Safety data sheet complying with Regulation 1907/2006/EC (REACH Regulation), EU 2015/830 and Regulation No 1272/2008/EC (CLP)

Transcription

1 Page 1/7 * SECTION 1: Identification of the substance/mixture and of the company/undertaking 1.1 Product identifier Registration number: Substances contained in the mixture have already (pre)-registered by the suppliers. 1.2 Relevant identified uses of the substance or mixture and uses advised against No relevant identified uses-mixture of substances. Application of the substance / the mixture: Lubricant 1.3 Details of the supplier of the safety data sheet Manufacturer/Supplier: Aegean Marine Petroleum S.A 10, Akti Kondyli, Piraeus, Greece, Tel: (+30) Fax: (+30) alfalubes@ampni.com 1.4 Emergency telephone number: Emergency telephone number: 112 * SECTION 2: Hazards identification 2.1 Classification of the substance or mixture Classification according to Regulation EC No 1272/2008 CLP: This product does not meet the criteria for classification in any hazard class according to Regulation (EC) No 1272/2008 on classification, labelling and packaging of substances and mixtures. 2.2 Label elements Labelling according to Regulation EC No 1272/2008 CLP: Hazard pictograms: Signal word: Hazard statements: Additional information: EUH208 Contains Long-chain alkyl amine. May produce an allergic reaction. 2.3 Other hazards Results of PBT and vpvb assessment PBT: Not applicable. vpvb: Not applicable. * SECTION 3: Composition/information on ingredients 3.2 Chemical characterisation: Mixtures Description: Lubricant Ingredients according Regulation (EU) 830/2015: Additional information: For the wording of the listed hazard phrases refer to section 16. (Contd. on page 2)

2 Page 2/7 (Contd. of page 1) SECTION 4: First aid measures 4.1 Description of first aid measures General information: No special measures required. Take affected persons out into the fresh air. After inhalation: Seek medical treatment in case of complaints. After skin contact: Wash the skin immediately with soap and water. If skin irritation continues, consult a doctor. After eye contact: Rinse opened eye for several minutes under running water. If symptoms persist, consult a doctor. After swallowing: Never give anything by mouth to an unconscious person. Drink plenty of water and provide fresh air. Call for a doctor immediately. Seek immediate medical advice. 4.2 Most important symptoms and effects, both acute and delayed No further relevant information available. 4.3 Indication of any immediate medical attention and special treatment needed No further relevant information available. SECTION 5: Firefighting measures 5.1 Extinguishing media Suitable extinguishing agents: CO2, powder or water spray. Fight larger fires with water spray. 5.2 Special hazards arising from the substance or mixture In case of fire, the following can be released: Carbon monoxide (CO) Carbon dioxide (CO2) 5.3 Advice for firefighters Protective equipment: Use of protective clothes and respiratory device is being recommended in case of fire. Additional information Collect contaminated fire fighting water separately. It must not enter the sewage system. SECTION 6: Accidental release measures 6.1 Personal precautions, protective equipment and emergency procedures: For non-emergency personnel Keep away from ignition sources. Ensure sufficient ventilation For emergency responders Use safety goggles, in case of contact with the eyes. Use chemicals resistant gloves. Use antistatic and slip resistant boots. 6.2 Environmental precautions: No special measures required. 6.3 Methods and material for containment and cleaning up: Pick up mechanically with a non combustible material such as earth or sand. 6.4 Reference to other sections: See Section 7 for information on safe handling. See Section 8 for information on personal protection equipment. (Contd. on page 3)

3 Page 3/7 See Section 13 for disposal information. (Contd. of page 2) SECTION 7: Handling and storage 7.1 Precautions for safe handling Avoid contact with hot product Information about fire - and explosion protection: No special measures required. 7.2 Conditions for safe storage, including any incompatibilities Storage: Requirements to be met by storerooms and receptacles: Store in a cool location. Information about storage in one common storage facility: Not required. Further information about storage conditions: Store in cool, dry conditions in well sealed receptacles. Protect from heat and direct sunlight. 7.3 Specific end use(s) No further relevant information available. SECTION 8: Exposure controls/personal protection 8.1 Control parameters Ingredients with limit values that require monitoring at the workplace: The product does not contain any relevant quantities of materials with critical values that have to be monitored at the workplace. Additional information: The lists valid during the making were used as basis. 8.2 Exposure controls Personal protective equipment General protective and hygienic measures: The usual precautionary measures are to be adhered to when handling chemicals. Respiratory protection: Not required. Protection of hands: Protective gloves Penetration time of glove material The determined penetration times according to EN 374 part III are not performed under practical conditions. Therefore a maximum wearing time, which corresponds to 50% of the penetration time, is recommended. Eye protection: Not required under normal conditions of use. Body protection: Not required under normal conditions of use. * SECTION 9: Physical and chemical properties 9.1 Information on basic physical and chemical properties General Information Appearance: Form: Liquid Colour: Light-coloured to brown Odour: Characteristic of lubricants Odour threshold: ph value: (Contd. on page 4)

4 Page 4/7 Melting point/freezing point: Initial boiling point and boiling range: (Contd. of page 3) Flash point: 215 C Flammability (solid, gas): Auto-ignition temperature: Decomposition temperature: Auto-ignition temperature: Explosive properties: Explosion limits: Lower: Upper: Vapour pressure: Density: Relative density Vapour density Evaporation rate Solubility in / Miscibility with water: Not applicable Product is not selfigniting. Product does not present an explosion hazard. Not miscible Partition coefficient: n-octanol/water: Viscosity: Dynamic: Kinematic at 20 C: 68 cst (DIN 53211/4) 9.2 Other information No further relevant information available. SECTION 10: Stability and reactivity 10.1 Reactivity No further relevant information available Chemical stability Thermal decomposition / conditions to be avoided No decomposition if used and stored according to specifications. Stable at environment temperature Possibility of hazardous reactions No dangerous reactions known Conditions to avoid Oxidising agents 10.5 Incompatible materials No further relevant information available Hazardous decomposition products No dangerous decomposition products known. SECTION 11: Toxicological information 11.1 Information on toxicological effects Acute toxicity Based on available data, the classification criteria are not met. (Contd. on page 5)

5 Page 5/7 LD/LC50 values relevant for classification: Dermal LD mg/kg (ATE) Inhalative LC50/4 h (vapours) 253 mg/l (ATE) Skin corrosion/irritation Based on available data, the classification criteria are not met. Serious eye damage/irritation Based on available data, the classification criteria are not met. Respiratory or skin sensitisation Based on available data, the classification criteria are not met. CMR effects (carcinogenity, mutagenicity and toxicity for reproduction) Germ cell mutagenicity Based on available data, the classification criteria are not met. Carcinogenicity Based on available data, the classification criteria are not met. Reproductive toxicity Based on available data, the classification criteria are not met. STOT-single exposure Based on available data, the classification criteria are not met. STOT-repeated exposure Based on available data, the classification criteria are not met. Aspiration hazard Based on available data, the classification criteria are not met. (Contd. of page 4) SECTION 12: Ecological information 12.1 Toxicity Aquatic toxicity: No further relevant information available Persistence and degradability No further relevant information available Bioaccumulative potential No further relevant information available Mobility in soil No further relevant information available. Additional ecological information: General notes: Not known to be hazardous to water Results of PBT and vpvb assessment PBT: Not applicable. vpvb: Not applicable Other adverse effects No further relevant information available. SECTION 13: Disposal considerations 13.1 Waste treatment methods Recommendation Dispose according to National Regulations. Uncleaned packaging: Recommendation: Disposal must be made according to official regulations. Packaging may be reused or recycled after cleaning. SECTION 14: Transport information 14.1 UN-Number ADR, ADN, IMDG, IATA 14.2 UN proper shipping name ADR, ADN, IMDG, IATA (Contd. on page 6)

6 Page 6/ Transport hazard class(es) (Contd. of page 5) ADR, ADN, IMDG, IATA Class 14.4 Packing group ADR, IMDG, IATA 14.5 Environmental hazards: Not applicable Special precautions for user Not applicable Transport in bulk according to Annex II of Marpol and the IBC Code Not applicable. UN "Model Regulation": SECTION 15: Regulatory information 15.1 Safety, health and environmental regulations/legislation specific for the substance or mixture REACH Regulation 1907/2006/EC Regulation (EU) 2015/830 CLP Regulation 1272/2008/EC Constituents of the mixture that fall within the scope of REACH Regulation 1907/2006/EC, have been (pre)- registered. National regulations: Other regulations, limitations and prohibitive regulations Substances of very high concern (SVHC) according to REACH, Article 57 It doesn't contain substances of very high concern (SVHC) Chemical safety assessment: Has been performed for the main ingredients of the product. A Chemical Safety Assessment has not been carried out. SECTION 16: Other information This information is based on our present knowledge. However, this shall not constitute a guarantee for any specific product features and shall not establish a legally valid contractual relationship. Department issuing SDS: SUSTCHEM Engineering Ltd REACH & Chemical Services Department 144, 3rd Septemvriou, GR , Athens, Greece Tel.: Fax: info@suschem.gr Website: Abbreviations and acronyms: ADR: Accord européen sur le transport des marchandises dangereuses par Route (European Agreement concerning the International Carriage of Dangerous Goods by Road) IMDG: International Maritime Code for Dangerous Goods IATA: International Air Transport Association GHS: Globally Harmonised System of Classification and Labelling of Chemicals EINECS: European Inventory of Existing Commercial Chemical Substances ELINCS: European List of Notified Chemical Substances CAS: Chemical Abstracts Service (division of the American Chemical Society) (Contd. on page 7)

7 Page 7/7 LC50: Lethal concentration, 50 percent LD50: Lethal dose, 50 percent PBT: Persistent, Bioaccumulative and Toxic SVHC: Substances of Very High Concern vpvb: very Persistent and very Bioaccumulative * Data compared to the previous version altered. (Contd. of page 6)