LOW ENERGY SPENT WASH CONCENTRATION FOR GRAIN BASED DISTILLERY. Presented by Team ROCHEM
|
|
- Agatha Harris
- 6 years ago
- Views:
Transcription
1 LOW ENERGY SPENT WASH CONCENTRATION FOR GRAIN BASED DISTILLERY Presented by Team ROCHEM
2 ROCHEM INDIA - MISSION Changing the Face of Water & Waste Water Treatment!
3 The Challenge High to very High TSS in Spent wash Very Fine Particles High COD, less compare to molasses spent wash TDS quite low compare to molasses spent wash TDS post integrated evaporator is slightly high but still treatable through RO System
4 The Solution Need of the Hour Spent was need the treatment for removal of TSS and very fine particle Advance DAF is an answer to it. Concentrate spent wash volume at lowest energy input cost i.e. ROCHEM PT RO. Maximum Resource Conservation (Water Re-use) Concentrated spent wash can be further concentrated through evaporator and dryer for solidification of TDS.
5 Why the solution was not implemented yet Due to absence technology which can offer proven results. Due to non availability of commercial scale plant/pilot plant to check treatability study. Evaporator route was working fine although it was an expensive affair. ROCHEM s Advance DAF is an answer to all the above.
6 GEM System ROCHEM in exclusive Technical collaboration with Clean Water Technology USA, brings CWT's innovative flocculation and floatation unit is a unique approach and feed TSS reduction in cases with small and light TSS with high loads such as in the Distillery sector for Grain & Molasses based effluents. The Gas Energy Mixing (GEM) System can generate better results, handle a much greater contaminant loading, adapt to flow changes and produce much drier solids with a much smaller footprint and using less chemicals than typical DAF systems. Confidential
7 Confidential GEM System
8 GEM SYSTEM Bubble Attachment Method Gas is dissolved into 100% of the stream first. Gas is homogeneously mixed into the waste water before floc structure is formed. The dissolved gas comes in contact with the particles before it even becomes a bubble. The smaller the bubble the smallest particles will be attached. Confidential
9 Bubble Attachment Method More Bubbles Smaller Bubbles Better Bubbles & Better Results Confidential
10 Results on Grain Based spentwash after Decanter Possible to Install RO now with >70% Recovery!
11 The Scheme Spent was from Distillery Advance DAF for Removal of TSS ROCHEM PT RO (low cost spent wash concentration) Evaporator + Dryer (solidification) Detail Techno Commercial Case Study can be prepared on case to case basis depending upon geographical tertiary.
12 Concerns / limitations of Distillery Steam cost is high or non-availability of low cost steam unlike molasses based distillery Non availability of bagasse Non availability of biogas All the above factors will lead to high steam cost resulting in high cost for evaporator operations.
13 The Solution for Molasses Based Distillery 1. CONTINUOUS PRODUCT DEVELOPMENT High Pressure-RO 2. COST EFFECTIVE SOLUTIONS ROSERVE our pay per use concept
14 1. PT(HP)-RO! High Pressure 75, 90, 120 & 225 Bar RO Systems
15 ROCHEM High Pressure-RO Systems PT(HP)-RO An Overview A few advantages of Rochem PT(HP)-RO systems are as follows: 1. Reduction in costs for the thermal systems Rochem PT(HP)-RO system can be applied on existing RO rejects thereby further reducing the final volume of effluent to be treated for disposal. 2. Reduction in steam consumption As HP-RO gives a more concentrated reject at further reduced volumes, the steam consumption is reduced. 3. Lower operating/ treatment cost of HP-RO systems Lesser power requirement & no steam consumption. Treatment costs can be drastically reduced due to absence of need for operating fuel and lower power costs.
16 ROCHEM High Pressure-RO Systems PT(HP)-RO: An Overview 4. Compact and modular construction of the membrane system The unique design offers versatile features like smaller foot print, ease in handling, replicability and isolation in case of fault. 5. No thermal stress Handling higher volumes of RO reject effluents by HP-RO systems is easier and with no frequent mechanical & process failures.
17 What is ROSERVE? 2. ROSERVE! SERVICE CONCEPT! Customer Buys nothing. Customer defines Service need and scope. Customer only enters into a Service Agreement. ( Min 3 to Max 6 year tenure) Rochem brings to site, best suited Plant & Machinery RO/MEE/Compost/Dryers/Others to meet the Service Need. Client undertakes Civil works ( limited due containerised equipment) Rochem operates the equipment and provides the Customer the Service of Reducing Spentwash volume Customer pays Rochem agreed Service charges per m3 of Volume reduced.
18 2. ROSERVE! Customer Upfront Capital Investment is NIL (only outflow is security deposit) Customer Pays only for What He Gets. Technology, Performance, Obsolescence, Upgrade ALL RISK OF ROCHEM! Customer can focus Investment into Distillery, rather than ETP!
19 We have now achieved Overall 70 80% Water Recovery from BMSW..!!
20 Case Study Background Plant Installed Input Recovery Rate Distillery Bio Methanated Effluent Rochem PT-RO + PT(HP)-RO system (Micro Processor controlled, Fully Fail safe and Unattended Operation) 800 cum/day at 8 brix max. of BME as input. 53.5% 26.88% Total 66% Further recovery enhancement can be achieved by using higher pressure systems at 120 bar & 220 bar depending on brix value of BME.
21 Case Study Parameters Unit Input to PT-RO Stage-1 Input to PT(HP)-RO Stage-2 Feed Flow cum/day Inorganic TDS ppm < 25,000 < 50,000 Brix ppm < 8 < 14 TSS ppm <3,000 <3,000 Temperature C Operating pressure bar Recovery as % of feed % Permeate cum/day Reject cum/day
22 What does ROCHEM offer for ZLD today? Upcoming Concepts... WHE (Waste Heat Evaporators) Solar Thermal heat assisted Evaporators Others
23 Let us join hands to.. achieve Zero Discharge.. conserve large quantity of water.. conserve Energy.. conserve Capex.. preserve the Environment Please call or write to us at : Tel : Cell : Web : / enquiry@rochemindia.com rochem@rochemindia.com
ROCHEM RESPONDS TO THE NEED OF THE INDUSTRY! INNOVATIVE PRODUCTS & COST EFFECTIVE SOLUTIONS. Presented by Team ROCHEM
ROCHEM RESPONDS TO THE NEED OF THE INDUSTRY! INNOVATIVE PRODUCTS & COST EFFECTIVE SOLUTIONS Presented by Team ROCHEM ROCHEM INDIA - MISSION Changing the Face of Water & Waste Water Treatment! INNOVATIVE
More informationRohan M. Patil NIRTECH Pvt. Ltd., Mumbai. ALL INDIA DISTILLERS ASSOCIATION TECHNICAL SEMINAR, NEW DELHI Date : 19 th February, 2016
Rohan M. Patil NIRTECH Pvt. Ltd., Mumbai ALL INDIA DISTILLERS ASSOCIATION TECHNICAL SEMINAR, NEW DELHI Date : 19 th February, 2016 Objectives of Distilleries Achieve ZSD Zero Spent Wash Discharge Have
More informationDR. SANJAY V. PATIL HEAD AND TECHNICAL ADVISER DEPARTMENT OF ALCOHOL TECHNOLOGY VASANTDADA SUGAR INSTITUTE, MANJARI, PUNE (INDIA)
DR. SANJAY V. PATIL HEAD AND TECHNICAL ADVISER DEPARTMENT OF ALCOHOL TECHNOLOGY VASANTDADA SUGAR INSTITUTE, MANJARI, PUNE (INDIA) Email: sv.patil@vsisugar.org.in AIDA Technical Seminar www.vsisugar.com
More informationOsmoBC Integrated Membrane Systems
OsmoBC Integrated Membrane Systems For Industrial Wastewater Treatment Fluid Technology Solutions, Inc. OsmoF2O FO Membranes HBCR High Brine Concentrator OsmoZLD Treatment Process INTEGRA Disk Filtration
More informationEffluent Treatment Methods And Reverse Osmosis and its Rejects Handling
Effluent Treatment Methods And Reverse Osmosis and its Rejects Handling Dr P P Lal Krishna Chief Executive Officer Ramky Pharma City (India) Ltd Developer of Jawaharlal Nehru Pharma City - Vizag TREATMENT
More informationEnergy-Efficient Textile Dyeing Effluent Recycling
Efficient Effluent Recycling Jai Swaminathan 1 Energy-Efficient Textile Dyeing Effluent Recycling Jaichander Swaminathan Prof. John H. Lienhard V Dept. of Mechanical Engineering Problem: Cheap Zero Discharge
More informationWaste Management Waste Heat Evaporator for RO Reject Management Bosch Limited Nashik Plant
1 Waste Management Waste Heat Evaporator for RO Reject Management Bosch Limited Nashik Plant Background Need for the Project Requirement of low cost & optimized solution for RO reject handling Trigger
More informationAmendment required in the existing EC
Amendment required in the existing EC Change/Addition in Phase I; 250 KLPD Grain based Distillery with 20 MW Co-gen Power Plant / Molasses 160 KLPD based distillery with 12 MW Co-gen Power Plant in Environmental
More informationTITLE : ZERO LIQUID DISCHARGE TECHNOLOGIES & ECONOMICS
TITLE : ZERO LIQUID DISCHARGE TECHNOLOGIES & ECONOMICS Author : Soham Mehta Managing Director Advent Envirocare Technology Pvt. Ltd. A-1, 8th Floor, Safal Profitaire, Corporate Road, Prahaladnagar, Ahmedabad
More informationPretreatment of Industrial Wastewater for ZLD/Resources Recovery
Pretreatment of Industrial Wastewater for ZLD/Resources Recovery An Application of Oxidative Evaporation Technology Philip Chen, PhD, P.E. O E Technology, LLC Info@oetech.com 1 Process Plant Bio-Unfit
More informationBiothane Anaerobic Technology Memthane 2.0 WATER TECHNOLOGIES
Biothane Anaerobic Technology Memthane 2.0 WATER TECHNOLOGIES State-of-the-art solution Memthane is an Anaerobic Membrane Bio-Reactor (AnMBR) which maximizes renewable energy production while producing
More informationwww.regreenexcel.com Excel Engineers & Consultants, Pune INDIA Welcomes You To AIDA 2 Days Technical Seminar 26 th & 27 th March 2018 www.regreenexcel.com Sheer Excellence! Pioneering Technology E-max
More informationZERO LIQUID DISCHARGE The Ultimate Challenge Fluor. All rights reserved. FLUOR is a registered service mark of Fluor Corporation.
ZERO LIQUID DISCHARGE The Ultimate Challenge 2015 Fluor. All rights reserved. FLUOR is a registered service mark of Fluor Corporation. 1 Agenda Introduction Drive towards ZLD Block Flow Diagram Fluor s
More informationCooling Tower Blowdown Treatment and Reuse in a Coal Fired Power Plant in India - Reducing the water footprint in coal fired power plants -
Powergen Bangkok 3 rd October 2103 Session 5 Intake, Cooling and Blowdown Treatment Considerations Cooling Tower Blowdown Treatment and Reuse in a Coal Fired Power Plant in India - Reducing the water footprint
More informationZERO LIQUID DISCHARGE CONCEPT, WATER REUSE : REGULATORY REQUIREMNTS
ZERO LIQUID DISCHARGE CONCEPT, WATER REUSE : REGULATORY REQUIREMNTS Dr.M.Madhusudanan Central Pollution Control Board madhu1960@gmail.com 08745057374 DISTILLERIES NATIONAL SCENARIO There are around 505
More informationZero Discharge for Textile Industry
Zero Discharge for Textile Industry C K Sandeep, General Manager Corporate Marketing, Ion Exchange (India) Ltd. Introduction The post liberalization period has led to the rapid growth of industrial output
More informationBiothane Anaerobic Technology Memthane 2.0
Biothane Anaerobic Technology Memthane 2.0 WATER TECHNOLOGIES State-of-the-art solution Memthane is an Anaerobic Membrane Bio-Reactor (AnMBR) which maximizes renewable energy production while producing
More informationBiothane Anaerobic Technology Memthane 2.0
Biothane Anaerobic Technology Memthane 2.0 Memthane step-by-step Anaerobic digestion plus cross-flow membranes After equalization, highstrength wastewater is conditioned as needed. Influent is fed to the
More informationPURPOSE PROCESS PAYOFF
Water Reuse 4/04/13 PURPOSE PROCESS PAYOFF Water Water Everywhere but not a drop to drink! Seawater versus Water Reuse UF - RO for brackish waste water streams: 0.81.2 kw h/m3 MBR RO for brackish waste
More informationTreatment of Distillery Spent wash. Babu Alappat Professor Department of Civil Engineering I.I.T Delhi.
Treatment of Distillery Spent wash Babu Alappat Professor Department of Civil Engineering I.I.T Delhi bjalappat@yahoo.com Problems with Anaerobic Systems Requirement of polishing Uncertainity involved
More informationZero Liquid discharge for the Industrial sector. by Amit Udgirkar Sr. Manager Environmental Engineering Praj Industries Ltd
Zero Liquid discharge for the Industrial sector by Amit Udgirkar Sr. Manager Environmental Engineering Praj Industries Ltd Major Concerns... Where is the space for process plant??? Reduce Foot Print Major
More informationLATEST GUIDELINES & DIRECTIVES OF POLLUTION BOARDS FOR DISTILLERS VIDE THEIR CIRCULAR DATED 2 nd JUNE 2017
By K.P.SINGH LATEST GUIDELINES & DIRECTIVES OF POLLUTION BOARDS FOR DISTILLERS VIDE THEIR CIRCULAR DATED 2 nd JUNE 2017 1. Distilleries to install Online Mass Flow Measurement with online data transfer
More informationWater Reuse and. Gasification Technologies Conference 2011
Water Reuse and ZLD Technologies Gasification Technologies Conference 2011 Presentation Traditional Wastewater Management Strategy Water Recycle and Re use Conventional Industrial Wastewater Treatment
More informationNovel Memthane Anaerobic MBR realizing sustainable ambitions. Frankfurt; June 19, 2012; 11:30 Jan Pereboom and Jeroen van der Lubbe
Novel Memthane Anaerobic MBR realizing sustainable ambitions Frankfurt; June 19, 2012; 11:30 Jan Pereboom and Jeroen van der Lubbe Contents 1. Introduction 2. Drivers for AnMBR 3. Novel Memthane technology
More informationNadeem Shakir Qatar Petroleum. The 2nd Joint Qatar Japan Environmental Symposium, QP JCCP The 21st Joint GCC Japan Environmental Symposium
Nadeem Shakir Qatar Petroleum Scheme of Presentation General Overview of QP Refinery, Mesaieed. Challenges in Treatment Existing Waste Water Treatment Facilities Capacity Expansion and Upgradation of WWTP
More informationWASTE WATER RECYCLE MANAGEMENT ION EXCHANGE INDIA LTD
WASTE WATER RECYCLE MANAGEMENT ION EXCHANGE INDIA LTD Blue Issues Scarcity & rising costs Drought Pollution Tremendous pressure on available finite water resources due to Rapid industrialisation, Expanding
More informationProven Solutions for the Most Challenging Wastewaters
Proven Solutions for the Most Challenging Wastewaters Fluid Technology Solutions, Inc. Fluid Technology Solutions (FTS) is a global leader in water treatment technology, providing innovative and proven
More informationCooling Tower Blowdown Treatment and Reuse in a Coal Fired Power Plant in India Reducing the water footprint in coal fired power plants
Cooling Tower Blowdown Treatment and Reuse in a Coal Fired Power Plant in India Reducing the water footprint in coal fired power plants Author name Deepak Kachru Company Aquatech Systems (Asia) Pvt. Ltd.
More informationFLAGSHIP DHAKA CETP (BD) LTD DHAKA EXPORT PROCESSING ZONE CENTRAL ETP
FLAGSHIP DHAKA CETP (BD) LTD DHAKA EXPORT PROCESSING ZONE CENTRAL ETP ECC ENHANCEMENT FROM 21,000M3/DAY DEPARTMENT OF ENVIRONMENT 2017 o 1 ST FOREIGN OWNED & OPERATED CETP UNDER PMO o PROVIDES FOREIGN
More informationSonoran CryoDesal LLC Freeze Desalination: non-membrane desalination technology for difficult water / wastewater streams.
Sonoran CryoDesal LLC Freeze Desalination: non-membrane desalination technology for difficult water / wastewater streams July 17, 2017 1 CryoDesalination: When RO Is Not a Good Option Reverse Osmosis (RO)
More informationZero Liquid Discharge for Water Remediation. Bill Berzins, M.A.Sc. P.Eng.
Zero Liquid Discharge for Water Remediation Bill Berzins, M.A.Sc. P.Eng. Zero Liquid Discharge Strategy Technology Selection Case Studies Recommendations Project Portfolio: Design-Build-Operate-Transfer
More informationZero Liquid discharge for the Industrial sector
Zero Liquid discharge for the Industrial sector 22.04.2014 Major Concerns... Where is the space for process plant??? Reduce Foot Print Major Concerns... Can I use treated wastewater somewhere??? Recycle
More informationRecycling of Food Processing Wastewater to Potable Water Standards
Recycling of Food Processing Wastewater to Potable Water Standards The issues surrounding wastewater recycling in the food and drinks sector are generally well known. Over the past ten years a UK owned
More informationidraflot.com Multi DAF Technology WATER TECHNOLOGIES
idraflot.com Multi DAF Technology WATER TECHNOLOGIES Technology An innovative and effective Flotation is a physical process where water is separated from the suspended solids to be reused. Stable suspended
More informationZLD solution for Pharmaceutical Industry
ZLD solution for Pharmaceutical Industry Hemant Wagh Associate Vice President Water & WW solutions Group Major Concerns... Where is the space for process plant??? Can I generate/save energy??? Can I use
More informationPresenter Allan McMurray Conestoga-Rovers & Associates (CRA)
Presenter Allan McMurray Conestoga-Rovers & Associates (CRA) Presentation Pilot Scale Study Removal of Uranium, Radium-226 and Arsenic from Impacted Leachate by Reverse Osmosis Session: Stream B - Innovative
More informationdischarge summary system design
liquid discharge ZLDzero summary system design ZLD TECHNOLOGY S.M.A.R.T. Z PROCESS TM S.M.A.R.T. Z PROCESS TM Zero Liquid Discharge (ZLD) is the ultimate cutting-edge process for the total elimination
More informationHow A Vertical Tube Falling Film Evaporator Can Be Used to Deliver the Lowest Total Life Cycle Cost for Alberta Produced Water Treatment
How A Vertical Tube Falling Film Evaporator Can Be Used to Deliver the Lowest Total Life Cycle Cost for Alberta Produced Water Treatment Overview Minimizing Installation Costs Evaporator Pilot Program
More informationWater supplied by Marafiq does not meet the process requirements.
WATER TREATMENT In Industries Water is used for: a. Drinking b. Cleaning c. Cooling d. Producing Steam e. Process requirement Why we need to treat water? For human consumption a. Water to be purified (Make
More informationSOLIDS REMOVAL SYSTEMS IN WASTEWATER TREATMENT TIME FOR SOME AGILE THINKING
SOLIDS REMOVAL SYSTEMS IN WASTEWATER TREATMENT TIME FOR SOME AGILE THINKING Dr Chris Bullen, Technical Manager & Rich Matthews, General Manager Siltbuster Process Solutions Abstract Solids removal systems
More information"Significant Cost Savings Obtained Using Advanced Membrane Systems for Cooling Tower Water Treatment and in ZLD plants
Better Lives. Better Planet.SM "Significant Cost Savings Obtained Using Advanced Membrane Systems for Cooling Tower Water Treatment and in ZLD plants Webcast December 2012 Bernhard Doll Pall GmbH Disclaimer
More informationZero Liquid Discharge for Pharma Challenges & Solutions
Zero Liquid Discharge for Pharma Challenges & Solutions 5.02.2013 1 Green Chemistry Water & Wastewater Solution www.praj.net 2 Effluent Composition Solvents Methanol MDC ACN IPA Toluene Acetone Ethanol
More informationCLEANING UP GANGA RIVER HOW EASY IS IT?
CLEANING UP GANGA RIVER HOW EASY IS IT? WWW.GANGAACTION.ORG PREPARED BY KIRAN PANDYA TECHNICAL CONSULTANT WATER TREATMENT PROJECTS GANGA ACTION PARIVAR For questions email: pandyaken@gmail.com Introduction
More informationDISSOLVED AIR FLOTATION (DAF)
ECOLOGIX Ecologix Environmental Systems, LLC 5100 Old Ellis Point Roswell, GA 30076 Toll Free: 888-326-2020 Tel: 678-514-2100 Fax: 678-514-2106 Email: info@ecologixsystems.com Web Site: www.ecologixsystems.com
More informationLeopold Desalination Pretreatment Systems
Leopold Desalination Pretreatment Systems Reliable Protection from Membrane-Fouling, Performance-Inhibiting Seawater Contaminants Why Leopold for Your Desalination Pretreatment Solution? Leopold desalination
More informationMembrane BioReactor: Technology for Waste Water Reclamation
Membrane BioReactor: Technology for Waste Water Reclamation Sachin Malekar - Senior Manager, Technology & Nilesh Tantak - Executive, Technology Ion Exchange (India) Ltd. BACKGROUND Due to diminishing water
More informationTurn waste into value. Industrial water and waste treatment solutions
Turn waste into value Industrial water and waste treatment solutions Turn waste into value Most industrial processes consume lots of water and generate waste that needs to be treated to meet tough legislation
More informationcost of ownership total cost ownership per year $764 $1,322 cost of ownership per m3 $0.87 $1.51 EWP is 42% less than RO
WHY EWP vs RO I am seeking to introduce a new water purification technology. It s a form of capacitive deionization called EWP (Electronic Water Purification). The time has come for a change. We have been
More informationAquaporin Inside Forward Osmosis Technology
Aquaporin Inside Forward Osmosis Technology WHAT IS FORWARD OSMOSIS (FO)? solution Low osmotic pressure (low TDS) Draw solution (high TDS) Aquaporin Inside FO is a gentle process that transports water
More informationREQUIREMENTS FOR AMENDMENT IN ENVIRONMENTAL CLEARANCE JUSTIFICATION FOR MODIFICATION IN THE SCHEME FOR SPENT WASH HANDLING IN THE DISTILLERY PLANT
AMENDMENT IN ENVIRONMENTAL CLEARANCE GRANTED BY MINISTRY OF ENVONMENT AND FORESTS, NEW DELHI VIDE FILE NO. J-11011/773/2007 IA II (I) DATED 16 TH JANUARY, 2008 REQUIREMENTS FOR AMENDMENT IN ENVIRONMENTAL
More informationNTPC NETRA's Conference on R&D for Energy Sustainability
NTPC NETRA's Conference on R&D for Energy Sustainability NETRA Presentation on Non-chemical Technology for High COC Operation with Scale Inhibition for achieving ZLD 31 st March 2016 SCALE-BAN TM A Sustainable
More informationWastewater Reuse in Combined Cycle Power Plants Behrang (Ben) Pakzadeh, PhD, PE
Wastewater Reuse in Combined Cycle Power Plants Behrang (Ben) Pakzadeh, PhD, PE 2017 OUTLINE Introduction Water Use in CCGT Power Plants Reducing Water Consumption Power Plant Example 3-1x1 CCGT units
More informationWaste Water Treatment Technologies and Practices in Indian Pulp and Paper Industries
Waste Water Treatment Technologies and Practices in Indian Pulp and Paper Industries Dr. B. P. Thapliyal Director Central Pulp & Paper Research Institute Saharanpur -247001 (U.P.) INDIA Email : bipin_thapliyal@yahoo.com
More informationProcess Water and Wastewater Treatment. for the Food and Beverage Industry WATER TECHNOLOGIES
Process Water and Wastewater Treatment for the Food and Beverage Industry WATER TECHNOLOGIES Industries Served > > Food Processing > > Beverage Production > > Breweries > > Wineries > > Distilleries >
More informationDevelopments in Anaerobic treatment of F&B wastewaters
Developments in Anaerobic treatment of F&B wastewaters More biogas at lower investment and operating costs 3 rd European Food Manufacturing & Safety Summit 2013 Noordwijk; February 11/12 Jan Pereboom Veolia
More informationInternational Journal of Science, Environment and Technology, Vol. 4, No 5, 2015,
International Journal of Science, Environment and Technology, Vol. 4, No 5, 2015, 1330 1335 ISSN 2278-3687 (O) 2277-663X (P) TREATABILITY STUDY METHODOLOGY & APPLICATION Ms. Seema A. Nihalani Head and
More informationMEMBRANE BIOREACTOR NIHAR DOCTOR. Director
TM MEMBRANE BIOREACTOR NIHAR DOCTOR Director en-vısı n Enviro Technologies Pvt. Ltd. (Pollution Control Consultants & Engineers) Shree Ram Complex, 2 nd Floor, Above Bank Of India, Near Kargil Chowk, Surat
More informationProcessing Distillery MEE Condensate as an Energy Source with Water Recycle
Processing Distillery MEE Condensate as an Energy Source with Water Recycle All India Distillers Association Annual Conference 2018 Arvind Lali 1, Hitesh Pawar 1, Sukhraj Soni 2 1 DBT-ICT Centre for Energy
More informationBOOMERANG FROM BIO-EFFLUENT TO POTABLE WATER
BOOMERANG FROM BIO-EFFLUENT TO POTABLE WATER FROM BIO-EFFLUENT TO POTABLE WATER Waterleau uses state of the art membrane technology for closing the loop in the water cycle. A double barrier membrane concept
More informationDetermination of Kinetic Coefficients for Secondary Aerobic Treatment of Digested Spentwash based on COD Analysis
Determination of Kinetic Coefficients for Secondary Aerobic Treatment of Digested Spentwash based on COD Analysis Shrenik T Patil Asst Prof, FCivil, College of Military Engineering, Pune, India,411031
More informationNew anaerobic technologies More biogas at lower costs
New anaerobic technologies More biogas at lower costs Jan Pereboom Wastewater, greener and more cost effective Aquavakbeurs, Gorkum, 20 maart 2013 Contents 1. Introduction 2. Novel granular technology:
More informationFlocculation Flotation Pretreatment Improves Operation of MBR Installed to Treat Snack Food Manufacturing Wastewater
Flocculation Flotation Pretreatment Improves Operation of MBR Installed to Treat Snack Food Manufacturing Wastewater *Miroslav Colic 1, Jack Hogan 1, Ariel Lechter 1 1 Clean Water Technology Inc. *To whom
More informationCarbon Electrodes for the Electro Accumulation of Potassium from Distillery Spentwash
Carbon Electrodes for the Electro Accumulation of Potassium from Distillery Spentwash Eknath Alhat 1, Vishal Duraphe 2 Dr. Deepali Nimbalkar 3 and Vikram Ghole 4 Research Assistant, Department of Environmental
More informationFrom Zero to Hero: Adoption of Zero Liquid Discharge across Industries
From Zero to Hero: Adoption of Zero Liquid Discharge across Industries Abhirabh Basu Research Associate The Great Energy Transition June 1, 2017 Agenda The problem with liquid discharge Making a case for
More informationMEMBRANE BIO-REACTOR. Prashanth N 1 1. INTRODUCION
International Journal of Latest Trends in Engineering and Technology Vol.(7)Issue(3), pp. 296 301 DOI: http://dx.doi.org/10.21172/1.73.540 e ISSN:2278 621X MEMBRANE BIO-REACTOR Prashanth N 1 ABSTRACT:
More informationA new HP version of Lurgi s FBDBTM gasifier is bringing more value to clients
A new HP version of Lurgi s FBDBTM gasifier is bringing more value to clients 2011 Max-Michael Weiss Air Liquide E&C/ Lurgi GmbH, Frankfurt, Germany GAP Conference Beijing 2011 Outline AIR LIQUIDE Group
More informationU-Version. Incoming City Water
Ultra-Flo U-Version Ultra-Flo is a hollow-fibre based membrane filtration product. This filtration process covers the ultrafiltration range of between 0.1 to 0.01 micron. It is designed to remove suspended
More informationSTW Water Process & Technologies! A Water Solutions Company!
STW Water Process & Technologies! A Water Solutions Company! Processing and Zero Liquid Discharge of Seawater, Brackish Water, Flowback & Produced Water STW/Salttech- July 2014 Midland, Texas STW/Salttech
More informationLowering The Total Cost Of Operation
Lowering The Total Cost Of Operation The system removes more solids than conventional clarification, so filters can run longer between backwash cycles. Fewer backwash cycles means less backwash water,
More informationSOIL WASHING PLANT TRANSPORTABLE CONTAMINANTS FROM SOIL CONTAMINANTS OUT OF WASTE MATERIALS. / Coarse-grained soil / Coarse-grained waste materials
TRANSPORTABLE SOIL WASHING PLANT REMOVING CONTAMINANTS FROM SOIL FLUSHING CONTAMINANTS OUT OF WASTE MATERIALS / Coarse-grained soil / Coarse-grained waste materials PROCESS FLOW DIAGRAM Soil feeding unit
More informationREPORT TREATABILITY STUDIES, FEASIBILITY REPORT FOR TREATMENT OF WASTE WATER FOR. M/s DEEPAK NITRITE LTD., MIDC Taloja
REPORT ON TREATABILITY STUDIES, FEASIBILITY REPORT FOR TREATMENT OF WASTE WATER FOR M/s DEEPAK NITRITE LTD., MIDC Taloja January -- 2017 PREPARED BY Goldfinch Engineering Systems Private Limited Plot No.
More informationTreatment and Reuse of Tannery Waste Water by Embedded System
Modern Applied Science January, 2009 Treatment and Reuse of Tannery Waste Water by Embedded System S.Krishanamoorthi (Corresponding author) Dept. of Civil Engineering Kongu Engineering College, Perundurai,
More information"Desalination the past, present and potential future technologies" Ali Ben Haj Hamida Engineered Systems Commercial Leader, MENA
"Desalination the past, present and potential future technologies" Ali Ben Haj Hamida Engineered Systems Commercial Leader, MENA 1 Presentation Outline Past: > Market Drivers > Key Technologies Present:
More informationADI ANAEROBIC MEMBRANE BIOREACTOR (AnMBR)
REACTION TANKS ADI ANAEROBIC MEMBRANE BIOREACTOR (AnMBR) SUPERIOR TREATMENT SOLUTION FOR HIGH-STRENGTH WASTEWATER THE TECHNOLOGY The ADI anaerobic membrane bioreactor (AnMBR) is the latest innovation in
More informationImportant Elements for successful biogas projects. Steve Brewster
Important Elements for successful biogas projects Steve Brewster Webinar - May 2015 1 IDENTIFY DRIVERS Energy extraction Regulatory compliance Landfill Minimisation Green House Gas control Environmental
More informationProcess Water and Wastewater Treatment. for the Food and Beverage Industry WATER TECHNOLOGIES
Process Water and Wastewater Treatment for the Food and Beverage Industry WATER TECHNOLOGIES Industries Served > > Food Processing > > Beverage Production > > Breweries > > Wineries > > Distilleries >
More informationKings Industries.
+91-8071806332 Kings Industries https://www.kingsenvirotech.com/ We Kings Industries are among the reliable manufacturer and exporter of technologically advanced ETP, Industrial Evaporators, Industrial
More informationHorizontal Falling Film Brine Concentrator
Horizontal Falling Film Brine Concentrator The 3rd International Sede Boqer Conference on Water Technologies, 2012: Advanced Technologies in Water Management Tuesday 16 October 2012 Dr. Yony Weiss, VP,
More informationIntegrated Water & Wastewater Treatment Solutions Extending Nature s Capacity
Integrated Water & Wastewater Treatment Solutions Extending Nature s Capacity www.aqwise.com OVerVieW Aqwise is a world leader in the development and implementation of innovative water and wastewater treatment
More informationFILTER CLEAR VESSEL FCV
FOUR MEDIA FILTRATION IN SINGLE VESSEL High Performance Multimedia Filtration FILTER CLEAR VESSEL FCV EUREKA FORBES LIMITED Head Office: B1/B2, 701 Marathon Innova, Off Ganpatrao Kadam Marg, Lower Parel,
More informationTechnology for Water
Technology for Water Waste Water Solutions Municipal Industrial www.tseco.in klkl Today the world is witnessing ever growing demand in water consumption facing with a diminishing supply due to acute decrease
More informationPacific States Water, Inc. Solution for the Treatment and Recovery of Oil & Gas Produced Water
Pacific States Water, Inc. Solution for the Treatment and Recovery of Oil & Gas Produced Water The safe and sustainable treatment of its processed water remains a priority for the Oil & Gas industry. Increased
More informationAddressing increasing wastewater volumes in industrial and oil & gas operations using thermal systems
Water Arabia 2013 Conference & Exhibition Innovative Water and Wastewater Technologies for a Sustainable Environment 4 to 6 February, 2013 Le Meridien Khobar, Saudi Arabia Addressing increasing wastewater
More informationBiotechnological Solutions on Wastewater & Solidwaste Management
MAKE INDIA CLEAN Biotechnological Solutions on Wastewater & Solidwaste Management Wastewater Systems Installation, Upgradation, Replacement, Services & Chemicals. www.hindagrochem.com Company Introduction
More informationTreatability Study and Reverse Osmosis Pilot Study of Industrial Wastewater at a Wood Products Mill
Treatability Study and Reverse Osmosis Pilot Study of Industrial Wastewater at a Wood Products Mill NC AWWA-WEA 2017 Annual Conference Randall Foulke, PE, BCEE, LEED AP Tracey Daniels, EI November 14,
More informationAdvances in Media Filtration
Advances in Media Filtration By Chad Felch Water Arabia 2015, Al Khobar, Saudi Arabia 19 Feb 2015 Siemens AG 2014. All rights reserved. Meeting New Challenges with an Old Technology Walnut Shell Filtration
More informationCLEANER PRODUCTION, A SUSTAINABLE STRATEGY FOR THE SMALL SCALE INDUSTRIES-A LITERATURE REVIEW
CLEANER PRODUCTION, A SUSTAINABLE STRATEGY FOR THE SMALL SCALE INDUSTRIES-A LITERATURE REVIEW Dixita Vyas 1 ME Environmental, Sarvajanik college of engineering and technology, Surat, Gujarat, India 1 Abstract:
More informationCarden. CARDEN WATER SYSTEMS, LLC 3440 E. Broadway Phoenix, Arizona Water Systems. Industry Applications
Carden Water Systems Industry Applications CARDEN WATER SYSTEMS, LLC 3440 E. Broadway Phoenix, Arizona 85040 Carden-A New Competitive Advantage CARDEN Water Systems, LLC (CWS), an Arizona LLC, is based
More informationVSEP Membrane Filtration of Table Olive Wastewater
VSEP Membrane Filtration of Table Olive Wastewater New Logic Research manufactures a proprietary vibrating membrane filtration system that is uniquely suited for treatment of all kinds of wastewater generated
More informationSelenium Removal from Scrubber Water VSEP RO membrane treatment for water reuse
Selenium Removal from Scrubber Water VSEP RO membrane treatment for water reuse Flue Gas Scrubber When coal is burned to make energy, a flue gas is produced that must be exhausted. This flue gas contains
More informationAdvances in media filtration. Leveraging advanced filtration media with a high oil loading capacity to improve water treatment
Advances in media filtration Leveraging advanced filtration media with a high oil loading capacity to improve water treatment Siemens AG 2015. 2014. All rights reserved. Meeting new challenges with an
More informationWATER RECYCLING PLANT IN WAFRA. Feras Al Salem
WATER RECYCLING PLANT IN WAFRA Feras Al Salem Introduction 2 The Joint Operations (JO) was born in 1960 when the two oil companies formed a joint committee to oversee and supervise their operations with
More informationAppendix C. Chemical Extraction Bench-Scale Study Evaluation
Appendix C Chemical Extraction Bench-Scale Appendix C Chemical Extraction Bench-Scale Response to EPA Interim Comments on CMS Report Appendix C Chemical Extraction Bench-Scale Housatonic River Rest of
More informationIntroduction. Membrane Filtration
Introduction The current trend in the papermaking industry is toward closed-loop water circuits resulting in greatly reduced or eliminated effluent discharge to the environment. There are several difficulties
More informationTechnologies and Methods for Treatment of Wastewater from O&G Exploration and Production: Limitations, Economics, and Reuse Opportunities
Technologies and Methods for Treatment of Wastewater from O&G Exploration and Production: Limitations, Economics, and Reuse Opportunities Tzahi Y. Cath, Ph.D. Colorado School of Mines Department of Civil
More informationL EADER IN S EPARATION T ECHNOLOGIES
L EADER IN S EPARATION T ECHNOLOGIES MEMBRANE SEPARATION SYSTEM E N V I R O N M E N T Hydro Air Research Italia Since 1979 HAR has gained extensive expertise in process and waste water applications, becoming
More informationSaving Energy and Water. Working with High Recovery Water Treatment Plants
Saving Energy and Water Working with High Recovery Water Treatment Plants > Saving Energy and Water Working with High Recovery Treatment Plants Reverse Osmosis - Benefits o Reliable and Consistent Technology
More informationNext Generation SAGD Produced Water Treatment Technology Development. ESAA Watertech 2012 Banff, Alberta April 12, 2012
Next Generation SAGD Produced Water Treatment Technology Development ESAA Watertech 2012 Banff, Alberta April 12, 2012 Energy and water are co-dependent Energy is required for making water and water is
More informationAchieve Zero-liquid Discharge of Industrial Wastewater. (Distill Process Waste for Reuse)
(Distill Process Waste for Reuse) by Gary N. Dixon, Sr.Application Engineer, Samsco Water Evaporators Innovative, patented, multi-staged, full distillation, vacuum technology evaporation equipment from
More informationInnovation for Sustainable Production i-sup 2008 April 24 th
Innovation for Sustainable Production i-sup 2008 April 24 th Nanofiltration (NF) technology removes non biodegradable API s (active pharmaceutical ingredients) from aqueous & organic solvent mixtures Kamla
More information