CANSOLV SO2 Scrubbing System - 10 Years of Reliable Operation Integration with SRU Tail Gas Incineration

Size: px
Start display at page:

Download "CANSOLV SO2 Scrubbing System - 10 Years of Reliable Operation Integration with SRU Tail Gas Incineration"

Transcription

1 CANSOLV SO2 Scrubbing System - 1 Years of Reliable Operation Integration with SRU Tail Gas Incineration NICOLAS EDKINS, NANCY MORETON Cansolv Technologies Inc. (an affiliate of Shell Global Solutions BV) Montreal, Canada In 22 Cansolv was proud to announce the start-up of its second commercial plant at the Lanxess Chemical plant in Belgium. At this particular site the Cansolv process is treating flue gas generated from an incinerator which burns waste tar as well the tail gas from a sulphur recovery unit (SRU or Claus unit). At that time Lanxess was faced with the challenge of meeting new environmental emissions standards in the region. Through a series of piloting campaigns Lanxess evaluated several SO2 capture technologies but Cansolv proved to be the best fit in successfully treating the sites combined waste tar incineration and SRU tail gas. As a result, the Cansolv SO2 Scrubbing System was selected by Lanxess in order to comply with the new environmental regulations and the unit was efficiently integrated into their existing line-up in 21. The maximum SO2 emission limit of 45 mg/nm3 came into effect January 1, 23 and Lanxess have been in compliance ever since. The integration and optimization of a 2 stage SRU and the Cansolv unit has proven to be a reliable and robust operation. Lanxess have successfully been able to control feed ratios at lower H2S flow rates (4 Nm3/hr > 98% H2S) while capturing higher concentrations of SO2 in the incinerator flue gas (1-2%vol SO2) from the 2 stage SRU. With tailgas incineration, the control of the air / H2S ratio to the thermal stage is less demanding, since the Cansolv System can inexpensively scrub the higher SO2 concentrations that may result from off-ratio operation for shorter periods. The SO2 product generated by the Cansolv process is recycled back to the SRU at 6-7 Nm3/hr, expanding its sulfur recovery capacity by reducing the thermal stage combustion air

2 N. Edkins, N. Moreton requirement, while controlling total sulfur emissions to less than 11 mg/nm3 SO2. Operation of the plant has been stable and reliable for 1 years and operators attest to the robustness and trouble-free nature of the Camsolv System. This paper aims to highlight the reliability, on-line availability, performance and general ease of operation that Laxness has achieved with the Cansolv system over the past 1 years. It will also focus on the overall integration and optimization of the Cansolv unit as part of a 2- stage SRU with tail-gas incineration line up and touch on its potential use in other similar applications. This paper highlights the reliability, on-line availability, performance and general ease of operation that Lanxess has achieved with the CANSOLV SO2 Scrubbing System over the past 1 years. The overall integration and optimization of the CANSOLV unit as part of a 2- stage sulfur recovery unit (SRU) with tail-gas incineration line-up has provided a means for Lanxess to optimize their rubber chemicals plant as well as keep emissions within the environmental regulatory limits. INTRODUCTION In 22, the CANSOLV SO2 Scrubbing System was started-up at the Lanxess chemical plant in Belgium. At this particular site, the CANSOLV process treats the flue gas generated from an incinerator which burns waste tar as well the tail gas from a sulfur recovery unit (SRU or Claus unit). At the time of the CANSOLV unit s inception, Lanxess was faced with the challenge of meeting new regional environmental emissions standards. The maximum SO2 emission limit of 45 mg/nm 3 (16 ppmv) would be coming into effect January 1, 23. In addition to meeting the environmental emissions standards, Lanxess was looking for a cost-efficient technology that could easily be integrated in its line-up and would not generate additional turn-downs. Through a series of piloting campaigns, Lanxess evaluated several SO2 capture technologies and Cansolv was proven to be the best fit in successfully treating the site s combined waste tar incineration combustion gas and SRU tail gas. As a result, the CANSOLV SO2 Scrubbing System was selected by Lanxess in order to comply with the new environmental regulations and the unit was efficiently integrated into their existing line-up in 21. PROCESS DESCRIPTION & BENEFITS OF CANSOLV - INTEGRATION INTO SRU Prior to the CANSOLV unit, the SO2-rich flue gas from the incinerator unit is processed through three pre-treatment steps. First, it is treated for NOx removal in the Selective Non-Catalytic Reduction (SNCR) unit, then it is cooled in a waste heat boiler (WHB), and finally, it is quenched in a venturi-type pre-scrubber which also serves to remove the majority of particulates and chlorides. The CANSOLV unit is a typical regenerative amine line-up as shown in the block diagram below (Figure 1B). The recovered SO2 is recycled to the front end of the Claus unit in order to increase the sulfur recovery capacity of the existing SRU. The SO2 removed from the flue gas exiting the incinerator (generated from incineration of SRU tail gas and waste tars) reduces the inert flow through the SRU acting to debottleneck the unit and increase sulfur production. The integration and optimization of a 2-stage SRU and the CANSOLV unit has proven to be a reliable and robust operation. Lanxess have successfully been able to control feed ratios at lower H2S flow rates (4 Nm 3 /hr > 98% H2S) while capturing higher concentrations of SO2 in the incinerator flue gas (.7-1.5%vol SO2) from the 2-stage SRU. With tail gas incineration, the control of the air / H2S ratio to the thermal stage is less demanding, since the CANSOLV System can inexpensively scrub the higher SO2 concentrations that may result from off-ratio operation for shorter periods. The SO2 product generated by the CANSOLV process is recycled back to the SRU at 6-7 Nm 3 /hr, expanding its sulfur recovery capacity by reducing the thermal stage combustion air requirement, while controlling total sulfur emissions to less than 11 mg/nm 3 SO2 (39 ppmv) which is significantly below the current regulatory requirement of 5 mg/nm 3 SO2 emissions. 352 Sulphur 212 International Conference (Berlin, Germany October 212)

3 CANSOLV SO 2 scrubbing system - 1 years of reliable operation Integration with SRU tail gas incineration Claus Unit and Cansolv Integration Treated Flue Gas Raw Materials S SO 2 DeNOx (SNCR) H 2 S Claus Unit H 2 S Incinerator WHB Cansolv Production SO 2 SO 2 Waste Tar Quench & Chlorides/ Particulates Removal Process Stream organic sulfur compounds Extraction Water Treatment Treated Water Rubber Chemical Fig. 1A: Block diagram of Lanxess plant SO 2 Recycle: Cansolv SO 2 to Treated Flue Gas Sulfur Recovery Lean Cansolv DS Amine Tail GasSO 2 SO 2 -Absorber SO 2 -Stripper Rich Cansolv Amine Fig. 1B: Block diagram of Lanxess s CANSOLV Unit Sulphur 212 International Conference (Berlin, Germany October 212) 353

4 N. Edkins, N. Moreton Fig. 2: CANSOLV SO 2 Scrubbing System at the Lanxess, Belgium plant (September 11, 212) The original 22 design basis used for the Lanxess CANSOLV System Recovery unit is the following: 354 Sulphur 212 International Conference (Berlin, Germany October 212)

5 CANSOLV SO 2 scrubbing system - 1 years of reliable operation Integration with SRU tail gas incineration Table 1 Design basis for Lanxess, Belgium s CANSOLV unit Gas Flow 11, Nm 3 /hr Gas Temperature 65 C Composition Component Vol% (wet) kg/hr N O H2O CO SO SO Additional Feedstock Specification HCl.2.35 NOx H2S.1.2 Organic Compounds 2 mg/nm 3 Dust 5 mg/nm 3 Cations 2 mg/nm 3 Outlet Specifications (cleaned gas) SOx 45 mg/nm 3 EMISSIONS CONTROL As shown in the following graph, despite fluctuations in the SO2 concentration in the inlet gas, the SO2 in the cleaned outlet gas has consistently remained below 36 mg/nm 3 SO2 (125 ppmv SO2). The only rare exceptions are during start-ups and shut-downs when there is insufficient H2S feed to the Claus unit. Since start-up, the unit has successfully met the design and environmental SO2 emissions targets. Figure 3 below is a trend of the inlet SO2 concentration and the outlet concentration in the treated gas (both in ppmv). Day-to-day operating averages are well below emissions targets. Sulphur 212 International Conference (Berlin, Germany October 212) 355

6 N. Edkins, N. Moreton 14 SO 2 Conc. Inlet and Outlet vs. Time (averaged annual values, logorithmic scale) INLET 6 5 SO2 Conc. (ppmv) OUTLET SO2 Inlet (ppmv) SO2 Outlet from Cansolv (ppmv) Fig. 3A: Inlet SO 2 vs. Outlet SO 2 (22-212) The CANSOLV process displays a robust ability to handle changes in SO2 inlet concentration while maintaining the desired emissions. As shown in Figure 3A above, since 22 to present-day, the inlet SO2 concentration has almost doubled, however SO2 treated gas concentration has consistently remained well below the design emissions specification of 16 ppmv. In fact, in recent years, the SO2 treated gas concentration has remained below 5 ppmv. The robustness of the CANSOLV unit is further shown in Figure 3B and Figure 4 below. The fluctuations of the SO2 concentration in the inlet gas is mainly attributed to the intermittent operation of the waste tar incineration. The SRU tail gas, on the other hand, is continuously fed through to the CANSOLV unit. Despite the wide fluctuations in SO2 inlet concentration, the emissions are maintained 356 Sulphur 212 International Conference (Berlin, Germany October 212)

7 CANSOLV SO 2 scrubbing system - 1 years of reliable operation Integration with SRU tail gas incineration 18 SO 2 in and SO 2 out (ppm) vs. Time - 211/212 monthly average INLET SO2 Conc. (ppmv) OUTLET 1 5 Nov-1 Feb-11 Jun-11 Sep-11 Dec-11 Apr-12 Jul-12 Oct-12 SO2 In (ppm) SO2 In Treated Gas (ppm) Fig. 3B: Inlet SO 2 vs. Outlet SO 2 ( ) 14 Inlet/Outlet SO 2 Conc. and Flue Gas Flow vs. Time (averaged annual values) Flue Gas Flow (Nm3/hr) and SO2 Inlet and Outlet Conc. (ppmv) SO2 Inlet (ppmv) Throughput (Nm3/hr) SO2 Outlet (ppmv) Fig. 4: Flue gas flow rate and SO 2 inlet concentration (22-212) In 27, Lanxess added a Waste Heat Boiler (WHB) into the line-up to recover energy and generate steam for use in other locations around the facility (see block diagram in Figure 1A). This resulted in a reduction of the flue gas temperature entering the CANSOLV absorber of ~1-15 C (45-6 C pre-whb, 3-45 C Sulphur 212 International Conference (Berlin, Germany October 212) 357

8 N. Edkins, N. Moreton post- WHB). This trend can be seen in Figure 5 below. The CANSOLV process benefits from lower operating conditions in the absorber and as a result SO2 capture is improved. 6 Flue Gas Inlet Temperature and SO 2 Outlet vs. Time (averaged annual values) 4 5 Installed WHB in late Flue Gs inlet Temperature (C) SO2 in Treated Gas (ppmv) Flue Gas Inlet Temperature (C) SO2 in Treated Gas (ppmv) Fig. 5: Flue gas inlet temperature ( C) and SO 2 outlet concentration (ppmv) Also, by sending excess steam to the stripper, even lower emissions were attained. The flexibility provided by increasing steam above original values has allowed the site to increase throughput of sulfur as well as reduce emissions. RELIABILITY AND EASE OF OPERATION The CANSOLV unit has required essentially no maintenance over the past 1 years. The CANSOLV unit is off-line once a year when the SRU Claus unit is shut down for maintenance reasons. The plant has never shutdown due to unavailability of the CANSOLV unit. Regarding its ease of operation, the CANSOLV unit is essentially self-sufficient and does not require a full-time operator. One operator runs the entire Claus unit, which includes the CANSOLV unit. The overall yearly operating expense of the CANSOLV unit is low. The required utilities are cooling water for the regenerator condenser and lean amine cooler, steam for the stripper, and demineralized water and caustic for the amine purification unit. Amine losses are also kept very low, at approximately 5-8% make-up per year. For Lanxess, this translates to 2-3 drums of amine per year. The source of the losses are mainly mechanical and as a result of solvent degradation. When the CANSOLV system was starting in 22, an electro-dialysis unit (EDU) was provided to control heat stable salt (HSS) level in the amine inventory. After overcoming several challenges related to deploying the EDU technology, it was successfully integrated and used to manage HSS levels until 25. In 25, Lanxess opted to switch to a skidded ion exchange (IX) technology in favor of lower operating and maintenance expenses. This technology is currently still in use at the site and has proven to be a low maintenance, cost-effective method of managing HSS levels in the CANSOLV amine. 358 Sulphur 212 International Conference (Berlin, Germany October 212)

9 CANSOLV SO 2 scrubbing system - 1 years of reliable operation Integration with SRU tail gas incineration CLOSING SUMMARY After 1 years of trouble-free operation, the Lanxess rubber plant in Belgium attests to the reliability, the cost-effectiveness and the ease of maintenance of the CANSOLV SO2 Scrubbing System. The level of emissions has been kept below the imposed regulatory limits, whilst the SO2 recycled back to the SRU unit has optimized its operations and lowered its operating costs. In addition, the flexibility of the CANSOLV SO2 Scrubbing System proved useful to surpass the environmental regulations and optimize the unit. Simply by cooling the feed gas to the unit and by increasing the steam feed to the stripper, the emissions were reduced by a factor of 2 and sulfur recovery was further increased. From an emerging technology in the late 9s, the CANSOLV SO2 Scrubbing System has proven to be a mature cost-efficient technology, adopted by numerous plants around the world. CANSOLV PRESENTATION Cansolv Technologies Incorporated (CTI) is an innovative, technology-centered company that offers its clients high efficiency air pollution and capture solutions for the removal of SO2 and CO2 from gas streams in various industrial applications. Our commitment is to provide custom designed economic solutions to our clients' environmental problems. Cansolv Technologies Incorporated was formed in 1997 to commercialize the CANSOLV SO2 Scrubbing System. On November 3th of 28, Shell Global Solutions International B.V (SGSI) purchased 1% of the shares of CTI. The company now operates as a wholly owned subsidiary of SGSI. CTI has maintained a strong Research and Development program focused on continuously improving the CANSOLV SO2 process, developing a CO2 Capture process, and integrating advanced amine purification systems. Sulphur 212 International Conference (Berlin, Germany October 212) 359

10 N. Edkins, N. Moreton 36 Sulphur 212 International Conference (Berlin, Germany October 212)

Cansolv Technologies Inc. Alberta NOx and SOx Control Technologies Symposium April 9, Rick Birnbaum

Cansolv Technologies Inc. Alberta NOx and SOx Control Technologies Symposium April 9, Rick Birnbaum A Novel SO 2 Scrubbing Process For Industrial SO 2 Emission Control Alberta NOx and SOx Control Technologies Symposium April 9, 2008 Rick Birnbaum rick.birnbaum@cansolv.com OUTLINE Gas Absorption Solutions

More information

Cansolv Technologies Inc. Air and Waste Management Association South Coast AQMD May 14, Rick Birnbaum

Cansolv Technologies Inc. Air and Waste Management Association South Coast AQMD May 14, Rick Birnbaum A Versatile SO 2 Scrubbing Process For Industrial SO 2 Emission Control Air and Waste Management Association South Coast AQMD May 14, 2008 Rick Birnbaum rick.birnbaum@cansolv.com OUTLINE Gas Absorption

More information

Ms. Valérie Léveillé Cansolv Technologies, Inc. Thys Claassens Chemical Initiatives

Ms. Valérie Léveillé Cansolv Technologies, Inc. Thys Claassens Chemical Initiatives CANSOLV SO 2 SCRUBBING SYSTEM: REVIEW OF COMMERCIAL APPLICATIONS FOR SMELTER SO 2 EMISSIONS CONTROL Ms. Valérie Léveillé Cansolv Technologies, Inc. Thys Claassens Chemical Initiatives ABSTRACT As new legislation

More information

Refinery SRU s Tail Gas Handling Options. 2 nd Middle East Sulphur Plant Operations Network Forum Abu Dhabi October 18-20, 2015

Refinery SRU s Tail Gas Handling Options. 2 nd Middle East Sulphur Plant Operations Network Forum Abu Dhabi October 18-20, 2015 Refinery SRU s Tail Gas Handling Options 2 nd Middle East Sulphur Plant Operations Network Forum Abu Dhabi October 18-20, 2015 Refinery SRU tail gas handling options Shell Global Solutions Achim Epping

More information

Cansolv Technologies Inc.

Cansolv Technologies Inc. 6 C 16 S Cansolv Technologies Inc. About Cansolv Cansolv Technologies Incorporated was formed in 1997 to commercialize and market the CANSOLV SO Scrubbing System developed at Union Carbide Canada. Since

More information

Dow Oil, Gas & Mining

Dow Oil, Gas & Mining Dow Oil, Gas & Mining Application of UCARSOL TM HS-103 high performance solvent for energy conservation and emission compliance in refinery Sulphur recovery tail gas treating unit (TGTU) Dow.com Yousuf

More information

THE CANSOLV SO 2 - CO 2 CAPTURE PROCESS

THE CANSOLV SO 2 - CO 2 CAPTURE PROCESS THE CANSOLV SO 2 - CO 2 CAPTURE PROCESS Carbon Capture Workshop Texas A&M University, Qatar April 2-3, 2012 Niels Fabricius Qatar Shell Copyright of Royal Dutch Shell plc April 2011 Presentation Outline

More information

Cansolv Activities & Technology Focus for CO 2 Capture. John Sarlis / Devin Shaw

Cansolv Activities & Technology Focus for CO 2 Capture. John Sarlis / Devin Shaw Cansolv Activities & Technology Focus for CO 2 Capture John Sarlis / Devin Shaw IEA Meeting, Vienna, May 2008 1 Outline Company background Technology development strategy Technology developent status Piloting

More information

by: Steven M. Puricelli and Ernesto Vera-Castaneda MECS, Inc USA

by: Steven M. Puricelli and Ernesto Vera-Castaneda MECS, Inc USA MECS SOLVR REGENERATIVE SULFUR DIOXIDE TECHNOLOGY by: Steven M. Puricelli and Ernesto Vera-Castaneda MECS, Inc USA Prepared for AMERICAN INSTITUTE OF CHEMICAL ENGINEERS 4798 S. Florida Ave. #253 Lakeland,

More information

Successful Sulfur Control & Hydrogen Purification at Saras World-Scale IGCC Plant

Successful Sulfur Control & Hydrogen Purification at Saras World-Scale IGCC Plant Successful Sulfur Control & Hydrogen Purification at Saras World-Scale IGCC Plant Enrico Maffeis, Claudio Allevi & Ivo Cicerelli Saras S.p.A. Bart Beuckels, Elena Truffa & Mike Whysall, A Honeywell Company

More information

Progress on CO 2 Capture Pilot Plant at RIST

Progress on CO 2 Capture Pilot Plant at RIST IEAGHG/IETS Iron & Steel Industry CCUS & Process Integration Workshop Date: 5th to 7th November 2013 Tokyo Tech Front, Tokyo Institute of Technology, Japan Progress on CO 2 Capture Pilot Plant at RIST

More information

Environmental Improvement Plan. Sohar Refinery

Environmental Improvement Plan. Sohar Refinery Environmental Improvement Plan Sohar Refinery Feb 2014 Page 1 of 18 Waste Water Treatment Plant Improvements Background The treatment of the waste water of the Refinery was malfunctioning for a long period.

More information

Removal of Heat Stable Salts A Solution to Amine Plant Operational Problems

Removal of Heat Stable Salts A Solution to Amine Plant Operational Problems Removal of Heat Stable Salts A Solution to Amine Plant Operational Problems Chemical Engineering in Petroleum & Natural Gas Journal, China, December 2002 J. Shao, Technical Marketing Specialist, Eco-Tec

More information

pilot plant for CO 2 capture in Esbjerg

pilot plant for CO 2 capture in Esbjerg Emission measurements at Dong s pilot plant for CO 2 capture in Esbjerg EU Project CESAR Prepared by N. Aas, Statoil; presented by E. da Silva, Sintef Materials and Chemistry 1 Overview Background to the

More information

February 2017 SCOT ULTRA POWERS PERFORMANCE

February 2017 SCOT ULTRA POWERS PERFORMANCE February 2017 SCOT ULTRA POWERS PERFORMANCE POWER PERFORMANCE COVER FEATURE John Specht, Shell Global Solutions International B.V., the Netherlands, and Pat Holub, Huntsman Corp., USA, profile two projects

More information

LANXESS CO 2 Capture plant

LANXESS CO 2 Capture plant LANXESS CO 2 Capture plant * October 2015 Dawie vd Merwe 1 Title of presentation Speaker Place, date [ OPTIONAL ] Lanxess CO 2 capture plant Specified Plant Parameters Latest CO 2 capture plant in region

More information

Available online at ScienceDirect. Energy Procedia 63 (2014 ) GHGT-12

Available online at   ScienceDirect. Energy Procedia 63 (2014 ) GHGT-12 Available online at www.sciencedirect.com ScienceDirect Energy Procedia 63 (2014 ) 1678 1685 GHGT-12 Shell Cansolv CO 2 capture technology: Achievement from First Commercial Plant Ajay Singh a *, Karl

More information

Callidus Oxidizer Systems. Thermal and Catalytic Oxidizer Systems

Callidus Oxidizer Systems. Thermal and Catalytic Oxidizer Systems Callidus Oxidizer Systems Thermal and Catalytic Oxidizer Systems Meet the Thermal Oxidizer Experts Wide Range of Applications Honeywell UOP Callidus is an industry leader in environmental combustion technology.

More information

Thermal Oxidation plants February 2016

Thermal Oxidation plants February 2016 Thermal Oxidation plants February 2016 Thermal Oxidation of gaseous waste Typical Processed Stream: Contaminated Air by Hydrocarbons Contaminated Air by Solvents Contaminated Air by Stripping/Scrubbing

More information

ThioSolv, LLC s SWAATS Process A Low-Cost Alternative for increasing SRU Capacity ThioSolv, LLC, Spring Branch, TX ph:

ThioSolv, LLC s SWAATS Process A Low-Cost Alternative for increasing SRU Capacity ThioSolv, LLC, Spring Branch, TX ph: ThioSolv, LLC s SWAATS Process A Low-Cost Alternative for increasing SRU Capacity ThioSolv, LLC, Spring Branch, TX ph: 832-443-0952 SWAATS Process SWAATS was developed to process sour water stripper gas

More information

OPTIMISATION OF ANGLO PLATINUM S ACP ACID PLANT CATALYTIC CONVERTER. M. K. SICHONE Anglo Platinum, ACP, Kroondal, South Africa

OPTIMISATION OF ANGLO PLATINUM S ACP ACID PLANT CATALYTIC CONVERTER. M. K. SICHONE Anglo Platinum, ACP, Kroondal, South Africa OPTIMISATION OF ANGLO PLATINUM S ACP ACID PLANT CATALYTIC CONVERTER Anglo Platinum, ACP, Kroondal, South Africa ABSTRACT Anglo Platinum s Waterval smelting complex based in South Africa operates the Anglo

More information

Handling of Trace Components for Rectisol Wash Units

Handling of Trace Components for Rectisol Wash Units Handling of Trace Components for Rectisol Wash Units Ulvi Kerestecioğlu, Thomas Haberle Washington DC, 08 th Oct. 2008 Rectisol Wash Unit in Jilin, China General Information about the Rectisol Process

More information

Experiences from Commissioning and Test Operation of Vattenfall s Oxyfuel Pilot Plant

Experiences from Commissioning and Test Operation of Vattenfall s Oxyfuel Pilot Plant Experiences from Commissioning and Test Operation of Vattenfall s Oxyfuel Pilot Plant 1 st International Oxyfuel Combustion Conference Germany, Cottbus, 7 th 11 th September 2009 Uwe Burchhardt Project

More information

PROClaus: The New Standard for Claus Performance

PROClaus: The New Standard for Claus Performance PROClaus: The New Standard for Claus Performance Mahin Rameshni, P.E. Chief Process Engineer WorleyParsons 125 West Huntington Drive Arcadia, CA, USA Phone: 626-294-3549 Fax: 626-294-3311 E-Mail: mahin.rameshni@worleyparsons.com

More information

CEMENT PLANT ENVIRONMENTAL TECHNOLOGY FOR ACHIEVING HIGH SO 2 REMOVAL

CEMENT PLANT ENVIRONMENTAL TECHNOLOGY FOR ACHIEVING HIGH SO 2 REMOVAL CEMENT PLANT ENVIRONMENTAL TECHNOLOGY FOR ACHIEVING HIGH SO 2 REMOVAL Sara Safariyeganeh sara.safariyeganeh@mecsglobal.com Cary Joe Lovett, PE joe.lovett@holcim.com Abstract - The EPA has adopted revised

More information

S THERMAL OXIDIZER SOLUTIONS TO MEET TOMORROW S CHALLENGES

S THERMAL OXIDIZER SOLUTIONS TO MEET TOMORROW S CHALLENGES UOP Callidus Oxidizers for Waste Destruction TODAY S THERMAL OXIDIZER SOLUTIONS TO MEET TOMORROW S CHALLENGES Thermal oxidizer systems Catalytic oxidizer systems Callidus, experts in Thermal Oxidizers

More information

WWT Two-Stage Sour Water Stripping

WWT Two-Stage Sour Water Stripping WWT Two-Stage Sour Water Stripping Improve performance of sulfur recovery units ben efits The Chevron WWT Process is a two-stage stripping process which separates ammonia and hydrogen sulfide from sour

More information

SULPHUR RECOVERY BY TAIL GAS TREATING TECHNOLOGY (MCRC PROCESS) MAXIMUM CLAUS

SULPHUR RECOVERY BY TAIL GAS TREATING TECHNOLOGY (MCRC PROCESS) MAXIMUM CLAUS International Journal of Science, Environment and Technology, Vol. 3, No 4, 2014, 1609 1613 ISSN 2278-3687 (O) SULPHUR RECOVERY BY TAIL GAS TREATING TECHNOLOGY (MCRC PROCESS) MAXIMUM CLAUS Sulabh Jangra

More information

AMINE GAS SWEETENING & SULPHUR RECOVERY

AMINE GAS SWEETENING & SULPHUR RECOVERY AMINE GAS SWEETENING & SULPHUR RECOVERY SECTOR / MAINTENANCE MANAGMENT NON-TECHNICAL & CERTIFIED TRAINING COURSE The removal of acidic components (primarily H2S and CO2) from hydrocarbon streams can be

More information

Successful SmartSulf unit starting up at PEMEX Salamanca Refinery

Successful SmartSulf unit starting up at PEMEX Salamanca Refinery Successful SmartSulf unit starting up at PEMEX Salamanca Refinery SULPHUR CONFERENCE 2014 3 rd - 6 th November, 2014 Michael P. Heisel ITS REAKTORTECHNIK GMBH PROSERNAT Group, Pullach, Germany Frank A.

More information

SaskPower s Boundary Dam power plant: Integrated Carbon Capture and Storage project Boundary Dam, Saskatchewan, Canada

SaskPower s Boundary Dam power plant: Integrated Carbon Capture and Storage project Boundary Dam, Saskatchewan, Canada SaskPower s Boundary Dam power plant: Integrated Carbon Capture and Storage project Boundary Dam, Saskatchewan, Canada Report on the industrial visit (11-09-2015) Dr Lionel Dubois Research Coordinator

More information

SULFUR RECOVERY UNIT. Thermal Oxidizer

SULFUR RECOVERY UNIT. Thermal Oxidizer SULFUR RECOVERY UNIT Thermal Oxidizer BURNERS FLARES INCINERATORS PARTS & SERVICE SULFUR RECOVERY UNIT Thermal Oxidizer Tail Gas Thermal Oxidizer designed and built to GOST-R requirements. Zeeco can meet

More information

CONTROL STRTEGIES FOR FLEXIBLE OPERATION OF POWER PLANT INTEGRATED WITH CO2 CAPTURE PLANT

CONTROL STRTEGIES FOR FLEXIBLE OPERATION OF POWER PLANT INTEGRATED WITH CO2 CAPTURE PLANT CONTROL STRTEGIES FOR FLEXIBLE OPERATION OF POWER PLANT INTEGRATED WITH CO2 CAPTURE PLANT Yu-Jeng Lin a, Chun-Cheng Chang a, David Shan-Hill Wong a Shi-Shang Jang a * and Jenq-Jang Ou b a National Tsing-Hua

More information

Performance Review of CASTOR Pilot Plant at Esbjerg

Performance Review of CASTOR Pilot Plant at Esbjerg IEA GHG 11 th Capture Network Meeting 20 21 May 2008, Vienna, Austria Performance Review of CASTOR Pilot Plant at Esbjerg Jacob Nygaard Knudsen, Poul-Jacob Vilhelmsen, Jørgen N. Jensen (DONG Energy) Ole

More information

Development status of the EAGLE Gasification Pilot Plant

Development status of the EAGLE Gasification Pilot Plant Development status of the EAGLE Gasification Pilot Plant Gasification Technologies 2002 San Francisco, California, USA October 27-30, 2002 Masaki Tajima Energy and Environment Technology Development Dept.

More information

Start-Up of World s First Commercial Post-Combustion Coal Fired CCS Project: Contribution of Shell Cansolv to SaskPower Boundary Dam ICCS Project

Start-Up of World s First Commercial Post-Combustion Coal Fired CCS Project: Contribution of Shell Cansolv to SaskPower Boundary Dam ICCS Project Available online at www.sciencedirect.com ScienceDirect Energy Procedia 00 (2013) 000 000 www.elsevier.com/locate/procedia GHGT-12 Start-Up of World s First Commercial Post-Combustion Coal Fired CCS Project:

More information

ADVANCED PROCESS CONTROL QATAR GAS ONE YEAR EXPERIENCE

ADVANCED PROCESS CONTROL QATAR GAS ONE YEAR EXPERIENCE ADVANCED PROCESS CONTROL QATAR GAS ONE YEAR EXPERIENCE Bouchebri El-Hadi Senior Process Engineer Benmouley Abdelkader Head of Process Qatar Liquefied Gas Company Limited. Ras Laffan Industrial Area, Doha,

More information

Using a Process Simulator to Improve Sulphur Recovery

Using a Process Simulator to Improve Sulphur Recovery Page 1 of 8 Using a Process Simulator to Improve Sulphur Recovery KARL W. MATTSSON-BOZE, LILI G. LYDDON, Bryan Research & Engineering, Inc., Bryan, Texas ABSTRACT Increasingly stringent sulphur emissions

More information

2011 BRIMSTONE SULFUR SYMPOSIUM. Fundamentals 2011: Ammonia Destruction in SRU Furnaces

2011 BRIMSTONE SULFUR SYMPOSIUM. Fundamentals 2011: Ammonia Destruction in SRU Furnaces 2011 BRIMSTONE SULFUR SYMPOSIUM Fundamentals 2011: Ammonia Destruction in SRU Furnaces Peter Clark, Alberta Sulphur Research Ltd. Paul d Haene, DANA Technical Services Jim Jenkins, Shell Contents: 1. History

More information

POZP 8 EN Incineration. Combustion Flares Combustion units Catalytic VOC oxidation Incineration of Hazard materials Vent gas cleaning Summary

POZP 8 EN Incineration. Combustion Flares Combustion units Catalytic VOC oxidation Incineration of Hazard materials Vent gas cleaning Summary POZP 8 EN Incineration Combustion Flares Combustion units Catalytic VOC oxidation Incineration of Hazard materials Vent gas cleaning Summary Thermal Oxidation Description Thermal oxidation is the oxidation

More information

Rectisol Wash Units Acid Gas Removal for Polygeneration Concepts downstream Gasification

Rectisol Wash Units Acid Gas Removal for Polygeneration Concepts downstream Gasification Rectisol Wash Units Acid Gas Removal for Polygeneration Concepts downstream Gasification Ulvi Kerestecioğlu, Thomas Haberle GTC Conference, Washington DC, USA, November 3rd, 2010 Agenda of the Presentation

More information

Chilled Ammonia - Pilot Testing at the We Energies Pleasant Prairie Power Plant

Chilled Ammonia - Pilot Testing at the We Energies Pleasant Prairie Power Plant Chilled Ammonia - Pilot Testing at the We Energies Pleasant Prairie Power Plant 12 th IEA Post-Combustion Meeting Regina, Saskatchewan Sean Black, Alstom Richard Rhudy, EPRI 30 th September 2009 Chilled

More information

Fluor s Econamine FG Plus SM Technology For CO 2 Capture at Coal-fired Power Plants

Fluor s Econamine FG Plus SM Technology For CO 2 Capture at Coal-fired Power Plants Fluor s Econamine FG Plus SM Technology For CO 2 Capture at Coal-fired Power Plants Satish Reddy Dennis Johnson John Gilmartin Presented At: Power Plant Air Pollutant Control Mega Symposium August 25-28,

More information

Evaluation of Reclaimer Sludge Disposal from Post- Combustion CO 2 Capture

Evaluation of Reclaimer Sludge Disposal from Post- Combustion CO 2 Capture Evaluation of Reclaimer Sludge Disposal from Post- Combustion CO 2 Capture Prachi Singh, IEA Greenhouse Gas R&D Programme, UK Paul Nielsen, University of Texas at Austin Trimeric Corporation, University

More information

SYNTHETIC NATURAL GAS PLANT. Philadelphia, PA

SYNTHETIC NATURAL GAS PLANT. Philadelphia, PA SYNTHETIC NATURAL GAS PLANT Philadelphia, PA SYNTHETIC NATURAL GAS PLANT The SNG facility was constructed in 1977 but has seen very little operational activity. The SNG Facility employs the British Gas

More information

IGCC Plants : a Practical Pathway for Combined Production of Hydrogen and Power from Fossil Fuels

IGCC Plants : a Practical Pathway for Combined Production of Hydrogen and Power from Fossil Fuels International Hydrogen Energy Congress and Exhibition IHEC 2005 Istanbul, Turkey, 13-15 July 2005 IGCC Plants : a Practical Pathway for Combined Production of Hydrogen and Power from Fossil Fuels Luigi

More information

Technology & Solutions Availability SOx. September 2017

Technology & Solutions Availability SOx. September 2017 Technology & Solutions Availability SOx September 2017 1. Introduction of JET and JNEP Topics 2. Solutions Available for DeSOx 3. Introduction of EADS Technology 4. Reference Projects Introductions of

More information

Integrated CO 2 capture study for a coal fired station. Philippe Delage (ALSTOM) & Paul Broutin (IFP)

Integrated CO 2 capture study for a coal fired station. Philippe Delage (ALSTOM) & Paul Broutin (IFP) Integrated CO 2 capture study for a coal fired station Philippe Delage (ALSTOM) & Paul Broutin (IFP) 1 Introduction Bases of the study Integration study Conclusions 2 Objectives of the eco2 Study Study

More information

Repowering Conventional Coal Plants with Texaco Gasification: The Environmental and Economic Solution

Repowering Conventional Coal Plants with Texaco Gasification: The Environmental and Economic Solution Repowering Conventional Coal Plants with Texaco Gasification: The Environmental and Economic Solution INTRODUCTION Coal fired power plants have been producing a significant amount of power in the United

More information

OPERATIONAL EXPERIENCE AND CURRENT DEVELOPMENTS.

OPERATIONAL EXPERIENCE AND CURRENT DEVELOPMENTS. PUERTOLLANO Puertollano IGCC IGCC Power Plant POWER - ELCOGAS PLANT. OPERATIONAL EXPERIENCE AND CURRENT DEVELOPMENTS. International Freiberg Conference on IGCC & XtL Technologies 8-12 May, 2007 Freiberg,

More information

Sulfur Tail Gas Thermal Oxidizer Systems By Peter Pickard

Sulfur Tail Gas Thermal Oxidizer Systems By Peter Pickard Sulfur Tail Gas Thermal Oxidizer Systems By Peter Pickard Introduction SRU s (Sulfur Recovery Units) are critical pieces of equipment in refineries and gas plants. SRUs remove sulfur compounds from certain

More information

Sandhya Eswaran, Song Wu, Robert Nicolo Hitachi Power Systems America, Ltd. 645 Martinsville Road, Basking Ridge, NJ 07920

Sandhya Eswaran, Song Wu, Robert Nicolo Hitachi Power Systems America, Ltd. 645 Martinsville Road, Basking Ridge, NJ 07920 ABSTRACT COAL-GEN 2010 Advanced Amine-based CO 2 Capture for Coal-fired Power Plants Sandhya Eswaran, Song Wu, Robert Nicolo Hitachi Power Systems America, Ltd. 645 Martinsville Road, Basking Ridge, NJ

More information

UMATAC Industrial Processes. Fushun ATP Project Update & Value Added Processing. UMATAC Industrial Processes

UMATAC Industrial Processes. Fushun ATP Project Update & Value Added Processing. UMATAC Industrial Processes Fushun ATP Project Update & Value Added Processing Colorado School of Mines 35 th Oil Shale Symposium (Salt Lake City) October 5, 2015 ThyssenKrupp Industrial Solutions Rev: 0 FMG Operation Update Plant

More information

Latest Development of Lurgi s MPG-technology Update on Hydrogen Unit for NWU Project

Latest Development of Lurgi s MPG-technology Update on Hydrogen Unit for NWU Project Latest Development of Lurgi s MPG-technology Update on Unit for NWU Project U. Wolf, H. Schlichting, S. Walter, Lurgi AG J. Quinn, North West Upgrading Inc. Gasification Technologies Conference 2007 October

More information

Technical Description Package Micro Auto Gasification System (MAGS )

Technical Description Package Micro Auto Gasification System (MAGS ) 1 Technical Description Package Micro Auto Gasification System (MAGS ) written consent of Terragon Environmental Technologies Inc. is forbidden. Date 2 1. TECHNOLOGY DESCRIPTION 1.1. Process Overview Terragon

More information

Boiler & Heater Group

Boiler & Heater Group Boiler & Heater Group Boiler & Heater Group New Trends in Tail Gas Fired Boiler Carbon Black Conference 2017 Chennai, India About Thermax A leading engineering company providing equipment and solutions

More information

TRONDHEIM CCS CONFERENCE

TRONDHEIM CCS CONFERENCE TRONDHEIM CCS CONFERENCE June 15, 2011 6th Trondheim Conference on CO 2 Capture, Transport and Storage Pedro Casero Cabezón (pcasero@elcogas.es) ELCOGAS S.A (www.elcogas.es) 1 SCOPE IGCC & ELCOGAS, S.A

More information

CEE 452/652. Week 14, Lecture 1 NOx control. Dr. Dave DuBois Division of Atmospheric Sciences, Desert Research Institute

CEE 452/652. Week 14, Lecture 1 NOx control. Dr. Dave DuBois Division of Atmospheric Sciences, Desert Research Institute CEE 45/65 Week 14, Lecture 1 NOx control Dr. Dave DuBois Division of Atmospheric Sciences, Desert Research Institute Today s topics Today s topic: NOx control Read chapter 16 Presentations on Nov 9 and

More information

Minimize Sulfur Pit Vent Contribution to Stack Emissions

Minimize Sulfur Pit Vent Contribution to Stack Emissions Minimize ulfur Pit Vent Contribution to tack Emissions Grant Qui, P.E. Excel Paralubes - ConocoPhillips 2800 Old panish Trail 3008 MO Westlake, LA 70609 Houston, TX 77079 Al Keller Refining Technical ervices

More information

Advanced Sulfur Technologies for Mega Size Sulfur Complexes in Arid Environments. Presented by Thomas Chow

Advanced Sulfur Technologies for Mega Size Sulfur Complexes in Arid Environments. Presented by Thomas Chow Advanced Sulfur Technologies for Mega Size Sulfur Complexes in Arid Environments Presented by Thomas Chow Presentation Agenda Introduction Fluor Patented Air Demand Feedback Control Systems Fluor/GAA Patented

More information

4.0 HYDROGEN GENERATION UNIT (PREP) 4.1 INTRODUCTION

4.0 HYDROGEN GENERATION UNIT (PREP) 4.1 INTRODUCTION 4.0 HYDROGEN GENERATION UNIT (PREP) 4.1 INTRODUCTION 4.1.1 PURPOSE The objective of the unit is to produce hydrogen by steam reforming of full range naphtha i.e. C 5-140 O C SR naphtha & coker naphtha

More information

A preliminary evaluation of post-combustion CO 2 capture in a CSIRO pilot plant using MEA at Loy Yang Power in Australia

A preliminary evaluation of post-combustion CO 2 capture in a CSIRO pilot plant using MEA at Loy Yang Power in Australia A preliminary evaluation of post-combustion CO 2 capture in a CSIRO pilot plant using MEA at Loy Yang Power in Australia Fourth International Conference on Clean Coal Technologies (CCT2009) Dresden, Germany,

More information

Taravosh Jam Design & Engineering Co.

Taravosh Jam Design & Engineering Co. Taravosh Jam Design & Engineering Co. Taravosh Jam co. as an Iranian EPC contractor supplies following refinery equipment and facilities based on the know-how and to international standards. 1- The Main

More information

WOOD PELLETS- A GROWING MARKETPLACE

WOOD PELLETS- A GROWING MARKETPLACE WOOD PELLETS- A GROWING MARKETPLACE The present drive for carbon neutral energy sources has given rise to increasing focus on biomass for energy. A big component of the world s biomass energy resource

More information

EFFECTIVENESS OF CONTINUOUS REMOVAL

EFFECTIVENESS OF CONTINUOUS REMOVAL EFFECTIVENESS OF CONTINUOUS REMOVAL OF HEAT STABLE SALTS FROM CONTAMINATED AMINE SCRUBBING SOLUTIONS Sunil Dandekar, Global Product Manager Eco-Tec Inc., Ontario, Canada sdandekar@eco-tec.com Jenny Shao,

More information

Carbon (CO 2 ) Capture

Carbon (CO 2 ) Capture Carbon (CO 2 ) Capture Kelly Thambimuthu, Chief Executive Officer, Centre for Low Emission Technology, Queensland, Australia. & Chairman, International Energy Agency Greenhouse Gas Program (IEA GHG) CSLF

More information

Oslo, February 17th, 2010

Oslo, February 17th, 2010 Oslo, February 17th, 2010 HIGH DUST SELECTIVE CATALYTIC NOx REDUCTION AT WTE PLANT IN BRESCIA Paolo Rossignoli Mario Nenci Lorenzo Zaniboni A2A, Brescia, Italy INTEGRATED WASTE MANAGEMENT SYSTEM Waste

More information

Plasma Gasification Facility

Plasma Gasification Facility Westinghouse Plasma Corporation Plasma Gasification Facility Westinghouse Plasma has over 30 years of experience in research, development, testing, design and commercial use of proven plasma torch technology.

More information

UOP Selexol TM Technology Applications for CO 2 Capture

UOP Selexol TM Technology Applications for CO 2 Capture UOP Selexol TM Technology Applications for CO 2 Capture 3rd Annual Wyoming CO2 Conference June 23rd and 24th 2005 2009 UOP LLC. All rights reserved. Typical Gasification Complex Typical Raw Syngas H2 30-50%

More information

SO 2 Clean for SRU Expansion

SO 2 Clean for SRU Expansion SO 2 Clean for SRU Expansion Jeff Hammerstrom Calabrian Corp jhammerstrom@calabriancorp.com Ron Schendel Process Consultant Ron@RSchendel.com Brimstone Sulfur Symposium Vienna, Austria May 27 31, 2013

More information

Holds a B. Sc. in Mechanical Power Engineering and has over 15 years hands-on experience working in operation, commissioning and start-up.

Holds a B. Sc. in Mechanical Power Engineering and has over 15 years hands-on experience working in operation, commissioning and start-up. 103461-MEC-OS-E-2000 Shift Leader Holds a B. Sc. in Mechanical Power Engineering and has over 15 years hands-on experience working in operation, commissioning and start-up. PERSONAL DATA Nationality :

More information

Integration of carbon capture unit with power generation: technology advances in oxy-combustion plants

Integration of carbon capture unit with power generation: technology advances in oxy-combustion plants Integration of carbon capture unit with power generation: technology advances in oxy-combustion plants 3 rd Oxyfuel Combustion Conference, OCC3 9 th -13 th September 2013, Ponferrada, Spain Luca Mancuso,

More information

Available online at Energy Procedia 4 (2011) Energy Procedia 00 (2010)

Available online at   Energy Procedia 4 (2011) Energy Procedia 00 (2010) Available online at www.sciencedirect.com Energy Procedia 4 (2011) 1925 1932 Energy Procedia 00 (2010) 000 000 Energy Procedia www.elsevier.com/locate/procedia www.elsevier.com/locate/xxx GHGT-10 Evaluation

More information

Pre-Combustion Technology for Coal-fired Power Plants

Pre-Combustion Technology for Coal-fired Power Plants Pre-Combustion Technology for Coal-fired Power Plants Thomas F. Edgar University of Texas-Austin IEAGHG International CCS Summer School July, 2014 1 Introduction 2 CO 2 Absorption/Stripping of Power Plant

More information

Up gradation of Boilers to Implement New Pollution Norms

Up gradation of Boilers to Implement New Pollution Norms Up gradation of Boilers to Implement New Pollution Norms 1 Key Regulatory Drivers: Power Plants Pollutant Unit* TPPs installed before December 31, 2003 (Refer Note 1) TPPs installed after 2003 to December

More information

First Year of Operational Experience with the Negishi IGCC

First Year of Operational Experience with the Negishi IGCC First Year of Operational Experience with the Negishi IGCC Gasification Technologies 2004 October 3-6, 2004 JW Marriott Hotel Washington, DC Makoto Yamaguchi Group Manager IPP Group Negishi Refinery Nippon

More information

Hadong and Boryeong 10 MW Pilot Projects

Hadong and Boryeong 10 MW Pilot Projects CSLF Technology Workshop in Seoul Korea Hadong and Boryeong 10 MW Pilot Projects Landscape of KEPCO RI Dr. Chong Kul Ryu (ckryu@kepri.re.kr) Renaissance Seoul Hotel, 26 March 2014 1 Contents KEPCO & KEPCO

More information

Recent Developments of Hitachi s Advanced Solvent Technology for Post-combustion CO 2 Capture

Recent Developments of Hitachi s Advanced Solvent Technology for Post-combustion CO 2 Capture Recent Developments of Hitachi s Advanced Solvent Technology for Post-combustion CO 2 Capture ABSTRACT Sandhya Eswaran, Song Wu Hitachi Power Systems America, Ltd. 645 Martinsville Road, Basking Ridge,

More information

KM-CDR Post-Combustion CO 2 Capture with KS-1 Advanced Solvent

KM-CDR Post-Combustion CO 2 Capture with KS-1 Advanced Solvent EIGHTH ANNUAL CONFERENCE ON Carbon Capture & Sequestration Pittsburgh, PA May 2009 Determining the Technologies & System Components for Commercially Viable CCS IEA GHG What Have We Learned From Large-Scale

More information

Corrosion in GASCO Habshan CBA Units and its mitigation

Corrosion in GASCO Habshan CBA Units and its mitigation Corrosion in GASCO Habshan CBA Units and its mitigation Orlando de Matos Inspection Department Head MESPON 2016 - Abu Dhabi 9 th to 11 th October 2016 AGENDA Introduction Process Description for CBA Units

More information

WSA. - Meeting industry demands by Jens K. Laursen and Frands E. Jensen

WSA. - Meeting industry demands by Jens K. Laursen and Frands E. Jensen - Meeting industry demands by Jens K. Laursen and Frands E. Jensen Meeting industry demands Jens K. Laursen and Frands E. Jensen of Haldor Topsøe A/S give an overview of the process principles of the process

More information

DYNAMIC MODELING OF THE ISAB ENERGY IGCC COMPLEX

DYNAMIC MODELING OF THE ISAB ENERGY IGCC COMPLEX DYNAMIC MODELING OF THE ISAB ENERGY IGCC COMPLEX F. Pisacane R. Domenichini L. Fadabini Foster Wheeler Italiana S.p.A. Via Caboto 1 20094 CORSICO, Italy Abstract During the execution of detailed engineering

More information

CO 2 Capture and Storage: Options and Challenges for the Cement Industry

CO 2 Capture and Storage: Options and Challenges for the Cement Industry CO 2 Capture and Storage: Options and Challenges for the Cement Industry Martin Schneider, Düsseldorf, Germany CSI Workshop Beijing, 16 17 November 2008 CO 2 abatement costs will tremendously increase

More information

EnBW s post-combustion capture pilot plant at Heilbronn

EnBW s post-combustion capture pilot plant at Heilbronn EnBW s post-combustion capture pilot plant at Heilbronn OCTAVIUS project - Results MEA campaign CCS Conference Paris 17-19 November 2015 Alexander Rieder EnBW T-BTV EnBW s post-combustion pilot plant at

More information

Downsizing a Claus Sulfur Recovery Unit

Downsizing a Claus Sulfur Recovery Unit INFRASTRUCTURE MINING & METALS NUCLEAR, SECURITY & ENVIRONMENTAL Downsizing a Claus Sulfur Recovery Unit OIL, GAS & CHEMICALS By Charles L. Kimtantas and Martin A. Taylor ckimtant@bechtel.com & mataylo1@bechtel.com

More information

WSA-DC NEXT GENERATION TOPSØE WSA TECHNOLOGY FOR STRONGER SO 2 GASES AND VERY HIGH CONVERSION. Helge Rosenberg Haldor Topsoe

WSA-DC NEXT GENERATION TOPSØE WSA TECHNOLOGY FOR STRONGER SO 2 GASES AND VERY HIGH CONVERSION. Helge Rosenberg Haldor Topsoe WSA-DC NEXT GENERATION TOPSØE WSA TECHNOLOGY FOR STRONGER SO 2 GASES AND VERY HIGH CONVERSION Helge Rosenberg Haldor Topsoe Up to now, Topsøe WSA (Wet gas Sulphuric Acid) plants have been in operation

More information

IMPROVED PERFORMANCE OF THE DESTEC GASIFIER Gasification Technologies Conference

IMPROVED PERFORMANCE OF THE DESTEC GASIFIER Gasification Technologies Conference IMPROVED PERFORMANCE OF THE DESTEC GASIFIER 1999 Gasification Technologies Conference Dr. David L. Breton Dynegy, Inc. 1000 Louisiana Street, Suite 5800 Houston, Texas 77002 ABSTRACT The DESTEC gasification

More information

The types of industrial exhaust streams that present particular pollution-control challenges include:

The types of industrial exhaust streams that present particular pollution-control challenges include: Choosing the Right Emissions Control Option Steve Blocki, P.E, Durr Systems, Inc. Determining the most economical option to control airborne emissions during chemical process operations presents several

More information

Development of the Highly Durable COS Hydrolysis Catalyst for IGCC Gas Clean-up System

Development of the Highly Durable COS Hydrolysis Catalyst for IGCC Gas Clean-up System Development of the Highly Durable COS Hydrolysis Catalyst for IGCC Gas Clean-up System Mitsubishi Heavy Industries, Ltd. Kaori Yoshida 2012 MITSUBISHI HEAVY INDUSTRIES, LTD. All Rights Reserved. October

More information

Southern Company/MHI Ltd. 500 TPD CCS Demonstration. Jerrad Thomas Research Engineer Southern Company Services, Inc.

Southern Company/MHI Ltd. 500 TPD CCS Demonstration. Jerrad Thomas Research Engineer Southern Company Services, Inc. Southern Company/MHI Ltd. 500 TPD CCS Demonstration Jerrad Thomas Research Engineer Southern Company Services, Inc. The Commercialization Puzzle Economic Capture Advanced processes New chemistry Economies

More information

Ronald L. Schoff Parsons Corporation George Booras Electric Power Research Institute

Ronald L. Schoff Parsons Corporation George Booras Electric Power Research Institute Pre-Investment of IGCC for CO 2 Capture with the Potential for Hydrogen Co-Production Gasification Technologies 2003 - San Francisco, California - October 12-15, 2003 Michael D. Rutkowski, PE Parsons Corporation

More information

SRU-TGTU Analyzer Best Practices. RefComm Galveston 2016 Sulfur Recovery

SRU-TGTU Analyzer Best Practices. RefComm Galveston 2016 Sulfur Recovery SRU-TGTU Analyzer Best Practices RefComm Galveston 2016 Sulfur Recovery 1 SRU-TGT Analyzer Tags 2 AT-1 (Acid Gas) H 2 S + Total Hydrocarbon (CO 2, H 2 O, NH 3 ) (BTEX, MeOH) 3 O 2 Required to Burn Hydrocarbons

More information

Available online at Energy Procedia 1 (2009) (2008) GHGT-9. Sandra Heimel a *, Cliff Lowe a

Available online at   Energy Procedia 1 (2009) (2008) GHGT-9. Sandra Heimel a *, Cliff Lowe a Available online at www.sciencedirect.com Energy Procedia 1 (2009) (2008) 4039 4046 000 000 Energy Procedia www.elsevier.com/locate/procedia www.elsevier.com/locate/xxx GHGT-9 Technology Comparison of

More information

Optimal Design and Operation of SNCR System for a 150t/h CFB Boiler and Discussion on the Measurement of Flue Gas Components

Optimal Design and Operation of SNCR System for a 150t/h CFB Boiler and Discussion on the Measurement of Flue Gas Components Optimal Design and Operation of SNCR System for a 150t/h CFB Boiler and Discussion on the Measurement of Flue Gas Components Yang Hairui Tsinghua University 66 th IEA-FBC meeting 18-20, March, 2013 Brno,

More information

Table of Contents. iii. vi Tables. Figures. viii Foreword. ix Acknowledgments

Table of Contents. iii. vi Tables. Figures. viii Foreword. ix Acknowledgments Figures vi Tables viii Foreword ix Acknowledgments xi About the authors xiii Chapter 1. Fundamentals 1 Fluid Properties 1 Temperature 2 Pressure 3 Gravity and Miscibility 3 Solubility 4 The Ideal Gas Law

More information

Integrated processes for converting coal to chemicals and fuels. Maninder Jit Singh Haldor Topsøe

Integrated processes for converting coal to chemicals and fuels. Maninder Jit Singh Haldor Topsøe Integrated processes for converting coal to chemicals and fuels Maninder Jit Singh Haldor Topsøe Converting coal to chemicals and fuels Sulfuric acid SNG Coal Coal gasification Syngas conditioning Ammonia

More information

CO 2 Capture. John Davison IEA Greenhouse Gas R&D Programme.

CO 2 Capture. John Davison IEA Greenhouse Gas R&D Programme. CO 2 Capture John Davison IEA Greenhouse Gas R&D Programme Overview of this Presentation Leading CO 2 capture technologies for power generation Descriptions Main advantages and disadvantages Examples of

More information

MODERN COKE OVEN GAS TREATMENT TECHNOLOGY AT A NEW COKE MAKING PLANT IN BRAZIL*

MODERN COKE OVEN GAS TREATMENT TECHNOLOGY AT A NEW COKE MAKING PLANT IN BRAZIL* MODERN COKE OVEN GAS TREATMENT TECHNOLOGY AT A NEW COKE MAKING PLANT IN BRAZIL* Wolfgang Kern 1 Mario Petzsch 2 Antonio Esposito 3 Helênio Resende Silva Júnior 4 Abstract The implementation of the Gas

More information

Available online at ScienceDirect. Energy Procedia 63 (2014 ) GHGT-12. a Alstom Power, USA

Available online at   ScienceDirect. Energy Procedia 63 (2014 ) GHGT-12. a Alstom Power, USA Available online at www.sciencedirect.com ScienceDirect Energy Procedia 63 (2014 ) 6173 6187 GHGT-12 Advanced Amine Process Technology Operations and Results from Demonstration Facility at EDF Le Havre

More information

Field Testing and Independent Review of Post-Combustion CO 2 Capture Technology

Field Testing and Independent Review of Post-Combustion CO 2 Capture Technology Field Testing and Independent Review of Post-Combustion CO 2 Capture Technology Presented by Phil Boyle, President and COO, Powerspan Corp. McIlvaine Company, Carbon Management Strategies & Technologies

More information