Issue Date: 17-Sep-2014 Revision Date: 27-Oct-2014 Version 1 1. IDENTIFICATION. SmartWash SmartBrite 2. HAZARDS IDENTIFICATION

Transcription

1 Safety Data Sheet Issue Date: 17-Sep-2014 Version 1 1. IDENTIFICATION Product Identifier Product Name Other means of identification SDS # SmartWash SmartBrite WS-058 Recommended use of the chemical and restrictions on use Recommended Use Cleaning agent. Details of the supplier of the safety data sheet Supplier Address Whiting Systems, Inc Highway 5 North Alexander, AR Emergency Telephone Number Company Phone Number Emergency Telephone (24 hr) INFOTRAC (International) (North America) 2. HAZARDS IDENTIFICATION EMERGENCY OVERVIEW: The product contains no substances which, at their given concentration, are considered to be hazardous to health. Appearance Clear green Physical State Liquid Odor No detectable odor Classification This chemical does not meet the hazardous criteria set forth by the 2012 OSHA Hazard Communication Standard (29 CFR ). However, this Safety Data Sheet (SDS) contains valuable information critical to the safe handling and proper use of this product. This SDS should be retained and available for employees and other users of this product. Unknown Acute Toxicity 5% of the mixture consists of ingredient(s) of unknown toxicity 3. COMPOSITION/INFORMATION ON INGREDIENTS Chemical Name CAS No Weight-% Diethylene Glycol Monobutyl Ether Organic acid salt Proprietary 1-10 **If Chemical Name/CAS No is "proprietary" and/or Weight-% is listed as a range, the specific chemical identity and/or percentage of composition has been withheld as a trade secret.** Page 1 / 7

2 4. FIRST-AID MEASURES First Aid Measures Eye Contact Skin Contact Inhalation Ingestion Immediately flush with plenty of water. After initial flushing, remove any contact lenses and continue flushing for at least 15 minutes. If eye irritation persists: Get medical advice/attention. Wash with soap and water. Take off contaminated clothing. Wash contaminated clothing before reuse. If skin irritation persists, call a physician. Remove to fresh air. If breathing is difficult, give oxygen. Call a physician immediately. Rinse mouth. Do not induce vomiting without medical advice. Never give anything by mouth to an unconscious person. Call a physician or poison control center immediately. Most important symptoms and effects Symptoms Exposed individuals may experience eye tearing, redness, and discomfort. Contact may cause irritation and redness. Will cause gastrointestinal tract irritation. Indication of any immediate medical attention and special treatment needed Notes to Physician Treat symptomatically. 5. FIRE-FIGHTING MEASURES Suitable Extinguishing Media Carbon dioxide (CO2). Water. Water spray (fog). Dry chemical. Chemical foam. Unsuitable Extinguishing Media. Specific Hazards Arising from the Chemical None known. Hazardous Combustion Products Carbon oxides. Protective equipment and precautions for firefighters As in any fire, wear self-contained breathing apparatus pressure-demand, MSHA/NIOSH (approved or equivalent) and full protective gear. 6. ACCIDENTAL RELEASE MEASURES Personal precautions, protective equipment and emergency procedures Personal Precautions Environmental Precautions Use personal protective equipment as required. Ventilate affected area. See Section 12 for additional Ecological Information. Methods and material for containment and cleaning up Methods for Containment Methods for Clean-Up Prevent further leakage or spillage if safe to do so. Soak up and contain spill with an absorbent material. Sweep up and shovel into suitable containers for disposal. Discard any product, residue, disposable container or liner in full compliance with federal, state, and local regulations. Page 2 / 7

3 7. HANDLING AND STORAGE Precautions for safe handling Advice on Safe Handling Handle in accordance with good industrial hygiene and safety practice. Wash thoroughly after handling. Use personal protection recommended in Section 8. Protect container from physical damage. Emptied container retains product residue. Observe all labeled safeguards until container is cleaned, reconditioned or destroyed. Do not breathe vapors or spray mist. Conditions for safe storage, including any incompatibilities Storage Conditions Incompatible Materials Keep containers tightly closed in a dry, cool and well-ventilated place. Keep out of the reach of children. Strong oxidizing agents. 8. EXPOSURE CONTROLS/PERSONAL PROTECTION Exposure Guidelines No exposure limits noted for ingredient(s) The following information is given as general guidance Appropriate engineering controls Engineering Controls Maintain eye wash fountain and quick-drench facilities in work area. Individual protection measures, such as personal protective equipment Eye/Face Protection Skin and Body Protection Respiratory Protection Wear approved safety goggles. Neoprene, butyl or nitrile rubber gloves with cuffs. Wear impervious protective clothing, including boots, gloves, lab coat, apron or coveralls, as appropriate, to prevent skin contact. Wear an appropriate NIOSH/MSHA approved respirator if ventilation is inadequate. General Hygiene Considerations Handle in accordance with good industrial hygiene and safety practice. Information on basic physical and chemical properties 9. PHYSICAL AND CHEMICAL PROPERTIES Physical State Liquid Appearance Clear green Odor No detectable odor Color Green Odor Threshold Property Values Remarks Method ph Melting Point/Freezing Point Boiling Point/Boiling Range 100 C / 212 F Flash Point Non-flammable Evaporation Rate Flammability (Solid, Gas) n/a-liquid Upper Flammability Limits Not applicable Lower Flammability Limit Not applicable Vapor Pressure Vapor Density Specific Gravity Water Solubility Completely soluble Page 3 / 7

4 Solubility in other solvents Partition Coefficient Auto-ignition Temperature Decomposition Temperature Kinematic Viscosity Dynamic Viscosity Explosive Properties Oxidizing Properties Reactivity Not reactive under normal conditions. Chemical Stability Stable under recommended storage conditions. Possibility of Hazardous Reactions None under normal processing. 10. STABILITY AND REACTIVITY Hazardous Polymerization Hazardous polymerization does not occur. Conditions to Avoid Avoid all possible sources of ignition. Incompatible Materials. Incompatible Materials Strong oxidizing agents. Hazardous Decomposition Products Carbon monoxide. Carbon dioxide (CO2). Information on likely routes of exposure Product Information 11. TOXICOLOGICAL INFORMATION Eye Contact Skin Contact Inhalation Ingestion May cause temporary irritation on eye contact. Prolonged contact may cause redness and irritation. Avoid breathing vapors or mists. Do not taste or swallow. Component Information Chemical Name Oral LD50 Dermal LD50 Inhalation LC50 Diethylene Glycol Monobutyl Ether = 3384 mg/kg ( Rat ) = 2700 mg/kg ( Rabbit ) Organic acid salt = 1500 mg/kg ( Rat ) - - Information on physical, chemical and toxicological effects Symptoms Please see section 4 of this SDS for symptoms. Page 4 / 7

5 Delayed and immediate effects as well as chronic effects from short and long-term exposure Carcinogenicity This product does not contain any carcinogens or potential carcinogens as listed by OSHA, IARC or NTP. Numerical measures of toxicity Unknown Acute Toxicity 5% of the mixture consists of ingredient(s) of unknown toxicity. 12. ECOLOGICAL INFORMATION Ecotoxicity An environmental hazard cannot be excluded in the event of unprofessional handling or disposal. Component Information Chemical Name Algae/aquatic plants Fish Toxicity to microorganisms Diethylene Glycol Monobutyl 100: 96 h Desmodesmus 1300: 96 h Lepomis Ether subspicatus mg/l EC50 macrochirus mg/l LC static Organic acid salt : 96 h Brachydanio rerio mg/l LC50 static Crustacea 2850: 24 h Daphnia magna mg/l EC50 100: 48 h Daphnia magna mg/l EC50 Persistence/Degradability. Bioaccumulation. Mobility Other Adverse Effects 13. DISPOSAL CONSIDERATIONS Waste Treatment Methods Disposal of Wastes Contaminated Packaging Disposal should be in accordance with applicable regional, national and local laws and regulations. Disposal should be in accordance with applicable regional, national and local laws and regulations. 14. TRANSPORT INFORMATION Note DOT IATA Please see current shipping paper for most up to date shipping information, including exemptions and special circumstances. Not regulated Not regulated IMDG Not regulated Page 5 / 7

6 15. REGULATORY INFORMATION International Inventories Chemical Name TSCA DSL NDSL EINECS ELINCS ENCS IECSC KECL PICCS AICS Diethylene Glycol Monobutyl Present X Present Present X Present X X Ether Organic acid salt Present X Present Present X Present X X Legend: TSCA - United States Toxic Substances Control Act Section 8(b) Inventory DSL/NDSL - Canadian Domestic Substances List/Non-Domestic Substances List EINECS/ELINCS - European Inventory of Existing Chemical Substances/European List of Notified Chemical Substances ENCS - Japan Existing and New Chemical Substances IECSC - China Inventory of Existing Chemical Substances KECL - Korean Existing and Evaluated Chemical Substances PICCS - Philippines Inventory of Chemicals and Chemical Substances AICS - Australian Inventory of Chemical Substances US Federal Regulations CERCLA This material, as supplied, does not contain any substances regulated as hazardous substances under the Comprehensive Environmental Response Compensation and Liability Act (CERCLA) (40 CFR 302) or the Superfund Amendments and Reauthorization Act (SARA) (40 CFR 355). SARA 313 Section 313 of Title III of the Superfund Amendments and Reauthorization Act of 1986 (SARA). This product contains a chemical or chemicals which are subject to the reporting requirements of the Act and Title 40 of the Code of Federal Regulations, Part 372 Chemical Name CAS No Weight-% SARA Threshold Values % Diethylene Glycol Monobutyl Ether CWA (Clean Water Act) This product does not contain any substances regulated as pollutants pursuant to the Clean Water Act (40 CFR and 40 CFR ) US State Regulations U.S. State Right-to-Know Regulations Chemical Name New Jersey Massachusetts Pennsylvania Diethylene Glycol Monobutyl Ether X X Organic acid salt X Page 6 / 7

7 16. OTHER INFORMATION NFPA HMIS Health Hazards Health Hazards 2 Flammability Flammability Instability Physical Hazards 0 Special Hazards Personal Protection Issue Date: Revision Date: Revision Note: 17-Sep Oct-2014 New format Disclaimer The information provided in this Safety Data Sheet is correct to the best of our knowledge, information and belief at the date of its publication. The information given is designed only as a guidance for safe handling, use, processing, storage, transportation, disposal and release and is not to be considered a warranty or quality specification. The information relates only to the specific material designated and may not be valid for such material used in combination with any other materials or in any process, unless specified in the text. End of Safety Data Sheet Page 7 / 7