Material Safety Data Sheet

Transcription

1 Material Safety Data Sheet Revision Date: June 9, 2011 Issue Date: December, Product and Company Identification Product Name: S-5425-A Bar Compound Product: Cut/Color Bar Compound Company Address: Contact Information: Schaffner Manufacturing Co. Inc. Telephone: Herron Ave. Emergency Telephone: Emsworth, Pa Internet: 2. Composition - Information on Ingredients CAS No. Component Aluminum Oxide (Non-fibrous) Petroleum Wax. Hazards Identification EMERGENCY OVERVIEW Physical State: Solid Color: Grey Odor: Slight Fatty Odor Health:1 Flammability:1 Reactivity:0 Personal Protection:E Potential Health Effects Inhalation: This product has a low vapor pressure and is not expected to present an inhalation hazard at ambient conditions or under normal conditions while buffing or polishing. Skin Contact: This product is not considered to be a skin irritant. Eye Contact: This product is considered to be an eye irritant Ingestion: This product is not expected to be ingested during normal conditions of use. Page 1 of 5 12//2012

2 4. First Aid Measures Inhalation: Remove to fresh air, consult a physician if symptoms develop and persist. Skin Contact: Wash with mild soap and water. If irritation develops, consult a physician. Eye Contact: Flush with copious amounts of water for 15 min. Consult a physician Ingestion: Seek medical attention 5. Fire Fighting Measures Flash Point: Greater Than 60º F ( 18º C) - Cleveland Open Cup Auto ignition Temperature: Not Determined Flammable/Explosive Limits - upper: Not Established Flammable/Explosive Limits - lower: Not Established Extinguishing Media: Dry chemical, foam or carbon dioxide recommended. Water spray should be used with caution - should be treated as a grease fire. Special Fire Fighting Procedures: Firefighters should wear self contained breathing apparatus in the positive pressure mode when there is a possibility of of exposure to smoke, fumes or hazardous decomposition products. Unusual Fire or Explosion Hazards: None Known Hazards Combustion Products: Product may release small amounts of CO due to incomplete combustion of the fatty acids. This product will not release CO under normal operating conditions. 6. Accidental Release Measures Environmental Precautions: No special precautions required, disposal must be made in accordance with Federal, State and Local regulations. Clean-up Methods: Vacuum or sweep spilled material and place waste material in approved container. Page 2 of 5 12//2012

3 7. Handling and Storage Handling: Moisture resistant work gloves are recommended for prolonged handling. Storage: Store in a cool, dry area. Incompatible Products: Avoid strong oxidizers. 8. Exposure Controls/ Personal Protection Exposure Limits: TWA Aluminum Oxide CAS No ACGIH TLV: 10.0 mg/m (Non Fibrous) OSHA PEL: 10.0 mg/m Petroleum Wax CAS No ACGIH TLV: 5.0 mg/m OSHA PEL: 5.0 mg/m Engineering Controls: Use local ventilation if general ventilation is insufficient to maintain concentrations below established limits listed above. Respiratory Protection: Use NIOSH approved respirator or dust mask if there is a potential to exceed exposure limits listed above. Skin Protection: Cotton or Poly Cotton Work Gloves for handling Eye/Face Protection: Safety glasses with side shields or goggles recommended. 9. Physical and Chemical Properties Physical State: Solid Color: White Odor: Slight Fatty Odor Vapor Pressure: Unknown PH: N/A Boiling Point: N/A Melting Point: Binders - Greater than 10º F, ( 54º C) Specific Gravity: G.T. 1.5 Solubility in Water: Saponifiable, but not water soluble as supplied VOC Content: None Solids Content: ~ 75% Page of 5 12//2012

4 10. Stability and Reactivity Stability: Product is Stable Hazardous Polymerization: Will not occur. Incompatibility: Avoid Strong oxidizing agents, strong bases. Conditions to Avoid: Avoid high heat, open flame Hazardous Decomposition Products: Product may release small amounts of CO due to incomplete combustion of the fatty acids. This product will not release CO under normal operating conditions. Carcinogenicity: None 11. Toxicological Information Acute Toxicity: On the skin can cause mild irritation. On the eye can cause mild irritation. Ingestion - can cause mild irritation. 12. Ecological Information Ecological Toxicity: Not Determined Environmental Fate: Not Determined 1. Disposal Considerations Recommended Method of Disposal: Collect in containers, bags, or covered boxes. All disposal must comply with Federal, State, and local regulations. EPA Hazardous Waste Number: Not a RCRA hazardous waste. Page 4 of 5 12//2012

5 14. Transport Information U.S. Department of Transportation Ground (49CFR) Packing Group: None International Air Transportation (ICAO/IATA) Water Transportation (IMO/IMDG) Packing Group: None Maritime Pollutant: None 15. Regulatory Information U.S. Federal Regulations: TSCA Status: All Components of this product are listed on the TSCA Inventory CERCLA Reportable Quantity: None SARA Title III: Section 02 Extremely Hazardous Substances: None. Section 11/12 Hazard Categories: Reportable Section 1 Toxic Categories: None California Proposition 65 Components: None Prepared By: Allen Schaffner 16. Other Information Disclaimer: The data and information contained herein are furnished for information only and are believed to be reliable. However, it is the user's responsibility to determine the suitability of Schaffner Manufacturing's products or any production methods for a particular purpose and to adopt such precautions as may be advisable for the protection of property and persons against any hazards that may be involved in the handling and use of any of Schaffner Manufacturing's products. In light of the foregoing, Schaffner Manufacturing disclaims all warranties, express or implied, including warranties of merchantability and fitness for a particular purpose, arising from sale of or use of Schaffner Manufacturing's products. Schaffner Manufacturing further disclaims any liability for consequential or incidental damages of any kind, including lost profits. Page 5 of 5 12//2012