Safety Data Sheet according to Regulation (EC) No 1907/2006

Transcription

1 Safety Data Sheet according to Regulation (EC) No 1907/2006 Page 1 of 7 Teroson AD KDS SDS No. : Revision: printing date: Replaces version from: SECTION 1: Identification of the substance/mixture and of the company/undertaking 1.1. Product identifier Teroson AD KDS 1.2. Relevant identified uses of the substance or mixture and uses advised against Intended use: Sealant 1.3. Details of the supplier of the safety data sheet Henkel AG & Co. KGaA Henkelstr Düsseldorf Germany Phone: +49 (211) Fax-no.: +49 (211) ua-productsafety.de@henkel.com 1.4. Emergency telephone number The Henkel information service also provides an around-the-clock telephone service on phone no.+49-(0) for exceptional cases. Further information is available at Poison Control Centers Classification of the substance or mixture SECTION 2: Hazards identification Classification (CLP): The substance or mixture is not hazardous according to Regulation (EC) No 1272/2008 (CLP) Label elements Label elements (CLP): The substance or mixture is not hazardous according to Regulation (EC) No 1272/2008 (CLP). Precautionary statement: P102 Keep out of reach of children. P101 If medical advice is needed, have product container or label at hand. P262 Do not get in eyes, on skin, or on clothing. P271 Use only outdoors or in a well-ventilated area.

2 Teroson AD KDS Page 2 of Other hazards Evolves methanol during cure. Not fulfilling Persistent, Bioaccumulative and Toxic (PBT), very Persistent and very Bioaccumulative (vpvb) criteria Mixtures General chemical description: Sealant Base substances of preparation: Polymer, silan- terminated SECTION 3: Composition/information on ingredients Declaration of the ingredients according to CLP (EC) No 1272/2008: Contains no dangerous substances exceeding the limits of the EU-Regulation 4.1. Description of first aid measures General information: In case of adverse health effects seek medical advice. Inhalation: Move to fresh air, consult doctor if complaint persists. SECTION 4: First aid measures Skin contact: Rinse with running water and soap. Apply replenishing cream. Change all contaminated clothing. Eye contact: Rinse immediately with plenty of running water, seek medical advice if necessary. Ingestion: Rinse mouth and throat. Drink 1-2 glasses of water. Seek medical advice Most important symptoms and effects, both acute and delayed 4.3. Indication of any immediate medical attention and special treatment needed See section: Description of first aid measures SECTION 5: Firefighting measures 5.1. Extinguishing media Suitable extinguishing media: carbon dioxide, foam, powder, water spray jet, fine water spray Extinguishing media which must not be used for safety reasons: High pressure waterjet 5.2. Special hazards arising from the substance or mixture In the event of a fire, carbon monoxide (CO) and carbon dioxide (CO2) can be released Advice for firefighters Wear self-contained breathing apparatus. Wear protective equipment. SECTION 6: Accidental release measures

3 Teroson AD KDS Page 3 of Personal precautions, protective equipment and emergency procedures Wear protective equipment. Ensure adequate ventilation. Avoid contact with skin and eyes Environmental precautions Do not empty into drains / surface water / ground water Methods and material for containment and cleaning up Remove mechanically. Dispose of contaminated material as waste according to Section Reference to other sections See advice in section Precautions for safe handling Ensure that workrooms are adequately ventilated. Avoid skin and eye contact. Hygiene measures: Do not eat, drink or smoke while working. Wash hands before work breaks and after finishing work. SECTION 7: Handling and storage 7.2. Conditions for safe storage, including any incompatibilities Ensure good ventilation/extraction. Store in a cool, frost-free place. Storage at 5 to 25 C is recommended. Do not store together with food or other consumables (coffee, tea, tobacco, etc.) Specific end use(s) Sealant SECTION 8: Exposure controls/personal protection 8.1. Control parameters Occupational Exposure Limits Valid for Germany Ingredient [Regulated substance] ppm mg/m 3 Value type Short term exposure limit category / Remarks Time Weighted Average Indicative (TWA): [METHANOL] Skin designation: Can be absorbed through the skin Exposure limit(s): 4 If the AGW and BGW values are complied with, there should be no risk of reproductive damage (see Number 2.7). Short Term Exposure Classification: Category II: substances with a resorptive effect. Regulatory list ECTLV TRGS 900 TRGS 900 TRGS 900 Biological Exposure Indices: None 8.2. Exposure controls:

4 Teroson AD KDS Page 4 of 7 Respiratory protection: Suitable breathing mask when there is inadequate ventilation. Filter : AX (EN 14387) This recommendation should be matched to local conditions. Hand protection: Not needed. Eye protection: Not needed. SECTION 9: Physical and chemical properties 9.1. Information on basic physical and chemical properties Appearance paste pasty black Odor characteristic Odour threshold ph Melting point Solidification temperature Initial boiling point Flash point Evaporation rate Flammability Explosive limits Vapour pressure Relative vapour density: Density (20 C (68 F)) Bulk density Solubility Solubility (qualitative) (23 C (73.4 F); Solvent: Water) Partition coefficient: n-octanol/water Auto-ignition temperature Decomposition temperature Viscosity (; 20 C (68 F); Conc.: 100 % product) Viscosity (kinematic) Explosive properties Oxidising properties 1,5 g/cm3 Partially soluble 350 pa.s 9.2. Other information SECTION 10: Stability and reactivity Reactivity None if used for intended purpose Chemical stability Stable under recommended storage conditions Possibility of hazardous reactions See section reactivity Conditions to avoid None if used for intended purpose.

5 Teroson AD KDS Page 5 of Incompatible materials None if used properly Hazardous decomposition products Evolves methanol during cure Information on toxicological effects SECTION 11: Toxicological information General toxicological information: To the best of our knowledge no harmful effects are to be expected if the product is handled and used properly. General ecological information: Do not empty into drains, soil or bodies of water. SECTION 12: Ecological information Toxicity Persistence and degradability Bioaccumulative potential / Mobility in soil Results of PBT and vpvb assessment Other adverse effects SECTION 13: Disposal considerations Waste treatment methods Product disposal: Dispose of waste and residues in accordance with local authority requirements. Disposal of uncleaned packages: Use packages for recycling only when totally empty. Waste code

6 Teroson AD KDS Page 6 of 7 SECTION 14: Transport information UN number UN proper shipping name Transport hazard class(es) Packing group Environmental hazards Special precautions for user Transport in bulk according to Annex II of Marpol and the IBC Code not applicable SECTION 15: Regulatory information Safety, health and environmental regulations/legislation specific for the substance or mixture VOC content 0,00 % (VOCV VOC regulation CH) Chemical safety assessment A chemical safety assessment has not been carried out. National regulations/information (Germany): WGK: 1, slightly water-endangering product. (German VwVwS of May 17, 1999 ) Classification in conformity with the calculation method WGK: WGK = 1, slightly water endangering mixture. Classification according to the mixture rules in German AwSV regulation annex 1, number 5.2 from 18. April Storage class according to TRGS 510: 11 SECTION 16: Other information Further information: This information is based on our current level of knowledge and relates to the product in the state in which it is delivered. It is intended to describe our products from the point of view of safety requirements and is not intended to guarantee any particular properties. Relevant changes in this safety data sheet are indicated by vertical lines at the left margin in the body of this document. Corresponding text is displayed in a different color on shadowed fields.

7 Teroson AD KDS Page 7 of 7