Why LNG? LNG is mainly produced for transportation purposes. More economical to transport gas as LNG compared to pipelines over long distances

Size: px
Start display at page:

Download "Why LNG? LNG is mainly produced for transportation purposes. More economical to transport gas as LNG compared to pipelines over long distances"

Transcription

1 Classification: Internal Status: Draft LNG Shipping TEP 10 Gas Processing and LNG Trygve G. Egge 2 Topics Why LNG? Historic overview Commercial fundamentals Technical aspects Operational aspects Technology trends

2 3 Why LNG? LNG is mainly produced for transportation purposes. More economical to transport gas as LNG compared to pipelines over long distances Volume ratio between natural gas and LNG is approximate 600:1. 4

3 5 European Cryogenic Courses Commercial fundamentals 6 LNG chain & cost - indications Gas Production Liquefaction Transportation Receiving Terminal $ Bill. $ Bill. $ Bill. $ Bill. $ /MMBtu $ 1-1.5/MMBtu $ /MMBtu $ /MMBtu Total Chain Cost $ per MMBtu US Average forward HH gas price = USD 10 MMBtu Source: Fearnley Consultants AS

4 7 LNG trade routes 8 Development of LNG carrier fleet

5 9 Newbuilding prices LNGC & VLCC 10 Newbuilding acquisition schedule

6 11 LNG transportation safety record LNG shipments started experimentally in the mid 1950 s, but the main trades did not begin until late 1970 s. To date there have been close to 40,000 LNG voyages (80,000 loaded port transits) with no loss of cargo! There have been two serious groundings, both in the late 1970 s, but neither of these resulted in cargo loss. As the El Paso Kayser event was very serious, striking a rock at 19kts, and the LNG Taurus grounding at 12 kts, these events are good confirmations of the inherent strength of this type of vessel with its additional barriers and physical separation of the cargo to the sea. 12 European Cryogenic Courses Technical aspects

7 13 Design Code Design, construction and operation of gas carriers are regulated through UN s shipping organisation IMO (International Maritime Organisation). The regulations are given in the publication International Code for the Construction and Equipment of Ships Carrying Liquefied Gases in Bulk ( Gas Code ). Ships intended for carrying liquefied gases in bulk are categorised in three different types (type 1G, 2G/2PG and 3G) according to the product s hazard potential. LNG is classified as requiring type 2G ship 14 LNG transportation technical aspects LNG is transported at 163 deg. C and at atmospheric pressure This extreme low temperature require that the LNG is transported and handled with special consideration, i.e. Completely separated from the ship s hull LNG temperature must be maintained during the voyage requiring efficient insulation of the cargo tanks All cargo handling equipment must be able to operate at the extreme low temperature of -163 degr. C Two basically different cargo containment systems are used: Self supported independent tanks (Moss Rosenberg spherical tanks, IHI SPB, cylindrical tanks) Membrane tanks (Gaz Transport and Technigaz (GTT)) Market share between the two concepts has been ab. 50/50 - but the membrane concept has been increasingly selected for recent newbuilding orders.

8 15 Spherical tank cargo containment systems (Moss Rosenberg ) 16 Spherical LNG cargo tanks pros & cons Advantages Independent from the ship s hull hull stresses not transferred into the cargo tanks Very robust design No sloshing problems Can operate with partly filled tanks Allow simultaneous building of hull and cargo tanks Easy to inspect Easy to detect and repair leakages Disadvantages Low volumetric utilisation of the hull Larger physical dimensions for same capacity compared with prismatic tanks Visibility from bridge reduced compared with ships with prismatic tanks Require return cargo ( heel ) on ballast voyage to keep cargo tanks cooled

9 17 Upper half of spherical cargo tank 18 IHI SPB Tank

10 19 SPB cargo containment system pros & cons Advantages Independent from ship s hull Robust design No sloshing problems/ no filling restrictions High utilisation factor of the ship s hull Allow simultaneous construction of hull and tanks Smaller physical dimensions for same capacity compared to spherical tank design Disadvantages Costly to manufacture the cargo tanks Require heel on ballast voyage to maintain cooled down tanks 20 Ocean LNG Cylindrical Independent Tank

11 21 LNGC Membrane cargo containment system (GT No. 96, MK I and MK III, and CS1) 22 Mark III (Technigaz) Membrane system

12 23 Membrane cargo containment system (GTT) pros & cons Advantages High volumetric utilisation of ship s hull Less sensitive to temperature changes as inner membrane (invar steel) has very low thermal contraction coefficient Limited need for heel on ballast voyage Disadvantages Cargo tanks are an integrated part of the ship s hull - hull stresses transferred to cargo tanks Does not allow simultaneous construction of hull and cargo tanks Difficult to detect and costly to repair leakages Restricted filling ratio LNG Carriers Cargo containment systems 24

13 25 European Cryogenic Courses Operational aspects LNGC operating particulars 26 During transit voyages, boil off gas (BOG) is either used as fuel in the boilers for generating steam (steam ship) or re liquefied A small amount of LNG is retained onboard after discharging ( heel ) and is used for cooling the cargo tanks during the ballast voyage Measurements (custody and fiscal) of LNG is performed on board the ship after loading and discharging. LNG used by the ship is determined for each voyage Total port time is hours including port clearance, safety checks, loading/discharging, cargo measurements, connection/disconnection of cargo arms Transit speed between knots Fuel consumption about t/24 h (steam ship) Complement persons

14 27 Ship/shore interfaces In order to achieve safe and efficient loading and discharging operation, standardised ship/shore interfaces are important. For LNG ships, the ship/shore interfaces are designed according to the following standards: SIGTTO (Society of International Gas Tanker and Terminal Operators) OCIMF (Oil Companies International Maritime Forum) EN 1532 (European Norm) Typical Ship/Shore interfaces include: Ship size (max/min) Arrangement of loading arms Fender arrangement Mooring arrangement Shore gangway ESD (Emergency Shut Down System) Normal and emergency communication system 28 European Cryogenic Courses Technology trends

15 29 Market and Technology trends Shipping demand is driven by: New trading routes Increased trading volumes Increased trading distances New vessels are adapting: New areas harsh environment arctic design conditions Increased vessel size Alternative propulsion system 30 LNG trade the past situation

16 31 LNG trade the future 32 New LNG trades harsh environment New LNG projects are being developed in remote and environmentally sensitive areas. Snøhvit Sakhalin Shtokman For arctic projects, the transportation will require special consideration wrt: Low sea and air temperatures High wind velocity High sea states Reduced visibility Long duration of adverse weather

17 33 LNG ships design aspects To secure the required off-take and transportation regularity with the highest level of safety, the following design aspects need to be considered: Structural safety (ice strengthening, fatique, extended FEM calculations). Environmental and safety features Navigation Winterisation (enclosed working areas, heat tracing of equipment). 34 Increased ship sizes The increasing demand for LNG, especially in the US and Europe, and the need to reduce long haul transportation costs from the Middle East to US/Europe, is driving the current increase in ship size. While max. ship size for existing terminals is ab m3, sizes in excess of m3 has recently been ordered. These bigger sizes are limited to specific projects which involve either the construction of new terminals or the construction of offshore terminals ( Energy Bridge, SRV, etc.)

18 35 LNG Carriers Growth in the average capacity 36 Illustration of relative size of LNG carriers

19 37 Alternative propulsion system For the larger ship sizes, propulsion system has become an issue. The draft limitation makes it difficult to design an efficient propeller and hull form for a single screw vessel. This has led to the development of a twin-skeg, twin-screw propulsion arrangement as a design solution for maintaining normal trading speed ( ab. 20 kn). In turn, this has led the industry to look for alternative propulsion systems to the commonly used steam turbine plant. Systems considered are: Dual fuel diesel electric Twin slow speed diesel engines with reliquefaction of boil off gas Gas turbine Of these alternatives, the two first have already been selected for recent large size newbuilding orders. 38 Alternative propulsion system, cont. The main advantage of the diesel alternatives over steam turbine is the improvement in fuel efficiency. Diesel engines have 20 % better thermal efficiency compared to steam turbines. For a diesel LNGC with reliquefaction of BOG, this results in fuel saving of ab. 50 t HFO pr. day (24 h) for a Snøhvit size LNGC. In addition, a full cargo of LNG will be delivered (and paid for)!

20 39 Steam turbine FO Boiler BOG Advantages Low vibrations High proven reliability Low maintenance cost Dual fuel capability Low NOx emission R/G S/T Disadvantages Low fuel efficiency (ab 30 %) High CO2 emission Large engine room space Few makers Reduced number of skilled engineers 40 Dual Mode Gas/Diesel engines Advantages Environmentally friendly by using gas (no SO x, reduced NO x, reduced amount of particles) High redundancy of propulsion and power generating system Reduced total power installed due to flexibility in different operating modes Disadvantages High initial cost Reduced delivered cargo LNG used as fuel Require high quality fuel (LNG/MDO)

21 41 Slow speed diesel engines with re-liquefaction system (twin screw) FO Tank G BOG Cycle G C E C G N2 Cycle G FO Tank 42 Slow speed diesel engine with re-liquefaction plant Advantages High overall fuel efficiency Proven propulsion system with high level of reliability No loss of cargo 100% delivered to customer Lower initial cost Reduced CO 2 emission Disadvantages Slightly higher vibration compared to steam and diesel-electric propulsion Need separate auxiliary generators therefore high total installed power High NOx emission Single fuel capability High maintenance cost

22 43 Gas turbine & electric motors Advantages FO BOG Exh.gas MGO BOG Reduced engine room space Low level of vibration and noise Redundant propulsion Reduced maintenance Gas turbine Low NOx emission Boiler S/T Disadvantages Not used in LNGC yet R/G Motor High initial cost 44 Arctic Shipping

23 Shipping distances and unit cost 45

Marine Transportation of LNG. Intertanko Conference March 29, 2004 Bob Curt Ship Acquisition Manager, QatargasII Development

Marine Transportation of LNG. Intertanko Conference March 29, 2004 Bob Curt Ship Acquisition Manager, QatargasII Development Marine Transportation of LNG Intertanko Conference March 29, 2004 Bob Curt Ship Acquisition Manager, QatargasII Development Marine Transportation of LNG Topics What is LNG? History of LNG Marine Transportation

More information

American Institute of Marine Underwriters

American Institute of Marine Underwriters American Institute of Marine Underwriters State of the LNG Industry: A Class Perspective William J. Sember Vice President, Energy Development ABS New York City 30 September 2005 1 Overview Ship Capacity

More information

Handling and Transportation of LNG

Handling and Transportation of LNG Handling and Transportation of LNG History and Examples of LNG use Whereas Liquid Petroleum Gas (LPG) is carried under pressure, Liquid Natural Gas (LNG) is carried at atmospheric pressure and has been

More information

Lecture 10 LNG Shipping

Lecture 10 LNG Shipping Liquefaction Processes Lecture 10 LNG Shipping Slide 1 Liquefaction Processes Tanker Types Slide 2 1 Containment Systems Self- Supporting Liquefaction Processes Membrane Type A Type B Gaz Transport (GT)

More information

RISKS ASSOCIATED WITH THE MARINE ASPECTS OF LNG FPSOs (FLOATING PRODUCTION, STORAGE AND OFFLOAD) UNITS. Braemar Engineering

RISKS ASSOCIATED WITH THE MARINE ASPECTS OF LNG FPSOs (FLOATING PRODUCTION, STORAGE AND OFFLOAD) UNITS. Braemar Engineering RISKS ASSOCIATED WITH THE MARINE ASPECTS OF LNG FPSOs (FLOATING PRODUCTION, STORAGE AND OFFLOAD) UNITS Agenda Introduction to LNG what is it, what are the risks, what are the myths? Introduction to FLNG

More information

Ship Transportation of Natural Gas

Ship Transportation of Natural Gas Ship Transportation of Natural Gas Market and Technology. Presented by Jan Koren, Business Director Tankers 26th May, 2005 Slide 1 The Scene is changing what is happening? Dramatic increase in number of

More information

GUIDANCE ON LNG BoG MONITORING

GUIDANCE ON LNG BoG MONITORING 23 rd May 2017 GUIDANCE ON LNG BoG MONITORING 1 PURPOSE This paper provides guidance to the verifier and the company for the on-onboard monitoring of boil off gas (BoG) and recording of data for the purpose

More information

Development of Efficient, Environmentally Friendly and Flexible Shipboard Regasification Vessel

Development of Efficient, Environmentally Friendly and Flexible Shipboard Regasification Vessel 13 Development of Efficient, Environmentally Friendly and Flexible Shipboard Regasification Vessel KENJI TSUMURA *1 MASARU OKA *1 TOSHIO OGATA *2 MAKOTO TABIRA *2 Mitsubishi Heavy Industries, Ltd., (MHI)

More information

A Leader In Maritime Technology

A Leader In Maritime Technology A Leader In Maritime Technology Table of Contents Overview 1 LNG Carriers 4 Floating Units 6 Offshore Platforms 8 Octabouy Production Platforms 10 Supply and Service Vessels 12 From the beginning, the

More information

The World First Ever Very Large Ethane Carrier (VLEC)

The World First Ever Very Large Ethane Carrier (VLEC) The World First Ever Very Large Ethane Carrier (VLEC) Gastech 2017, Tokyo 4 th April 2017 This document contains information resulting from testing, experience and know-how of GTT, which are protected

More information

EUROPEAN ENERGY FORUM 2013

EUROPEAN ENERGY FORUM 2013 EUROPEAN ENERGY FORUM 2013 28 th May 2013 1 Wärtsilä Our business areas POWER PLANTS SHIP POWER SERVICES 2 Wärtsilä This is what we bring to the market EFFICIENCY ENVIRONMENTAL SOLUTIONS FUEL FLEXIBILITY

More information

Environmentally Friendly & Superior Solution with LNG as Fuel

Environmentally Friendly & Superior Solution with LNG as Fuel Environmentally Friendly & Superior Solution with LNG as Fuel ClassNK R&D Project LNG-Fuelled Vessel Technologies Seminar July 2014 Takashi Unseki Ship & Ocean Engineering Department 2012 MITSUBISHI HEAVY

More information

Comparison of Spherical and Membrane Large LNG Carriers in Terms of Cargo Handling

Comparison of Spherical and Membrane Large LNG Carriers in Terms of Cargo Handling Comparison of Spherical and Membrane Large LNG Carriers in Terms of Cargo Handling Kiho Moon,, Daejun Chang, Donghun Lee Myung-Bae Kim, Ho-Jong Ahn, and Jong-Pil Ha Hyundai Heavy Industries Co., Ltd. HIGHLIGHTS

More information

MB05. RESPOND TO EMERGENCIES BASIC KNOWLEDGE OF EMERGENCY PROCEDURES, INCLUDING EMERGENCY SHUTDOWN

MB05. RESPOND TO EMERGENCIES BASIC KNOWLEDGE OF EMERGENCY PROCEDURES, INCLUDING EMERGENCY SHUTDOWN MB05. RESPOND TO EMERGENCIES BASIC KNOWLEDGE OF EMERGENCY PROCEDURES, INCLUDING EMERGENCY SHUTDOWN Plan of the lecture 1. DRILLS AND EMERGENCY EXERCISES (general requirements) 2. Emergency procedures and

More information

ConferenzaGNL 2014 GENOVA 27/10/2014. Tipologie e caratteristiche di navi con propulsione GNL e relative sistemazioni degli impianti M.E.S.

ConferenzaGNL 2014 GENOVA 27/10/2014. Tipologie e caratteristiche di navi con propulsione GNL e relative sistemazioni degli impianti M.E.S. 27/10/2014 GENOVA 27/10/2014 Tipologie e caratteristiche di navi con propulsione GNL e relative sistemazioni degli impianti M.E.S. MARINE ENGINEERING SERVICES PRESENTATION Introduction INTRODUCTION M.E.S.

More information

Development of SPB LNG Fuel Tank for Ships

Development of SPB LNG Fuel Tank for Ships Gastech 2017 Development of SPB LNG Fuel Tank for Ships Structure Engineering Group Gas Project Department Offshore and Engineering Division Contents (1)Introduction (2)Concept Design of SPB LNG Fuel Tank

More information

Creating Optimal LNG Storage Solutions. 40 in detail

Creating Optimal LNG Storage Solutions. 40 in detail [ MARINE / IN DETAIL ] [ MARINE / IN DETAIL ] Creating Optimal LNG Storage Solutions AUTHOR: Sören Karlsson, Business Development Manager, Wärtsilä Marine Solutions mail: soren.karlsson@wartsila.com 40

More information

Need update. Maritime Forecast to 2050 SAFER, SMARTER, GREENER DNV GL 2018

Need update. Maritime Forecast to 2050 SAFER, SMARTER, GREENER DNV GL 2018 Need update Maritime Forecast to 2050 1 SAFER, SMARTER, GREENER FORECAST TO 2050 - SUITE OF PUBLICATIONS 2 The Maritime forecast to 2050 provides projections for Maritime forecast to 2050 provides outlooks

More information

MB05. RESPOND TO EMERGENCIES BASIC KNOWLEDGE OF EMERGENCY PROCEDURES, INCLUDING EMERGENCY SHUTDOWN

MB05. RESPOND TO EMERGENCIES BASIC KNOWLEDGE OF EMERGENCY PROCEDURES, INCLUDING EMERGENCY SHUTDOWN MB05. RESPOND TO EMERGENCIES BASIC KNOWLEDGE OF EMERGENCY PROCEDURES, INCLUDING EMERGENCY SHUTDOWN Plan of the lecture 1. DRILLS AND EMERGENCY EXERCISES (general requirements) 2. Emergency procedures and

More information

JungHan Lee, Principal Research Engineer, Daewoo Shipbuilding & Marine Engineering Company

JungHan Lee, Principal Research Engineer, Daewoo Shipbuilding & Marine Engineering Company PROGRAMME GASTECH 2OO2 JungHan Lee, Principal Research Engineer, Daewoo Shipbuilding & Marine Engineering Company JungHan Lee is currently the leader of Ship/Plant System R&D team of Daewoo Shipbuilding

More information

Environmentally Superior Vessels with LNG as Fuel; Achievements and Prospects for the Near Future

Environmentally Superior Vessels with LNG as Fuel; Achievements and Prospects for the Near Future Environmentally Superior Vessels with LNG as Fuel; Achievements and Prospects for the Near Future The 7 th Asian shipbuilding Experts Forum (ASEF) 7 Nov. 2013 Takashi Unseki Ship & Ocean Engineering Department

More information

Anatomy of LNG Shipping & Operations

Anatomy of LNG Shipping & Operations Anatomy of LNG Shipping & Operations 13-17 May 2018 The Møller Centre Cambridge Organised by Cambridge Academy of Transport 48 Whittlesford Road Little Shelford Cambridge CB22 5EW Tel: +44 (0)1223 845242

More information

Risk Assessment of Operation of LNG Tankers. LNG Conference Copenhagen

Risk Assessment of Operation of LNG Tankers. LNG Conference Copenhagen Risk Assessment of Operation of LNG Tankers LNG Conference Copenhagen Risk Assessment of LNG Tanker Operations Liquefied Gas ships are unlike any other in the risks that they pose to the ship and environment.

More information

SCF Shipping Solutions for Yamal LNG Innovative Design for the Arctic Sergey Frank, President & CEO

SCF Shipping Solutions for Yamal LNG Innovative Design for the Arctic Sergey Frank, President & CEO SCF Shipping Solutions for Yamal LNG Innovative Design for the Arctic Sergey Frank, President & CEO Gastech Exhibition & Conference 4-7 April 2017 Tokyo, Japan SCF 2016: Global Leadership in Seaborne Energy

More information

LNG Systems for Marine Application. LNG Reliquefaction & LNG Regasification. Oil & Gas Systems

LNG Systems for Marine Application. LNG Reliquefaction & LNG Regasification. Oil & Gas Systems LNG Systems for Marine Application LNG Reliquefaction & LNG Regasification Oil & Gas Systems LNG reliquefaction plant arrangement for a Q-flex membrane tanker Reliquefaction system for LNG Carriers Hamworthy

More information

2017 LPG Loading Master & Certification (3 Days)

2017 LPG Loading Master & Certification (3 Days) 2017 LPG Loading Master & Certification (3 Days) To work as a Loading Master, one has to have the operational knowledge, the technical skill and has to understand the LPG ship/shore Interface. This training

More information

Need update. Maritime Forecast to 2050 SAFER, SMARTER, GREENER DNV GL 2018

Need update. Maritime Forecast to 2050 SAFER, SMARTER, GREENER DNV GL 2018 Need update Maritime Forecast to 2050 1 SAFER, SMARTER, GREENER The Maritime forecast to 2050 provides projections for Maritime forecast to 2050 provides projections for key drivers Regulation Technology

More information

On Board Regasification for LNG Ships. 22 nd World Gas Conference WS 3-2 Tokyo 2003 Wayne Perry

On Board Regasification for LNG Ships. 22 nd World Gas Conference WS 3-2 Tokyo 2003 Wayne Perry On Board Regasification for LNG Ships 22 nd World Gas Conference WS 3-2 Tokyo 2003 Wayne Perry New Greenfield U.S. Terminals Will Be Almost Impossible to Site Key opportunity is to solve U.S. terminalling

More information

Hamburg, October 2014 Brian Bender Madsen

Hamburg, October 2014 Brian Bender Madsen Hamburg, October 2014 Brian Bender Madsen OVERVIEW OF PRESENTATION 1. INTRODUCTION OF KNUD E. HANSEN A/S 2. ECO SHIP DESIGN? 3. WHAT IS OUR OPTIONS? 4. TAILOR MADE -KEH DESIGN PHASES OUR OPTIONS INITIAL/CONCEPT

More information

MARITIME LNG, REGULATION AND LOCAL DEVELOPMENT FRAMEWORK 25 November 2014 Andrew Morris, Director

MARITIME LNG, REGULATION AND LOCAL DEVELOPMENT FRAMEWORK 25 November 2014 Andrew Morris, Director MARITIME LNG, REGULATION AND LOCAL DEVELOPMENT FRAMEWORK 25 November 2014 Andrew Morris, Director INTRODUCTION Providing clarity to the regulatory issues around LNG for marine transport SOx emission limits

More information

IMO future plans for regulation

IMO future plans for regulation 1) / MARPOL Annex VI SOx Emission Limit Data: tri-zen MARPOL Annex VI NOx Emission Limits Data: tri-zen IMO future plans for regulation The vessel which has been built since January, 2013 should observe

More information

Structural and Containment System Design Aspects of Large LNG Ships

Structural and Containment System Design Aspects of Large LNG Ships Structural and Containment System Design Aspects of Large LNG Ships by Jim MacDonald LNG Ship Maximum Capacity Progression 250000 200000 150000 100000 50000 0 1950 1960 1970 1980 1990 2000 2010 Mid 1970

More information

LNG as a Bunker Fuel - LNGF (3 Days)

LNG as a Bunker Fuel - LNGF (3 Days) 2017-2018 LNG as a Bunker Fuel - LNGF (3 Days) This LNG as a Bunker Fuel training course explains everything you need to know to ensure you are up to date with this exciting new development in the marine

More information

2019 LNG as a Bunker Fuel - LNGF (3 Days)

2019 LNG as a Bunker Fuel - LNGF (3 Days) 2019 LNG as a Bunker Fuel - LNGF (3 Days) This LNG as a Bunker Fuel training course explains everything you need to know to ensure you are up to date with this exciting new development in the marine sector.

More information

The Steps Before Unmanned Ships

The Steps Before Unmanned Ships The Steps Before Unmanned Ships Oskar Levander, VP Innovation, Rolls-Royce Marine Smart Operations Copenhagen, 6.10.2015 2015 Rolls-Royce plc The information in this document is the property of Rolls-Royce

More information

Chapter 23. Liquefied Natural Gas

Chapter 23. Liquefied Natural Gas Chapter 23 Liquefied Natural Gas In 1959, the Methane Pioneer carried the first experimental LNG cargo and, in 1964, British Gas at Canvey Island received the inaugural cargo from Arzew on the Methane

More information

LNG carriers and bunkering vessels

LNG carriers and bunkering vessels ConferenzaGNL - ROMA 10/04/2014 LNG carriers and bunkering vessels M.E.S. MARINE ENGINEERING SERVICES PRESENTATION SUMMARY INTRODUCTION SUMMARY COMPANY PROFILE History PRODUCTS / SERVICES LNG Extract from

More information

A new re-liquefaction system of MRS-F (Methane Refrigeration System Full re-liquefaction) for LNG Carriers

A new re-liquefaction system of MRS-F (Methane Refrigeration System Full re-liquefaction) for LNG Carriers A new re-liquefaction system of MRS-F (Methane Refrigeration System Full re-liquefaction) for LNG Carriers DongKyu Choi *, Hyunjun Shin DAEWOO SHIPBUILDING AND MARINE ENGINEERING Co., Ltd. Dual fuel slow-speed

More information

The Technical & Practical challenges of FLNG

The Technical & Practical challenges of FLNG SUT Evening Technical Meeting: On the Fringes of FLNG, Perth 19/08/2015 Jeff Baker Energy Compliance Technical Manager, Australasia Working together for a safer world Agenda Introduction Acknowledgement

More information

The latest issues on gas fuelled ship (including New IGF Code)

The latest issues on gas fuelled ship (including New IGF Code) The latest issues on gas fuelled ship (including New IGF Code) S. S. LEE December 2015 Contents 1. How to decide gas fuelled ship for new shipbuilding? 2. Selection of gas fuel tanks 3. Use LNG as fuel

More information

Table of contents. 1. Global Environments 2. Green Ship Technologies in Korea

Table of contents. 1. Global Environments 2. Green Ship Technologies in Korea 1 Table of contents 1. Global Environments 2. Green Ship Technologies in Korea 2 1. Global Environments 3 IMO Regulations International Maritime Organization Energy Efficiency, NOx, SOx, PM/BC, VOCs, Fuel

More information

LNG Carriers Ship Life Extension. Ed Waryas. Lloyd s Register North America, Inc.

LNG Carriers Ship Life Extension. Ed Waryas. Lloyd s Register North America, Inc. LNG Carriers Ship Life Extension Ed Waryas Lloyd s Register North America, Inc. Longevity Study - Outline Owners Records Classification Records Ship inspection RAM Study Structural Integrity Analysis Owner

More information

B.C. TOWBOAT INDUSTRY CONFERENCE

B.C. TOWBOAT INDUSTRY CONFERENCE LN G T erm inals on C ana da s W est C oast Kitimat LNG LN G T erm inals on C ana da s W est C oast Presentation to 17 th B.C. TOWBOAT INDUSTRY CONFERENCE Whistler, BC Kitimat LNG Alfred Sorensen Kitimat

More information

(12) Patent Application Publication (10) Pub. No.: US 2008/ A1

(12) Patent Application Publication (10) Pub. No.: US 2008/ A1 (19) United States US 20080276627A1 (12) Patent Application Publication (10) Pub. No.: US 2008/0276627 A1 Lee et al. (43) Pub. Date: Nov. 13, 2008 (54) FUEL GAS SUPPLY SYSTEMAND METHOD (30) Foreign Application

More information

OVER VIEW OF LNG SHIPPING SAFETY CONCERNS. Presentation by Capt. B.B. Sinha. The Shipping Corporation of India Ltd New Delhi.

OVER VIEW OF LNG SHIPPING SAFETY CONCERNS. Presentation by Capt. B.B. Sinha. The Shipping Corporation of India Ltd New Delhi. OVER VIEW OF LNG SHIPPING SAFETY CONCERNS Presentation by Capt. B.B. Sinha. The Shipping Corporation of India Ltd. 15.02.2010. New Delhi. Journey of LNG 1917: First commercial natural gas liquefaction

More information

LNG CARRIERS. Eniram Solutions for H I G H W I N D S O N T H E R O U T E - T R I M 2 3 C M B Y T H E B O W F O U L I N G I N C R E A S E D B Y 1 2

LNG CARRIERS. Eniram Solutions for H I G H W I N D S O N T H E R O U T E - T R I M 2 3 C M B Y T H E B O W F O U L I N G I N C R E A S E D B Y 1 2 H I G H W I N D S O N T H E R O U T E - T R I M 2 3 C M B Y T H E B O W F O U L I N G I N C R E A S E D B Y 1 2. 3 % - D R O P R P M B Y 4 R U N D G 3 I N S T E A D O F D G 1 - Y O U A R E A N K E D 2

More information

Marine Facilities for LNG Carrier Transfer Alternatives

Marine Facilities for LNG Carrier Transfer Alternatives 2.3.3.2 Marine Facilities for LNG Carrier Transfer Alternatives Two alternatives were considered for the marine facilities to support the transfer of LNG between the LNG carriers and onshore storage tanks.

More information

Low Carbon Technology for Marine Application. Hyundai Heavy Industries / Corporate Research Center Se-Young Oh, Sangmin Park Nov.

Low Carbon Technology for Marine Application. Hyundai Heavy Industries / Corporate Research Center Se-Young Oh, Sangmin Park Nov. Low Carbon Technology for Marine Application Hyundai Heavy Industries / Corporate Research Center Se-Young Oh, Sangmin Park Nov. 29, 2018 Contents 1. Background 2. Hydrogen Energy for Marine Application

More information

Ship Powering Options for the Future. An Outline Synopsis of the Study

Ship Powering Options for the Future. An Outline Synopsis of the Study Ship Powering Options for the Future An Outline Synopsis of the Study Maritime Studies at City University London Propeller Vibration Marine Supply Chain Dynamics Institute of Cavitation Research Container

More information

2019 LPG Loading Master & LPG Terminal Operations - 3 days

2019 LPG Loading Master & LPG Terminal Operations - 3 days 2019 LPG Loading Master & LPG Terminal Operations - 3 days Session 1. Skills and Knowledge Evaluation Examine through brief interaction existing knowledge of the attendees to identify which areas need

More information

Panel Discussion: Energy Conservation

Panel Discussion: Energy Conservation Panel Discussion: Energy Conservation CLIA Leadership Forum Westin Diplomat Resort & Spa Hollywood, FL Nov 29 Dec 2, 2011 Eero Mäkinen SVP Marketing STX Finland Oy Energy Consumption - Environment Energy

More information

Christopher R Clucas. Current Position at CWA

Christopher R Clucas. Current Position at CWA Christopher R Clucas Qualifications Affiliations Chartered Engineer BSc (Sp Hons) Chemistry (1970/73), University of Sheffield MSc Cryogenic Engineering (1978/79), University of Southampton Member of the

More information

SAMSUNG Energy Plant: All-in-One Solution for Floating Power Plants with Gas-fired Combined Cycle Gas Turbines

SAMSUNG Energy Plant: All-in-One Solution for Floating Power Plants with Gas-fired Combined Cycle Gas Turbines SAMSUNG Energy Plant: All-in-One Solution for Floating Power Plants with Gas-fired Combined Cycle Gas Turbines Myung-Kwan Song, Yongseok Song, Jeong Oh Hwang, Changwoo Lee, and Wonkyu Lee 5 th April 2017

More information

LNG Bunkering and the risks involved in operations using LNG as fuels

LNG Bunkering and the risks involved in operations using LNG as fuels LNG Bunkering and the risks involved in operations using LNG as fuels May 2018 1 SAFER, SMARTER, GREENER How to handle LNG mainly driven by: Physical properties The Fundamental role of Class to ensure

More information

Design Concept and Features of the Mitsubishi LNG-FPSO (Floating Production, Storage and Offloading Unit)

Design Concept and Features of the Mitsubishi LNG-FPSO (Floating Production, Storage and Offloading Unit) 7 Design Concept and Features of the Mitsubishi LNG-FPSO (Floating Production, Storage and Offloading Unit) YOSHIKAZU FUJINO *1 AKIRA ZAITSU *1 YASUHIKO HINATA *2 HIROTOMO OTSUKA *1 In recent years, floating

More information

Part 0 - Classification and Surveys Classification and Surveys I Classification and Surveys I

Part 0 - Classification and Surveys Classification and Surveys I Classification and Surveys I This edition of GL rules & guidelines is the latest and current edition. Previous editions of GL rules & guidelines, as well as all DNV GL rules and supporting documents, are available from https://www.dnvgl.com/rules-standards.

More information

Ship Efficiency: The Event 2016 Fathom Maritime Intelligence. Going Green as Sustainable Business Strategy

Ship Efficiency: The Event 2016 Fathom Maritime Intelligence. Going Green as Sustainable Business Strategy Ship Efficiency: The Event 2016 Fathom Maritime Intelligence Going Green as Sustainable Business Strategy Wilh. Wilhelmsen ASA /// November 2016 Iver Iversen, Director New Technology and Regulatory affairs

More information

Braemar Technical Services

Braemar Technical Services Braemar Technical Services Cargo Handling and Emergency Shutdown Systems in an LNG cargo vessel - What is the Connection? By Ray Martyn 20 th April 2017 Overview Introduction to the Cargo Handling System

More information

Transport Costs Affecting LNG Delivery by Moss Type Carriers

Transport Costs Affecting LNG Delivery by Moss Type Carriers Transport Costs Affecting LNG Delivery by Moss Type Carriers Tatjana Stanivuk, Tonći Tokić a, Svetislav Šoškić b The paper discusses the influence of transportation costs on the delivery of liquefied natural

More information

LNG as a marine bunker fuel

LNG as a marine bunker fuel LNG as a marine bunker fuel Technical Committees September 2012 Tim Kent Technical Director, Marine Agenda Drivers for the use of LNG as fuel Issues associated with the use of LNG as fuel Rules, Regulations

More information

Introduction of Gas Turbine- Powered, LPG Fueled Ship. Byeongyeol Baek Advanced Lead Engineer GE s Marine Solutions March 6 to 7, 2018

Introduction of Gas Turbine- Powered, LPG Fueled Ship. Byeongyeol Baek Advanced Lead Engineer GE s Marine Solutions March 6 to 7, 2018 Introduction of Gas Turbine- Powered, LPG Fueled Ship Byeongyeol Baek Advanced Lead Engineer GE s Marine Solutions March 6 to 7, 2018 Presentation Title February 9, 2 GE s Marine Solutions +1,400 Vessel

More information

Properties Of Membrane Tanks For Transportation Of LNG Cargo On Ships

Properties Of Membrane Tanks For Transportation Of LNG Cargo On Ships 1 Properties Of Membrane Tanks For Transportation Of LNG Cargo On Ships LNG as fuel is now a proven and available solution for the shipping industry. While conventional oil-based fuels remain the main

More information

Alternative approaches to monitoring - 'Digital Twin' of vessel performance -

Alternative approaches to monitoring - 'Digital Twin' of vessel performance - Green Ship Technology 2017 Copenhagen, Denmark Alternative approaches to monitoring - 'Digital Twin' of vessel performance - 24 th March 2017 Hideyuki Ando MTI, NYK Group Monohakobi Outline 1. Introduction

More information

LNG: strategic challenge for the Mediterranean Shipping

LNG: strategic challenge for the Mediterranean Shipping LNG: strategic challenge for the Mediterranean Shipping Michele FRANCIONI COO RINA Services S.p.A. 9 th MARE FORUM Italy 08 th May 2013 A holistic approach Regulatory and Authorization Aspects Technical

More information

Current Development of Shipbuilding Technology - Japan. Dave (Hiroshi) IWAMOTO Chairman of International sub-committee, SAJ

Current Development of Shipbuilding Technology - Japan. Dave (Hiroshi) IWAMOTO Chairman of International sub-committee, SAJ Current Development of Shipbuilding Technology - Japan Dave (Hiroshi) IWAMOTO Chairman of International sub-committee, SAJ Contents : - Environmentally Friendly Ship e Future Series (IHIMU) - LNG-Fuelled

More information

Ship Energy Efficiency Management Plan (SEEMP) Guidance Notes for Ship Owners and Ship Operators. Asia Pacific Ship Registry

Ship Energy Efficiency Management Plan (SEEMP) Guidance Notes for Ship Owners and Ship Operators. Asia Pacific Ship Registry Ship Energy Efficiency Management Plan (SEEMP) Guidance Notes for Ship Owners and Ship Operators 2014-2016 Asia Pacific Ship Registry Asia Pacific Ship Registry Recent developments at IMO in the form of

More information

A clean environment. Towards zero-emission shipping BUSINESS WHITE PAPER KEY BENEFITS CONTENTS

A clean environment. Towards zero-emission shipping BUSINESS WHITE PAPER KEY BENEFITS CONTENTS A clean environment Towards zero-emission shipping BUSINESS WHITE PAPER CONTENTS KEY BENEFITS I. Introduction... 2 II. Striving for sustainable performance and ensuring compliance... 2 III. Cutting costs

More information

Energy Efficiency SEEMP

Energy Efficiency SEEMP Energy Efficiency SEEMP Contents Introduction How to Implement the SEEMP Best Practices Advantages Limitations Introduction What is the SEEMP The Ship Energy Efficiency Management Plan (SEEMP) is a plan/tool

More information

LNG Shipping. Taking Gas and Power Further. Shell Gas & Power

LNG Shipping. Taking Gas and Power Further. Shell Gas & Power LNG Shipping Taking Gas and Power Further Shell Gas & Power TRANSPORTATION OF NATURAL GAS BY SEA A critical part of the natural gas supply chain is transportation. When a natural gas source is near a significant

More information

RESOLUTION MEPC.213(63) Adopted on 2 March GUIDELINES FOR THE DEVELOPMENT OF A SHIP ENERGY EFFICIENCY MANAGEMENT PLAN (SEEMP)

RESOLUTION MEPC.213(63) Adopted on 2 March GUIDELINES FOR THE DEVELOPMENT OF A SHIP ENERGY EFFICIENCY MANAGEMENT PLAN (SEEMP) MEPC 63/23 Annex 9, page 1 ANNEX 9 RESOLUTION MEPC.213(63) THE MARINE ENVIRONMENT PROTECTION COMMITTEE, RECALLING article 38(a) of the Convention on the International Maritime Organization concerning the

More information

Big Data in Ship Operation

Big Data in Ship Operation World NAOE Forum 2014 The Use of Big Data in Marine & Ocean Engineering Big Data in Ship Operation 28 th November 2014 Hideyuki Ando, MTI 1 Monohakobi What is big data? Big data refers to datasets whose

More information

This document is a preview generated by EVS

This document is a preview generated by EVS INTERNATIONAL STANDARD ISO 20519 First edition 2017-02 Ships and marine technology Specification for bunkering of liquefied natural gas fuelled vessels Navires et technologie maritime Spécification pour

More information

SUSTAINABLE SHIPPING AND PORT TRENDS. Habil. Dr., Captain, Prof. Vytautas Paulauskas Klaipeda Shipping Research Centre

SUSTAINABLE SHIPPING AND PORT TRENDS. Habil. Dr., Captain, Prof. Vytautas Paulauskas Klaipeda Shipping Research Centre SUSTAINABLE SHIPPING AND PORT TRENDS Habil. Dr., Captain, Prof. Vytautas Paulauskas Klaipeda Shipping Research Centre SUSTAINABLE SHIPPING AND PORT DEVELOPMENT WHOT IT IS? The aim of this presentation

More information

IACS Rec s and Panel Responsible

IACS Rec s and Panel Responsible 1 Portable electrical equipment - Deleted Dec 1996 2 Type of hatch cover required if a lower deck is designated as the freeboard deck - Deleted Nov 2010 3 Deleted 4 Deleted 1996 5 Method of corrosion fatigue

More information

Ship to Ship Transfer (POAC/Superintendent) for Liquefied Natural Gas and Liquefied Petroleum Gas (LNG or LPG) (3 days) (OCIMF)

Ship to Ship Transfer (POAC/Superintendent) for Liquefied Natural Gas and Liquefied Petroleum Gas (LNG or LPG) (3 days) (OCIMF) 2017-2018 Ship to Ship Transfer (POAC/Superintendent) for Liquefied Natural Gas and Liquefied Petroleum Gas (LNG or LPG) (3 days) (OCIMF) This training program was created based on the 2013 OCIMF, CDI,

More information

IACS Rec s and Panel Responsible

IACS Rec s and Panel Responsible 1 Portable electrical equipment - Deleted Dec 1996 2 Type of hatch cover required if a lower deck is designated as the freeboard deck - Deleted Nov 2010 3 Deleted 4 Deleted 1996 5 Method of corrosion fatigue

More information

ABI6010 International Technical Certificate in Jetty and Terminal Operational Safety UNIT 1 TERMINAL MANAGEMENT, SAFETY AND SECURITY

ABI6010 International Technical Certificate in Jetty and Terminal Operational Safety UNIT 1 TERMINAL MANAGEMENT, SAFETY AND SECURITY ABI6010 International Technical Certificate in Jetty and Terminal Operational Safety UNIT 1 TERMINAL MANAGEMENT, SAFETY AND SECURITY ELEMENT 1 Regulations, Guidance and Legislation 1.1 Shipping Industry

More information

READY FOR EVERYTHING

READY FOR EVERYTHING READY FOR EVERYTHING Manos Migadis DYNACOM TANKERS MANAGEMENT LTD Greener Shipping Summit 2018 The Power of Legislation New environmental regulations are making shipbuilding industry to get prepared and

More information

Fuel Efficient Container Liner Fleet Operations

Fuel Efficient Container Liner Fleet Operations Fuel Efficient Container Liner Fleet Operations Digital Ship Hamburg, March 2015 Andreas Mrozek 1 Hamburg Süd 1 2 4 Oetker-Group Hamburg Süd Fuel Saving Challenges and future factors to consider 2 Divisions

More information

LNG BUNKERING VESSELS AND CNG CARRIERS -Innovative solutions to improve sustainability- LNG/SHORE POWER Workshop TRIESTE 10 th of March 2016

LNG BUNKERING VESSELS AND CNG CARRIERS -Innovative solutions to improve sustainability- LNG/SHORE POWER Workshop TRIESTE 10 th of March 2016 LNG BUNKERING VESSELS AND CNG CARRIERS -Innovative solutions to improve sustainability- LNG/SHORE POWER Workshop TRIESTE 10 th of March 2016 1 CONTENTS 1. CNG TECHNOLOGY FOR MARITIME TRANSPORTATION 2.

More information

Application for a recommendation on the use of membrane tanks for transport of liquefied natural gas on the tank vessel Argos-GL

Application for a recommendation on the use of membrane tanks for transport of liquefied natural gas on the tank vessel Argos-GL Economic Commission for Europe Inland Transport Committee Working Party on the Transport of Dangerous Goods Joint Meeting of Experts on the Regulations annexed to the European Agreement concerning the

More information

Innovative solutions for LNG carriers. A classification society view.

Innovative solutions for LNG carriers. A classification society view. Innovative solutions for LNG carriers. A classification society view. International LNG Congress - London 14 th March 2016 Carlos GUERRERO Business Development Manager Oil Tankers and Gas Carriers Bureau

More information

General presentation May 2016

General presentation May 2016 General presentation May 2016 Disclaimer This presentation (the "Presentation") has been prepared by LNG New Technologies ("the Company"). This Presentation has been compiled by LNG New Technologies in

More information

LNG sloshing for new designs, new operations and new trades

LNG sloshing for new designs, new operations and new trades LNG sloshing for new designs, new operations and new trades Gastech Bilbao, March 16 th 2005 Wouter Pastoor, Tom Østvold, Eirik Byklum, Sverre Valsgård Hydrodynamics & Structures Det Norske Veritas Contents

More information

Classification of FSRUs

Classification of FSRUs Classification of FSRUs Intertanko Gas Seminar London May 2, 2018 Carlos Guerrero, Global Market Leader - Tankers & Gas Carriers Bureau Veritas Marine and Offshore 2018 Bureau Veritas Marine & Offshore

More information

Climate Change and Energy

Climate Change and Energy Climate Change and Energy International shipping Key trends and developments in carbon & energy performance Steve O Malley Ken Walsh 1 Ships are and will continue to be significant emitters International

More information

LNG supply Chain From the LNG receiving terminal to the LNG truck TrainMoS II

LNG supply Chain From the LNG receiving terminal to the LNG truck TrainMoS II LNG supply Chain From the LNG receiving terminal to the LNG truck TrainMoS II Madrid, November 4 th 2015 Jesus Losada Maseda (Project Manager) Laurent Moriceau (European Affairs) Index: Company presentation

More information

Marine Terminal Information Booklet

Marine Terminal Information Booklet 1 Marine Terminal Information Booklet: Guidelines and Recommendations Marine Terminal Information Booklet Guidelines and Recommendations (First edition 2018) Issued by the Oil Companies International Marine

More information

Design of LNG Powered Ships

Design of LNG Powered Ships Design of LNG Powered Ships Joint PNW SNAME CIMarE SAE Meeting 28 April 2012 Dan McGreer Principal Engineer STX Canada Marine 01 May 2012 Page 1 PRESENTATION OVERVIEW Company Background Market Forces for

More information

Membrane CCS for LPG Carrier

Membrane CCS for LPG Carrier Membrane CCS for LPG Carrier INTERTANKO 04/04/2017 Disclaimer This document is strictly confidential. Any unauthorised access to, appropriation of, copying, modification, use or disclosure thereof, in

More information

IACS Rec s and Panel Responsible

IACS Rec s and Panel Responsible 1 Portable electrical equipment - Deleted Dec 1996 2 Type of hatch cover required if a lower deck is designated as the freeboard deck - Deleted Nov 2010 3 Deleted 4 Deleted 1996 5 Method of corrosion fatigue

More information

GAZOCEAN Pioneer in Maritime Transportation of Liquefied gas

GAZOCEAN Pioneer in Maritime Transportation of Liquefied gas GAZOCEAN Pioneer in Maritime Transportation of Liquefied gas AFG méditerranée GAZOCEAN 23 Mai 2014 Introduction to GAZOCEAN January 2014 This presentation is not to be reproduced without the permission

More information

SEITZ Manfred Pro Danube Management GmbH, Vienna, Austria

SEITZ Manfred Pro Danube Management GmbH, Vienna, Austria Paper 41 - LNG Masterplan for Rhine-Main-Danube corridor - Lessons learned from a highly innovative and complex transport innovation project to facilitate LNG as fuel and as a cargo on Europe s main inland

More information

UK P&I CLUB. Gas matters A focus on some of the issues surrounding gas tanker fleets in the P&I world UK P&I CLUB IS MANAGED BY THOMAS MILLER

UK P&I CLUB. Gas matters A focus on some of the issues surrounding gas tanker fleets in the P&I world UK P&I CLUB IS MANAGED BY THOMAS MILLER UK P&I CLUB Gas matters A focus on some of the issues surrounding gas tanker fleets in the P&I world UK P&I CLUB IS MANAGED BY THOMAS MILLER 1 2 Introduction The renewed interest in gas, which started

More information

SHIP ENERGY EFFICIENCY MANAGEMENT PLAN SEEMP. Edilberto Peralta Lloyd s Register Operations Manager Central and South America

SHIP ENERGY EFFICIENCY MANAGEMENT PLAN SEEMP. Edilberto Peralta Lloyd s Register Operations Manager Central and South America SHIP ENERGY EFFICIENCY MANAGEMENT PLAN SEEMP Edilberto Peralta Lloyd s Register Operations Manager Central and South America "If you can't measure it, you can't improve it. Peter Drucker SEEMP An energy

More information

LNG as fuel. OTMW-Module 5 Monday 23 rd of November 2015 University of Piraeus. Working together for a safer world

LNG as fuel. OTMW-Module 5 Monday 23 rd of November 2015 University of Piraeus. Working together for a safer world LNG as fuel OTMW-Module 5 Monday 23 rd of November 2015 University of Piraeus Working together for a safer world What is LNG? Economical Drivers Regional - US LNG export dynamics - ECA-NOx area - USCG

More information

Enabling safe and reliable offshore LNG transfer operations By Vincent Lagarrigue, Marketing & Project Manager within Trelleborg Industrial Solutions

Enabling safe and reliable offshore LNG transfer operations By Vincent Lagarrigue, Marketing & Project Manager within Trelleborg Industrial Solutions Enabling safe and reliable offshore LNG transfer operations By Vincent Lagarrigue, Marketing & Project Manager within Trelleborg Industrial Solutions Executive Summary Moving liquefied natural gas (LNG)

More information

Port infrastructure for alternative fuels and maritime transport: the Livorno case

Port infrastructure for alternative fuels and maritime transport: the Livorno case Port infrastructure for alternative fuels and maritime transport: the Livorno case Green Port Congress 2016 Venice, 12 th October, 2016 Francesco PAPUCCI Research, Innovation & Technologies Livorno Port

More information

LNG Plant Overview. Seminar with Supplier Association Murmanshelf Murmansk, 15 May 2012 Jostein Pettersen

LNG Plant Overview. Seminar with Supplier Association Murmanshelf Murmansk, 15 May 2012 Jostein Pettersen LNG Plant Overview Seminar with Supplier Association Murmanshelf Murmansk, 15 May 2012 Jostein Pettersen Table of Content Part 1 : LNG plant overview (Jostein) Part 2 : Main equipment units (Jostein) Part

More information

The Naming and Delivery Ceremony of Seri Cenderawasih on 20 January 2017 at the HHI Shipyard in Ulsan, South Korea

The Naming and Delivery Ceremony of Seri Cenderawasih on 20 January 2017 at the HHI Shipyard in Ulsan, South Korea MISC Berhad ( MISC ), a world leading energy related maritime solutions and services provider today held the naming and delivery ceremony of its new LNG carrier, Seri Cenderawasih. The 150,200 CBM Liquefied

More information