MATERIAL SAFETY DATA SHEET 1. Product and Company Identification

Transcription

1 Product Name IMS-II Sanitizer () CAS # Product use Manufacturer LEGEND HMIS/NFPA Severe 4 Serious 3 Moderate 2 Slight 1 Minimal 0 MATERIAL SAFETY DATA SHEET 1. Product and Company Identification Mixture Disinfectant / Cleaner / Sanitizer / Deodorizer Nu-Calgon 2008 Altom Court St. Louis, MO US Phone: / Emergency Phone: (CHEMTREC) Health / 2 Flammability 0 Physical Hazard 0 Personal Protection X 2. Hazards Identification Emergency overview Potential short term health effects Routes of exposure Eyes Skin Inhalation Ingestion Target organs Chronic effects Signs and symptoms Hazards to humans and domestic animals. DANGER Keep out of reach of children. CORROSIVE. Do not get in eyes, on skin or on clothing. Eye, Skin contact, Inhalation, Ingestion. Causes irreversible eye damage. Causes chemical burns. May cause respiratory tract irritation or chemical burns. Harmful if swallowed. May cause chemical burns to mouth, throat and stomach. Skin. Eyes. Prolonged or repeated exposure to dilutions can cause drying, defatting and dermatitis. The product causes burns of eyes, skin and mucous membranes. 3. Composition / Information on Ingredients Ingredient(s) CAS # Percent First aid procedures 4. First Aid Measures Eye contact Hold eye open and rinse slowly and gently with water for minutes. Remove contact lenses, if present, after the first 5 minutes, then continue rinsing eye. Call a poison control center or doctor for treatment advice. Skin contact Take off contaminated clothing. Rinse skin immediately with plenty of water for minutes. Call a poison control center or doctor for treatment advice. Inhalation Remove affected person to fresh air. If person is not breathing, call 911 or an ambulance, then give artificial respiration, preferably mouth-to-mouth if possible. Call a poison control center or doctor for further treatment advice. #18527 Page 1 of 6 Issue date 18-Sep-2008

2 Ingestion Notes to physician General advice Call a poison control center or doctor immediately for treatment advice. Have person sip a glass of water if able to swallow. DO NOT induce vomiting unless told to do so by a poison control center or doctor. Do not give anything by mouth to an unconscious person. If the product is ingested, probable mucosal damage may contraindicate the use of gastric lavage. Treat the affected person appropriately. If you feel unwell, seek medical advice (show the label where possible). Ensure that medical personnel are aware of the material(s) involved, and take precautions to protect themselves. Show this safety data sheet to the doctor in attendance. Avoid contact with eyes and skin. Keep out of reach of children. Flammable properties Extinguishing media Suitable extinguishing media Unsuitable extinguishing media Protection of firefighters Specific hazards arising from the chemical Protective equipment for firefighters Hazardous combustion products Explosion data Sensitivity to mechanical impact Sensitivity to static discharge 5. Fire Fighting Measures Not flammable by OSHA criteria. Water spray. Fog. Carbon dioxide. Dry chemical. Firefighters should wear full protective clothing including self contained breathing apparatus. May include and are not limited to: Oxides of carbon. Oxides of nitrogen. 6. Accidental Release Measures Personal precautions Methods for containment Methods for cleaning up Keep unnecessary personnel away. Do not touch or walk through spilled material. Do not touch damaged containers or spilled material unless wearing appropriate protective clothing. Keep people away from and upwind of spill/leak. Stop leak if you can do so without risk. Prevent entry into waterways, sewers, basements or confined areas. Before attempting clean up, refer to hazard data given above. Small spills may be absorbed with non-reactive absorbent and placed in suitable, covered, labelled containers. Prevent large spills from entering sewers or waterways. Contact emergency services and supplier for advice. Never return spills in original containers for re-use. 7. Handling and Storage Handling Storage Use good industrial hygiene practices in handling this material. Do not get this material in your eyes, on your skin, or on your clothing. Keep out of the reach of children.store in a closed container away from incompatible materials. Store in a dry place no lower in temperature than 50 F or higher than 120 F. Do not contaminate water, food or feed by storage or disposal. #18527 Page 2 of 6 Issue date 18-Sep-2008

3 8. Exposure Controls / Personal Protection Exposure limits Ingredient(s) Exposure Limits TWA: 10 mg/m3 TWA: 15 mg/m3 Engineering controls Personal protective equipment Eye / face protection Hand protection Skin and body protection General ventilation normally adequate. Wear chemical goggles. Use a face shield if splashing is possible. Rubber gloves. Confirm with a reputable supplier first. As required by employer code. Respiratory protection Where exposure guideline levels may be exceeded, use an approved NIOSH respirator. Avoid breathing mists or vapors. General hygiene considerations Use good industrial hygiene practices in handling this material. When using do not eat or drink. Wash hands before breaks and immediately after handling the product. Appearance Color Form Odor Odor threshold Physical state ph Freezing point Boiling point Flash point Evaporation rate Flammability limits in air, lower, % by volume Flammability limits in air, upper, % by volume Vapor pressure Vapor density 9. Physical & Chemical Properties Clear. Colorless to Slightly amber Liquid Characteristic Liquid 13.1 (Concentrate) 0 C (32.00 F) 100 C ( F) None to boiling Same as water Specific gravity 1.1 ± Octanol/water coefficient Solubility (H2O) Complete #18527 Page 3 of 6 Issue date 18-Sep-2008

4 Auto-ignition temperature VOC (Weight %) Viscosity Percent volatile 87 Chemical stability Conditions to avoid Incompatible materials 10. Chemical Stability & Reactivity Information Stable under recommended storage conditions. Do not mix with other chemicals. Reacts violently with acids. This product may react with oxidizing agents. Hazardous vapours may be produced when mixed with chlorinated detergents or sanitizers. Acids. Oxidizing agents. Hazardous decomposition products May include and are not limited to: Oxides of carbon. Oxides of nitrogen. Possibility of hazardous reactions Hazardous polymerization does not occur. 11. Toxicological Information Component analysis - LC50 Ingredient(s) Component analysis - Oral LD50 Ingredient(s) LC50 LD mg/kg rat 1153 mg/kg rat 4000 mg/kg rat 1658 mg/kg rat Effects of acute exposure Eye Causes irreversible eye damage. Skin Causes chemical burns. Inhalation May cause respiratory tract irritation or chemical burns. Ingestion Harmful if swallowed. May cause chemical burns to mouth, throat and stomach. Sensitization Chronic effects Carcinogenicity Mutagenicity Reproductive effects Teratogenicity #18527 Page 4 of 6 Issue date 18-Sep-2008

5 12. Ecological Information Ecotoxicity Components of this product have been identified as having potential environmental concerns. Ecotoxicity - Freshwater Algae Data Tetrasodium ethylenediamine tetraacetate Hr EC50 Scenedesmus subspicatus: 1.01 mg/l Ecotoxicity - Freshwater Fish Species Data Hr LC50 Brachydanio rerio: 210 mg/l [semi-static] Hr LC50 Oncorhynchus mykiss: >100 mg/l Tetrasodium ethylenediamine tetraacetate Hr LC50 Lepomis macrochirus: 41 mg/l [static]; 96 Hr LC50 Pimephales promelas: 59.8 mg/l [static] Ecotoxicity - Water Flea Data Hr EC50 Daphnia magna: 216 mg/l Hr EC50 water flea: >100 mg/l Tetrasodium ethylenediamine tetraacetate Hr EC50 Daphnia magna: 610 mg/l Environmental effects Aquatic toxicity Persistence / degradability Bioaccumulation / accumulation Partition coefficient Mobility in environmental media Chemical fate information 13. Disposal Considerations Waste codes Disposal instructions Waste from residues / unused products Contaminated packaging IF EMPTY: Do not reuse this container. Place in trash or offer for recycling if available. Dispose in accordance with all applicable regulations. 14. Transport Information U.S. Department of Transportation (DOT) Not regulated as dangerous goods. 15. Regulatory Information US Federal regulations This product is a "Hazardous Chemical" as defined by the OSHA Hazard Communication Standard, 29 CFR EPA registration number All components are on the U.S. EPA TSCA Inventory List. CERCLA/SARA Hazardous Substances - Not applicable. Occupational Safety and Health Administration (OSHA) 29 CFR hazardous Yes chemical CERCLA (Superfund) reportable quantity None Superfund Amendments and Reauthorization Act of 1986 (SARA) Hazard categories Immediate Hazard - Yes Delayed Hazard - No Fire Hazard - No Pressure Hazard - No Reactivity Hazard - No Section 302 extremely No hazardous substance #18527 Page 5 of 6 Issue date 18-Sep-2008

6 Section 311 hazardous chemical Yes Clean Air Act (CAA) Clean Water Act (CWA) Safe Drinking Water Act (SDWA) Drug Enforcement Agency (DEA) Food and Drug Administration (FDA) State regulations This product does not contain a chemical known to the State of California to cause cancer, birth defects or other reproductive harm. Inventory status Country(s) or region Inventory name On inventory (yes/no)* United States & Puerto Rico Toxic Substances Control Act (TSCA) Inventory Yes A "Yes" indicates that all components of this product comply with the inventory requirements administered by the governing country(s) Disclaimer Issue date Effective date 16. Other Information Information contained herein was obtained from sources considered technically accurate and reliable. While every effort has been made to ensure full disclosure of product hazards, in some cases data is not available and is so stated. Since conditions of actual product use are beyond control of the supplier, it is assumed that users of this material have been fully trained according to the requirements of all applicable legislation and regulatory instruments. No warranty, expressed or implied, is made and supplier will not be liable for any losses, injuries or consequential damages which may result from the use of or reliance on any information contained in this document. 18-Sep Sep-2008 Prepared by Nu-Calgon Technical Service (314) #18527 Page 6 of 6 Issue date 18-Sep-2008