Issue Date: 22-Oct-2013 Revision Date: 28-Oct-2013 Version 1 1. IDENTIFICATION. Coil cleaner/degreaser. For professional use only.

Transcription

1 Safety Data Sheet Issue Date: 22-Oct-213 Version 1 1. IDENTIFICATION Product Identifier Product Name CalClean Other means of identification Part Number , , Recommended use of the chemical and restrictions on use Recommended Use Coil cleaner/degreaser. For professional use only. Details of the supplier of the safety data sheet Supplier Address Nu-Calgon 28 Altom Court St. Louis, MO Emergency Telephone Number Company Phone Number (314) (8) Emergency Telephone (24 hr) Chemtrec HAZARDS IDENTIFICATION Appearance Clear opal liquid Physical State Liquid Odor Fresh Classification Skin corrosion/irritation Category 2 Serious eye damage/eye irritation Category 1 Signal Word Danger Hazard Statements Causes skin irritation Causes serious eye damage Precautionary Statements - Prevention Wash face, hands and any exposed skin thoroughly after handling Wear protective gloves/protective clothing/eye protection/face protection Page 1 / 7

2 Precautionary Statements - Response IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing Immediately call a poison center or doctor/physician IF ON SKIN: Wash with plenty of soap and water If skin irritation occurs: Get medical advice/attention Take off contaminated clothing and wash it before reuse Unknown Acute Toxicity 5.6% of the mixture consists of ingredient(s) of unknown toxicity 3. COMPOSITION/INFORMATION ON INGREDIENTS Chemical Name CAS No Weight-% Sodium metasilicate <5 **If Chemical Name/CAS No is "proprietary" and/or Weight-% is listed as a range, the specific chemical identity and/or percentage of composition has been withheld as a trade secret.** First Aid Measures 4. FIRST-AID MEASURES Eye Contact Skin Contact Inhalation Ingestion IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing. Immediately call a poison center or doctor/physician. IF ON SKIN: Wash with plenty of soap and water. If skin irritation occurs: Get medical advice/ attention. Take off contaminated clothing and wash it before reuse. IF INHALED: Remove victim to fresh air and keep at rest in a position comfortable for breathing. Get medical attention if necessary. IF SWALLOWED: rinse mouth. Get medical attention if necessary. Most important symptoms and effects Symptoms Causes skin irritation. Causes serious eye damage. Indication of any immediate medical attention and special treatment needed Notes to Physician Treat symptomatically. 5. FIRE-FIGHTING MEASURES Suitable Extinguishing Media Use extinguishing measures that are appropriate to local circumstances and the surrounding environment. Unsuitable Extinguishing Media. Specific Hazards Arising from the Chemical None known. Protective equipment and precautions for firefighters As in any fire, wear self-contained breathing apparatus pressure-demand, MSHA/NIOSH (approved or equivalent) and full protective gear. Page 2 / 7

3 6. ACCIDENTAL RELEASE MEASURES Personal precautions, protective equipment and emergency procedures Personal Precautions Environmental Precautions Use personal protective equipment as required. Prevent from entering into soil, ditches, sewers, waterways and/or groundwater. See Section 12, Ecological Information. See Section 13: DISPOSAL CONSIDERATIONS. Methods and material for containment and cleaning up Methods for Containment Methods for Clean-Up Prevent further leakage or spillage if safe to do so. Keep in suitable, closed containers for disposal. 7. HANDLING AND STORAGE Precautions for safe handling Advice on Safe Handling Handle in accordance with good industrial hygiene and safety practice. Use personal protection recommended in Section 8. Avoid contact with skin, eyes or clothing. Wash face, hands, and any exposed skin thoroughly after handling. Conditions for safe storage, including any incompatibilities Storage Conditions Incompatible Materials Keep container tightly closed and store in a cool, dry and well-ventilated place. Keep out of the reach of children. Acids. Oxidizing agents. Bleach. Do not mix with other chemicals or cleaners. 8. EXPOSURE CONTROLS/PERSONAL PROTECTION Exposure Guidelines Chemical Name ACGIH TLV OSHA PEL NIOSH IDLH 15 mg/m 3 15 mg/m 3 - Sodium metasilicate mg/m 3 2 mg/m 3 - Appropriate engineering controls Engineering Controls Apply technical measures to comply with the occupational exposure limits. Eyewash stations. Showers. Individual protection measures, such as personal protective equipment Eye/Face Protection Skin and Body Protection Respiratory Protection Wear approved safety goggles where a splash hazard exists. Wear suitable protective clothing. Ensure adequate ventilation, especially in confined areas. In case of inadequate ventilation wear respiratory protection. General Hygiene Considerations Wash contaminated clothing before reuse. Wash face, hands and any exposed skin thoroughly after handling. Page 3 / 7

4 9. PHYSICAL AND CHEMICAL PROPERTIES Information on basic physical and chemical properties Physical State Liquid Appearance Clear opal liquid Odor Fresh Color Opal Odor Threshold Property Values Remarks Method ph 11.3 (1% in water) 13. (concentrate) Melting Point/Freezing Point Boiling Point/Boiling Range 1 C / 212 F IBP Flash Point None to boiling Tag Closed Cup Evaporation Rate Equal to water Flammability (Solid, Gas) Liquid-not applicable Upper Flammability Limits Lower Flammability Limit Vapor Pressure Vapor Density Specific Gravity 1.8 Water Solubility Soluble in water Solubility in other solvents Partition Coefficient Auto-ignition Temperature Decomposition Temperature Kinematic Viscosity Dynamic Viscosity Water thin (<5 cps) Explosive Properties Oxidizing Properties VOC Content (%) < 1%/wt Density 9. lb/gal Reactivity Not reactive under normal conditions. Chemical Stability Stable under recommended storage conditions. Possibility of Hazardous Reactions None under normal processing. 1. STABILITY AND REACTIVITY Hazardous Polymerization Hazardous polymerization does not occur. Conditions to Avoid Keep out of reach of children. Incompatible Materials Acids. Oxidizing agents. Bleach. Do not mix with other chemicals or cleaners. Hazardous Decomposition Products None known based on information supplied. Page 4 / 7

5 11. TOXICOLOGICAL INFORMATION Information on likely routes of exposure Product Information Eye Contact Skin Contact Inhalation Ingestion Causes serious eye damage. Causes skin irritation. Avoid breathing vapors or mists. Do not taste or swallow. Component Information Chemical Name Oral LD5 Dermal LD5 Inhalation LC5 Water > 9 ml/kg ( Rat ) = 31 mg/kg ( Rat ) > 794 mg/kg ( Rabbit ) - Sodium metasilicate = 6 mg/kg ( Rat ) - - Information on physical, chemical and toxicological effects Symptoms Please see section 4 of this SDS for symptoms. Delayed and immediate effects as well as chronic effects from short and long-term exposure Carcinogenicity This product does not contain any carcinogens or potential carcinogens as listed by OSHA, IARC or NTP. Numerical measures of toxicity Unknown Acute Toxicity 5.6% of the mixture consists of ingredient(s) of unknown toxicity. 12. ECOLOGICAL INFORMATION Ecotoxicity The product is not classified as environmentally hazardous. However, this does not exclude the possibility that large or frequent spills can have a harmful or damaging effect on the environment. Component Information Chemical Name Algae/aquatic plants Fish Toxicity to microorganisms 165: 48 h Leuciscus idus mg/l LC5 Sodium metasilicate 21: 96 h Brachydanio rerio mg/l LC5 semi-static 21: 96 h Brachydanio rerio mg/l LC5 Crustacea 216: 96 h Daphnia magna mg/l EC5 Page 5 / 7

6 Persistence/Degradability. Bioaccumulation. Mobility Other Adverse Effects Waste Treatment Methods 13. DISPOSAL CONSIDERATIONS Disposal of Wastes Disposal should be in accordance with applicable regional, national and local laws and regulations. Contaminated Packaging Disposal should be in accordance with applicable regional, national and local laws and regulations. 14. TRANSPORT INFORMATION Note DOT Please see current shipping paper for most up to date shipping information, including exemptions and special circumstances. Not regulated IATA Not regulated IMDG Not regulated 15. REGULATORY INFORMATION International Inventories Legend: TSCA - United States Toxic Substances Control Act Section 8(b) Inventory DSL/NDSL - Canadian Domestic Substances List/Non-Domestic Substances List EINECS/ELINCS - European Inventory of Existing Chemical Substances/European List of Notified Chemical Substances ENCS - Japan Existing and New Chemical Substances IECSC - China Inventory of Existing Chemical Substances KECL - Korean Existing and Evaluated Chemical Substances PICCS - Philippines Inventory of Chemicals and Chemical Substances Page 6 / 7

7 US Federal Regulations CERCLA This material, as supplied, does not contain any substances regulated as hazardous substances under the Comprehensive Environmental Response Compensation and Liability Act (CERCLA) (4 CFR 32) or the Superfund Amendments and Reauthorization Act (SARA) (4 CFR 355). SARA 313 Section 313 of Title III of the Superfund Amendments and Reauthorization Act of 1986 (SARA). This product does not contain any chemicals which are subject to the reporting requirements of the Act and Title 4 of the Code of Federal Regulations, Part 372 CWA (Clean Water Act) This product does not contain any substances regulated as pollutants pursuant to the Clean Water Act (4 CFR and 4 CFR ) US State Regulations California Proposition 65 This product does not contain any Proposition 65 chemicals. U.S. State Right-to-Know Regulations Chemical Name New Jersey Massachusetts Pennsylvania X X 16. OTHER INFORMATION NFPA HMIS Health Hazards 2 Health Hazards 2 Flammability Flammability Instability Physical Hazards Special Hazards None Personal Protection X Issue Date: Revision Date: Revision Note: 22-Oct Oct-213 New format Disclaimer The information provided in this Safety Data Sheet is correct to the best of our knowledge, information and belief at the date of its publication. The information given is designed only as a guidance for safe handling, use, processing, storage, transportation, disposal and release and is not to be considered a warranty or quality specification. The information relates only to the specific material designated and may not be valid for such material used in combination with any other materials or in any process, unless specified in the text. End of Safety Data Sheet Page 7 / 7