Issuing Date 08-Jun-2015 Revision Date 07-Mar-2017 Revision Number 2 1. IDENTIFICATION OF THE SUBSTANCE/PREPARATION AND THE COMPANY/UNDERTAKING

Transcription

1 SAFETY DATA SHEET Issuing Date 08-Jun-2015 Revision Number 2 1. IDENTIFICATION OF THE SUBSTANCE/PREPARATION AND THE COMPANY/UNDERTAKING GHS product identifier Product Name EZY-PAK TM #115 Other means of identification Product Code(s) 985 Synonyms JET-LUBE - EZY-PAK TM #115; ILEX EZY-PAK #115 Recommended use of the chemical and restrictions on use Recommended Use Uses advised against Lubricants, Greases and Release Products information available Supplier's details Manufacturer Address Jet-Lube, LLC 930 Whitmore Dr. Rockwall, Texas TEL: Toll Free: Emergency telephone number Emergency Telephone Number CHEMTREC: (INTERNATIONAL) (NORTH AMERICA) Classification 2. HAZARDS IDENTIFICATION This chemical is not considered hazardous according to the OSHA Hazard Communication Standard 2012 (29 CFR ). GHS Label elements, including precautionary statements Emergency Overview Signal Word ne The product contains no substances which at their given concentration are considered to be hazardous to health Appearance Green Physical State Semi-Solid, Paste. Odor Slight Precautionary Statements Prevention ne Page 1 / 7

2 General Advice ne Storage ne Disposal ne Hazard t Otherwise Classified (HNOC) t applicable Other information 50.61% of the mixture consists of ingredient(s) of unknown toxicity. 3. COMPOSITION/INFORMATION ON INGREDIENTS Synonyms JET-LUBE - EZY-PAK TM #115; ILEX EZY-PAK #115 Chemical Name CAS- Weight % Trade secret Glass, oxide * Talc * *The exact percentage (concentration) of composition has been withheld as a trade secret. 4. FIRST AID MEASURES Description of necessary first-aid measures Eye Contact Rinse thoroughly with plenty of water, also under the eyelids. If symptoms persist, call a physician. Skin Contact Inhalation Ingestion Wash skin with soap and water. If skin irritation persists, call a physician. Move to fresh air. Do NOT induce vomiting. Drink plenty of water. Never give anything by mouth to an unconscious person. If symptoms persist, call a physician. Most important symptoms/effects, acute and delayed Most Important Symptoms/Effects Indication of immediate medical attention and special treatment needed, if necessary tes to Physician Treat symptomatically. 5. FIRE-FIGHTING MEASURES Suitable Extinguishing Media Water spray. Carbon dioxide (CO 2 ). Dry chemical. Alcohol-resistant foam. Unsuitable Extinguishing Media Do not use a solid water stream as it may scatter and spread fire. Specific Hazards Arising from the Chemical Burning produces obnoxious and toxic fumes. Carbon monoxide, carbon dioxide and unburned hydrocarbons (smoke). Halogenated compounds Explosion Data Sensitivity to Mechanical Impact Sensitivity to Static Discharge ne. ne. Page 2 / 7

3 Protective Equipment and Precautions for Firefighters As in any fire, wear self-contained breathing apparatus pressure-demand, MSHA/NIOSH (approved or equivalent) and full protective gear. 6. ACCIDENTAL RELEASE MEASURES Personal precautions, protective equipment and emergency procedures Personal Precautions Use personal protective equipment. Environmental Precautions Environmental Precautions Prevent further leakage or spillage if safe to do so. Methods and materials for containment and cleaning up Methods for Containment Methods for Cleaning Up Prevent further leakage or spillage if safe to do so. Dam up. Soak up with inert absorbent material. Pick up and transfer to properly labeled containers. 7. HANDLING AND STORAGE Precautions for safe handling Handling Wear personal protective equipment. Ensure adequate ventilation. Wash thoroughly after handling. Conditions for safe storage, including any incompatibilities Storage Incompatible Products Keep containers tightly closed in a dry, cool and well-ventilated place. Strong oxidizing agents. 8. EXPOSURE CONTROLS / PERSONAL PROTECTION Control parameters Exposure Guidelines Chemical Name ACGIH TLV OSHA PEL NIOSH IDLH Glass, oxide TWA: 1 fiber/cm3 respirable fibers: length >5 µm, aspect ratio >=3:1, as determined by the membrane filter method at X magnification [4-mm objective], using phase-contrast illumination TWA: 5 mg/m 3 inhalable fraction - - Talc TWA: 2 mg/m 3 (vacated) TWA: 2 mg/m 3 IDLH: 1000 mg/m 3 containg no asbestos and <1% quartz TWA: 2 mg/m 3 Immediately Dangerous to Life or Health. ACGIH TLV: American Conference of Governmental Industrial Hygienists - Threshold Limit Value. OSHA PEL: Occupational Safety and Health Administration - Permissible Exposure Limits. NIOSH IDLH: Other Exposure Guidelines Vacated limits revoked by the Court of Appeals decision in AFL-CIO v. OSHA, 965 F.2d 962 (11th Cir., 1992). Appropriate engineering controls Engineering Measures Showers Eyewash stations Ventilation systems Page 3 / 7

4 Individual protection measures, such as personal protective equipment Eye/Face Protection Skin and Body Protection Respiratory Protection Hygiene Measures special protective equipment required. special protective equipment required. protective equipment is needed under normal use conditions. If exposure limits are exceeded or irritation is experienced, NIOSH/MSHA approved respiratory protection should be worn. When using, do not eat, drink or smoke. Remove and wash contaminated clothing before re-use. Information on basic physical and chemical properties 9. PHYSICAL AND CHEMICAL PROPERTIES Physical State Semi-Solid, Paste. Appearance Green. Odor Slight. Odor Threshold Property Values Remarks/ - Method ph Neutral ne known Melting Point/Range NONE ne known Boiling Point/Boiling Range > 316 C / F ne known Flash Point > 260 C / 500 F ne known Evaporation rate data available ne known Flammability (solid, gas) data available ne known Flammability Limits in Air upper flammability limit data available lower flammability limit data available Vapor Pressure data available ne known Vapor Density data available ne known Specific Gravity 1.38 ne known Water Solubility Insoluble in water. ne known Solubility in other solvents Largely. ne known Partition coefficient: n-octanol/water data available ne known Autoignition Temperature data available ne known Decomposition Temperature data available ne known Viscosity data available ne known Flammable Properties Explosive Properties Oxidizing Properties t flammable data available data available Other information VOC Content (%) ne 10. STABILITY AND REACTIVITY Reactivity data available. Chemical stability Stable under recommended storage conditions. Possibility of hazardous reactions ne under normal processing. Hazardous Polymerization Page 4 / 7

5 Hazardous polymerization does not occur. Conditions to avoid Incompatible products. Incompatible materials Strong oxidizing agents. Hazardous decomposition products ne known based on information supplied. Information on likely routes of exposure 11. TOXICOLOGICAL INFORMATION Product Information Inhalation Eye Contact Skin Contact Ingestion There is no data available for this product. There is no data available for this product. There is no data available for this product. t an expected route of exposure. Ingestion may cause gastrointestinal irritation, nausea, vomiting and diarrhea. Symptoms related to the physical, chemical and toxicological characteristics Symptoms Delayed and immediate effects and also chronic effects from short and long term exposure Sensitization Mutagenic Effects Carcinogenicity The table below indicates whether each agency has listed any ingredient as a carcinogen. Chemical Name ACGIH IARC NTP OSHA Glass, oxide Group 3 IARC: (International Agency for Research on Cancer) Group 3 - t Classifiable as to its Carcinogenicity to Humans Reproductive Toxicity STOT - single exposure STOT - repeated exposure Aspiration Hazard Numerical measures of toxicity - Product Acute Toxicity 50.61% of the mixture consists of ingredient(s) of unknown toxicity. The following values are calculated based on chapter 3.1 of the GHS document: LD50 Oral mg/kg; Acute toxicity estimate LD50 Dermal 6098 mg/kg; Acute toxicity estimate 12. ECOLOGICAL INFORMATION Ecotoxicity The environmental impact of this product has not been fully investigated. Chemical Name Toxicity to Algae Toxicity to Fish Toxicity to Microorganisms Daphnia Magna (Water Flea) Page 5 / 7

6 Talc Persistence and Degradability Bioaccumulation LC50 96 h: > 100 g/l semi-static (Brachydanio rerio) Other Adverse Effects 13. DISPOSAL CONSIDERATIONS Waste Disposal Methods This material, as supplied, is not a hazardous waste according to Federal regulations (40 CFR 261). This material could become a hazardous waste if it is mixed with or otherwise comes in contact with a hazardous waste, if chemical additions are made to this material, or if the material is processed or otherwise altered. Consult 40 CFR 261 to determine whether the altered material is a hazardous waste. Consult the appropriate state, regional, or local regulations for additional requirements. Contaminated Packaging Do not re-use empty containers. 14. TRANSPORT INFORMATION DOT t regulated International Inventories 15. REGULATORY INFORMATION Legend TSCA - United States Toxic Substances Control Act Section 8(b) Inventory DSL/NDSL - Canadian Domestic Substances List/n-Domestic Substances List U.S. Federal Regulations Section 313 of Title III of the Superfund Amendments and Reauthorization Act of 1986 (SARA). This product does not contain any chemicals which are subject to the reporting requirements of the Act and Title 40 of the Code of Federal Regulations, Part 372. SARA 311/312 Hazard Categories Acute Health Hazard Chronic Health Hazard Fire Hazard Sudden Release of Pressure Hazard Reactive Hazard Clean Water Act This product does not contain any substances regulated as pollutants pursuant to the Clean Water Act (40 CFR and 40 CFR ). CERCLA This material, as supplied, does not contain any substances regulated as hazardous substances under the Comprehensive Environmental Response Compensation and Liability Act (CERCLA) (40 CFR 302) or the Superfund Amendments and Reauthorization Act (SARA) (40 CFR 355). There may be specific reporting requirements at the local, regional, or state level pertaining to releases of this material. Page 6 / 7

7 U.S. State Regulations California Proposition 65 This product does not contain any Proposition 65 chemicals. U.S. State Right-to-Know Regulations "X" designates that the ingredients are listed on the state right to know list. Chemical Name New Jersey Massachusetts Pennsylvania Illinois Rhode Island Ptfe X X Talc X X X X U.S. EPA Label Information EPA Pesticide Registration Number t applicable 16. OTHER INFORMATION NFPA Health Hazard 1 Flammability 1 Instability 0 Physical and Chemical Hazards - HMIS Health Hazard 1 Flammability 1 Physical Hazard 0 Personal Protection X Prepared By Issuing Date Revision Date Revision te Product Stewardship 23 British American Blvd. Latham, NY Jun Mar-2017 Updated company information. General Disclaimer The information provided on this SDS is correct to the best of our knowledge, information and belief at the date of its publication. The information given is designed only as a guide for safe handling, use, processing, storage, transportation, disposal and release and is not to be considered as a warranty or quality specification. The information relates only to the specific material designated and may not be valid for such material used in combination with any other material or in any process, unless specified in the text. End of Safety Data Sheet Page 7 / 7