Ecopump work by Europump. Brussels 07. March 2013

Transcription

1 Ecopump work by Europump Brussels 07. March 2013

2 Europumps ecopump initiative ecopump The pump industry s answer to the Ecodesign directive! Product (Pump) Extended Product (Pump, PDS, Controls) System 07/03/2013 2

3 System Highest energy saving potential Not in scope of ErP Audits based on ISO /03/2013 3

4 Product Regulation (EC) No 641/2009 and (EU) No 622/2012 Ecodesign requirements for glandless circulators Europump Guideline 07/03/2013 4

5 Product Regulation (EU) No 547/2012 Ecodesign requirements for Water Pumps Europump Guideline 07/03/2013 5

6 Future EU Approach Extended Product Approach Regulation (EU) 547/2012: Article 7 Revision The Commission shall review this Regulation in the light of technological progress and shall present the result of this review to the Consultation Forum no later than four years after its entry into force. The review shall aim at adopting an extended product approach.. 07/03/2013 6

7 Extended Product Approach (EPA) vs. Extended Products (EP) Extended Product Approach is a methodology to calculate the energy efficiency Index (EEI) of an Extended Product (EP), which incorporates load profiles and control method. Extended Products (EP) consists of physical components 07/03/2013 7

8 Pump EuP/ErP Extended Product Approach (EPA) Extended Product Fluid Outlet Terminal box, or VSD Mains Pump Fluid Inlet Pump Coupling Electric Motor EuP/ErP Pumps MEI EuP/ErP - Electric Motors IEX Extended Product Approach EEI 07/03/

9 Example for Extended Product: Source: CENELEC PDS Standard, page 3 Motor System Extended Product Power Drive System (PDS) Mains & mains cabling Driven equipment Trans- Load mission Machine Auxiliaries Motor Complete Drive Module (CDM) Basic Feedin Auxil- Drive g iaries Module section (BDM) Process Motor Starter (contactor, softstarter ) System feed back* Motor Control System = CDM orstarter The Extended Product Approach needs additionally a duty profile and a control curve. The adaequate graph will be prepared for the next issue. 07/03/2013 9

10 EuP/ErP Extended Product Approach (EPA) Example for Extended Product System without frequency converter: Source: CENELEC PDS Standard, page 4 Mains & mains cabling Motor System Motor Starter Contactor, soft-starter Extended Product Motor Driven equipment Trans - mission Load Machine Process System feed back* Time (%) * i.e. a level switch Typical load profile Load (%) 07/03/

11 EuP - New Work Items ENER Lot 28: Pumps (extended product approach including motors, VSD and controls, where appropriate) for private and public waste water (including all stages including buildings, networks and treatment facilities) and for fluids with high solids content 07/03/

12 Pump Extended Product Approach Lot 28 Waste Water Pump 07/03/

13 Research Proposal Lot 28 Europump Project Planing 1. Year 2. Year Work package / Project Time Analysis of screened material Definition of Waste Water Materials Definition of test setup and procedures Definition of function factor Pump testing to veriefy funktion factor Documentation 07/03/

14 EuP - New Work Items ENER Lot 29: Pumps (extended product approach including motors, VSD and controls, where appropriate) for private and public swimming pools, ponds, fountains and aquariums, as well as clean water pumps larger than those regulated under Lot 11 07/03/

15 Energy efficiency requirements Summary of EuP/ErP legislation for pumps and motors Adoption/ Expected adoption Energy efficiency requirements Expected future requirements Clean water pumps Wastewater pumps EP (EEI<zz) EP (EEI<yy) MEI>0,1 MEI>0,4 EP (EEI<xx) Water pumps EEI<0,27 EEI<0,23 Circulators Motors IE2 IE3 or IE2+VSD IE3 or IE2+VSD* *Increased scope

16 Thank you for your attention 07/03/