Material Safety Data Sheet TEGOSOFT PSE 141 G

Transcription

1 1. IDENTIFICATION OF THE SUBSTANCE/PREPARATION AND OF THE COMPANY/UNDERTAKING Trade name : PRODUCT CODE : CHEMICAL FAMILY : Sucrose ester with fatty acid esters based on palmitic/ stearic acid Information on manufacturer/supplier : Evonik Goldschmidt GmbH Goldschmidtstr. 100 Essen, Emergency telephone number (24h) : CHEMTREC CANUTEC Non-Emergency Phone Number: Telephone: (800) (613) (800) COMPOSITION/INFORMATION ON INGREDIENTS Components CAS-No. Concentration [%] All Ingredients Are Proprietary 3. HAZARDS IDENTIFICATION Emergency Overview Physical Appearance Form : Pellets Colour : yellow Odour : odourless ph : Potential health effects Eyes : No harmful effects have been reported upon contact with the eyes. Skin : No harmful effects have been reported upon contact with skin Page 1/8

2 Ingestion : No harmful effects have been reported upon ingestion. Inhalation : No harmful effects have been reported upon inhalation. Carcinogenicity : Not listed by NTP, IARC, ACGIH, or OSHA as a carcinogen. 4. FIRST AID MEASURES Eyes : Flush eye(s) for 15 minutes or more; if irritation persists, consult a physician (preferably an eye specialist) and show MSDS. Skin : Remove contaminated clothing immediately. Wash off with soap and water. If irritation persists, consult a physician and show this data sheet. Ingestion : Drink large quantities of water. Do not induce vomiting. Consult a physician and show this data sheet. Inhalation : Remove individual from site of exposure and place in fresh air. If symptoms occur, seek medical attention and show this data sheet. 5. FIRE-FIGHTING MEASURES Flash point : > 356 F Method: TAG CC Suitable extinguishing media Extinguishing media which must not be used for safety reasons : foam, carbon dioxide, dry powder, water spray. : not applicable Products in case of fire : In the event of fire the following can be released: - carbon dioxide, carbon monoxide Special protective equipment for fire-fighters Hazardous decomposition products : As in any fire, wear self-contained breathing apparatus pressure-demand, (MSHA/NIOSH approved or equivalent) and full protective gear. : None with proper storage and handling Page 2/8

3 OSHA flammable class : Not Applicable 6. ACCIDENTAL RELEASE MEASURES Methods for cleaning up / taking up : Small spills : Control spill with adsorbant pads or booms, if necessary. Apply granular or loose sorbent to spill. When adsorbed, sweep or otherwise collect and dispose of properly. Release Notes : US regulations require reporting spills of this material that could reach any surface waters In case of accident or road spill notify : CHEMTREC USA CANUTEC Canada CHEMTREC (other countries) Telephone: (800) (613) (International code) HANDLING AND STORAGE General Procedures Handling Advice on protection against fire and explosion : Avoid formation of dust Storage Requirements for storage areas and containers : Keep only in original container. 8. EXPOSURE CONTROLS / PERSONAL PROTECTION Personal protective equipment General protective measures : Avoid contact with eyes and skin Page 3/8

4 Hygiene measures : No smoking, eating or drinking allowed when using this product. Wash hands before breaks and at end of work shift. No other precautions required. Respiratory protection : Respiratory protection is not required. Hand protection : PVC gloves Eye protection : Safety Goggles recommended for use. Protective clothing : protective clothing Engineering controls : Good general (mechanical) ventilation should be sufficient to control airborne levels. 9. PHYSICAL AND CHEMICAL PROPERTIES Form : Pellets Colour : yellow Odour : odourless Melting temperature : approx F Boiling temperature : not measured Weight per volume : 5.00 Lb/Gal Bulk density : approx. 600 kg/m3 ph : at 50 g/l Methanol/Water at 20 C Viscosity, dynamic : not applicable Evaporation rate : Unavailable Volatile organic compound : volatile in water: 4 % 10. STABILITY AND REACTIVITY Conditions to avoid : None with proper storing and handling Page 4/8

5 Hazardous reactions : No hazardous reactions with proper storage and handling. Hazardous polymerisation : No Stability : Yes Hazardous decomposition products : None with proper storage and handling. 11. TOXICOLOGICAL INFORMATION Acute oral toxicity : LD50 Species: rat Dose: > 2,000 mg/kg Method: OECD 401 Skin irritation : Species: rabbit non-irritant Method: OECD 404 Tested as 25 % solution Eye irritation : Species: rabbit non-irritant Method: OECD 405 Tested as 50 % solution Sensitization : Species: Guinea pig non-sensitizing Method: OECD 406 Note : The substance has no mutagenic activity (Ames Test) According to experience, the product is considered to harmless to health if handled in the correct manner 12. ECOLOGICAL INFORMATION Elimination information (persistence and degradability) Biological degradability : > 95% Method: OECD 301 D Ecotoxicity effects Toxicity to fish : LC50 Species: gold orfe Dose: 3.1 g/l Method: OECD Page 5/8

6 Toxicity to bacteria : EC10 Dose: > 10 g/l Method: DIN T.27 Further ecological information Ecological notes : The product is considered to be a weak water pollutant (German law). Do not allow to enter soil, waterways or waste water canal. 13. DISPOSAL CONSIDERATIONS Dispose of in accordance with local, state, and federal regulations. Product disposal and disposal requirements : In accordance with local authority regulations, take to special waste incineration plant Contaminated packaging : If empty contaminated containers are recycled or disposed of, the receiver must be informed about possible hazards. 14. TRANSPORT INFORMATION Sea transport IMDG: Air transport ICAO/IATA: DOT (Department of Transportation) CFR Road: CFR Rail: CANADA Transport of Dangerous goods TDG Road: Page 6/8

7 TDG Rail: 15. REGULATORY INFORMATION United States SARA Section 311/312 : Fire: No Pressure generating: No Reactivity: No Acute: No Chronic: No SARA Sections : SECTION 313 Notification : No This product contains no SARA Title III, Section 313 listed chemicals. SARA Sections : SARA EHS Notification : No Notification Status : TSCA Notification : No All components of this product are not TSCA registered. California Proposition 65 Statement : Notification : No This product does not contain any substance(s) which are defined by the state of California to cause cancer, birth defects, or other reproductive effects Page 7/8

8 Canada : WHMIS CLASSIFICATION Non-WHMIS Notification Status : Canadian Environmental Protection Act DSL Notification : Yes All intentional ingredients are listed on the DSL (Domestic Substance List) or have been notified pursuant to the NSN regulations. CTFA : CTFA regulation: All components of this product are INCI (CTFA) registered. Cosmetic use only. 16. OTHER INFORMATION HMIS Codes : Fire : 1 Health : 1 Physical Hazard : 0 Protection : X Manufacturer disclaimer : While the information and recommendations contained herein are believed to be accurate, we make no warranty with respect hereto and disclaim all liability from reliance thereon Page 8/8