide. Preparation Profiles Sheet preparation and installation After care

Premium wall cladding. Complete system. Installation guide. Preparation Profiles Sheet preparation and installation After care Premium wall cladding Complete system Installation guide 1969 Preparation Profiles Sheet preparation and installation After care Cladright wall cladding installation guide This installation guide complies

More information

Shower Pan Extension Installation Guide

Shower Pan Extension Installation Guide Shower Pan Extension Installation Guide Before Installing your HYDRO-BLOK Shower System Perform a final floor and wall measurement check to ensure all walls are square and make any adjustments required

More information

Tarkett Vylon Plus, Standard Plus, Somplan Plus, Contract Plus Tiles & Sheet

Tarkett Vylon Plus, Standard Plus, Somplan Plus, Contract Plus Tiles & Sheet METHOD STATEMENT Tarkett Vylon Plus, Standard Plus, Page 1 The preparation/dryness of the subfloor and installation procedures should all be as BS 8203: 2001. i.e.: The relative humidity of a solid subfloor

More information

The Complete Waterproofing Solution over Shower Trays and Baths

The Complete Waterproofing Solution over Shower Trays and Baths The Complete Waterproofing Solution over Shower Trays and Baths 1 Sealux Shower Kit Materials: 1) 3 No. Sealux Reg 20 Profiles 2) 1 No. Tube Sealux-N 3) Strip End Caps & Spatula 4) Alcohol Wipes 2 Tools

More information

Dural Durabase WP Installation Instructions For showers and general waterproofing (800)

Dural Durabase WP Installation Instructions For showers and general waterproofing (800) Dural Durabase WP Installation Instructions For showers and general waterproofing (800) 369-5458 www.prosourcecenter.com Tools & Materials Required Premium Modified (Latex/Polymer) Thin-set Mortar (no

More information

Outward Folding Bathscreen Instruction Manual

Outward Folding Bathscreen Instruction Manual Outward Folding Bathscreen Instruction Manual OBV3 Important Information Toughened glass is completely safe for use in our shower enclosures and bath screens; providing our products are installed according

More information

Detailing guide for senior living facilities

Detailing guide for senior living facilities Detailing guide for senior living facilities Creating an integrated system with Altro flooring and wall cladding is an ideal solution for areas in which hygiene and water resistance are a top concern.

More information

Contents. Timber framing to be installed in accordance with AS:1684 Metal framing to be installed in accordance with BCA Volume: 2

Contents. Timber framing to be installed in accordance with AS:1684 Metal framing to be installed in accordance with BCA Volume: 2 Contents BCA Codes 3 General 4 Fire Performances Thermal and Acoustic Insulation Wall Installation 4 Timber Frame Separation Walls 5 Steel Frame Separation Walls 6 External Fire Rated Walls 7 Floor Installation

More information

SlimLine Single Threshold Base & Q-Wall-5.1 BASE & BACKWALL INSTALLATION INSTRUCTIONS

SlimLine Single Threshold Base & Q-Wall-5.1 BASE & BACKWALL INSTALLATION INSTRUCTIONS SlimLine Single Threshold Base & Q-Wall-5.1 BASE & BACKWALL INSTALLATION INSTRUCTIONS IMPORTANT DreamLine reserves the right to alter, modify or redesign products at any time without prior notice. For

More information

Straight Panel Bath Screen Instruction Manual

Straight Panel Bath Screen Instruction Manual Straight Panel Bath Screen Instruction Manual Consumer Guarantee - Please make sure the purchaser/end user completes and returns the Guarantee card which is enclosed with this product. Failure to validate

More information

OPEN SET SYSTEM. Easy-to-install Waterproofi ng Shower System. Installation guide

OPEN SET SYSTEM. Easy-to-install Waterproofi ng Shower System. Installation guide OPEN SET SYSTEM Easy-to-install Waterproofi ng Shower System Installation guide ÍNDEX The GURU products... Pag. 3 Contents, Description and characteristics...pag. 4 Installation steps...pag. 6 Manufacturer

More information

TECHNICAL BULLETIN TB147 THE INSTALLATION OF ARDEX DS40 SOUND REDUCTION MATTING IN INTERNAL INSTALLATIONS

TECHNICAL BULLETIN TB147 THE INSTALLATION OF ARDEX DS40 SOUND REDUCTION MATTING IN INTERNAL INSTALLATIONS TECHNICAL BULLETIN TB147 THE INSTALLATION OF ARDEX DS40 SOUND REDUCTION MATTING IN INTERNAL INSTALLATIONS TB147.004 Ardex Australia 2008-2014 Date, Wednesday, 12 March 2014 INTRODUCTION & SCOPE There is

More information

Typical Installation Details

Typical Installation Details Installation Manual DRAIN SET AT ENTRY TO CURBLESS SHOWER ON CONCRETE SUBFLOOR Typical Installation Details Office : 970.668.0805 or 866.998.6685 Fax : 866.357.8502 P.O. Box 1358 Frisco, Colorado 80443

More information

aquapanel InstallatIon GuIde

aquapanel InstallatIon GuIde Installation Guide AQUAPANEL BEFORE YOU START It s a good idea to stand the AQUAPANEL sheets in the area for 2 days prior to cutting and installing, to allow the sheets to breathe and reach moisture equilibrium.

More information

ARDEX UNDERTILE INTERNAL LIQUID WATERPROOFING MEMBRANES. Product. Scope. Building Regulations. Appraisal No. 472 [2017]

ARDEX UNDERTILE INTERNAL LIQUID WATERPROOFING MEMBRANES. Product. Scope. Building Regulations. Appraisal No. 472 [2017] ARDEX UNDERTILE INTERNAL LIQUID WATERPROOFING This Appraisal replaces BRANZ Appraisal No. 472 (2011) BRANZ Appraisals Technical Assessments of products for building and construction. ARDEX New Zealand

More information

Pro Advanced Custom MUD Tiled Shower Kit

Pro Advanced Custom MUD Tiled Shower Kit Pro Advanced Custom MUD Tiled Shower Kit Installation Instructions Applies to any sized MUD waterproofing kit (800) 369-5458 www.prosourcecenter.com Please read all instructions thoroughly before beginning.

More information

ARDEX UNDERTILE WET AREA MEMBRANES. Product. Scope. Building Regulations. Appraisal No. 702 [2017]

ARDEX UNDERTILE WET AREA MEMBRANES. Product. Scope. Building Regulations. Appraisal No. 702 [2017] ARDEX UNDERTILE WET AREA This Appraisal replaces BRANZ Appraisal No. 702 (2011) BRANZ Appraisals Technical Assessments of products for building and construction. ARDEX Australia Pty Ltd 20 Powers Road

More information

Euro Corner Entry Shower Screen Installation Instructions

Euro Corner Entry Shower Screen Installation Instructions Euro Corner Entry Shower Screen Installation Instructions Corner Entry Space Saving Design Dual Sliding Doors, magnetic seals Silver Frame 6mm Clear Safety Glass Can be installed on shower base or tiled

More information

HYBRID. Pre-Laying Checks

HYBRID. Pre-Laying Checks Warning Veles CK has been developed for exceptional stability in low and high temperatures, however, after installation extreme temperatures (under 5 C or over 50 C) should be avoided by use of interior

More information

When I started tiling, we didn t do our own shower pans that BATHS

When I started tiling, we didn t do our own shower pans that BATHS BATHS Preventing Leaks in Tiled Showers Detail the pan properly before any tile is installed BY TOM MEEHAN Photos by Roe Osborn When I started tiling, we didn t do our own shower pans that job fell to

More information

CYPRUS STONEX SHOWER FLOORS

CYPRUS STONEX SHOWER FLOORS page 1 of 14 Arena lanco Cemento Pizarra SPECIFICATIONS Recommended use Material Colour Availability Outlet Position Waste Type ase Height Size Availability & Weight Features Domestic, Hotel and Commercial

More information

FreeStyle Linear Drain with Full Mortar Bed Adapter Kit

FreeStyle Linear Drain with Full Mortar Bed Adapter Kit FreeStyle Linear Drain with Full Mortar Bed Adapter Kit U.S. Patent No. 8,474,068 Patents Pending: Canada & EP Publication No. 2354339 Discard Linear Drain installation instructions and refer to these

More information

Euro Frameless Sliding Shower Screen Installation Instructions

Euro Frameless Sliding Shower Screen Installation Instructions Euro Frameless Sliding Shower Screen Installation Instructions Frameless Reversible Chrome Fittings 8mm Clear Safety Glass Can be installed on shower base or tiled floor Front Only Available sizes: To

More information

Terms and Conditions of Sale All purchases are subject to our published Terms and Conditions of Sale visit

Terms and Conditions of Sale All purchases are subject to our published Terms and Conditions of Sale visit Important Notice Any circumstances not covered by this guide should be referred to Regupol (Australia) Pty. Ltd. or its Distributors for any particular attention required. There are many factors that may

More information

Eco-Grip Flooring Installation Manual Version: 2018/12

Eco-Grip Flooring Installation Manual Version: 2018/12 Eco-Grip Flooring Installation Manual Version: 2018/12 PRIOR TO JOB START: Allied Industries strongly recommends that adequate relative humidity testing be performed on all concrete substrate prior to

More information

BRISTOL SHOWER SYSTEMS

BRISTOL SHOWER SYSTEMS SHOWER SYSTEMS page of 000 x 000 x 000mm Shower Wall Shower Base SPECIFICATIONS Recommended Use Material Domestic, hotel and commercial 6mm toughened glass shower screen with fully framed chrome door and

More information

For wooden fabricated underlay e.g. plywood, care must be taken to store the material in an area where it will not become damp or contaminated.

For wooden fabricated underlay e.g. plywood, care must be taken to store the material in an area where it will not become damp or contaminated. Page 1 The preparation/dryness of the subfloor and installation procedures should all be as BS 8203: 2001. i.e.: The relative humidity of a solid subfloor should be below 75%RH when tested with a Hygrometer

More information

Triton WP Waterproof Membrane

Triton WP Waterproof Membrane 1 Triton WP Waterproof Membrane Industry Leading Waterproof Membrane System. Manufactured to provide a consistent layer of protection throughout your wet area Vapor barrier and waterproof load bearing

More information

Frameless Hinged Door - Alcove. These instructions must be left with the user. Installation Guide W2-B

Frameless Hinged Door - Alcove. These instructions must be left with the user. Installation Guide W2-B Frameless Hinged Door - Alcove These instructions must be left with the user Installation Guide 1 1290647-W2-B 1290647-W2-B 2 Introduction Thank you for purchasing a quality product. To enjoy the full

More information

BASE MKII SHOWER SCREEN & BASE

BASE MKII SHOWER SCREEN & BASE page of 8 900 x 900 x 000 (mm) 000 x 000 x 000 (mm) Dimensions are nominal measurements only. To see the complete BASE range go to www.reece.com.au/bathrooms SPECIFICATIONS Recommended use Material Frame

More information

Glasboard Liners. installation details. Installation Guide for Glasbord Fibreglass Reinforced Plastic (FRP) panels

Glasboard Liners. installation details. Installation Guide for Glasbord Fibreglass Reinforced Plastic (FRP) panels Glasboard Liners installation details Installation Guide for Glasbord Fibreglass Reinforced Plastic (FRP) panels PLEASE READ ALL INSTRUCTIONS BEFORE BEGINNING INSTALLATION These guidelines are provided

More information

Tidy tiles Walls, floors, stairs and tiles on tiles Building materials of brand-name quality for your home Nur im

Tidy tiles Walls, floors, stairs and tiles on tiles Building materials of brand-name quality for your home Nur im www.probau.eu Building materials of brand-name quality for your home PROBAU offers a wide range of products in many areas of application for home improvement, renovation and construction. In professional

More information

Texline Ideal loose lay

Texline Ideal loose lay Installation Guide Texline Ideal loose lay When installed correctly Gerflor Texline s patented construction makes it an ideal loose lay solution since it does not expand or contract with changing weather.

More information

Eco-Grip Flooring Installation Manual Version: 2018

Eco-Grip Flooring Installation Manual Version: 2018 Eco-Grip Flooring Installation Manual Version: 2018 PRIOR TO JOB START: Allied Industries strongly recommends that adequate relative humidity testing be performed on all concrete substrate prior to installation.

More information

Impresa. The Standard in Custom Showers. impresa. tile showers

Impresa. The Standard in Custom Showers. impresa. tile showers Impresa. The Standard in Custom Showers impresa tile showers Contents: 01. Impresa Defined 02. Impresa Sets the Standard 03. METRO 11. Stile 19. Stile Stainless 23. QuikNICHE Recessed Shampoo Shelf 25.

More information

2. Subfloor Preparation - Removal of Existing Floor Coverings

2. Subfloor Preparation - Removal of Existing Floor Coverings Generic Scope of Works - Forbo Sure Step and Safe Step Sheet Vinyls 1) Subfloor Preparation - New Concrete Floors 2) Subfloor Preparation Preparing Existing Concrete / Removal of Existing Floorcoverings

More information

BRISTOL SHOWER SYSTEMS

BRISTOL SHOWER SYSTEMS page of 6 900 x 900 x 000 (mm) 000 x 000 x 000 (mm) 00 x 900 x 000 (mm) Dimensions are nominal measurements only. To see the complete BRISTOL range go to www.reece.com.au/bathrooms SPECIFICATIONS Recommended

More information

INSTALLATION GUIDELINES

INSTALLATION GUIDELINES INSTALLATION GUIDELINES NOTES - This is intended only as a quick reference to the basics of tile installation. - Tape is adhered to the front face of the mosaic sheets. Do not install this side into the

More information

INSTALLATION INSTRUCTIONS This leaflet must be read thoroughly before commencing installation. Scan for more information

INSTALLATION INSTRUCTIONS This leaflet must be read thoroughly before commencing installation. Scan for more information Scan for more information INSTALLATION INSTRUCTIONS This leaflet must be read thoroughly before commencing installation Showerwall is the ultimate versatile easy to fit waterproof panelling system, with

More information

Single Source Comprehensive Warranty. ARDEX Americas. Swimming Pool Guide

Single Source Comprehensive Warranty. ARDEX Americas. Swimming Pool Guide Single Source Comprehensive Warranty ARDEX Americas Swimming Pool Guide The ARDEX Pool System Wall Preparation WALLS SMOOTHING AND REPAIR ARDEX AM 100 TM Rapid Set Pre-Tile Smoothing and Ramping Mortar

More information

Eco friendly manufacture which is kind to the environment. Kind to the Environment. High Compressive Strength. Lightweight & Easy to Handle

Eco friendly manufacture which is kind to the environment. Kind to the Environment. High Compressive Strength. Lightweight & Easy to Handle Kind to the Environment High Compressive Strength Lightweight & Easy to Handle Fire Retardant Waterproof Properties Insulating Properties Easy to Cut Economical Construction Product 10 TEN YEAR G U A R

More information

BUILD A SHOWER CUBICLE

BUILD A SHOWER CUBICLE BUILD A SHOWER CUBICLE Building a shower cubicle requires some experience in carpentry and tiling. You also need a degree of expertise in wiring and plumbing in order to install a shower unit. By all means

More information

Warmup helpline:

Warmup helpline: Contents 3 4 5 6 Sizing guide Calculate the actual spacing of the heating element Technical notes Wiring configuration Your Warmup Undertile Heater has been designed so that installation is quick and straight

More information

AUSTRALIAN MADE AND OWNED

AUSTRALIAN MADE AND OWNED AUSTRALIAN MADE AND OWNED THE BENEFITS UNIVERSAL SHOWER BASE OFFERS A RANGE OF STANDARD AND CUSTOM OPTIONS TO MEET YOUR SPACE AND/OR DESIGN REQUIREMENTS. Whether you are building, renovating, extending,

More information

AS The External Waterproofing Membranes Standard

AS The External Waterproofing Membranes Standard AS 4654-2 The External Waterproofing Membranes Standard NOTE This external waterproofing standard contains solutions for problems which have not been addressed in other countries. CONFORMANCE CONDITIONS

More information

TECHNICAL BULLETIN TB178

TECHNICAL BULLETIN TB178 TECHNICAL BULLETIN TB178 TB178.004 Ardex Australia 2008-2011 PREPARATION OF WALLS & FLOORS IN WET AREAS OF HEALTH CARE FACILITIES AND INSTITUTIONS TO RECEIVE SHEET VINYL COVERINGS USING ARDEX FLC WATERPROOF

More information

Cornerview Shower Enclosure & Base

Cornerview Shower Enclosure & Base Cornerview Shower Enclosure & Base SHOWER ENCLOSURE AND BASE INSTALLATION INSTRUCTIONS IMPORTANT DreamLine reserves the right to alter, modify or redesign products at any time without prior notice. For

More information

imperbox Waterproofing imperbox Waterproofing Recommended use: Features: Materials: Coverage: Angles and waterproof bands: Substrates: Packaging

imperbox Waterproofing imperbox Waterproofing Recommended use: Features: Materials: Coverage: Angles and waterproof bands: Substrates: Packaging imperbox Wet areas imperbox is paste, ready-to-use waterproofing system specially recommended for waterproofing plasterboard indoors. Compatible with type C2 cement-based adhesive as per EN 12004. Indoor

More information

2K UniSlope Kit. Wet Room Materials UK: 25 Town Street, Duffield, Belper, Derbyshire, DE56 4EH

2K UniSlope Kit. Wet Room Materials UK: 25 Town Street, Duffield, Belper, Derbyshire, DE56 4EH 1K 2K Installation Instructions 1K UniSlope Kit 2K UniSlope Kit Installation Videos www.wetroommaterials.com and YouTube Technical Support UK: +44 (0) 1332 840 820 IRL: + 353 (0) 1 2973488 Wet Room Materials

More information

SECTION RESILIENT SHEET FLOORING

SECTION RESILIENT SHEET FLOORING SECTION 09665 RESILIENT SHEET FLOORING PART 1 - GENERAL 1.1 DESCRIPTION A. This Section specifies the installation of sheet flooring with backing and integral cove base. 1.2 RELATED WORK A. Color and pattern:

More information

Design No. HI/BP PERIMETER FIRE BARRIER SYSTEM Hilti, Inc. ASTM E 2307 Table 1

Design No. HI/BP PERIMETER FIRE BARRIER SYSTEM Hilti, Inc. ASTM E 2307 Table 1 FIRESTOP JOINT SPRAY CFS-SP WB SILICONE JOINT SPRAY CFS-SP SIL F-RATING 2-HR. 2-HR. T-RATING -HR. -HR. APPLICATION THICKNESS PERIMETER FIRE BARRIER SYSTEM Hilti, Inc. ASTM E 2307 Table /8" WET FILM (/6"

More information