SAFETY DATA SHEET. Creation Date 10-Nov-2010 Revision Date 18-Jan-2018 Revision Number Identification

Transcription

1 SAFETY DATA SHEET Creation Date 10-Nov-2010 Revision Number 5 Product Name Cat No. : 1. Identification Petrolatum, white P66-1LB; P66-7LB CAS-No Synonyms Petroleum jelly Recommended Use Uses advised against Laboratory chemicals. Not for food, drug, pesticide or biocidal product use Details of the supplier of the safety data sheet Company Fisher Scientific One Reagent Lane Fair Lawn, NJ Tel: (201) Emergency Telephone Number CHEMTRECÒ, Inside the USA: CHEMTRECÒ, Outside the USA: Hazard(s) identification Classification This chemical is not considered hazardous by the 2012 OSHA Hazard Communication Standard (29 CFR ) Based on available data, the classification criteria are not met Label Elements None required Hazards not otherwise classified (HNOC) None identified 3. Composition/Information on Ingredients Component CAS-No Weight % Petrolatum, white >95 4. First-aid measures Eye Contact Rinse immediately with plenty of water, also under the eyelids, for at least 15 minutes. If symptoms persist, call a physician. Page 1 / 6

2 Skin Contact Inhalation Ingestion Most important symptoms and effects Notes to Physician Suitable Extinguishing Media Unsuitable Extinguishing Media Wash off with warm water and soap. Remove from exposure, lie down. Move to fresh air. If symptoms persist, call a physician. Do not induce vomiting. Get medical attention.. Treat symptomatically 5. Fire-fighting measures Water spray. Carbon dioxide (CO 2). Dry chemical. Chemical foam. Flash Point > 150 C Method - Autoignition Temperature Explosion Limits Upper Lower Sensitivity to Mechanical Impact Sensitivity to Static Discharge Specific Hazards Arising from the Chemical Keep product and empty container away from heat and sources of ignition. Hazardous Combustion Products Carbon monoxide (CO) Carbon dioxide (CO2) Protective Equipment and Precautions for Firefighters As in any fire, wear self-contained breathing apparatus pressure-demand, MSHA/NIOSH (approved or equivalent) and full protective gear. NFPA Health 0 Flammability 0 Instability 0 Physical hazards N/A Personal Precautions Environmental Precautions 6. Accidental release measures Use personal protective equipment. Ensure adequate ventilation. See Section 12 for additional ecological information. Methods for Containment and Clean Soak up with inert absorbent material. Keep in suitable, closed containers for disposal. Up Contaminated surfaces will be extremely slippery. Handling Storage Exposure Guidelines 7. Handling and storage Avoid contact with skin and eyes. Do not breathe vapors or spray mist. Keep in a dry, cool and well-ventilated place. Keep container tightly closed. 8. Exposure controls / personal protection This product does not contain any hazardous materials with occupational exposure limitsestablished by the region specific regulatory bodies. Page 2 / 6

3 Engineering Measures None under normal use conditions. Personal Protective Equipment Eye/face Protection Skin and body protection Respiratory Protection Hygiene Measures Wear appropriate protective eyeglasses or chemical safety goggles as described by OSHA's eye and face protection regulations in 29 CFR or European Standard EN166. Wear appropriate protective gloves and clothing to prevent skin exposure. No protective equipment is needed under normal use conditions. Handle in accordance with good industrial hygiene and safety practice. 9. Physical and chemical properties Physical State paste Appearance White Odor Odorless Odor Threshold ph Melting Point/Range C / F Boiling Point/Range > 300 C / > 572 F Flash Point > 150 C Evaporation Rate Flammability (solid,gas) Flammability or explosive limits Upper Lower Vapor Pressure Vapor Density Specific Gravity Solubility Partition coefficient; n-octanol/water Autoignition Temperature Decomposition Temperature Viscosity ca 7 mm²/s (100 C) 10. Stability and reactivity Reactive Hazard Stability Conditions to Avoid Incompatible Materials None known, based on information available Stable under normal conditions. Incompatible products. Strong oxidizing agents Hazardous Decomposition Products Carbon monoxide (CO), Carbon dioxide (CO2) Hazardous Polymerization Hazardous Reactions Acute Toxicity Hazardous polymerization does not occur. None under normal processing. 11. Toxicological information Product Information Component Information Component LD50 Oral LD50 Dermal LC50 Inhalation Page 3 / 6

4 Petrolatum, white >5000 mg/kg (Rat) >2000 mg/kg (Rabbit) Not listed Toxicologically Synergistic Products Delayed and immediate effects as well as chronic effects from short and long-term exposure Irritation Sensitization Carcinogenicity The table below indicates whether each agency has listed any ingredient as a carcinogen. The classification as a carcinogen need not apply if the full refining history is known and it can be shown that the substance from which it is produced is not a carcinogen. This note applies only to certain complex oil derived substances in Annex I. Component CAS-No IARC NTP ACGIH OSHA Mexico Petrolatum, white Not listed Not listed Not listed Not listed Not listed Mutagenic Effects Reproductive Effects Developmental Effects Teratogenicity STOT - single exposure STOT - repeated exposure Aspiration hazard Symptoms / effects,both acute and delayed Endocrine Disruptor Information Other Adverse Effects Ecotoxicity... None known None known The toxicological properties have not been fully investigated. 12. Ecological information Component Freshwater Algae Freshwater Fish Microtox Water Flea Petrolatum, white Not listed >100 mg/l/96h (Pimephales promelas) Not listed >10000 mg/l/48h Persistence and Degradability Insoluble in water Bioaccumulation/ Accumulation Mobility Waste Disposal Methods DOT TDG IATA. Is not likely mobile in the environment due its low water solubility. 13. Disposal considerations Chemical waste generators must determine whether a discarded chemical is classified as a hazardous waste. Chemical waste generators must also consult local, regional, and national hazardous waste regulations to ensure complete and accurate classification. 14. Transport information Page 4 / 6

5 IMDG/IMO 15. Regulatory information International Inventories Component TSCA DSL NDSL EINECS ELINCS NLP PICCS ENCS AICS IECSC KECL Petrolatum, white X X X - X X X Legend: X - Listed E - Indicates a substance that is the subject of a Section 5(e) Consent order under TSCA. F - Indicates a substance that is the subject of a Section 5(f) Rule under TSCA. N - Indicates a polymeric substance containing no free-radical initiator in its inventory name but is considered to cover the designated polymer made with any free-radical initiator regardless of the amount used. P - Indicates a commenced PMN substance R - Indicates a substance that is the subject of a Section 6 risk management rule under TSCA. S - Indicates a substance that is identified in a proposed or final Significant New Use Rule T - Indicates a substance that is the subject of a Section 4 test rule under TSCA. XU - Indicates a substance exempt from reporting under the Inventory Update Rule, i.e. Partial Updating of the TSCA Inventory Data Base Production and Site Reports (40 CFR 710(B). Y1 - Indicates an exempt polymer that has a number-average molecular weight of 1,000 or greater. Y2 - Indicates an exempt polymer that is a polyester and is made only from reactants included in a specified list of low concern reactants that comprises one of the eligibility criteria for the exemption rule. U.S. Federal Regulations TSCA 12(b) SARA 313 SARA 311/312 Hazard Categories CWA (Clean Water Act) Clean Air Act See section 2 for more information OSHA Occupational Safety and Health Administration CERCLA California Proposition 65 U.S. State Right-to-Know Regulations This product does not contain any Proposition 65 chemicals U.S. Department of Transportation Reportable Quantity (RQ): DOT Marine Pollutant DOT Severe Marine Pollutant N N N U.S. Department of Homeland Security This product does not contain any DHS chemicals. Other International Regulations Mexico - Grade Slight risk, Grade 1 Prepared By 16. Other information Regulatory Affairs Thermo Fisher Scientific Page 5 / 6

6 Creation Date Revision Date Print Date Revision Summary 10-Nov Jan Jan-2018 This document has been updated to comply with the US OSHA HazCom 2012 Standard replacing the current legislation under 29 CFR to align with the Globally Harmonized System of Classification and Labeling of Chemicals (GHS). Disclaimer The information provided in this Safety Data Sheet is correct to the best of our knowledge, information and belief at the date of its publication. The information given is designed only as a guidance for safe handling, use, processing, storage, transportation, disposal and release and is not to be considered a warranty or quality specification. The information relates only to the specific material designated and may not be valid for such material used in combination with any other materials or in any process, unless specified in the text End of SDS Page 6 / 6