Safety Data Sheet. Issue Date: 26-Sep-2017 Version 1 1. IDENTIFICATION. Product Identifier. SSS Cleencrete Waterless Concrete Cleaner

Transcription

1 Safety Data Sheet Issue Date: 26-Sep-2017 Version 1 1. IDENTIFICATION Product Identifier Product Name Other means of identification SDS # SSS Cleencrete Waterless Concrete Cleaner Triple SSS-64 Product Code Recommended use of the chemical and restrictions on use Recommended Use Concrete Cleaner. Details of the supplier of the safety data sheet Supplier Address Triple S 2 Executive Park Drive Billerica, MA Emergency Telephone Number Company Phone Number Emergency Telephone (24 hr) HAZARDS IDENTIFICATION Appearance Gray powder Physical State Powder Odor Bland Classification Respiratory tract irritation Category 3 Signal Word Warning Hazard Statements May cause respiratory irritation Page 1 of 9

2 Precautionary Statements - Prevention Only use in well-ventilated areas. Do not breathe dust. Wear safety glasses with side shields. Wear impervious gloves for prolonged contact. Store in a well-ventilated place. Keep container tightly closed. Keep out of reach of Children. Dispose of waste and residues in accordance with local authority requirements. Precautionary Statements - Response IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing If eye irritation persists: Get medical advice/attention IF ON SKIN: Wash with plenty of soap and water If skin irritation occurs: Get medical advice/attention Take off contaminated clothing and wash it before reuse Other Hazards Harmful to aquatic life with long lasting effects 3. COMPOSITION/INFORMATION ON INGREDIENTS Chemical Name CAS No Weight-% Portland Cement Clinker <70 **If Chemical Name/CAS No is "proprietary" and/or Weight-% is listed as a range, the specific chemical identity and/or percentage of composition has been withheld as a trade secret.** 4. FIRST-AID MEASURES First Aid Measures Eye Contact Skin Contact Inhalation Ingestion IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing. If eye irritation persists: Get medical advice/attention. IF ON SKIN: Wash with plenty of soap and water. If skin irritation occurs: Get medical advice/ attention. Take off contaminated clothing and wash it before reuse. Remove to fresh air. Give large amounts of water. DO NOT induce vomiting. Get medical attention. Most important symptoms and effects Symptoms Burns to eyes and skin. Page 2 of 9

3 Indication of any immediate medical attention and special treatment needed Notes to Physician Treat symptomatically. 5. FIRE-FIGHTING MEASURES Suitable Extinguishing Media Use extinguishing measures that are appropriate to local circumstances and the surrounding environment. Unsuitable Extinguishing Media. Specific Hazards Arising from the Chemical Product is not flammable. Protective equipment and precautions for firefighters As in any fire, wear self-contained breathing apparatus pressure-demand, MSHA/NIOSH (approved or equivalent) and full protective gear. 6. ACCIDENTAL RELEASE MEASURES Personal precautions, protective equipment and emergency procedures Personal Precautions Protective Equipment and Emergency Procedures Wear appropriate personal protective equipment. Do not touch damaged containers or spilled material unless wearing appropriate protective clothing. Ensure adequate ventilation. For personal protection, see section 8 of the SDS. Methods and material for containment and cleaning up Sweep up and shovel into suitable containers for disposal. Minimize dust generation and accumulation. Do not flush large amounts to sewer. Never return spills to original containers for re-use. For waste disposal, see section 13 of the SDS. 7. HANDLING AND STORAGE Precautions for safe handling Page 3 of 9

4 Advice on Safe Handling Handle in accordance with good industrial hygiene and safety practice. Avoid contact with skin, eyes or clothing. Wash face, hands, and any exposed skin thoroughly after handling. Wear protective gloves/protective clothing and eye/face protection. Do not destroy or deface the label. Conditions for safe storage, including any incompatibilities Storage Conditions Incompatible Materials Keep container tightly closed and store in a cool, dry and well-ventilated place. Store containers upright. Oxidizing agents. Strong acids. 8. EXPOSURE CONTROLS/PERSONAL PROTECTION Occupational exposure limits US. ACGIH Threshold Limit Values Components Type Value Form Portland Cement TWA 1 mg/m3 Respirable fraction Clinker (CAS ) US. OSHA Table Z-1 Limits for Air Contaminants (29 CFR ) Components Type Value Form Portland Cement PEL 15 mg/m3 Total Dust Clinker (CAS ) 5 mg/m3 Respirable fraction US. OSHA Table Z-3 (29 CFR ) Components Type Value Portland Cement TWA 50 mppcf Clinker (CAS Appropriate engineering controls Engineering Controls Ensure adequate ventilation, especially in confined areas. Eyewash stations. Showers. Individual protection measures, such as personal protective equipment Eye/Face Protection Goggles. Skin and Body Protection Wear protective gloves and protective clothing. Respiratory Protection General Hygiene Considerations Wear a dust mask if dust is generated above exposure limits. Handle in accordance with good industrial hygiene and safety practice. Such as washing after handling material and before eating, drinking, and/or smoking. Routinely wash work clothing and protective equipment to remove contaminants. Page 4 of 9

5 9. PHYSICAL AND CHEMICAL PROPERTIES Information on basic physical and chemical properties Physical State Powder Appearance Gray Powder Odor Bland Color Gray Odor Threshold Property Values Remarks Method ph Not applicable Melting Point/Freezing Point Not Applicable Boiling Point/Boiling Range Flash Point None (will not burn) Evaporation Rate Flammability (Solid, Gas) Liquid-Not Applicable Upper Flammability Limits Lower Flammability Limit Vapor Pressure Not Applicable Vapor Density Specific Gravity Water Solubility Completely soluble Solubility in other solvents Partition Coefficient Auto-ignition Temperature Decomposition Temperature Kinematic Viscosity Dynamic Viscosity Explosive Properties Oxidizing Properties 10. STABILITY AND REACTIVITY Reactivity Not reactive under normal conditions. Chemical Stability Stable under recommended storage conditions. Possibility of Hazardous Reactions None under normal processing. Conditions to Avoid Contact with incompatible materials. Incompatible Materials Fluorine. Acids. Water, moisture. Hazardous Decomposition Products None known based on information supplied. Page 5 of 9

6 11. TOXICOLOGICAL INFORMATION Information on likely routes of exposure Product Information Eye Contact Skin Contact Inhalation Causes serious eye irritation. Contact with wet material may cause burns to eyes and skin. Causes severe skin irritation. Causes irritation to the respiratory system. Prolonged inhalation may be harful. Ingestion Expected to be a low ingestion hazard. Carcinogenicity This product is not considered to be a carcinogen by IARC, ACGIH, NTP, or OSHA. US. OSHA Specifically Regulated Substances (29 CFR ) Not listed. Reproductive toxicity Chronic effects Toxicological information This product is not expected to cause reproductive or developmental effects. Prolonged inhalation may be harmful. Occupational exposure to the substance or mixture may cause adverse effects. Information on physical, chemical and toxicological effects Symptoms Please see section 4 of this SDS for symptoms. 12. ECOLOGICAL INFORMATION Ecotoxicity Not classified as environmentally hazardous. However, this does not exclude the possibility that large or frequent spills can have a harmful or damaging effect on the environment. Persistence/Degradability. Bioaccumulation. Other Adverse Effects 13. DISPOSAL CONSIDERATIONS Waste Treatment Methods Page 6 of 9

7 Disposal of Wastes Disposal should be in accordance with applicable regional, national and local laws and regulations. Do not contaminate ponds, waterways or ditches with chemical or used container. Do not allow this material to drain into sewers/water supplies. Contaminated Packaging Disposal should be in accordance with applicable regional, national and local laws and regulations. Empty containers should be taken to an approved waste handling site for recycling or disposal. 14. TRANSPORT INFORMATION Note DOT IATA IMDG 15. REGULATORY INFORMATION Page 7 of 9

8 International Inventories US federal regulations This product is a Hazardous Chemical as defined by the OSHA Hazard Communication Standard, 29 CFR TSCA Section 12(b) Export Notification (40 CFR 707, Subpt. D) CERCLA Hazardous Substance List (40 CFR 302.4) Not listed CERCLA (Superfund) reportable quantity Not listed Superfund Amendments and Reauthorization Act of 1986 (SARA) Hazard Categories Immediate Hazard Yes Delayed Hazard No Fire Hazard No Pressure Hazard No Reactivity Hazard No SARA 302 Extremely No hazardous substance SARA 311/312 Hazardous No Chemical SARA 313 (TRI reporting) Other federal regulations Clean Air Act (CAA) Section 112 Hazardous Air Pollutions (HAPS) List Clean Air Act (CAA) Section 112(r) Accidental Release Prevention (40 CFR ) Safe Drinking Water Act (SDWA) US State Regulations US. Massachusetts RTK Substance List Portland Cement Clinker (CAS ) US. New Jersey Worker and Community Right-to-Know Act US. Pennsylvania RTK Hazardous Substances Portland Cement Clinker (CAS ) US. Rhode Island RTK US. California Proposition 65 California Safe Drinking Water and Toxic Enforcement Act of 1986 (Proposition 65): This material is not known to contain any chemicals currently listed as carcinogens or reproductive toxins. Page 8 of 9

9 International Inventories Country(s) or region Inventory name On inventory (yes/no) Australia Australian Inventory of Chemical Substance (AICS) NO Canada Domestic Substances List (DSL) NO Canada Non-Domestic Substances List (NDSL) NO China Inventory of Existing Chemical Substances in China (IECSC) NO Europe European Inventory of Existing Commercial Chemical Substances (EINECS) Europe European List of Notified Chemical Substances (ELINCS) NO Japan Inventory of Existing and New Chemical Substances (ENCS) NO Korea Existing Chemicals List (ECL) NO New Zealand New Zealand Inventory NO Philippines Philippine Inventory of Chemicals and Chemical Substances NO (PICCS) United States & Puerto Rico Toxic Substances Control Act (TSCA) Inventory YES *A Yes indicates that all components of this product comply with the inventory requirements administered by the governing country(s) A No indicates that one or more components of the product are not listed or exempt from listing on the inventory administered by the governing country(s). 16. OTHER INFORMATION Issue Date: Revision Note: 26-Sep-2017 New format Disclaimer The information provided in this Safety Data Sheet is correct to the best of our knowledge, information and belief at the date of its publication. The information given is designed only as a guidance for safe handling, use, processing, storage, transportation, disposal and release and is not to be considered a warranty or quality specification. The information relates only to the specific material designated and may not be valid for such material used in combination with any other materials or in any process, unless specified in the text. End of Safety Data Sheet Page 9 of 9