SECTION 1 * CHEMICAL PRODUCT AND COMPANY IDENTIFICATION SECTION 2 * COMPOSITION / INFORMATION ON INGREDIENTS

Transcription

1 SECTION 1 * CHEMICAL PRODUCT AND COMPANY IDENTIFICATION MATERIAL IDENTITY: PRODUCT NAME: GENERAL OR GENERIC ID: (AF78) PRECHARGED ANTIFREEZE FUSCIA ETHYLENE GLYCOL COMPANY EMERGENCY TELEPHONE NUMBER: EMERALD SERVICES, INC. CHEMTREC 1825 ALEXANDER AVENUE TACOMA, WA TECHNICAL ASSISTANCE: SECTION 2 * COMPOSITION / INFORMATION ON INGREDIENTS MATERIAL CAS PERCENT (BY VOLUME) 1,2-ETHANEDIOL %-51.5% (ETHYLENE GLYCOL) DISTILLED WATER %-47.5% SODIUM METASILLICATE %-0.2% PHOSPHATES VARIOUS 0.2%-0.5% SODIUM BORATE - DECAHYDRATE %-0.5% SODIUM NITRATE %-0.5% SILLICATE STABILIZER PROPRIETARY 0.05%-0.2% SODIUM HYDROXIDE %-1.0% POTASH %-0.5% SODIUM TOLYTRIAZOLE PROPRIETARY 0.05%-0.2% DYE N/A 0.005% SECTION 3 * HAZARDOUS IDENTIFICATION Potential Health Effects Eyes: Exposure can cause slight eye irritation. 1

2 Skin: Exposure can cause slight irritation upon prolonged contact. Ingestion Swallowing small amounts may cause slight irritation. Ingestion of large amounts may be fatal. SECTION 4 * FIRST AID MEASURES Eyes Skin Flush eyes gently with water for at least 15 minutes. Contact a physician. Wash thoroughly with soap and water. If irritation persists, contact a physician. Inhalation Remove to fresh air. Restore and\or support breathing as required. Keep victim warm and at rest. Ingestion Immediately contact a physician, poison control center or emergency treatment center. Place individual on left side with head down, seek advice of a physician about inducing vomiting. Flashpoint >128 degrees C (262 F) Unusual or Explosive Hazards None Ignition Temperature >413 degrees C (775 F) SECTION 5 * FIRE FIGHTING MEASURES Hazardous Products of Combustion Carbon Monoxide, and Carbon Dioxide may be formed when burning in a low air supply 2

3 Material reacts violently with Strong Oxidizers Extinguishing Media Water, Dry Chemical, Foam, or Carbon Dioxide Fire Fighting Instructions Water or foam may cause frothing. Use water to disperse the vapors, and provide protection for persons attempting to stop spill, or leak. SECTION 6 * ACCIDENTAL RELEASE MEASURES Small Spill Absorb all liquid on vermiculite, floor absorbent or other absorbent material, and dispose of accordingly. Large Spill Eliminate all sources of ignition ( flares, flames including pilot lights, electrical sparks ) Persons not wearing protective equipment should be excluded from area of spill until clean-up has been completed. Prevent spillage from entering drains, sewers, streams, or other bodies of water. Pump of vacuum transfer spilled product to clean containers for recovery. Asborb unrecoverable product. Transfer contaminated absorbent, soil and other materials to containers for disposal. Prevent any other sources run-off. If run-off occurs, notify proper authorities as required. SECTION 7 * HANDLING AND STORAGE Handling Wash thoroughly with soap, and water after handling. Use eye protection, and wear protective clothing and gloves. Storage Keep container closed when not in use. Store in a cool dry place. Avoid extreme temperatures. 3

4 SECTION 8 * EXPOSURE CONTROLS \ PERSONAL PRETECTION Eye Skin Saftey, or splash goggles are suggested to prevent contact Wear resistant gloves. To prevent repeated or prolonged skin contact wear impervious gloves, clothing, and boots Respiratory Protection Only necessary if the workplace atmospheric concentrations exceed the occupational exposure standards. A NIOSH \ MSHA approved air supplied respirator is advised Ventilation Ventilate as need to comply with exposure limit Boiling Point C SECTION 9 * PHYSICAL AND CHEMICAL PROPERTIES Vapor pressure (mm 20 C) 18 Specific 60 C Vapor Density 1.8 Solubility in Water Soluble ph

5 Evaporation Rate Not determined State Liquid Apperance Green liquid Chemical Stability Stable non-reactive SECTOIN 10 * STABILITY AND REACTIVITY Chemical Incompatibility Material reacts violently with strong oxidizers Hazardous Polymerization Does not occur Products of Hazardous Decomposition Carbon Dioxide, Carbon Monoxide SECTION 11 * TOXICOLOGICAL INFORMATION No Data SECTION 12 * ECOLOGICAL INFORMATION No Data SECTION 13 * DISPOSAL CONSIDERATIONS Waste Management Information Dispose of in accordance with all applicable Local, State and Federal regulations 5

6 SECTION 14 * TRANSPORT INFORMATION DOT Information 49 CFR DOT Description: NON-REGULATED MATERIAL, SPENT ANTIFREEZE SARA 313 Components ETHYLENE GLYCOL SECTION 15 * REGULATORY INFORMATION This product may contain components on the TSCA list. SECTION 16 * OTHER INFORMATION *The information accumulated herein is believed to be accurate but is not warranted to be whether originating with the company or not. Recipients are advised to confirm in advance of need that the information is current, applicable, and suitable to their circumstances. Date prepared: 10/2009 Last Page 6