Application of Organic Rankine Cycle technology in Biomass plants 1-5 MW. Eytan kaplan PowerGen Africa July 2015
|
|
- Jennifer Morgan
- 6 years ago
- Views:
Transcription
1 Application of Organic Rankine Cycle technology in Biomass plants 1-5 MW Eytan kaplan PowerGen Africa July 2015
2 INDEX SUMMARY The different ways to use Biomass for Power Comparison between Steam and ORC biomass systems The ORC Biomass solution Biomass power plant Biomass Potential in Africa Case studies About EXERGY & Other uses of ORC Geothermal Heat Recovery (engines / process) CSP
3 BIOMASS INTRODUCTION: the different ways to use Biomass for Power
4 ALTERNATIVE TECHNOLOGIES: 1) EFGT (External Fired Gas Turbine): High system efficiency No flexible feed: need to have a very clean biomass due to the problems on the heat exchanger Critical component: high temperature air/flue gas heat exchanger 2) Gassification (pyrolysis): High system efficiency No flexible feed: need to have a very high selected and pure biomass High cost of maintenance
5 ALTERNATIVE TECHNOLOGIES: 3) Screw/scroll steam expander: Low system efficiency No proven system reliability Lower flexibility at partial load due to the technology All these technologies have common issues: Low number proven commercial installations Poor reliability and availability results in operation No demonstration of the expected efficiency
6 PROVEN SOLUTIONS FOR BIOMASS 1) Biomass boiler and Steam Turbine: Efficient Proven 2) Biomass boiler and Organic Rankine Cycle System Efficient Proven Flexible
7 ORC vs. STEAM TECHNOLOGY - COMPARISON
8 ORC vs. STEAM TECHNOLOGY: OPTIMAL TEMPERATURE RANGE
9 BIOMASS POWER PLANTS: ORC SOLUTION Exergy solution for power generation from biomass is: ORC module + biomass boiler This solution has many advantages: Good compromise between investment cost and efficiency High reliability thanks to proven technology High flexibility in biomass feed quality High modularity and simple installation Few civil works required
10 ORC BIOMASS PLANTS Details
11 ORC BIOMASS SOLUTION System description: The boiler through the combustion process converts the biomass in thermal power to feed the ORC module. The hot exhaust gas warms up the intermediate fluid in a heat exchanger ORC/boiler interface circuit transfers the thermal power from the boiler to the ORC evaporator Usually the intermediate fluid between boiler and ORC are: thermal oil pressurized water steam EXERGY developed solutions with either thermal oil or saturated steam for different applications
12 ORC BIOMASS SOLUTION System description: The interface fluid transfers heat to the organic fluid in the ORC evaporator, where the organic fluid vaporizes The ORC module produces : Electrical power: expanding the vapor in the turbine Thermal power: discharging the medium temperature heat contained in the vapor at turbine outlet Thermal power can be utilized for cogeneration purposes: Cogeneration for industrial processes District or residential heating Trigeneration (production of warm and cold streams for heating and cooling purposes)
13 BIOMASS FEED The biomass feed of the boiler can be very flexible Saw dust maximum 50% in volume per unit of charge Wood chips P100 Ground wood P300 with max section 50x50 mm Bark max dimensions 300x10x20mm Wood industry waste Forestry waste Coal maximum section 30x30 mm Olive waste and other secondary biomass* * It may be necessary to mix it with wood chips to stabilise the feed
14 PROCESS FLOW DIAGRAM
15 TYPICAL PLANT LAYOUT SMALL SIZE ( kwe)
16 TYPICAL PLANT LAYOUT MEDIUM SIZE (1-3 MWe)
17 ORC PACKAGE Recuperator
18 BIOMASS PLANTS: TYPICAL SOLUTIONS PLANT 1 MWe OIL 2 MWe OIL 4 MWe OIL Thermal oil /steam inlet temperature C Thermal oil outlet temperature C Cogeneration water temperature C Gross Power kwe Average number of houses supplied n Gross efficiency (with/w.out cogeneration) % 19/24 20/25 20/25 Biomass consumption (PCI = 2400 kcal/kg) ton/year 17000/ / /54000
19 Biomass potential in Africa
20 BIOMASS IN AFRICA BIOMASS IN AFRICA Largest populations in sub-saharan Africa relying on traditional biomass for cooking, 2012 Based on International Energy Agency (IEA) data
21 BIOMASS IN AFRICA BIOMASS IN AFRICA Reliance on fuelwood and charcoal remains high, even as incomes grow; 650 million people still cook with biomass in an inefficient & hazardous way in 2040 Based on International Energy Agency (IEA) data
22 BIOMASS CASE STUDIES
23 BIOMASS CASE STUDIES Plant Type: Model: Client: Location: Biomass EP 110 ERS 1MWe Energia Vulture Alto Bradano Venosa, Italy
24 BIOMASS CASE STUDIES REQUIREMENT OF THE CLIENT 1. Dispose of waste from grape and olive production and waste from local wood processing industry 2. Developing a secondary revenue stream by selling electricity back top the grid QUANTITY OF BIOMASS 16000t/y ELECTRICAL EFFICIENCY OF THE ORC 24% ELECTRICAL GENERATION GROSS 990 KWE THERMAL MEDIUM THERMAL OIL C WATER COOLING AGENT DIRECT AIR COOLING GENERATION VOLTAGE 400 V INSTALLATION OUTDOOR
25 BIOMASS CASE STUDIES Plant Type: Biomass Model: HREX 110 Client: Del Tongo Location: Arezzo, Italy
26 BIOMASS REFERENCES CASE STUDIES HEAT RECOVERY FROM BIOGAS ENGINES Plant Type: Model: Power: Client: Location: HR BIOGAS EP10 POWERBOX 100 kwe Marsica Bioenergie Celano, Italy
27 ABOUT EXERGY
28 ABOUT EXERGY & OTHER USES of ORC: EXERGY designs, manufactures, supplies and operates Organic Rankine Cycle (ORC) systems for: GEOTHERMAL WASTE HEAT RECOVERY (FACTORIES/ ENGINES) BIOMASS SOLAR (CSP) EXERGY are unique in having the extremely efficient organic Radial Outflow Turbine.
29 EXERGY is the pioneer of ORC Radial Outflow technology. EXERGY undertake: Development and manufacturing of the ORC turbine and plant internally Testing Engineering Project management After Sales service Size range: between MW on a single turbine EXERGY is a subsidiary of the SECI Maccaferri Industrial Group within the SECI S.p.A holding. Offices Across the globe and AFRICA Employees
30 Designed and patented by EXERGY, the Radial Outflow Turbine is unique in the ORC marketplace. The idea was first conceptualized by EXERGY CEO Claudio Spadacini. The Radial Outflow Turbine is capable of converting the energy that is contained in the fluid with higher efficiency than competing technologies on the market.
31 REFERENCES REFERENCES HR FROM STEEL MILL: Plant Type: HR steel Model: EPSd 110 Power: 1000 kwe Client: ABS - Danieli Location: Udine, Italy
32 REFERENCES REFERENCES GEOTHERMAL : Plant Type: Geothermal Model: GEX 110 Client: Enel Green power Location: Bagnore, Italy
33 REFERENCES REFERENCES GEOTHERMAL : Plant Type: Geothermal Model: GEX 2300 Power: 22.5 MWe Client: Celikler Hodling Location: Pamukoren, Turkey
34 EXERGY S.p.A T: F: E: W: Head Office: via Santa Rita Olgiate Olona (VA) Italy Legal Office: Via degli Agresti, Boliogna (BO) Italy
GREEN POWER THROUGH INNOVATION
GREEN POWER THROUGH INNOVATION From an idea of EXERGY EXERGY become part of EXERGY install the Pamukören 1 and EXERGY experience In June the Denizli EXERGY start up their 01 02 04 CEO Claudio Spadacini,
More informationRADIAL OUTF LOW TURBIN E TECHN OLOGY IN ORC AP P LICATION F OR CO- P RODUCED WATER AN D OIL & GAS AP P LICATION
RADIAL OUTF LOW TURBIN E TECHN OLOGY IN ORC AP P LICATION F OR CO- P RODUCED WATER AN D OIL & GAS AP P LICATION 1 EXERGY AND THE RADIAL OUTFLOW TURBINE EXERGY designs, manufactures, and supplies Organic
More informationHeat recovery from industrial installations
Environmentally friendly For high temperature applications, AQYLON s organic working fluids have a very low Global Warming Potential (320). Rugged AQYLON s ORC modules are designed for durability and fit
More informationHeat recovery from diesel engines and gas turbines
Environmentally friendly Rugged Efficient For high temperature applications, AQYLON s organic working fluids have a very low Global Warming Potential (GWP 320). AQYLON s ORC modules are designed for durability
More informationHeat recovery from diesel engines and gas turbines
Environmentally friendly AQYLON s organic working fluids have a very low Global Warming Potential (320). Refrigerant fluids can be used but their GWP range between 800 to 1000. Rugged AQYLON s ORC modules
More informationORGANIC RANKINE CYCLE TECHNOLOGY PRODUCTS AND APPLICATIONS APRIL 2013 EAR 99 - NLR
ORGANIC RANKINE CYCLE TECHNOLOGY PRODUCTS AND APPLICATIONS APRIL 2013 UNITED TECHNOLOGIES CORP. Hamilton Sundstrand Pratt & Whitney Sikorsky Otis UTC Fire & Security UTC Power Carrier 2 TURBODEN OVERVIEW
More informationHeat recovery from diesel engines and gas turbines
Environmentally friendly For high temperature applications, AQYLON s organic working fluids have a very low Global Warming Potential (3-20). Rugged AQYLON s ORC modules are designed for durability and
More informationSTEAM & POWER THE NEW TURBODEN SOLUTION FOR POWER AND STEAM PRODUCITION FROM BIOMASS. SIMONE PASSERA Sales Manager & Business Development
STEAM & POWER THE NEW TURBODEN SOLUTION FOR POWER AND STEAM PRODUCITION FROM BIOMASS SIMONE PASSERA Sales Manager & Business Development Kyiv, September 25th -26th 2018 MILESTONES 2 GLOBAL AND PROVEN EXPERIENCE
More informationExperience and progress with ORC turbogenerators in Australia including the new kw e units
Experience and progress with ORC turbogenerators in Australia including the new 200-300 kw e units Carlo Minini 10 th Bioenergy Business Breakfast Doc.: 14-4-356-rev.0 Date: 23/05/2014 About Us Turboden
More informationGenerate Green Power. using ORC technology
Organic Rankine Cycle Technology Generate Green Power from agricultural waste biomass using ORC technology Antonio MENDES NAZARE Organic Rankine Cycle Technology 2 Summary Executive Summary 1) Current
More informationOrganic Rankine Cycle Technology
Power Systems Pratt & Whitney Power Systems Organic Rankine Cycle Technology TM It s in our power. Pratt & Whitney Organic Rankine Cycle Technology Quality High-volume components produced to strict tolerances
More informationSmall Scale CHP Using the Organic Rankine Cycle
Small Scale CHP Using the Organic Rankine Cycle Case Studies from Europe Ilaria Peretti Manager, Sales and Business Development for North America Denver - February 11 th, 2015 Biomass Fuels & Applications
More informationORC technology and its applications to the RE sector
ORC technology and its applications to the RE sector Marrakesk, November 15 th 2016 Cem Zulfikar Business Developer ORC: 130 Years of History The first ORC, featuring a reciprocating expander, fed by a
More informationA NEW CONFIGURATION FOR ORGANIC RANKINE CYCLE POWER SYSTEMS
A NEW CONFIGURATION FOR ORGANIC RANKINE CYCLE POWER SYSTEMS Authors: Claudio Spadacini, Lorenzo Centemeri, Luca G. Xodo, Marco Astolfi, Matteo C. Romano, Ennio Macchi WHO EXERGY is a private-owned company:
More informationDANIELI S GREEN STEEL VISION: FIRST STEP TOWARDS ZERO ENERGY FTP AT ABS STEELMAKING PLANT (ITALY)*
DANIELI S GREEN STEEL VISION: FIRST STEP TOWARDS ZERO ENERGY FTP AT ABS STEELMAKING PLANT (ITALY)* Nicola Santangelo 1 Luciano Tomadin 2 Arrigo Bertolissio 3 Abstract The current economic crisis and growing
More informationThe answer is... yes!
The answer is... yes! TURN YOUR HEAT INTO ELECTRICITY NO FUEL, ZERO EMISSION Can plain machines save costs and energy at the same time as saving our beautiful planet? ENERGY CONCERN Today s society is
More informationTurboden ORC technology for the wood industry. 12 Wood technology Conference June , Opatija, Croatia
Turboden ORC technology for the wood industry 12 Wood technology Conference June 1-2 2015, Opatija, Croatia Doc.: 15-COM.P-12-rev.0 Update: 01/06/2015 Today s topics What the ORC is ORC reference plants
More informationDecentralized Biomass Power Production
Decentralized Biomass Power Production by Dr. Eric Bibeau University of Manitoba (Alternative Energy Research) Biomass Energy II Heat and Power Workshop November 13, 2003 Activity at U of M biomass alternative
More informationElectricity Generation from Waste Heat
Electricity Generation from Waste Heat Organic Rankine Cycle (ORC) Technology www.durr.com Make the most out of your waste your waste heat heat Organic Rankine Cycle (ORC) is a key technology used for
More information2016 BioCleantech Forum TURBODEN ORC TECHNOLOGY: STATE-OF-THE-ART. Ilaria Peretti. Manager, Sales and Business Development North America
2016 BioCleantech Forum TURBODEN ORC TECHNOLOGY: STATE-OF-THE-ART Ilaria Peretti Manager, Sales and Business Development North America Ottawa, November 3rd, 2016 Table of Contents Who is Turboden and What
More informationRoberto Bini Turboden srl Brescia I Fabio Viscuso Turboden srl Brescia -I. cod. 11-A-858-rev.0
High efficiency (25%) ORC for power only generation mode in the range 1-3 MW: an already proven technology also available for partially cogenerative applications Roberto Bini Turboden srl Brescia I Fabio
More informationBiomass CHP Systems using Organic Rankine Cycle from Europe to North America
Biomass CHP Systems using Organic Rankine Cycle from Europe to North America Ilaria Peretti Manager, Sales and Business Development for North America Minneapolis April 20 th, 2015 2 What we do: ORC turbogenerators
More informationAlex Alexandrovich, P.E.
Alex Alexandrovich, P.E. Free Energy Potential The Rankine Cycle Barriers to The Rankine Cycle The Organic Rankin Cycle (ORC) Applications Packaged System Approach The majority of the heat resulting from
More informationTermotecnica Pompe di Industriale. Gli atti dei convegni e più di contenuti su
Termotecnica Pompe di Industriale Calore Gli atti dei convegni e più di 7.500 contenuti su www.verticale.net Doc. 16-COM.P-4-rev.0 Update: 27.06.2016 INDEX STEAM & POWER ORC A Look to the Product COMPANY
More informationOP TIMIZED CYCLE AND TURBOMACHINERY CONFIGURATION FOR AN INTERCOOLED, RECOMP RESSED SCO2 CYCLE
OP TIMIZED CYCLE AND TURBOMACHINERY CONFIGURATION FOR AN INTERCOOLED, RECOMP RESSED SCO2 CYCLE C. Spadacini, E. Pesatori, L. Centemeri et al. - EXERGY spa, ITALY 1 OVERVIEW SCO2 POWER CYCLES ATTRACTIVENESS
More informationTurboden Biomass Solutions
Cod. doc.: 11-COM.P-1-rev.7 Update :16/05/2011 Turboden Biomass Solutions Fortune 50 corporation $52.9B in 2009 sales 180 countries 206,700 employees About us A Pratt & Whitney Power Systems Company UTC
More informationPower cycle development
Power cycle development Steam cycles dominant for >300 yrs, mostly Rankine Gas Brayton cycles catching up last 50 years Organic Rankine Cycles (ORC) relatively recent 2 Why a new power cycle? Steam Good
More informationTHERMAL POWER RANGE: 200 kwt kwt. ELECTRICAL POWER RANGE: 170 kwe kwe.
From 60 years, Uniconfort produces boilers which works with forest and woodworking industry waste, agricultural waste, food processing industry waste, dedicated tree and grass crops, cleaning urban landscaping.
More informationTRIOGEN SMALL SCALE SOLID BIOMASS FUELLED ORC PLANTS FOR COMBINED HEAT AND POWER. Jos van Buijtenen, Stefano Ganassin. ASME ORC 2015 Brussels
TRIOGEN Jos van Buijtenen, Stefano Ganassin ASME ORC 2015 Brussels SMALL SCALE SOLID BIOMASS FUELLED ORC PLANTS FOR COMBINED HEAT AND POWER Intro In recent years the urge for utilizing all forms of available
More informationGEOTHERMAL SMARTER BINARY SYSTEMS DELIVERED.
GEOTHERMAL SMARTER BINARY SYSTEMS DELIVERED. Turn geothermal source into useful power Heat from the ground can be used as an energy source and it can be found in many regions of the world, especially at
More informationWaste Heat Recovery using Organic Rankine Cycle turbines
Nicolas Bernier, 5ft June 2018 Waste Heat Recover using Organic Rankine Ccle turbines Industrial waste heat : the example of France (1) Heat balance, fuel furnace, permanent regime Fumes loss 25 to 60
More informationCOMBINED CYCLE OPPORTUNITIES FOR SMALL GAS TURBINES
19 TH SYMPOSIUM OF THE INDUSTRIAL APPLICATION OF GAS TURBINES COMMITTEE BANFF, ALBERTA, CANADA OCTOBER 17-19, 2011 11-IAGT-204 COMBINED CYCLE OPPORTUNITIES FOR SMALL GAS TURBINES Michael Lucente Found
More information1 st Renewable Energy Technologies, LP. Organic Rankine Cycle
11/18/2010 1 st Renewable Energy Technologies, LP 8147 Clear Shade Drive, Windber, PA 15963 Phone: (814) 467-0431 Fax: (814) 467-8675 Email: Sales@1stRET.com Web: www.1stret.com Organic Rankine Cycle The
More information3 core areas of expertise
3 core areas of expertise clarity through simplicity Skills and Qualifications Membership of Safe Contractor Scheme Qualified CDM Duty Holders Qualified CDM Coordinators Prince 2 Project Management Practitioners
More informationGensets and cogeneration
Gensets and cogeneration Combined heat and power applications from Alfa Laval The full benefits of energy efficiency Cogeneration or combined heat and power application is a very effective and efficient
More informationThe future of sco 2 POWER CYCLE TECHNOLOGY - EU Perspective
The future of sco 2 POWER CYCLE TECHNOLOGY - EU Perspective C l a u d i o S p a d a c i n i C E O E X E R G Y S P A 6 th I n t e r n a t i o n a l S u p e r c r i t i c a l C O 2 P o w e r C y c l e s
More informationBUILDINGS & OFFICE SPACES INDUSTRIAL SOLUTIONS. Combined production of Heat and Power. Waste Heat Recovery Bottoming Cycle
BUILDINGS & OFFICE SPACES Combined production of Heat and Power INDUSTRIAL SOLUTIONS Waste Heat Recovery Bottoming Cycle The ENEFCOGEN GREEN line of products is designed for applications of Combined Heat
More informationTurboden Biomass solutions. Doc.: 12-COM.P-18-rev.18
Turboden Biomass solutions Doc.: 12-COM.P-18-rev.18 Update: 02/08/2016 ORC Applications - Biomass Biomass Heat Recovery Waste to energy Geothermal Solar Thermal Power Biomass Cogeneration plants with Turboden
More informationThe OriGen. Clean, Renewable Power From Waste Heat. AERCO.com
The OriGen Clean, Renewable Power From Waste Heat AERCO.com Turning Waste Heat into Usable Power What is Energy Recovery? Energy recovery is the method of using the waste heat of one process as the input
More information30 Years of Organic Rankine Cycle Development
30 Years of Organic Rankine Cycle Development Author: Mario Gaia 1 Prof. Gianfranco Angelino, Politecnico di Milano during meeting for the Almeria Solar Platform, S.José, California 1978. - Started Research
More informationHeat and Power ORC Solutions
Heat and Power ORC Solutions ORC solutions to transform heat into green power www.aqylon.com AQYLON, a Global ORC Company State of the art ORC solutions AQYLON is a global leader in the design and manufacturing
More informationWASTE HEAT RECOVERY INCREASE YOUR ENERGY EFFICIENCY WITH ORC TECHNOLOGY.
WASTE HEAT RECOVERY INCREASE YOUR ENERGY EFFICIENCY WITH ORC TECHNOLOGY. They believe in us Turn waste heat into useful power Turboden Organic Rankine Cycle (ORC) units enable power production by converting
More informationField Performance Evaluation of the Largest Geothermal Organic Rankine Cycle Plant
Proceedings World Geothermal Congress 2015 Melbourne, Australia, 19-25 April 2015 Field Performance Evaluation of the Largest Geothermal Organic Rankine Cycle Plant Reza Agahi and Pall Valdimarsson 119
More informationPresentation of the GMK ECOCAL ORC-power plant located in Hennstedt / Germany. Power from Biomass. Case Study
Presentation of the GMK ECOCAL ORC-power plant located in Hennstedt / Germany Power from Biomass Case Study Content I Content 1 The Organic Rankine Cycle... 1 1.1 General description... 1 1.2 ECOCAL ORC-power
More informationenertime CLEAN ENERGY HARVESTING THE FRENCH CLEANTECH THAT TRANSFORMS HEAT INTO ELECTRICITY
enertime CLEAN ENERGY HARVESTING THE FRENCH CLEANTECH THAT TRANSFORMS HEAT INTO ELECTRICITY HEAT RECOVERY EXCHANGERS WASTE HEAT RECOVERY ENGINES & TURBINES INCINERATORS THERMAL LOOP 600 to 40 000 kwth
More informationDennis St. George, M.Sc., P.Eng. Sr. Biosystems Engineer
Bioenergy Optimization Program Demonstration Project Presentation BIOCLEANTECH Forum In Ottawa ON Grid Stability, Remote Communities, and Air Quality Biopower Session on November 3, 2016 Dennis St. George,
More information19 th SYMPOSIUM ON INDUSTRIAL APPLICATIONS OF GAS TURBINES
19 th SYMPOSIUM ON INDUSTRIAL APPLICATIONS OF GAS TURBINES Combined cycle opportunities for small gas turbines by Michael Lucente - Found Energy, An Aecon Company Kristen Cofrancesco - Pratt & Whitney
More informationPITAGORAS project. General overview and main results
XX/XX/2017 PITAGORAS project General overview and main results Sustainable urban Planning with Innovative and low energy Thermal And power Generation from Residual And renewable Sources Efficient integration
More informationWaste Heat to Power (WHP) Technologies. Eric Maxeiner, PhD. May 24, 2017
Waste Heat to Power (WHP) Technologies Eric Maxeiner, PhD. May 24, 2017 Presentation Outline of WHP WHP Market : Thermoelectric Steam Organic Rankine Cycle (ORC) sco 2 power cycle Overview of WHP: Definitions
More informationFast pyrolysis: A sustainable new industry for South Australia
Fast pyrolysis: A sustainable new industry for South Australia Presentation by Colin Stucley Director, Enecon Pty Ltd Bioenergy Australia Business Breakfast Adelaide, 25 May 2017. Fast pyrolysis converts
More informationCombined Heat and Power
Lecture 12 Combined Heat and Power Combustion Turbines and Co-generation Combustion Turbines and Combined Heat and Power (CHP) Systems See B. K. Hodge, Chapter 5 and Chapter 11. ISBN: 978-0-470-14250-9
More informationPerformance evaluation of an ORC integrated to a waste heat recovery unit in a Steel mill. Presented by Miguel Ramirez
Performance evaluation of an ORC integrated to a waste heat recovery unit in a Steel mill Presented by Miguel Ramirez OUTLINE 1 INTRODUCTION 4 BRESCIA DEMO PLANT 2 PITAGORAS CONCEPT 5 ANALYSIS & RESULTS
More informationBioenergy Optimization Program Demonstration Project Presentation Compost Matters In Manitoba March 22, 2017
Bioenergy Optimization Program Demonstration Project Presentation Compost Matters In Manitoba March 22, 2017 Dennis St. George, M.Sc., P.Eng. Sr. Biosystems Engineer Biosystems Engineering Section Develop
More informationFIELD OPERATIONAL ANALYSIS OF AN EXISTING SMALL SIZE BIOMASS-FIRED ORC UNIT. M. Noussan, G. Cerino Abdin, A. Poggio, R. Roberto
FIELD OPERATIONAL ANALYSIS OF AN EXISTING SMALL SIZE BIOMASS-FIRED ORC UNIT M. Noussan, G. Cerino Abdin, A. Poggio, R. Roberto Outline Introduction CHP system description Operation data analysis ORC model
More informationORC Technology for waste Heat Recovery Power Generation. Dr Vijayakumar Kunche, M.Tech., Ph.D.
ORC Technology for waste Heat Recovery Power Generation Dr Vijayakumar Kunche, M.Tech., Ph.D. Waste Heat - Present situation Industrial Processes use Oil, Gas, Coal or electricity for Heating Furnaces,
More informationBiomass Cogeneration Network- BIOCOGEN
Biomass Cogeneration Network- BIOCOGEN Ms Ioanna Papamichael, Dr Calliope Panoutsou, Mr Andrew Lamb Center for Renewable Energy Sources (CRES), Pikermi - GREECE ABSTRACT The main goal of the BIOCOGEN network
More informationDesign and Off-Design Analysis of an ORC Coupled with a Micro-Gas Turbine
4 th International Seminar on ORGANIC RANKINE CYCLE POWER SYSTEMS September 13-15, 2017, Milano, Italy Design and Off-Design Analysis of an ORC Coupled with a Micro-Gas Turbine Authors: Alberto Benato
More informationExperimental Study on the Performance of Single Screw Expander with 195 mm Diameter Screw Yeqiang Zhang
Experimental Study on the Performance of Single Screw Expander with 195 mm Diameter Screw Yeqiang Zhang Key Lab of Enhanced Heat Transfer & Energy Conservation of Education Ministry Key Lab of Heat Transfer
More informationENERGY RECOVERY IMPROVEMENT USING ORGANIC RANKINE CYCLE AT COVANTA S HAVERHILL FACILITY
Proceedings of the 18th Annual North American Waste-to-Energy Conference NAWTEC18 May 11-13, 2010, Orlando, Florida, USA Paper Number: NAWTEC18-3563 ENERGY RECOVERY IMPROVEMENT USING ORGANIC RANKINE CYCLE
More informationTHERMAL POWER RANGE: 199 kwt kwt. ELECTRICAL POWER RANGE: 50 kwe kwe.
OUR HISTORY Uniconfort produces boilers which works with forest and woodworking industry waste, agricultural waste, food processing industry waste, dedicated tree and grass crops, cleaning urban landscaping.
More informationChapter 4.3: Cogeneration, Turbines (Gas, Steam)
Short type questions Chapter 4.3: Cogeneration, Turbines (Gas, Steam) 1. What could be the range of energy saving potential from co-generation systems? Co-generation offers energy savings in the range
More informationChapter 2.7: Cogeneration
Chapter 2.7: Cogeneration Part-I: Objective type questions and answers 1. In cogeneration, the system efficiencies can go up to ------ a) 70% b) 80% c) 90% d) 60% 2. Cogeneration is the simultaneous generation
More informationEnergy Generation from Recovered Wood for Greenhouse Gas Reduction
Energy Generation from Recovered Wood for Greenhouse Gas Reduction Gerfried Jungmeier Joint Workshop COST Action E31 and IEA Bioenergy Task 38 Greenhouse Gas Aspects of Biomass Cascading Reuse, Recycling
More informationEnglish CHP: cogeneration
English CHP: cogeneration Power & heat from biomass Competence is our success... HERZ FACTS: 60 companies Group headquarter in Austria Research & development in Austria Austrian owner 2.600 employees in
More informationThe Steam Machine Energy Recovery from The Most Powerful Machine in the World (1) Prepared by: Langson Energy, Inc. March 2013
TM The Steam Machine Energy Recovery from The Most Powerful Machine in the World (1) Prepared by: Langson Energy, Inc. March 2013 Langson Energy s Steam Machine is an economically viable solution to improving
More informationWaste Heat Recovery with Organic Rankine Cycle Technology
Power Generation Waste Heat Recovery with Organic Rankine Cycle Technology Power Generation with the Siemens ORC-Module Scan the QR code with the QR code reader in your mobile! www.siemens.com / energy
More informationEnhanced Efficiency, Sustainable Power Generation, and CO2 Emission Reduction through Organic Rankine Cycle Technology
Enhanced Efficiency, Sustainable Power Generation, and CO2 Emission Reduction through Organic Rankine Cycle Technology Simone Passera Dallas, April 26 th 2016 Turboden ORC turbogenerator fields of application
More informationElectricity from Low Temperaturewaste heat. Organic Rankine Cycle. with. BEP Europe. Guy De Graeve- BEP Europe /
Electricity from Low Temperaturewaste heat with Organic Rankine Cycle E-RATIONAL is a BEP Europe division E-RATIONAL Ten Briele6 8200 Brugge Belgium T +32 50 40 85 40 F +32 50 38 01 60 www.e-rational.net
More informationCogeneration with ORC at Elbe-Stahlwerke Feralpi EAF Shop
Cogeneration with ORC at Elbe-Stahlwerke Feralpi EAF Shop Bause T. Pelz T. Monti N. Campana F. Filippini L. Foresti A. Elbe Stahlwerke Feralpi Riesa, Germany Founded in 1968, Feralpi group produces 5 Mtons
More informationOrganic Rankine Cycle Waste Heat Solutions And Opportunities In Natural Gas Compression > The renewable energy source
Organic Rankine Cycle Waste Heat Solutions And Opportunities In Natural Gas Compression > The renewable energy source BY JOHN FOX t takes a significant amount of energy to transport the ever-growing supply
More informationConvert your waste heat into power GENERATOR WASTE HEAT F / C. kwe COOLING BENEFITS ADDITIONAL THERMAL USAGE INCENTIVES
WASTE HEAT 170-252 F / 77-122 C WASTE HEAT 170-252 F / 77-122 C kwe COOLING BENEFITS ADDITIONAL THERMAL USAGE INCENTIVES kwe COOLING BENEFITS ADDITIONAL THERMAL USAGE INCENTIVES GENERATOR Convert your
More informationBIOMASS CHP BASED ON GAS TURBINE PROCESSES. Dragan STEVANOVIĆ Engineering & Consulting, Sulzbach-Rosenberg, Germany
BIOMASS CHP BASED ON GAS TURBINE PROCESSES Dragan STEVANOVIĆ Engineering & Consulting, Sulzbach-Rosenberg, Germany INTRODUCTION The very fast increase of renewable power in some countries, mainly based
More informationTransPacific Energy Advantage: Case Studies
TransPacific Energy Advantage: Case Studies Typical Power Plant TPE-ORC 0.60 KWh ORC 2.3 KWh LP steam 0.35 KWh 30% (maximum) 2.05 KWh CHP Typical Power Generated 1.1 KWh Typical Power Wasted 2.31 KWh Typical
More informationHeat and Power (CHP) Buildings account for almost a third. WBA fact sheet
WBA fact sheet BIOMASS Combined Heat and Power (CHP) Summary Combined heat and power (CHP) means the simultaneous production and utilization of heat and electricity. Combined heat and power production
More informationCogeneration. Thermal Chillers. and. .. ASHRAE National Capital Chapter. Arlington, VA 10/10/2012
Cogeneration and Thermal Chillers.. ASHRAE National Capital Chapter. Arlington, VA 10/10/2012 Agenda Cogeneration Interest and Application Basics Equipment Matching Thermal Chiller Overview Steam Components
More informationEnvironmentally Sound Technology Biomass Fuelled Energy Plants. Combined Heat and Power Supply. Biomass Fired Steam Generator
Environmentally Sound Technology Biomass Fuelled Energy Plants BONO SISTEMI can boast 50 years experience, gained in the design and production of biomass fired steam generators and thermal fluid heaters
More informationEngineering aspects of a pellet production facility
2nd Biomass & Pellets Update Asia Engineering aspects of a pellet production facility Possible association to cogeneration with ORC Victam Asia 2012 THE COMPANY PRODESA is a Global partner for complete
More informationRank. Rank Technology.
Rank Rank designs and assembles microgeneration and microcogeneration, combined heat and power (micro-chp), equipments for energy recovery from low grade heat sources. So, Rank can generate electric power
More informationTHERMAL POWER RANGE: 199 kwt kwt. ELECTRICAL POWER RANGE: 50 kwe kwe.
OUR HISTORY Uniconfort produces boilers which works with forest and woodworking industry waste, agricultural waste, food processing industry waste, dedicated tree and grass crops, cleaning urban landscaping.
More informationYOUR WASTEI OUR RESOURCE. OUR TECHNOLOGYI YOUR ENERGY.
YOUR WASTEI OUR RESOURCE. OUR TECHNOLOGYI YOUR ENERGY. COMPANY PROFILE 2009, JANUARY 1 ST SEBIGAS becomes part of S.E.C.I. Energia, the sub-holding company of the MACCAFERRI INDUSTRIAL GROUP, a business
More informationCH2356 Energy Engineering Co-Generation. Dr. M. Subramanian
CH2356 Energy Engineering Co-Generation Dr. M. Subramanian Associate Professor Department of Chemical Engineering Sri Sivasubramaniya Nadar College of Engineering Kalavakkam 603 110, Kanchipuram (Dist)
More informationTechnology and Prospect of Process Heat Application of HTR(High temperature gas cooled reactor) Applications in Oil Refining Industry
Technology and Prospect of Process Heat Application of HTR(High temperature gas cooled reactor) Applications in Oil Refining Industry Dr. Min Qi, Associate Professor Institute of Nuclear and New Energy
More informationMs.P.Aileen Sonia Dhas
SUBJECT CODE SUBJECT NAME STAFF NAME : ME8792 : Power Plant Engineering : Prof.V.Tamil Selvi Ms.P.Aileen Sonia Dhas UNIT- I COAL BASED THERMAL POWER PLANTS Rankine cycle - improvisations, Layout of modern
More informationCOMPANY PROFILE OVER 35 YEARS OF ORGANIC RANKINE CYCLE TECHNOLOGY.
COMPANY PROFILE OVER 35 YEARS OF ORGANIC RANKINE CYCLE TECHNOLOGY. Turboden Turboden, a Mitsubishi Heavy Industries company, is an Italian firm and a global leader in the design, manufacture and maintenance
More informationCommercial Combined Heat & Power (CHP) Available via Fully Serviced Free to Fit, Cash, Leasing or Finance
Commercial Combined Heat & Power (CHP) Available via Fully Serviced Free to Fit, Cash, Leasing or Finance Deliver Heat & Electric to your Business from Combined Heat & Power (CHP) system I ONLY NEED MAINTENANCE
More informationOptimization of parameters for heat recovery steam generator (HRSG) in combined cycle power plants
Optimization of parameters for heat recovery steam generator (HRSG) in combined cycle power plants Muammer Alus, Milan V. Petrovic - Faculty of Mechanical Engineering Laboratory of Thermal Turbomachinery
More informationJOHANNEUM RESEARCH Interim Report 19
CONTENTS 1.1 Biomass CHP plants using solid biomass- Comparison of selected European countries.. 4 1.2 Construction year of existing solid biomass CHP plants... 8 1.3 Technologies of existing solid biomass
More informationBIOMASS COMBINED HEAT AND POWER (CHP)
WBA fact sheet BIOMASS COMBINED HEAT AND POWER (CHP) SUMMARY Combined heat and power (CHP) means the simultaneous production and utilization of heat and electricity. Combined heat and power production
More informationSmall scale geothermal successes utilizing various incentive opportunities. ElectraTherm John Fox, CEO
Small scale geothermal successes utilizing various incentive opportunities ElectraTherm John Fox, CEO Introduction to ElectraTherm, Inc. Highlights: Founded in 2005 Approx. 50 Employees Patented & Patent-Pending
More informationBjörn Kjellström Exergetics AB, Sweden
The technology and experience in the use of woody biomass for cogeneration of electricity and heat in large and small plants Björn Kjellström Exergetics AB, Sweden info@exergetics.se State of technology
More informationWaste heat recovery via Organic Rankine Cycle: Results of a ERA-SME Technology Transfer Project
08/10/2013 1 Waste heat recovery via Organic Rankine Cycle: Results of a ERA-SME Technology Transfer Project Presentation based on results from research, supported by IWT Ing. Bruno Vanslambrouck UGent
More informationITI Energy Limited. A New Era in Gasification. Presentation to. UK Energy Symposium Nottingham
ITI Energy Limited A New Era in Gasification Presentation to UK Energy Symposium Nottingham 14 th October, 2010 By Tony Fordham www.iti-energy.com Email: tony@iti-energy.com PROCESS INTENSIFICATION & MINIATURIZATION
More informationLow temperature cogeneration using waste heat from research reactor as a source for heat pump
National Centre for Nuclear Research in Poland Low temperature cogeneration using waste heat from research reactor as a source for heat pump Anna Przybyszewska International Atomic Energy Agency 14-16
More information26 th World Gas Conference
26 th World Gas Conference 1 5 June 2015, Paris, France UTILIZING WASTE HEAT IN A GAS RESERVOIR ENVIRONMENT Zavada Roman NAFTA a.s. INTRODUCTION OF NAFTA a.s. Modern and innovative company Key underground
More informationRichard Kablitz GmbH AHK Geschäftsreise Biomass and Waste to Energy
I Richard Kablitz GmbH AHK Geschäftsreise Biomass and Waste to by Mr. Andreas Hehn-Mark Donnerstag, 15. Juni 2017 R. Kablitz & Mitthof GmbH 1 Biomassen Power Stations Clean WORLD for our next I. The company
More informationenergytech.at energytech.at [ energy technology austria ] Cogeneration (CHP) TechnologyPortrait
energytech.at [ energy technology austria ] energytech.at The internet-platform for innovative energy technologies in the area of renewable energy sources and energy efficiency http://energytech.at TechnologyPortrait
More informationago congelo When hot turns to cold
ago congelo When hot turns to cold Efficient energy supply from small plants to industrial large-scale plants ago. One step ahead. Cooling from waste heat For industry and municipalities Economic conditions
More informationTechnology Approach and Sizing
Stantec Consulting Ltd. 845 Prospect Street, Fredericton NB E3B 2T7 January 15, 2016 File: 133547047_8_8 Attention: #2 Miles Canyon Road Box 5920, Whitehorse, Yukon, Y1A 6S7 Dear Ms. Mallory, Stantec Consulting
More informationCool Producing Systems Based on Burning and Gasification of Biomass
Cool Producing Systems Based on Burning and Gasification of Biomass J. POSPISIL, J. FIEDLER, Z. SKALA Energy Institute Faculty of Mechanical Engineering Brno University of Technology Technicka 2, Brno
More informationLARGE SCALE TRIGENERATION AND DISTRICT HEATING AND COOLING WITH RENEWABLE CONCEPTS WITHIN THE SPANISH POLYCITY PROJECT
POLYCITY FINAL CONFERENCE, VISIONS OF SUSTAINABLE URBAN ENERGY SYSTEMS 16th 17th SEPTEMBER 2010 LARGE SCALE TRIGENERATION AND DISTRICT HEATING AND COOLING WITH RENEWABLE CONCEPTS WITHIN THE SPANISH POLYCITY
More information