Shannonside Milk Products Limited

Transcription

1 IPPC APPLICATION General Information Dublin Road, Ballaghaderreen, Co Roscommon Appendix No B Version Block 2 Bruach Na habhainn, Quin Road, Ennis, Co Clare EPA Export :20:00:59

2 B1: Company Details Shannonside Milk Products was incorporated into the Connacht Gold Co-Op Society in Shannonside Milk Products Ltd is registered under the industrial and provident societies acts, 1893 to 1978 since the 1 st November The company s registration number is The Certificate of Incorporation for Shannonside, number has also been included. B1-1: Industrial & Provident Societies Act Registration Page 2 of 44 Version 1 EPA Export :20:00:59

3 B1-2: Certificate of Incorporation Page 3 of 44 Version 1 EPA Export :20:00:59

4 B2: Location Map with Grid Reference - Location Map and Site Notice Site Notice Located at Main Entrance Page 4 of 44 Version 1 EPA Export :20:01:00

5 Townland Location Map Ballaghaderreen Shannonside Milk Products Ltd Page 5 of 44 Version 1 EPA Export :20:01:00

6 B5: All Planning Permissions/ Permits/ Licences B5-1 Summary of Planning Permissions Date Reference Description Granted a Initial Development of Installation Yes b Erection of Offices Yes d Erect Clad Steel Building at Milk Spray Drier Yes e Powder Store Yes f Installation of Oil Storage Tank Yes g Erect Effluent Treatment Plant Yes h Erect 150,000 gallon storage tank for fuel oil Yes i Extension to existing drier Yes k Erection of Laboratory building Yes l Second Extension to Drier Room Yes m Loading Bay for Powder Dispatch Yes n Extension to Separator Station Yes o Erect 200,000 gallon Oil Storage Tank Yes p Elevate Existing Evaporator Building Yes q Installation of Heat Exchanger Yes r Tanker Washing Bay Yes s New Boiler House Yes t Erect new Fences Along Boundary Yes u/82 Install New Drier Yes v/83 Extension of Effluent Treatment Plant Yes w/87 Extension to Existing Offices and Lab Yes x/88 Extension of LPG Storage Tank Yes /487 Extension to Treatment Plant Yes / Installation of New Drier Yes Page 6 of 44 Version 1 EPA Export :20:01:00

7 B5-2: Permits Held By : Greenhouse Gas Emissions Permit No: GHG This permit is may be downloaded directly and free from the EPA website. A copy has been attached below: Page 7 of 44 Version 1 EPA Export :20:01:00

8 Page 8 of 44 Version 1 EPA Export :20:01:00

9 Page 9 of 44 Version 1 EPA Export :20:01:00

10 Page 10 of 44 Version 1 EPA Export :20:01:00

11 Page 11 of 44 Version 1 EPA Export :20:01:00

12 Page 12 of 44 Version 1 EPA Export :20:01:00

13 Page 13 of 44 Version 1 EPA Export :20:01:00

14 Page 14 of 44 Version 1 EPA Export :20:01:00

15 Page 15 of 44 Version 1 EPA Export :20:01:01

16 Page 16 of 44 Version 1 EPA Export :20:01:01

17 Page 17 of 44 Version 1 EPA Export :20:01:01

18 Discharge Licence: WP-1-6A This licence was issued by Roscommon Co Co on 19 th March 1999 for the treatment of effluent prior to discharge to the River Lung. A copy of the licence is attached to this section of the licence application. Page 18 of 44 Version 1 EPA Export :20:01:01

19 Page 19 of 44 Version 1 EPA Export :20:01:01

20 Page 20 of 44 Version 1 EPA Export :20:01:01

21 Page 21 of 44 Version 1 EPA Export :20:01:01

22 Page 22 of 44 Version 1 EPA Export :20:01:01

23 Page 23 of 44 Version 1 EPA Export :20:01:02

24 Page 24 of 44 Version 1 EPA Export :20:01:02

25 Page 25 of 44 Version 1 EPA Export :20:01:02

26 Page 26 of 44 Version 1 EPA Export :20:01:02

27 Page 27 of 44 Version 1 EPA Export :20:01:02

28 Page 28 of 44 Version 1 EPA Export :20:01:02

29 Page 29 of 44 Version 1 EPA Export :20:01:02

30 Radiological Protection Institute of Ireland Licence: This licence was issued by the RPII for the practices of Custody/ Use of the radioactive substance Caesium 137. The material was used in a piece of equipment in the evaporator room for density gauging. Page 30 of 44 Version 1 EPA Export :20:01:02

31 Page 31 of 44 Version 1 EPA Export :20:01:02

32 Page 32 of 44 Version 1 EPA Export :20:01:02

33 Page 33 of 44 Version 1 EPA Export :20:01:02

34 Page 34 of 44 Version 1 EPA Export :20:01:02

35 Page 35 of 44 Version 1 EPA Export :20:01:02

36 Page 36 of 44 Version 1 EPA Export :20:01:03

37 Page 37 of 44 Version 1 EPA Export :20:01:03

38 Page 38 of 44 Version 1 EPA Export :20:01:03

39 Page 39 of 44 Version 1 EPA Export :20:01:03

40 Page 40 of 44 Version 1 EPA Export :20:01:03

41 B8: Site Notice and Location Map The site notice has been compiled to conform to the requirements of Article 7 of SI No 85 of The site notice has been located as per map in section B2. B8-1: Site Notice. APPLICATION TO THE ENVIRONMENTAL PROTECTION AGENCY FOR AN IPPC LICENCE Shannonside Milk Products Ltd, Dublin Road, Ballaghaderreen, Co Roscommon intend to apply to the EPA for an IPPC licence. Information will be submitted to the agency under the requirements of Class for the treatment and processing of milk, the quantity of milk received being greater than 200 tonnes per day (average value on a yearly basis). The location of the activity is as addressed above. A copy of the licence application and adjoining supplementary information relating to the installation may be inspected at or obtained from the headquarters of the Agency, (Johnstown Castle, Wexford Tel ) as soon as is practicable after the receipt by the Agency. Page 41 of 44 Version 1 EPA Export :20:01:03

42 B8-2: Letter to Roscommon Co Co Roscommon Co Co, Planning and Development, County Offices, Courthouse, Roscommon. 16 th August 2006, Dear Sir/ Madam, RE: Notice of Intention to Apply to the EPA for an IPPC Licence Shannonside Milk Products Ltd, Dublin Road, Ballaghaderreen, Co Roscommon intend to apply to the EPA for an IPPC licence. Information will be submitted to the agency under the requirements of Class for the treatment and processing of milk, the quantity of milk received being greater than 200 tonnes per day (average value on a yearly basis). The location of the activity is as addressed above. A copy of the licence application and adjoining supplementary information relating to the installation may be inspected at or obtained from the headquarters of the Agency, (Johnstown Castle, Wexford Tel ) as soon as is practicable after the receipt by the Agency. If you have any queries, please do not hesitate to contact me. Yours Sincerely, William Murphy Shannonside Milk Products Ltd Page 42 of 44 Version 1 EPA Export :20:01:03

43 B8-3: Newspaper Advert: Page 43 of 44 Version 1 EPA Export :20:01:03

44 EPA Export :20:01:03

45 B9: Seveso II Regulations does not have the dangerous substances or carcinogens listed in Part 1 or Part 2 in sufficient quantities to be covered under the regulations. B10: IPPC Directive Annex 1 Shannonside Milk Products Ltd is covered in the Directive 96/61/EEC Annex 1 under paragraph 6 (Other Activities), section 6.4 C - Treatment and processing of milk, the quantity of milk received being greater than 200 tonnes per day (average value on an annual basis). Page 44 of 44 Version 1 EPA Export :20:01:03