Safety Data Sheet according to Regulation (EC) No 1907/2006. S0 Matting Compound. limonene ). May produce an allergic reaction.

Transcription

1 Page 1 of 9 SECTION 1: Identification of the substance/mixture and of the company/undertaking 1.1. Product identifier Product code: ZZS X Relevant identified uses of the substance or mixture and uses advised against Use of the substance/mixture Automotive care products 1.3. Details of the supplier of the safety data sheet Company name SCHOLL Concepts GmbH Polish & Pad Manufaktur Street Maybachstrasse 7 Place D Remseck Telephone +49 (0) Telefax +49 (0) info@schollconcepts.com Internet Emergency telephone number +49 (0) (8h - 16h) SECTION 2: Hazards identification 2.1. Classification of the substance or mixture Classification according to Directive 67/548/EEC or 1999/45/EC This mixture is not classified as hazardous according to Directive 1999/45/EC. Classification according to Regulation (EC) No. 1272/2008 [CLP] This mixture is not classified as hazardous according to Regulation (EC) No. 1272/ Label elements Danger symbols Special labelling of certain mixtures EUH208 Contains orange extract, sweet ( > 90% limonene ). May produce an allergic reaction Other hazards No information available.

2 Page 2 of 9 SECTION 3: Composition/information on ingredients 3.2. Mixtures Hazardous components EC No Chemical name Quantity CAS No Index No REACH No Classification according to Directive 67/548/EEC Classification according to Regulation (EC) No. 1272/2008 [CLP] aliphatic hydrocarbons, C11-C13, isoalkanes 10 - < 15 % Xn - Harmful R Full text of R-, H- and EUH-phrases: see section 16. Flam. Liq. 4, Skin Irrit. 3, Asp. Tox. 1; H227 H316 H304 EUH066 SECTION 4: First aid measures 4.1. Description of first aid measures After inhalation After contact with skin After contact with eyes After ingestion 4.2. Most important symptoms and effects, both acute and delayed 4.3. Indication of any immediate medical attention and special treatment needed Provide fresh air. Wash with plenty of water. Take off contaminated clothing and wash it before reuse. Rinse immediately carefully and thoroughly with eye-bath or water. Rinse mouth immediately and drink plenty of water. No information available. Treat symptomatically. SECTION 5: Firefighting measures 5.1. Extinguishing media Suitable extinguishing media Unsuitable extinguishing media 5.2. Special hazards arising from the substance or mixture 5.3. Advice for firefighters Additional information SECTION 6: Accidental release measures 6.1. Personal precautions, protective equipment and emergency procedures 6.2. Environmental precautions 6.3. Methods and material for containment and cleaning up 6.4. Reference to other sections Foam. Dry extinguishing powder. Carbon dioxide (CO2). Extinguishing powder Full water jet Non-flammable. In case of fire: Wear self-contained breathing apparatus. Collect contaminated fire extinguishing water separately. Do not allow entering drains or surface water. Use personal protection equipment. Do not allow to enter into surface water or drains. Take up mechanically. Treat the recovered material as prescribed in the section on waste disposal. Safe handling: see section 7

3 Page 3 of 9 SECTION 7: Handling and storage Personal protection equipment: see section 8 Disposal: see section Precautions for safe handling Advice on safe handling Advice on protection against fire and explosion 7.2. Conditions for safe storage, including any incompatibilities Requirements for storage rooms and vessels Advice on storage compatibility No special measures are necessary. No special fire protection measures are necessary. Keep container tightly closed. No special measures are necessary. SECTION 8: Exposure controls/personal protection 8.1. Control parameters Exposure limits (EH40) CAS No Substance ppm mg/m³ fibres/ml Category Origin Aluminium oxides, respirable dust - 4 TWA (8 h) WEL - - STEL (15 min) WEL Glycerol, mist - 10 TWA (8 h) WEL - - STEL (15 min) WEL Exposure limits (EH40) CAS No Substance ppm mg/m³ fibres/ml Category Origin Aluminium oxides, respirable dust - 4 TWA (8 h) WEL - - STEL (15 min) WEL Glycerol, mist - 10 TWA (8 h) WEL - - STEL (15 min) WEL 8.2. Exposure controls Protective and hygiene measures Eye/face protection Hand protection Take off contaminated clothing. Wash hands before breaks and after work. When using do not eat or drink. Wear eye/face protection. When handling with chemical substances, protective gloves must be worn with the CE-label including the four control digits. The quality of the protective gloves resistant to chemicals must be chosen as a

4 Page 4 of 9 Skin protection Respiratory protection function of the specific working place concentration and quantity of hazardous substances. For special purposes, it is recommended to check the resistance to chemicals of the protective gloves mentioned above together with the supplier of these gloves. Wear suitable protective clothing. In case of inadequate ventilation wear respiratory protection.

5 Page 5 of 9 SECTION 9: Physical and chemical properties 9.1. Information on basic physical and chemical properties Physical state Colour Odour: Paste light green fruity Test method ph-value (at 20 C): 8,5 Changes in the physical state Melting point Initial boiling point and boiling range 100 C Flash point >61 C Flammability Solid Gas not applicable Lower explosion limits 0,6 vol. % Upper explosion limits 7 vol. % Auto-ignition temperature Solid Gas not applicable Decomposition temperature Oxidizing properties Not oxidizing. Vapour pressure Density (at 20 C): Water solubility Solubility in other solvents Partition coefficient Viscosity / dynamic (at 20 C) Vapour density: Evaporation rate: 1,45 g/cm³ insoluble mpa s Solvent content 18,00 %, 9.2. Other information SECTION 10: Stability and reactivity Reactivity Chemical stability No hazardous reaction when handled and stored according to provisions Possibility of hazardous reactions Conditions to avoid none Incompatible materials No information available Hazardous decomposition products No known hazardous decomposition products.

6 Page 6 of 9 SECTION 11: Toxicological information Information on toxicological effects Route(s) of Entry Acute toxicity CAS No Chemical name Exposure routes Method aliphatic hydrocarbons, C11-C13, isoalkanes oral dermal Dose Species Source LD mg/kg Rat OECD-Richtlinien 401 LD mg/kg Rat OECD-Richtlinien 402 Carcinogenicity (IARC): Carcinogenicity (OSHA): Additional information on tests This mixture is classified as not hazardous according to 1999/45/EC. SECTION 12: Ecological information Toxicity Ecotoxicity The product is not: Ecotoxic Persistence and degradability The product has not been tested Bioaccumulative potential The product has not been tested Mobility in soil The product has not been tested Results of PBT and vpvb assessment The product has not been tested Other adverse effects No information available. Further information Avoid release to the environment. SECTION 13: Disposal considerations Waste treatment methods Advice on disposal Do not allow to enter into surface water or drains. Dispose of waste

7 Page 7 of 9 according to applicable legislation. Waste disposal number of contaminated packaging WASTE PACKAGING; ABSORBTS, WIPING CLOTHS, FILTER MATERIALS AND PROTECTIVE CLOTHING NOT OTHERWISE SPECIFIED; packaging (including separately collected municipal packaging waste); plastic packaging Contaminated packaging SECTION 14: Transport information Land transport (ADR/RID) Wash with plenty of water. Completely emptied packages can be recycled UN proper shipping name UN number Transport hazard class(es) Packing group Inland waterways transport (ADN) UN number UN proper shipping name Transport hazard class(es) Packing group Marine transport (IMDG) UN number UN proper shipping name Transport hazard class(es) Packing group Air transport (ICAO) UN number UN proper shipping name Transport hazard class(es) Packing group Environmental hazards VIRONMTALLY HAZARDOUS no Special precautions for user Transport in bulk according to Annex II of MARPOL73/78 and the IBC Code SECTION 15: Regulatory information Safety, health and environmental regulations/legislation specific for the substance or mixture EU regulatory information 2010/75/EU (VOC): 2004/42/EC (VOC): 13,5 % (195,75 g/l) 13,591 % (197,065 g/l)

8 Page 8 of 9 Additional information National regulatory information Water contaminating class (D) To follow: 850/2004/EC, 79/117/EEC, 689/2008/EC 1 - slightly water contaminating Chemical safety assessment Chemical safety assessments for substances in this mixture were not carried out. Substance/product listed in the following inventories EINECS/ELINCS/NLP yes NECl NZloC TSCA FDA CEPA DSL KECl/ECL PICCS MITI IECSC AICS ISHL NDSL SECTION 16: Other information Revision date: Revision No: Abbreviations and acronyms yes ,04 ADR: Accord européen sur le transport des marchandises dangereuses par Route (European Agreement concerning the International Carriage of Dangerous Goods by Road) IMDG: International Maritime Code for Dangerous Goods IATA: International Air Transport Association GHS: Globally Harmonized System of Classification and Labelling of Chemicals EINECS: European Inventory of Existing Commercial Chemical Substances ELINCS: European List of Notified Chemical Substances CAS: Chemical Abstracts Service LC50: Lethal concentration, 50% LD50: Lethal dose, 50% Relevant R-phrases (Number and full text) 65 Harmful: may cause lung damage if swallowed. 66 Repeated exposure may cause skin dryness or cracking. Relevant H- and EUH-phrases (Number and full text) H227 Combustible liquid. H304 May be fatal if swallowed and enters airways. H316 Causes mild skin irritation. EUH066 Repeated exposure may cause skin dryness or cracking. EUH208 Contains orange extract, sweet ( > 90% limonene ). May produce an allergic reaction. Further Information The above information describes exclusively the safety requirements of the product and is based on our present-day knowledge. The information is intended to give you advice about the safe handling of the product named in this safety data sheet, for storage, processing, transport and disposal. The information cannot be transferred to other

9 Page 9 of 9 products. In the case of mixing the product with other products or in the case of processing, the information on this safety data sheet is not necessarily valid for the new made-up material. (The data for the hazardous ingredients were taken respectively from the last version of the sub-contractor's safety data sheet.) by SCHOLL Concepts GmbH