TOTAL WATER MANAGEMENT
|
|
- Oswald Matthews
- 6 years ago
- Views:
Transcription
1 TOTAL WATER MANAGEMENT 1
2 JSW Steel Group Companies SISCOL, Salem Tarapur JSW Steel, Vijayanagar 4.0 mtpa. JSW Port, Goa VMPL, Iron Ore mining JPOCL JSW Captive power JSW Steel, Bellary 2
3 JSW : Process Raw materials to finished steel Non - coking coal Iron ore Coking coal Fluxes Lum mp ore Beneficiation Lump or re Coke oven Pelletization Sintering LCP HMDS Corex Blast furnace Converter LHF CCP HSM HOT METAL STEEL 3
4 JSW Steel Products HR Coils Plates and Slabs -Slabs - HR coils - Cold rolled coils - Pre coated - Galvanised - Bars & Rods - Structural etc. 4
5 Industrial management system Entire Integrated Steel Operation certified BENEFITS DERIVED: Consistent quality and quantity of water. Continuous improvements in quality. Lower Operational & Maintenance costs. Reliability of water for critical systems. 5
6 Water from Tunga Bhadra Reservoir (32 MGD) Tunga Bhadra Reservoir Intake water pump house Raw water pond(6.5 Mm 3 capacity) Clariflocculators(22.8 x 3 MGD) 6
7 Water usage at JSW Steel Power plants 38% Others 17% Corex-1 4% Corex-2 3% BF-1 3% BF-2 5% SMS-1 8% HSM 3% CRM 2% Coke Ovens I & II 2% Pellet Plant & Benification plant. 8% Sinter plant I 1% RMHS 1% FFPH 5% 7
8 Water Usage in Integrated Steel Plants 1. Cooling of Metallurgical equipment (ICW) 2. Gas cleaning &Fume flushing 3. Miscellaneous (Fire, drinking, gardening) 8
9 Water usage Company Policy 1. Efficient use of available water Reduction of evaporation rate Maximize use of alternate sources rain water & seepage. Reduction of fresh water in closed circuits by higher COC. Reverse osmosis plant for recovering good quality water. 2. Zero Discharge Cascading usage of water Use of blow down of one process as make up water in other processes. Equalization of final blow down water quality and its use in less critical applications. Treated sewage for gardening. 9
10 Efficient Use of water Fin-Fan heat exchanger Rain water harvesting Higher COC in Cooling towers Seepage water pumping 10
11 Cascading use of water 4.Consumptive use GCP Blow Down 3. DCW Blow Down 1.DM/So ft 2. ICW Blow Down 11
12 Water Cascading Corex Plant Corex DM Water Circuit Corex ICW Corex Slurry Water Circuit to PP Corex GCP Water Circuit GCP Water Clarifier Blow down to Ore Beneficiation SLIME POND 12
13 Waste water discharge zero GUARD POND -1 GUARD POND -2 Slag & Coke quenching Ore washing Best Practices-Green belt Greenery Development 13
14 Water conservation total involvement Employee involvement Awareness Water Help-Desk: Call Attend calls per day. Action taken within 6 hours. 14
15 Water Suggestion mela 15
16 Water - MIS Monitoring system Consumption: Flow meters at TOP of Shops:165 Nos. Daily readings at Production shops & Hourly reading readings at FFPHs. Quality: Hourly analysis of Raw water & Drinking water. Monthly water analysis by external chemical llaboratories. Reporting system Reports: Daily water consumption report (Enclosure3.xls). Monthly water report (Enclosure-5.xls) Monthly water cost (report) Review: Water consumption review in Daily HOD meeting. Weekly water conservation meeting (Enclosure4.xls). DQEC meeting (MOM-May 2008.doc). 16
17 Specific water consumption Year Annual Water consumption Specific fresh Production in tons water (April - Consumption Qantit 3 Source of Quantity (m ) March) Water Industrial Domestic Industrial ,28,810 7,06,050 River ,48, ,85,670 River ,51,293 11,38,490 River ,19,801 16,72,610 River Year Industrial Township water consumption Consumption m 3 Average employees per day Per capita consumption No of persons Per capita Consumption ,06,050 25, , ,85,670 28, , ,38,490 30, , ,72,610 35, ,
18 Water conservation projects A. Efficient use of water. Water Saving project implemented Sl No Year Savings a Collection of seepage water from raw water pond by constructing check dams and pump it back to reservoir m 3 Invest. Rs. Lakhs Payback Period (Months) b Construction of guard pond-1 for 4 mtpa units c Construction of guard pond-2 for 7 mtpa units c d Construction of lake in Vidyanagar to harvest rain water Improvement in the cycle of concentration ti by improving water treatment measures (continuous) e RVDF project in RWTP f g f Collection of seepage water by Bore wells and utilization in iron making zone. Collection of seepage water along the RWP bund area and pumping it back to pond Utilization of guard pond water for VVNagar township/vidyanagar township/plant horticulture/
19 B. Cascading use of Water. Sl No a b c d e Title of Water Saving project implemented Utilization of blow down of GCP water of Corex, BF 1&2 formakeupinore ore beneficiation plant Conversion of open circuit ID fan cooling to closed circuit cooling Utilization of blow down water from CPP-2 for coke quenching in to Coke oven-1,2 Collection of seepage water from MSDS cable tunnel and use in scale pit, of BOF. Recycling of fblow down water to slag quenching at BOF-CCP Year of Implement ation Annual Water Savings Invest. Made m 3 Rs. Rs. Lakhs Lakhs Lakhs Payback Period (Months)
20 Water usage - analysis Cement Plant Pellet Plant & Benification plant. Coke Ovens I & II CRM Sinter plant I HSM LCP RMHS Corex-1 SMS-1 Corex-2 BF-1 BF-2 HSM FFPH BF-2 FFPH Cokeoven FFPH Corex FFPH. Boilers utiltities (25 TPH) BOC-1 CPP-2 CPP-1 JPOCL JSWEL Chart-1,4 MT Production units Chart-2, Fire fighting pump houses Chart-3, Power Plants Boilers utiltities (80 TPH) WRM Water to Shankar Gudda colony IST steel plant 12 NTU Turbidity Chart SMS-2 BF-3 Sinter plant II Coke Ovens III VV Nagar Vaddu village Water supplied to Township Hort. Water from RWP to Lake Water to overhead tank in Vidyanagar. New batching plant Crushing plant 7 MTPA Labour Colony/Drinking water For BF-3. Drinking water supplied to plant. T u rbidity 7 NTU O NTU Hour Chart-4,7 MT Production units Chart-5,Miscellaneous units Chart-6 SPC 20
21 Conservation projects - highlights A. Application of Chemical in Raw water pond to reduce Evaporation. 1. Name of chemical : Ceta styrol Alcohol. 2. Supplier : Aqua Savia. 3. Cost (Rs/kg) : 120 Rs/kg. 4. Application rate (kg/day) : 64 kg/day. 5. Cost of application per day : 8500 Rs/day. 6. Potential saving of water at 50% efficiency : 8000 m 3 /day. 7. Savings due to reduction. : Rs 20,000/day 21
22 Evaloc is being mixed with water Solution is poured into a container Others 4% Water Consum ption - March 2007 Evaporation loss 17% Water Consumption - March 2008 Evaporation loss 13% Others 5% Ancillary units 19% JSW 56% Ancillary units 20% JSW 57% Drinking water 4% Total consumption = X 1000 m3 Drinking water 5% Total consumption = X 1000 m3 22
23 Raw Water Pond level Jan Feb Mar Apr May Jun Jl Jul Aug Sep Oct Nov Dec Fig-3: Comparison of Evaporation Rates in cm 2.5 rate in cm Evaporation With & without Evaloc application. 0 Jan Feb Mar Apr May June July Aug Sep Month Without Evaloc With Evaloc 23
24 Conservation projects - highlights B. Re use of seepage water & blow down water. Cable Tunnels constructed to collect seepage water. There are about 12 cable tunnel structures- VS-1, VS-2 VS-10. Entire seepage water is collected in VS-10(ventilation system). 24
25 Cable Tunnel water is measured using Electromagnetic flow meter. Cable tunnel water is being pumped to consumer units. About 150 to 200 m 3 /day water is being saved. 25
26 Conservation projects - highlights C. Use of Guard pond water. Capacity of Each Guard pond is 55,000 m 3. There are two separate Guard ponds for 4 MT & 7 MT Stage. 26
27 Guard pond pipeline network Excess s water taken to 7MT GP 2. Guard pond I Storage cap m 3 To 7MT ore Beneficiation plant pump house 7 MT Guard (1w+1s) pond II Storage cap m 3 Q= 300m 3 /hr VV Nagar horticulture 30 m 3 /hr Plant Horticulture 20 m 3 /hr Pump house (1w+1s) Each cap. Q=250m 3 /hr H=70mtr To Beneficiation plant 150m 3 /hr 300 m m 3 1 st Boosting 2 nd Boosting station at station ti at RM Gate Air strip Vidya Nagar township /Air port Horticulture 50m 3 /hr 27
28 THANK YOU 28
TOTAL WATER MANAGEMENT IN THE STEEL INDUSTRY. By N. Ramachandran, Ion Exchange (India) Ltd
TOTAL WATER MANAGEMENT IN THE STEEL INDUSTRY By N. Ramachandran, Ion Exchange (India) Ltd Large quantities of water are required to produce steel and steel products - typically 180-200 m 3 of water per
More informationParibesh Bhavan, A / 118, Nilakantha Nagar, Unit VIII, Bhubaneswar
ENVIRONMENTAL STATEMENT REPORT OF BHUSHAN POWER & STEEL LIMITED VILLAGE: THELKOLOI, POST: LAPANGA TEHSIL: RENGALI, DISTT: SAMBALPUR 768232 ODISHA FOR THE FINANCIAL YEAR ENDING 31 ST MARCH 2016 SUBMITTED
More informationBenchmarking for Enhancing Competitiveness of Indian Steel Plants
Benchmarking for Enhancing Competitiveness of Indian Steel Plants The IIM Delhi Chapter, 15 th September 2017 1 Prabhat Kumar Ghorui Sr. Vice President JSW Steel Ltd., Bellary, Karnataka Presentation Flow
More informationEssar Steel (I) Ltd. Hazira
Essar Steel (I) Ltd. Hazira Presentation on : Technological conjunction of Iron & Steel Making at Essar Steel India Ltd. By : Mr. Hitesh Sheth (Hitesh.Sheth@essar.com) Ms. Neeru Singh (Neeru.Singh@essar.com)
More informationSALE OF 0.5 MTPA MINI BLAST FURNACE COMPLEX. (Southeast Asia)
SALE OF 0.5 MTPA MINI BLAST FURNACE COMPLEX (Southeast Asia) 1 Executive Summary valuejunction, a business unit of mjunction (A SAIL Tata Steel joint venture) is appointed by a leading steel manufacturer
More informationProduction Facilities and Automotive Steel Grades from JSW Steel. 2 nd Automotive Steel Summit, Pune 15 th September, 2017
Production Facilities and Automotive Steel Grades from JSW Steel 2 nd Automotive Steel Summit, Pune 15 th September, 2017 Contents Organizational Overview and manufacturing Facilities JSW Group Overview
More informationArcelorMittal South Africa
Introduction to ArcelorMittal South Africa 1. History ArcelorMittal is one of the world s largest inland steelworks. The increasing demand for steel during the late 1930 s and the early years of the Second
More informationCondenser Water Heat Recovery"
PLEASE MUTE CELL PHONES Condenser Water Heat Recovery" Julian de Bullet ASHRAE Distinguished Lecturer Director of Industry Relations McQuay International 703-395-5054 1 What Is Sustainability? sustainable
More informationHINAUTI LIMESTONE MINE Mine Lease area ha. (A UNIT OF JAIPRAKASH ASSOCIATES LIMITED) JAYPEE VIHAR, SIDHI (M.P)
HINAUTI LIMESTONE MINE Mine Lease area 378.261 ha. (A UNIT OF JAIPRAKASH ASSOCIATES LIMITED) JAYPEE VIHAR, SIDHI (M.P) 2012-2013 SUBMITTED TO M.P.POLLUTION CONTROL BOARD BHOPAL (M.P.) Jaypee Sidhi Cement
More informationKALYANI STEELS LIMITED
SUMMARY 1. Kalyani Steels Limited (KSL), in strategic alliance with Mukand Limited is operating Hospet Steels Limited, an integrated steel plant in Koppal district of Karnataka. The existing plant capacity
More informationChallenges and limiting factors for the Recycling of steel scrap in Europe
Challenges and limiting factors for the Recycling of steel scrap in Europe International Workshop on Technospheric Mining 2 nd October 2015 Philip Bundschuh Table of Content Scrap availability trading
More informationElectric Forward Market Report
Mar-01 Mar-02 Jun-02 Sep-02 Dec-02 Mar-03 Jun-03 Sep-03 Dec-03 Mar-04 Jun-04 Sep-04 Dec-04 Mar-05 May-05 Aug-05 Nov-05 Feb-06 Jun-06 Sep-06 Dec-06 Mar-07 Jun-07 Sep-07 Dec-07 Apr-08 Jun-08 Sep-08 Dec-08
More informationTHE USE AND OPTIMISATION OF FERROUS FEED AT THE WHYALLA BLAST FURNACE
THE USE AND OPTIMISATION OF FERROUS FEED AT THE WHYALLA BLAST FURNACE AUSIMM Iron Ore 2015 Conference, Perth Australia 13 15 July 2015 Presented by John Tsalapatis Whyalla Location Whyalla Adelaide 2 Steelworks
More informationJSW STEEL LTD.: ENVIRONMENT MANAGEMENT
JSW STEEL LTD.: ENVIRONMENT MANAGEMENT Managing the environment plays a vital role in the assessment and mitigation of strategic risks associated with the environment, ensuring regulatory compliance, as
More informationThe OWASA UNC Reclaimed Water System: A Progress Review
The OWASA UNC Reclaimed Water System: A Progress Review 2016 NC WRRI Conference March 17, 2016 Pat Davis A public, non-profit agency providing water, sewer & reclaimed water services to the Carrboro-Chapel
More informationMAJHIGAWAN LIMESTONE MINE Mine Lease area ha. ( A UNIT OF JAIPRAKASH ASSOCIATES LIMITED) JAYPEE VIHAR, SIDHI (M.
MAJHIGAWAN LIMESTONE MINE Mine Lease area 362.68 ha. ( A UNIT OF JAIPRAKASH ASSOCIATES LIMITED) JAYPEE VIHAR, SIDHI (M.P) 2012-2013 SUBMITTED TO M.P.POLLUTION CONTROL BOARD BHOPAL (M.P.) Jaypee Sidhi Cement
More informationUrban Rainwater Harvesting Systems: Promises and Challenges
TheWaterChannel Webinar #5 Urban Rainwater Harvesting Systems: Promises and Challenges By Vishwanath S Zenrainman@gmail.com www.ircsa.org www.rainwaterclub.org Thanks for coming. The webinar will begin
More informationStahl-Zentrum. Influence of coke quality on BF hearth lifetime and operation results. Walter Hartig, Rongshan Lin * ) AG der Dillinger Huettenwerke
Influence of coke quality on BF hearth lifetime and operation results Walter Hartig, Rongshan Lin * ) AG der Dillinger Huettenwerke 135 Vollsitzung des Hochofenausschusses/Kokereiausschuss 1 Introduction
More informationWILPINJONG COAL PTY LTD. Environment Protection Licence (EPL) 12425
WILPINJONG COAL PTY LTD Environment Protection Licence (EPL) 12425 Link to Environment Protection Licence EPL12425 LICENCE MONITORING DATA MONTHLY SUMMARY REPORT for 1 June 2017 to 30 June 2017 Air Monitoring
More informationWILPINJONG COAL PTY LTD. Environment Protection Licence (EPL) 12425
WILPINJONG COAL PTY LTD Environment Protection Licence (EPL) 12425 Link to Environment Protection Licence EPL12425 LICENCE MONITORING DATA MONTHLY SUMMARY REPORT for 1 August 2017 to 31 August 2017 Air
More informationArcelorMittal Saldanha Works Analyst visit. 14 October 2011
ArcelorMittal Saldanha Works Analyst visit 14 October 2011 History of Saldanha Works 1995 1996 Nov 1995: Saldanha Steel project started (Iscor and IDC) Jan 1996: First bursars, recruited from the West
More informationUSIMINAS Tokyo, 16 th and 17 th of July
USIMINAS 2012 Tokyo, 16 th and 17 th of July - 2008 USIMINAS IN BRAZIL IN 2007, USIMINAS, THE MAJOR PLAYER OF THE BRAZILIAN FLAT STEEL, MARKET WAS RESPONSIBLE FOR 26% OF THE COUNTRY S CRUDE STEEL PRODUCTION
More informationJhajjar Project Management An Insight. March 4, 2013
Jhajjar Project Management An Insight March 4, 2013 2 x 660 MW Mahatma Gandhi Thermal Power Plant Jhajjar, Haryana, INDIA 2 A Brief Introduction 2x 660 MW greenfield project, named as Mahatma Gandhi Thermal
More informationTechnical and economic aspects of production and use of DRI in integrated steel works
Technical and economic aspects of production and use of DRI in integrated steel works The use of surplus energy from integrated steel works for the on-site production and use of DRI in blast furnaces and
More informationDRI Production Where are the new hubs?
DRI Production Where are the new hubs? 2 Objectives What are the central questions that this paper attempts to answer? How will the recent shale gas finds influence DRI production locations? How is the
More informationImplications of Measured Commercial Building Loads on Geothermal System Sizing
Implications of Measured Commercial Building Loads on Geothermal System Sizing ASHRAE Annual Meeting June 23, 1999 Hugh I Henderson, Jr.. P.E. CDH Energy Corp. Cazenovia,, NY www.cdhenergy.com Overview
More informationJSW STEEL COATED PRODUCTS LTD Kalmeshwar (Maharashtra)
Second Prize Steel Re-Rolling Mills JSW STEEL COATED PRODUCTS LTD Kalmeshwar (Maharashtra) Unit Profile JSW Steel Coated Products Limited Kalmeshwar is the part of JSW Group, a major player in steel industry
More informationProven Technology + Cost Effective + Perfect Service
Proven Technology + Cost Effective + Perfect Service A Lifetime Partner in Engineering, Procurement, Construction, Operation, Maintenance, Project Management TECHNOLOGY FOR SLAG PROCESSING --Slag Granulation
More informationGENERAL SHAREHOLDERS MEETING
GENERAL SHAREHOLDERS MEETING BUSINESS YEAR 2013 NORTH AMERICAN FACTORY SOUTH AFRICAN FACTORY RAW MATERIALS DEPOT STAINLESS STEEL COLD ROLLED SHEET PRICES AISI 304 2.0 mm 3,500 Euros/Mt EUROPEAN MARKET
More informationOPTIMISATION OF WATER USAGES IN THERMAL POWER PLANTS AND A STUDY ON DRY COOLING SYSTEM
CONFERENCE ON WATER OPTIMISATION IN THERMAL POWER PLANTS OPTIMISATION OF WATER USAGES IN THERMAL POWER PLANTS AND A STUDY ON DRY COOLING SYSTEM S. K. Thakur, Dr. L. D. Papney, Chief Engineer (I/C), TE&TD
More informationLake Erie Works 2010 Annual Toxics Reduction Report (O. Reg. 455/09)
Lake Erie Works 2010 Annual Toxics Reduction Report (O. Reg. 455/09) Issued June 14, 2011 Basic Facility Information Section 1 Facility Information Owner US Steel Canada Facility name Lake Erie Works Address
More informationEnergy Saving & Breakthrough Technologies. Dr Ladislav Horvath Zhang Jiagang, Jiangsu, China, August 1, 2013
Energy Saving & Breakthrough Technologies Dr Ladislav Horvath Zhang Jiagang, Jiangsu, China, August 1, 2013 Disclaimer text For presentations to the general public: This document is protected by copyright.
More informationHeavy Water Board, Mumbai
ORGANISATION CHART OF DEPARTMENT OF ATOMIC ENERGY ATOMIC ENERGY COMMISSION DAE Science Research Council DEPARTMENT OF ATOMIC ENERGY ATOMIC ENERGY REGULATORY BOARD R&D ORGANISATIONS PUBLIC SECTOR UNDERTAKINGS
More informationHIsarna, a Revolution in Steelmaking. June 21, 2013 CEPS Meeting, Brussels Tim Peeters
HIsarna, a Revolution in Steelmaking June 21, 2013 CEPS Meeting, Brussels Tim Peeters Paper & Steel : Common Ground? CO 2 intensive (1.1% vs 4% of man made CO 2 ) Energy intensive High recycling rate (70%
More informationMagnetite A Higher Grade Blast Furnace Feed and its Potential Benefits for the Ironmaker
Magnetite A Higher Grade Blast Furnace Feed and its Potential Benefits for the Ironmaker Andre Mouton Principal Consultant, Pyromet Consulting Pty Ltd Kris Edwards Consulting Process Engineer Disclaimer
More informationAdministration Division Public Works Department Anchorage: Performance. Value. Results.
Administration Division Anchorage: Performance. Value. Results. Mission Provide administrative, budgetary, fiscal, and personnel support to ensure departmental compliance with Municipal policies and procedures,
More informationThis document also describes the basis on which building permit fees should be calculated.
1/6 1.0 PURPOSE This specification outlines when a Building Permit is required pursuant to the Building Code Act and its Regulations. The Building Code Act prescribes that each municipality is responsible
More informationCHP Case Studies. Midwest CHP Application Center (MAC) .org (312) University of Illinois at Chicago Energy Resources Center UIC
CHP Case Studies Midwest CHP Application Center (MAC) www.chpcentermw.org.org (312)413-5448 University of Illinois at Chicago Energy Resources Center CHP Case Studies Elgin Community College Presbyterian
More informationNovember 28, Dear Mr. Bechtold:
4000 Hollywood Boulevard Seventh Floor, North Tower Hollywood, Florida 33021 (954) 987-0066 Fax: (954) 987-2949 November 28, 2012 Wastewater Compliance and Enforcement Section FLORIDA DEPARTMENT OF ENVIRONMENTAL
More informationOre-Based Metallics: adding value to the EAF SEASI CONFERENCE & EXHIBITION. MAY 2017
Ore-Based Metallics: adding value to the EAF SEASI CONFERENCE & EXHIBITION. MAY 2017 Disclaimer This presentation is intended for information purposes only and is not intended as commercial material in
More informationEFFLUENT REDUCTION PROJECTS SULPHURIC ACID PLANT
EFFLUENT REDUCTION PROJECTS SULPHURIC ACID PLANT BACKGROUND INFORMATION Sulphuric acid plant in Umbogintwini. Double absorption plant, capacity of 550MTPD. Built by Simon Carves in 1973. Side stream plants
More informationStrategic Cost Management in Black Tea Processing
Strategic Cost Management in Black Tea Processing Dr W S Botheju, Head Process Technology Division Te a Re se arch Institute of S ri Lank a Background Quality consumer demand driven Good Quality Tea better
More informationJAYPEE NIGRIE SUPER THERMAL POWER PROJECT
JAYPEE NIGRIE SUPER THERMAL POWER PROJECT (A Unit of M/s Jaiprakash Power Ventures Limited) Villages: Nigrie, Tehsil :Sarai District: Singrauli 2014 2015 SUBMITTED M.P. POLLUTION CONTROL BOARD BHOPAL (M.P.)
More informationRATING OF THE STEEL SECTOR. How we did it
RATING OF THE STEEL SECTOR How we did it Rating of Steel Sector Used a rigorous, independent, participatory and transparent mechanism of assessment - Quantitative assessment based on life cycle analysis
More informationDiscussion on change of threshold value of Iron Ore
Discussion on change of threshold value of Iron Ore IBM has invited imputes from the stake holders for revision of the threshold value of minerals vide notice dated 24.03.2017 on the following aspects:
More information2011 ANNUAL WATER REPORT
2011 ANNUAL WATER REPORT June 2012 Engineering and Operations Department TABLE OF CONTENTS Page 2 1.0 INTRODUCTION... 3 2.0 PARKSVILLE WATER SYSTEM... 3 3.0 DISTRIBUTION SYSTEM... 6 4.0 SCADA... 9 5.0
More informationExamples in Material Flow Analysis
China Steel Technical Report, No. 27, pp.1-5, (2014) Kuo-Chung Liu 1 Examples in Material Flow Analysis KUO-CHUNG LIU Office of Energy and Environmental Affairs China Steel Corporation The inputs and outputs
More informationManaging Iron Ore Fines of Dalli Rajhara For Improvement In Yield
Managing Iron Ore Fines of Dalli Rajhara For Improvement In Yield S K Raja, AGM, CET, Bhilai, S. Manoj Kumar, Sr. Mgr. (Mines-Project), BSP SAIL CET. Bhilai Email : saurabhkumar.raja@sailcet.co.in smanojkumar@sail-bhilaisteel.com
More informationa comparative study of secondary glycol and direct expansion refrigeration systems
a comparative study of secondary glycol and direct expansion refrigeration systems Second Nature Medium-Temperature secondary systems have been widely applied in commercial refrigeration since their introduction
More informationBajaj Auto Limited. Waluj. You All
Bajaj Auto Limited (Aurangabad Division) Waluj GC-1000 XCD-125 You All Passenger Platina-125 1 1 Company profile Manufacturing process Water Conservation Target Water Conservation Approach water Conservation
More informationWorld Steel Market and Ukrainian metallurgy in 2010
2-Dec-21 Ministry of Industrial Policy of Ukraine SE UPE Co. Research & Consulting World Steel Market and Ukrainian metallurgy in 21 Vlasyuk V.S. SE UPE Co. Research & Consulting, Ukraine 69 th Session
More informationPredictive Safety s Fatigue Management System: Benefits Realization Report
Predictive Safety s Fatigue Management System: Benefits Realization Report 1. Scope This document contains the benefits realization information as required for a follow up on FMS Implementation project.
More informationGroundwater, Mining and Sustainability in the Tropics :
Dr Gavin M Mudd Environmental Engineering Groundwater, Mining and Sustainability in the Tropics : Some Research Case Studies PECC Bora Bora Water Resources Seminar 13 November 2007 iswr.eng.monash.edu.au
More informationENERGY AND WATER STATISTICS 2016
ENERGY AND WATER STATISTICS 216 Introduction This issue of Economic and Social Indicators presents Statistics on Energy and Water for the years 215 and 216. The statistics have been compiled in close collaboration
More informationMetal Bulletin India Ferroalloy Conference Hyderabad 8-10 February Alloy Market: Present Situation & Trends
Metal Bulletin India Ferroalloy Conference Hyderabad 8-1 February 24 Alloy Market: Present Situation & Trends Introduction 1. BHP Billiton s position in the carbon steel materials and ferroalloy industry
More informationManufacture of Iron & Steel. Prepared By: John Cawley
Manufacture of Iron & Steel Prepared By: John Cawley Presentation Objectives Identify the basic steps in the production of steel. Identify the properties and uses of iron ore and pig iron. Differentiate
More informationCedar River Watershed Habitat Conservation Plan
Cedar River Watershed Habitat Conservation Plan Briefing for the WRIA 8 Salmon Recovery Council November 21, 2013 Cyndy Holtz Seattle Public Utilities cyndy.holtz@seattle.gov What is an HCP? Habitat Conservation
More informationENERGY AND WATER CONSERVATION AND DEMAND MANAGEMENT PLAN
ENERGY AND WATER CONSERVATION AND DEMAND MANAGEMENT PLAN 2014 2019 CONTENTS EXECUTIVE SUMMARY... 3 1. CENTENNIAL COLLEGE - DISTRIBUTION OF ENERGY CONSUMPTION IN 2012... 4 1.1. Overview of Centennial College
More informationNTPC, Simhadri, 4X500MW, Visakhapatnam, Andhra Pradesh
NTPC, Simhadri, 4X500MW, Visakhapatnam, Andhra Pradesh Unit Capacity Year of Comml Power Share AP TN Kar Ker Pud Unit-1 500 MW Sep 2002 100% X X X X Unit-2 500 MW Mar 2003 100% X X X X Unit-3 500 MW Sep
More informationYWCA 1503 S. Denver Tulsa, Oklahoma 5/18/2010 Performed By
Energy Audit for YWCA 1503 S. Denver Tulsa, Oklahoma 5/18/2010 Performed By 220 E. 8th Street Tulsa, Oklahoma 74119 918-582.0229 Fax: 918.599.0665 www.craftontullsparks.com Table of Contents Cover Page...
More informationThe Confluence Model. Presentation to Modeling and Forecasting Working Group January 21, 2015
The Confluence Model Presentation to Modeling and Forecasting Working Group January 21, 2015 Introductions Presenter: Gary Fiske Working Group Water Department staff Objective: Penetrate the Black Box
More informationPowering Michigan Agriculture with Renewable Energy
Powering Michigan Agriculture with Renewable Energy ENERGY AUDIT & RENEWABLE ENERGY ASSESSMENT ENERGY PYRAMID MICHIGAN STATE UNIVERSITY MI Agricultural Energy Use Significant MI Dairy Farms Energy Use
More informationNational Protection and Programs Directorate Office of Cyber and Infrastructure Analysis
1 Overview One of the Nation s most economically vital systems, the iron mining integrated steel production manufacturing supply chain is potentially one of the least resilient to disruption. The Poe Lock
More informationANNUAL ENERGY PERFORMANCE OF SOLAR THERMAL SYSTEMS IN BRAŞOV, ROMANIA
Bulletin of the Transilvania University of Braşov Series I: Engineering Sciences Vol. 5 (54) No. 2-212 ANNUAL ENERGY PERFORMANCE OF SOLAR THERMAL SYSTEMS IN BRAŞOV, ROMANIA C. ŞERBAN 1 E. EFTIMIE 1 Abstract:
More informationHotels: Water and Energy
Hotels: Water and Energy Agenda 01 Introduction 05 Hotel System Options 02 Company Overview 06 Hotel Energy Conservation 03 Hotel Energy & Water Use 07 Hotel Project Examples 04 Design Philosophy Introduction
More informationTexas Hospital. Central Plant Redesign. Central Utility Plant SECOND PLACE HEALTH CARE FACILITIES, EXISTING 2013 ASHRAE TECHNOLOGY AWARD CASE STUDIES
This article was published in ASHRAE Journal, January 2014. Copyright 2014 ASHRAE. Posted at www. ashrae.org. This article may not be copied and/or distributed electronically or in paper form without permission
More informationCAP Excess Water Task Force
Agenda Number 2. CAP Excess Water Task Force Patrick Dent PE CAP Water Control Manager September 6, 2017 Introduction Excess Water is defined as all Project Water that is in excess of the amounts used,
More informationThis document can be made available in other accessible formats as soon as practicable and upon request. Staff Report. Infrastructure & Public Works
This document can be made available in other accessible formats as soon as practicable and upon request Staff Report Infrastructure & Public Works Report To: Committee of the Whole Meeting Date: March
More informationRenewables. Vacuum Tube Solar Systems. Solar Energy to the Power of
Renewables Vacuum Tube Solar Systems Solar Energy to the Power of FREE HOT WATER FROM DAWN TO DUSK AND THROUGHOUT THE YEAR WITH Thermomax advanced vacuum tube solar systems provide hot water in all seasons.
More informationTata Steel India Analyst Day 2017 Sustainability Session 5 th October 2017
Tata Steel India Analyst Day 2017 Sustainability Session 5 th October 2017 1 1 Safe harbor statement Statements in this presentation describing the Company s performance may be forward looking statements
More informationPROJECT INFORMATION REPORT INFORMATION. Date: February 25, Owner s Rep: Alrich Lynch. 123 Project Address Drive, Savannah GA 31404
LDG Consulting Providing Orientation, Direction, and Execution to the Design, Construction, and Real Estate Industries REPORT INFORMATION Date: February 25, 2015 Owner s Rep: Alrich Lynch Electronic Copy:
More informationCITY OF LONDON ENVIRONMENTAL & ENGINEERING SERVICES DEPARTMENT WASTEWATER TREATMENT OPERATIONS GREENWAY POLLUTION CONTROL CENTRE 2013 ANNUAL REPORT
CITY OF LONDON ENVIRONMENTAL & ENGINEERING SERVICES DEPARTMENT WASTEWATER TREATMENT OPERATIONS GREENWAY POLLUTION CONTROL CENTRE 2013 ANNUAL REPORT FEBRUARY 2014 SUMMARY This annual report is in response
More informationThe Impacts of Climate Change on Portland s Water Supply
The Impacts of Climate Change on Portland s Water Supply Richard Palmer and Margaret Hahn University of Washington Department of Civil and Environmental Engineering Joe Dvorak, Dennis Kessler, Azad Mohammadi
More informationBHPBilliton Iron Ore Port Sweating the assets. September 2003
BHPBilliton Iron Ore Port Sweating the assets September 2003 Port Hedland Ports Operations Nelson Point 240 hectares Approx 400 employees 3 car dumpers 4 reclaimers 6 stackers 2 berths Finucane Island
More informationApplication of a cooling tower model for optimizing energy use
Advances in Fluid Mechanics X 305 Application of a cooling tower model for optimizing energy use G. C. O Mary & D. F. Dyer Department of Mechanical Engineering, Auburn University, USA Abstract The overall
More informationExpression of Interest
Expression of Interest (Advertisement to be published in the Newspapers) Sub: Expression of Interest ( EOI ) for appointment of Steel Processing Units (SPU) / Rolling Mills (RM) for Conversion of Billets
More informationVoisey s Bay Project Update
Voisey s Bay Project Update Presentation to the Newfoundland and Labrador Branch of the CIM November 5, 2004 This presentation will include projections and other forward-looking statements. While these
More informationAchieving a cost optimal balance between heat supply efficiency and moderation of demand
Achieving a cost optimal balance between heat supply efficiency and moderation of demand Dr. Christian Friebe Thüga Aktiengesellschaft COGEN Europe, 25th of February 560 cities and towns, 100 companies
More informationExpression of Interest
Expression of Interest (Advertisement to be published in the Newspapers) Sub: Expression of Interest ( EOI ) for appointment of Rolling Mills (RM) for Conversion of Billets into CTD/TMT Rebars and Structurals
More informationThe Sustainability of Floods Pond
The Sustainability of Floods Pond Bangor Water District s Public Water Supply Presented By: Rick Pershken Bangor Water District Overview Brief BWD History Watershed Characteristics Lake Characteristics
More informationDr. Joseph J Poveromo, Raw Materials & Ironmaking Global Consulting DR Pellet Quality & MENA Applications
Dr. Joseph J Poveromo, Raw Materials & Ironmaking Global Consulting joe.poveromo@rawmaterialsiron.com DR Pellet Quality & MENA Applications Chemistry Considerations direct reduction processes: chemical
More informationProductive recycling of basic oxygen furnace sludge in integrated steel plant
Journal of Scientific & Industrial Research Vol. 64, September 2005, pp 702-706 Productive recycling of basic oxygen furnace sludge in integrated steel plant Raj Kumar Agrawal 1 and Piyush Kant Pandey
More informationJohn H. Kerr Dam and Reservoir Virginia and North Carolina (Section 216)
John H. Kerr Dam and Reservoir Virginia and North Carolina (Section 216) Wilmington District, Corps of Engineers Stakeholder Update Presentation January 24, 2014 Authorized under Section 216 of Public
More informationSolvent Recovery Systems
Solvent Recovery Systems Use Steam Recycling A new technique that recycles the heat normally lost during solvent recovery can cut fuel bills and reduce plant exhaust emissions. by Stanley J. Macek Compliance
More information3Q10 Results. October 28, 2010
3Q10 Results October 28, 2010 1 Disclaimer This presentation may include declarations about Vale's expectations regarding future events or results. All declarations based upon future expectations, rather
More informationMEMORANDUM OF UNDERSTANDING BETWEEN HINDUSTAN COPPER LIMITED AND MINISTRY OF MINES FOR
i.exe MEMORANDUM OF UNDERSTANDING BETWEEN HINDUSTAN COPPER LIMITED AND MINISTRY OF MINES FOR 2010-2011 MEMORANDUM OF UNDERSTANDING (MOU) BETWEEN HINDUSTAN COPPER LIMITED AND MINISTRY OF MINES FOR 2010-2011
More informationEnergy Conservation. Work Shop on Knowledge exchange Platform on Best practices in Iron & Steel Industry. By MCJ Energy Engineers Pvt Ltd
Energy Conservation Work Shop on Knowledge exchange Platform on Best practices in Iron & Steel Industry By MCJ Energy Engineers Pvt Ltd Who We are? MCJ Energy Engineers Pvt Ltd serving in energy conservation
More informationUnion College Combined Cooling, Heat and Power Project
Union College Combined Cooling, Heat and Power Project Presented by: Mark Donovan, PE Union College, Assistant Director of Utilities Aaron Bolhous, PEng CHA, Project Engineer Agenda Introduction to Union
More informationDEALING WITH STRATIFICATION WITHIN A WATER SUPPLY RESERVOIR. Chris Perks. Central Highlands Water
DEALING WITH STRATIFICATION WITHIN A WATER SUPPLY RESERVOIR Paper Presented by : Chris Perks Author: Chris Perks, Water Resources Operator Central Highlands Water 69 th Annual Water Industry Engineers
More informationRainwater Management. Dr. Iftikhar Ahmad. College of Earth and. University of The Punjab Lahore
Rainwater Management in Major Cities of Punjab Dr. Iftikhar Ahmad College of Earth and Environmental Sciences. University of The Punjab Lahore Need For Rainfall Harvesting in Urban Areas of Punjab Groundwater
More informationIn Focus: The Saudi Steel Market 2008
THE NATIONAL COMMERCIAL BANK In Focus: The Saudi Steel Market 28 Steel Demand Growth To Continue 1 SEPTEMBER 28 Contents Page A. Steel Market Determinants 2 B. Saudi Steel Market Outlook 3 C. Global Crude
More informationCOLUMBUS: SOUTH AFRICAN STAINLESS ALL OVER THE WORLD
COLUMBUS: SOUTH AFRICAN STAINLESS ALL OVER THE WORLD Dave Martin Chief Executive Officer of Columbus Investor and Analyst s Day North American Stainless (NAS) 16th September 2010 Columbus South African
More informationRyo Hattori, Nisshin Steel Co., Ltd. Fundamental problems of the Asian Stainless Steel Market & the Recovery of the Japanese Stainless Steel Market
Ryo Hattori, Nisshin Steel Co., Ltd. Fundamental problems of the Asian Stainless Steel Market & the Recovery of the Japanese Stainless Steel Market 1 Summary World & Asian Stainless Steel Production China:
More informationWater Reuse for Managing Impacted Water At Sierrita
Connecting the World Water Reuse for Managing Impacted Water At Sierrita Martha G. Mottley May 3, 2011 www.fcx.com Sierrita Operations ARIZONA Bagdad Miami Morenci Safford SIERRITA Groundwater Sulfate
More informationHOLDER CONSTRUCTION COMPANY Superintendents Weekly Activity Report #92 Douthit Hills Student Community, Clemson University Project Joe Jett
SAFETY» Total Man Hours Worked This Week: 19935» Total Man Hours on Project: 689727» Crafts On Project This Week: 24» OSHA Recordable Rate: 0 November 13, 2016 Page 1 CURRENT CONSTRUCTION ACTIVITIES East
More informationLecture 9A: Drainage Basins
GEOG415 Lecture 9A: Drainage Basins 9-1 Drainage basin (watershed, catchment) -Drains surfacewater to a common outlet Drainage divide - how is it defined? Scale effects? - Represents a hydrologic cycle
More informationCircular Pelletizing Technology
Metal Bulletin s World DRI and Pellet Congress 29 th 30 th, Abu Dhabi Circular Pelletizing Technology A smart combination Christoph Aichinger, Siemens VAI We didn t invent Pelletizing. We just made it
More informationPRE-FEASIBILITY REPORT FOR OM SAIRAM STEEL AND ALLOYS PVT LTD
PRE-FEASIBILITY REPORT FOR OM SAIRAM STEEL AND ALLOYS PVT LTD PLOT No. F-1,2,3,8,9,10, ADDL. MIDC, PHASE II, AND GUT NO. 46 & 63, VILLAGE DAREGAON, TEHSIL: JALNA DIST: JALNA, MAHARASHTRA 2014-15 1. Executive
More informationAsturias plant tour for analysts and investors. Oswaldo Suárez. CEO Asturias Cluster Valérie Mella. Investor Relations Specialist
Asturias plant tour for analysts and investors Oswaldo Suárez. CEO Asturias Cluster Valérie Mella. Investor Relations Specialist Asturias (Spain), 27 May, 2016 Creation of the mining & steel industry leader
More information