Safety Data Sheet Dipropylene Glycol

Transcription

1 Section 1: Company and Product Identification Product Name: INCI Name: Material Uses: Active ingredient in cosmetic and personal care applications. Restrictions on Use: Repackaged for cosmetic use only Company: Emergency Response: Lotioncrafter LLC 48 Hope Ln Eastsound, WA PH: In USA, Canada and North America, 24 hour / 7 day emergency information for our product is provided by the CHEMTREC Emergency Call Center based in the USA. USA, Canada, Puerto Rico, Virgin Islands CALL In case of difficulties or for ships at sea CALL In Europe, Middle East, Africa, Asia Pacific, South America CALL Section 2: Hazards Identification BLANK BLANK BLANK BLANK Hazard Pictograms: Signal Word: Hazard Classification: Hazard Category: Hazard Statements: Precautionary Statements: Applicable classified as hazardous. Other Hazards: Date of issue/date of Revision: 2013/12/02 1 of 6

2 Section 3: Composition / Information on Ingredients Name Hazard Category CAS# Weight % Additional Information: For full text of any H-statements and R-phrases: see SECTION 16 Section 4: First Aid Measures If ingested: If inhaled: Eye contact: Skin contact: Rinse mouth with water. Give water or milk. DO NOT INDUCE VOMITING TO AVOID POSIBLE LUNG ASPIRATION. Obtain medical advice immediately. Move to fresh air. Contact a physician if necessary. Immediately flush with water for at least 15 minutes. Seek medical advice if irritation persists. Remove contaminated clothes. Wash affected areas with water. Seek medical advice if irritation persists. Section 5: Fire Fighting Measures Extinguishing Method / Equipment: Dry chemical, carbon dioxide (CO2), foam Special Firefighting Cool exposed containers with water spary after extinguishing fire. Procedures: Unusual Fire and Explosion Closed containers may build pressure when exposed to heat or fire. Drums may Hazards: burst or explode. Section 6: Accidental Release Measures If Material is Released or Eliminate all ignition sources. Ventilate area. Contain spill. Absorb remainder Spilled: with suitable absorbent material. Remove as regulated. Use of self contained breathing apparatus is recommended for any major chemical spill. Contact appropriate authorities if required. PREVENT LIQUID FROM ENTERING DRAINS OR SEWER SYSTEM. Additional Procedures: Refer to Section 8 for protective equipment and Section 13 for disposal considerations. Date of issue/date of Revision: 2013/12/02 2 of 6

3 Section 7: Handling and Storage Safe Handling Precautions: Provide good ventilation of work area. Avoid inhalation and contact with skin and eyes. Keep away from food and drink. Recommendations for Storage: Store in a cool, dry, ventilated area AWAY FROM HEAT SOURCES and direct sunlight. Keep containers tightly closed and as full as possible to eliminate excess oxygen in the headspace. Containers should be upright when not in use. Specific End Use(s): Active ingredient in cosmetic and personal care products. Section 8: Exposure Control / Personal Protection General / Engineering Controls: Eye/face protection: Chemical goggles with side splash protection recommended. Hand Protection: Protective gloves Respiratory Protection: required under normal conditions. Other: Local exhaust, meeting ACGIH criteria as needed Body Protection: required under normal conditions. An eye wash facility should be available. Employees should practice good industrial hygiene, washing exposed skin several times daily. Launder contaminated clothing before re-use. Section 9: Physical and Chemical Properties Physical State: Liquid Color: Colorless Odor: Odorless Purity: 100% Melting Point: Flash Point (COC): 250 F Auto-ignition Temperature: 581 F Evaporation Rate: Vapor Pressure: 0.01 (20 C) (mmhg) Vapor Density: 4.6 (Air=1) Specific Gravity: at 72 F Water Solubility: Miscible 10.0% soluble in water Density (Lbs/gallon) at 72 F Flammable Limits In-Air: Lower: 2.9% (V) Upper: 12.6% (V) Date of issue/date of Revision: 2013/12/02 3 of 6

4 Section 10: Stability and Reactivity Chemical Stability: Stable Hazardous Polymerization: Will not occur Conditions to Avoid: Excessive heat Incompatible Materials: Strong oxidizing agents Hazardous Decomposition Products: Carbon monoxide, carbon dioxide, fumes Section 11: Toxicological Information Acute Toxicity Data: Oral LD 50: >14,800 mg/kg rat GHS Category - classified Dermal LD 50: >20,000 mg/kg rabbit GHS Category - classified Inhalaction LC 50: >2.43m3 4 Hours R Phrases: - not classified S Phrases: - not classified Carcinogenicity: GHS Category - classified This material is NOT on the California Prop 65 List of Carcinogens and Reproductive Toxins dated September 27, 2013 Section 12: Ecological Information General: Do not allow this material to escape into waters, waste water or soil. Results of PBT Assessment: PBT Section 13: Disposal Information Product and Container Place material and absorbent into sealed containers and dispose of in Disposal: accordance with current applicable laws and regulations. May be incinerated in a suitable facility profided local regulations are observed. Other considerations: Do not allow product to reach ground water or sewage system. Date of issue/date of Revision: 2013/12/02 4 of 6

5 Section 14: Transport Information UN Number: UN Proper Shipping Name: Transport Hazard Class(es): Packing Group: Environmental Hazards: US DOT EU Land Transport (ADR/RID/AND) Sea Transport (IMDG) applicable Air Transport (ICAO/IATA) Special Precautions for User: Trasport in bulk according to Annex II of MARPOL 73/78 and the IBC Code: applicable Section 15: Regulatory Information EU EINECS/ELINCS/NLP This product is listed on the EINECS Canada DSL/NDSL: This product is listed on the DSL/NDSL US TSCA: This product is listed on the TSCA Korea KECI: This product is listed on the ECL China IECSC: This product is listed on the IECSC Japan ENCS: This product is listed on the ENCS Philippine PICCS: This product is listed on the PICCS Australia AICS: This product is listed on the AICS New Zealand NZIoC: This product is listed on the NZIoC Swiss INNS: This product is listed on the INNS Other Information: This material was manufactured and/or processed in compliance with the IFRA (International Fragrance Association), Code of Practice under the 47th amendment dated 06/10/2013. It is also in compliance with FDA, CGMP, COLIPA and the EU Chemicals Policy Manufacturing Regulations and Directives. This material is compliant with the California Safe Cosmetics Act of 2005 (SB484) and contains no ingredients on the California Safe Cosmetics Program chemicals known to cause cancer or reproductive toxicity list dated August 1, This material is pre-registered with REACH as of 12/01/2008 Date of issue/date of Revision: 2013/12/02 5 of 6

6 Section 16: Other Information Indication of Changes: Version 1 created December 02, 2013 List of Relevant R-phrases (number and full text): HMIS III: Health 1, Flammability 1, Reactivity 0. Legal Disclaimer: Since the user s working conditions are not known to us, the information supplied on this safety data sheet is based on our current level of knowledge and on national and community regulations. The product must not be used for any purposes other than those specified under heading 1 without first obtaining written handling instructions. Lotioncrafter provides the information contained herein in good faith but makes no representation as to its comprehensiveness or accuracy. This document is intended only as a guide to the appropriate precautionary handling of the material by a properly trained person using this product. Individuals receiving the information must exercise their independent judgment in determining its appropriateness for a particular purpose. LOTIONCRAFTER MAKES NO REPRESENTATIONS OR WARRANTIES, EITHER EXPRESS OR IMPLIED, INCLUDING WITHOUT LIMITATION ANY WARRANTIES OF MERCHANTABILITY, FITNESS FOR A PARTICULAR PURPOSE WITH RESPECT TO THE INFORMATION SET FORTH HEREIN OR THE PRODUCT TO WHICH THE INFORMATION REFERS. ACCORDINGLY, LOTIONCRAFTER WILL NOT BE RESPONSIBLE FOR DAMAGES RESULTING FROM USE OF OR RELIANCE UPON THIS INFORMATION. Date of issue/date of Revision: 2013/12/02 6 of 6