SAFETY DATA SHEET. 1. Product and Company Identification. Product Name : AQUA GLAZE Product Code : 890N Recommended Use: Putty

Transcription

1 Page 1 of 5 1. Product and Company Identification Product Name : Product Code : 890N Recommended Use: Putty Company Identification: 259 LENOX STREET PO BOX 130 NORWOOD, MA Information Phone: Emergency Phone: Website Address: Synonyms: ,021004,021016, Hazards Identification Classification: Not classified Label Hazard Statement: required. Potential Health Effects: Eye: May cause mild eye irritation. Symptoms include stinging, tearing, and redness Skin: known. Ingestion: May cause blockage. Inhalation: Vapors are unlikely due to physical properties. Chronic Overexposure Information: Teratology and Reproduction Information: Aggravation of Pre-Existing Conditions: OSHA Hazard Communication Standard: This product is not defined as hazardous by the OSHA Hazard Communication Standard, 29 CFR

2 Page 2 of 5 3. Composition/Information on Ingredients Component CAS# % by Wt. CALCIUM CARBONATE % - 40% ACGIH 10 mg/m3 TWA (total dust) ACGIH 5 mg/m3 TWA (respirable dust) CALCIUM CARBONATE % - 40% ACGIH 10 mg/m3 TWA (total dust) ACGIH 5 mg/m3 TWA (respirable dust) BUTYL BENZYL PHTHALATE % - 5% EXPOSURE GUIDELINES NOT ESTABLISHED ALIPHATIC HYDROCARBON (STODDARD TYPE) % - 5% ACGIH 100 ppm TWA OSHA 500 ppm TWA 4. First Aid Measures Eyes: Rinse with water for 15 minutes. If irritation persists seek medical attention. Skin: Remove contaminated clothing. Wash exposed area with soap and water. If symptoms persist, seek medical attention. Launder clothing before reuse. Ingestion: If ingested, DO NOT induce vomiting; call a physician immediately. Inhalation: If symptoms develop, immediately move individual away from exposure and into fresh air. Seek immediate medical attention. Note to Physicians: Treat symptomatically. No specific antidote available. 5. Fire Fighting Measures Flammable Properties: Hazardous Combustion Products: May form carbon dioxide and carbon monoxide, various hydrocarbons. Extinguishing Media: Not combustible. Use extinguishing method suitable for surrounding fire. Firefighting Procedures: NONE 6. Accidental Release Measures

3 Page 3 of 5 Small Spill: Large Spill: Environmental Precautions: Methods/Materials for Containment and Cleaning Up: Use normal clean up procedures. 7. Handling and Storage Handling: Wash thoroughly after handling. Storage: Keep container tightly closed. 8. Exposure Controls/Personal Protection Airborne Exposure Limits: See Section 3 Engineering Controls: Personal Protective Equipment: Respiratory Protection: Skin Protection: Eye Protection: 9. Physical and Chemical Properties Boiling Point: NA Melting Point: Freezing Point: Vapor Pressure: NA Vapor Density: NA Solubility in Water: Negligible; less than 0.1% Evaporation Rate: Flash Point: NONE Method: Lower explosive limit: Upper explosive limit: Autoignition Temperature: Specific Gravity: ph(1% in H2O): 7-9 Odor: Mild ammoniacal

4 Page 4 of 5 Appearance:: White paste 10. Stability and Reactivity Chemical Stability (Conditions to Avoid): Stable Incompatibility: known. Hazardous Decomposition Products: Carbon dioxide and carbon monoxide, various hydrocarbons. Hazardous Polymerization: Will not occur. 11. Toxicological Information Acute: Subchronic: Chronic/Carcinogenicity: Not listed by ACGIH, IARC, NIOSH, NTP or OSHA Routes of Exposure: Ingestion 12. Ecological Information Environmental Fate: This product has no known adverse effect on ecology. 13. Disposal Considerations Waste Disposal Method: Small quantities may be deposited in general trash and residue flushed down drain with water. Large spills must be disposed of in accordance with local state and federal regulations. 14. Transport Information Land Transport (DOT): Not Regulated 15. Regulatory Information U.S. Federal Regulations: TSCA: The intentional ingredients of this product are listed. OSHA: The intentional regulated ingredients of this product are listed.

5 Page 5 of 5 CERCLA: SARA Hazard Category: Section 313: Not Listed Reportable Quantity: of the chemicals in this material have an RQ State Regulations: Volatile Organic Compounds: 0.98 by wt.;19 g/l;0.16 lbs/gallon 16. Other Information: NFPA Ratings: 0,0,0 Manufacturer Disclaimer: Judgement of potential hazards of this product is based on information available about individual components listed under section 3 - Ingredients. Direct testing of mixture has not been done. Information given herein is believed to be accurate and is given in good faith. However, no warranty either expressed or implied is made. It is strongly suggested that users confirm in advance of need that the information is current and applicable to their situations.