Safety Data Sheet according to Federal Register / Vol. 77, No. 58 / Monday, March 26, 2012 / Rules and Regulations Revision date: 04/15/2015

Transcription

1 Revision date: 04/15/2015 SECTION 1: Identification of the substance/mixture and of the company/undertaking 1.1. Product identifier Product form Product name : Mixture : Safe 2 Clean RTU Product code : Relevant identified uses of the substance or mixture and uses advised against Use of the substance/mixture 1.3. Details of the supplier of the safety data sheet CSI Group Int'l Inc.-DBA Concrete Services Int'l 575 Route 73 North, Unit C-4 West Berlin, NJ T (856) Emergency telephone number SECTION 2: Hazards identification 2.1. Classification of the substance or mixture Classification (GHS-US) Eye Irrit. 2A H319 Full text of H-phrases: see section 16 : Cleaners, liquids (all purpose cleaners, sanitary products, floor cleaners, glass cleaners, carpet cleaners, metal cleaners) 2.2. Label elements GHS-US labeling Hazard pictograms (GHS-US) : Signal word (GHS-US) Hazard statements (GHS-US) Precautionary statements (GHS-US) GHS07 : Warning : H319 - Causes serious eye irritation : P264 - Wash hands and forearms thoroughly after handling P280 - Wear protective gloves/eye protection/face protection P305+P351+P338 - If in eyes: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing P337+P313 - If eye irritation persists: Get medical advice/attention 2.3. Other hazards 2.4. Unknown acute toxicity (GHS-US) SECTION 3: Composition/information on ingredients 3.1. Substance 3.2. Mixture 05/15/2015 EN (English US) Page 1

2 Name Product identifier % Classification (GHS-US) Hydrogen Peroxide, conc=35%, aqueous solution (CAS No) Skin Irrit. 2, H315 Eye Dam. 1, H318 STOT SE 3, H335 Aquatic Acute 2, H401 Full text of H-phrases: see section 16 SECTION 4: First aid measures 4.1. Description of first aid measures First-aid measures general First-aid measures after inhalation First-aid measures after skin contact First-aid measures after eye contact First-aid measures after ingestion : Never give anything by mouth to an unconscious person. If you feel unwell, seek medical advice (show the label where possible). : Allow victim to breathe fresh air. Allow the victim to rest. : Remove affected clothing and wash all exposed skin area with mild soap and water, followed by warm water rinse. : Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing. If eye irritation persists: Get medical advice/attention. : Rinse mouth. Do NOT induce vomiting. Obtain emergency medical attention Most important symptoms and effects, both acute and delayed Symptoms/injuries after eye contact : Causes serious eye irritation Indication of any immediate medical attention and special treatment needed SECTION 5: Firefighting measures 5.1. Extinguishing media Suitable extinguishing media : Foam. Dry powder. Carbon dioxide. Water spray. Sand. Unsuitable extinguishing media : Do not use a heavy water stream Special hazards arising from the substance or mixture 5.3. Advice for firefighters Firefighting instructions Protection during firefighting : Use water spray or fog for cooling exposed containers. Exercise caution when fighting any chemical fire. Prevent fire-fighting water from entering environment. : Do not enter fire area without proper protective equipment, including respiratory protection. SECTION 6: Accidental release measures 6.1. Personal precautions, protective equipment and emergency procedures For non-emergency personnel Emergency procedures For emergency responders Protective equipment Emergency procedures : Evacuate unnecessary personnel. : Equip cleanup crew with proper protection. : Ventilate area Environmental precautions Prevent entry to sewers and public waters. Notify authorities if liquid enters sewers or public waters Methods and material for containment and cleaning up Methods for cleaning up 6.4. Reference to other sections See Heading 8. Exposure controls and personal protection. SECTION 7: Handling and storage 7.1. Precautions for safe handling Precautions for safe handling Hygiene measures : Soak up spills with inert solids, such as clay or diatomaceous earth as soon as possible. Collect spillage. Store away from other materials. : Wash hands and other exposed areas with mild soap and water before eating, drinking or smoking and when leaving work. Provide good ventilation in process area to prevent formation of vapor. : Wash hands and forearms thoroughly after handling. 05/15/2015 EN (English US) 2/6

3 7.2. Conditions for safe storage, including any incompatibilities Storage conditions Incompatible products Incompatible materials 7.3. Specific end use(s) : Keep only in the original container in a cool, well ventilated place away from heat, hot surfaces, sparks, open flame and other ignition sources. No smoking. Keep container closed when not in use. : Strong bases. Strong acids. SECTION 8: Exposure controls/personal protection 8.1. Control parameters Safe 2 Clean RTU ACGIH : Sources of ignition. Direct sunlight. OSHA ACGIH ACGIH TWA (ppm) 1 ppm ACGIH ACGIH STEL (ppm) 1 ppm OSHA 8.2. Exposure controls Personal protective equipment : Avoid all unnecessary exposure. Hand protection Eye protection Respiratory protection : Wear protective gloves/eye protection/face protection protective gloves. : Chemical goggles or safety glasses. : Wear appropriate mask. : Do not eat, drink or smoke during use. SECTION 9: Physical and chemical properties 9.1. Information on basic physical and chemical properties Physical state Color Odor Odor threshold : Liquid : clear : orange ph : Melting point Freezing point Boiling point : F Flash point : 200 F Relative evaporation rate (butyl acetate=1) Flammability (solid, gas) Explosion limits Explosive properties Oxidizing properties Vapor pressure Relative density : 1.03 Relative vapor density at 20 C Solubility Log Pow Log Kow Auto-ignition temperature Decomposition temperature : Same as water : Soluble in water. Water: Solubility in water of component(s) of the mixture : : : : 05/15/2015 EN (English US) 3/6

4 Viscosity Viscosity, kinematic Viscosity, dynamic 9.2. SECTION 10: Stability and reactivity Reactivity Chemical stability Stable under normal conditions. Not established Possibility of hazardous reactions Not established Conditions to avoid Direct sunlight. Extremely high or low temperatures Incompatible materials Strong acids. Strong bases Hazardous decomposition products Fume. Carbon monoxide. Carbon dioxide. SECTION 11: Toxicological information Information on toxicological effects Acute toxicity Skin corrosion/irritation Serious eye damage/irritation Respiratory or skin sensitization Germ cell mutagenicity Carcinogenicity ph: : Causes serious eye irritation. ph: IARC group 3 - Not classifiable Reproductive toxicity Specific target organ toxicity (single exposure) Specific target organ toxicity (repeated exposure) Aspiration hazard Potential Adverse human health effects and symptoms Symptoms/injuries after eye contact : Based on available data, the classification criteria are not met. : Causes serious eye irritation. SECTION 12: Ecological information Toxicity LC50 fish mg/l (96 h; Pimephales promelas) EC50 Daphnia mg/l (48 h; Daphnia pulex; Solution >=50%) EC50 other aquatic organisms mg/l (72 h; Chlorella vulgaris) LC50 fish mg/l (96 h; Ictalurus punctatus) EC50 Daphnia mg/l (24 h; Daphnia magna; Solution >=50%) Threshold limit algae mg/l (72 h; Chlorella vulgaris) 05/15/2015 EN (English US) 4/6

5 12.2. Persistence and degradability Safe 2 Clean RTU Persistence and degradability Not established. Persistence and degradability Biochemical oxygen demand (BOD) Chemical oxygen demand (COD) ThOD BOD (% of ThOD) Bioaccumulative potential Safe 2 Clean RTU Bioaccumulative potential Biodegradability: not applicable. No (test)data on mobility of the components available. Photolysis in the air. Not established. Log Pow Bioaccumulative potential Bioaccumulation: not applicable Mobility in soil Other adverse effects Effect on the global warming : No known ecological damage caused by this product. : Avoid release to the environment. SECTION 13: Disposal considerations Waste treatment methods Waste disposal recommendations : Dispose in a safe manner in accordance with local/national regulations. Ecology - waste materials : Avoid release to the environment. SECTION 14: Transport information Department of Transportation (DOT) In accordance with DOT Not regulated for transport Additional information : No supplementary information available. ADR Transport by sea Air transport SECTION 15: Regulatory information US Federal regulations Listed on the United States TSCA (Toxic Substances Control Act) inventory Not listed on the United States SARA Section International regulations CANADA 05/15/2015 EN (English US) 5/6

6 EU-Regulations Classification according to Regulation (EC) No. 1272/2008 [CLP] Classification according to Directive 67/548/EEC [DSD] or 1999/45/EC [DPD] Not classified National regulations US State regulations SECTION 16: Revision date : 04/15/2015 : None. Full text of H-phrases: Aquatic Acute 2 Hazardous to the aquatic environment - Acute Hazard Category Eye Dam. 1 Serious eye damage/eye irritation Category Eye Irrit. 2A Serious eye damage/eye irritation Category 2A Skin Irrit. 2 Skin corrosion/irritation Category STOT SE 3 Specific target organ toxicity (single exposure) Category H315 Causes skin irritation H318 Causes serious eye damage H319 Causes serious eye irritation H335 May cause respiratory irritation H401 Toxic to aquatic life HMIS III Rating Health Flammability Physical Personal Protection : 1 Slight Hazard - Irritation or minor reversible injury possible : 0 Minimal Hazard - Materials that will not burn : 0 Minimal Hazard - Materials that are normally stable, even under fire conditions, and will NOT react with water, polymerize, decompose, condense, or self-react. Non-Explosives. : B B - Safety glasses, Gloves SDS US (GHS HazCom 2012) This information is based on our current knowledge and is intended to describe the product for the purposes of health, safety and environmental requirements only. It should not therefore be construed as guaranteeing any specific property of the product 05/15/2015 EN (English US) 6/6