DIESEL EXHAUST FLUID (DEF) Relevant identified uses of the substance or mixture and uses advised against

Transcription

1 Safety Data Sheet Section 1: Identification Product identifier Product Name Synonyms AB; AB; AB Relevant identified uses of the substance or mixture and uses advised against Recommended use Restrictions on use No information available No information available Details of the supplier of the safety data sheet Manufacturer Mopar (FCA US LLC Service & Customer Care Division) Lawrence Ave. Center Line, MI United States Telephone (General) Mopar Emergency telephone number Manufacturer Section 2: Hazard Identification United States (US) According to: OSHA 29 CFR HCS Classification of the substance or mixture Label elements Product is not hazardous HCS 2012 Other CARCINOGENICITY: Not listed by OSHA, IARC, OR NTP Information Other hazards Other information Page 1 of 7

2 HMIS Health = 1; Flammability = 0; Reactivity = 0 Section 3 - Composition/Information on Ingredients Substances Mixtures Chemical Name Water Urea Composition Identifiers % Classifications According to LD50/LC50 Regulation/Directive Comments CAS: EC Number: % : NDA EINECS: CAS: EINECS: % : Urea - OSHA PEL : 10 mg/m³ (8 hour TWA) Section 4: First-Aid Measures Description of first aid measures Inhalation Remove to fresh air. Skin Eye Ingestion Wash skin thoroughly with plenty of soap and water. Remove any contaminated clothes and wash before reuse. Get medical attention if irritation occurs. Flush eyes with running water for at least 15 minutes. If contact lenses are present remove them if possible and easy to do, continue rinsing. Get medical attention if irritation occurs. Wash out mouth with water. Do not induce vomiting unless directed to do so by medical personnel. Never give anything by mouth to an unconscious person. Get medical attention immediately. Most important symptoms and effects, both acute and delayed Indication of any immediate medical attention and special treatment needed Other information Section 5: Fire-Fighting Measures Extinguishing media Suitable Extinguishing Media Use an extinguishing agent suitable for the surrounding fire. Unsuitable Extinguishing Media Special hazards arising from the substance or mixture Unusual Fire and Explosion Hazards Hazardous Combustion Products In a fire or if heated, a pressure increase will occur and the container may burst. Page 2 of 7

3 Advice for firefighters Section 6 - Accidental Release Measures Personal precautions, protective equipment and emergency procedures Personal Precautions Emergency Procedures Environmental precautions Keep unnecessary and unprotected personnel from entering. Wear respiratory protection if odor is overwhelming. Methods and material for containment and cleaning up Containment/Clean-up Measures Section 7 - Handling and Storage Precautions for safe handling Handling Use an absorbant material to dry the spill, collect and dispose in accordance with all local, state, national and international regulations. Recommend the use of nitrile gloves and safety glasses when handling to reduce risk of any possible chemical irritation. Conditions for safe storage, including any incompatibilities Storage Do not store near Hypochlorite Solutions. Section 8 - Exposure Controls/Personal Protection Control parameters Exposure controls Engineering No special ventilation requirements. Good general ventilation should be sufficient to Measures/Controls control worker exposure. Personal Protective Equipment Pictograms Respiratory Eye/Face Hands Skin/Body Environmental Exposure Controls Not generally needed unless exposure limits are exceeded. If exceeded, use a properly fitted, air-purifying or air-fed respirator. Chemical splash goggles when transferring is taking place. Nitrile gloves are recommended. CLOTHING AND FOOTWEAR: Not generally needed. Section 9 - Physical and Chemical Properties Information on Physical and Chemical Properties Page 3 of 7

4 Material Description Physical Form Liquid Fluid Appearance/Description Colorless liquid. Color No data available Odor slight ammonia. Taste No data available Particulate Type No data available Particulate Size No data available Aerosol Type No data available Odor Threshold No data available Physical and Chemical Properties No data available General Properties Boiling Point 212 F(100 C) Melting Point/Freezing Point 32 F(0 C) Decomposition Temperature No data available Heat of Decomposition No data available ph 9.8 to 10 Specific Gravity/Relative Density = 1.09 Water=1 Density No data available Bulk Density No data available Water Solubility Solvent Solubility No data available Viscosity No data available Explosive Properties No data available Oxidizing Properties: No data available Volatility Vapor Pressure Vapor Density Evaporation Rate VOC (Wt.) 0 % VOC (Vol.) No data available Volatiles (Wt.) No data available Volatiles (Vol.) No data available Flammability Flash Point No data available UEL No data available LEL No data available Autoignition No data available Self-Accelerating Decomposition Temperature (SADT) No data available Heat of Combustion (ΔHc) No data available Burning Time No data available Flame Height No data available Flame Extension No data available Ignition Distance No data available Flame Duration No data available Flammability (solid, gas) No data available Environmental Half-Life No data available Octanol/Water Partition coefficient No data available Coefficient of water/oil distribution No data available Bioaccumulation Factor No data available Bioconcentration Factor No data available Biochemical Oxygen Demand BOD/BOD5 No data available Chemical Oxygen Demand No data available Persistence No data available Degradation No data available Other Information Freezing point: 32 F Section 10: Stability and Reactivity Reactivity Chemical stability The product is stable. Possibility of hazardous reactions Page 4 of 7

5 Conditions to avoid Incompatible materials HAZARDOUS POLYMERIZATION: Will not occur under normal conditions of storage and use. Extremely reactive or incompatible with the following materials: Hypochlorite Solutions. Hazardous decomposition products Should not be produced under normal conditions. Section 11 - Toxicological Information Information on toxicological effects Components Urea (32.7%) Acute Toxicity: Unreported Route-Mouse LD mg/kg; Unreported Route-Rat LD mg/kg GHS Properties Acute toxicity Skin corrosion/irritation Serious eye damage/irritation Skin sensitization Respiratory sensitization Aspiration Hazard Carcinogenicity Germ Cell Mutagenicity Toxicity for Reproduction STOT-SE STOT-RE Potential Health Effects Inhalation Skin Eye Ingestion Classification Data lacking Data lacking Data lacking Data lacking Data lacking Data lacking Data lacking Data lacking Data lacking Data lacking Data lacking Page 5 of 7

6 Section 12 - Ecological Information Toxicity CAS NDA Aquatic Toxicity-Fish: 24 Hour(s) EC50 Daphnia magna straus >10000 mg/l Persistence and degradability Bioaccumulative potential Mobility in Soil Other adverse effects Other Information Section 13 - Disposal Considerations Urea: Ecotoxicity - Freshwater Fish Species Data Ecotoxicity - Microtox Data. Waste treatment methods Product waste Dispose of material in accordance with all local, state, federal and international Packaging waste Section 14 - Transport Information regulations. UN number UN proper shipping name Transport hazard class (es) Packing group Environmental hazards DOT NDA NDA NDA NDA NDA TDG NDA NDA NDA NDA NDA IMO/IMDG NDA NDA NDA NDA NDA ADN NDA NDA NDA NDA NDA ADR/RID NDA NDA NDA NDA NDA IATA/ICAO NDA NDA NDA NDA NDA Special precautions for user Transport in bulk according to Annex II of MARPOL 73/78 and the IBC Code Other information NOT REGULATED Section 15 - Regulatory Information Safety, health and environmental regulations/legislation specific for the substance or mixture SARA Hazard Classifications SARA 302 COMPONENTS:none, SARA 311/312: Immediate ( ) Delayed ( ) Fire ( ) Page 6 of 7

7 Reactive ( ) Sudden release of Pressure ( ), SARA 313 COMPONENTS: None Inventory Component CAS Canada DSL EU EINECS TSCA Urea Yes Yes Yes Water Yes Yes Yes Canada Labor Canada - WHMIS - Classifications of Substances Water Urea Uncontrolled product according to WHMIS classification criteria Uncontrolled product according to WHMIS classification criteria Other Information OSHA HAZARDOUS CHEMICAL: NO Section 16 - Other Information Revision Date Last Revision Date Preparation Date Disclaimer/Statement of Liability Page 7 of 7