Issuing Date 01-Aug-2014 Revision Date 01-Aug-2014 Revision Number 0 1. IDENTIFICATION OF THE SUBSTANCE/PREPARATION AND THE COMPANY/UNDERTAKING

Transcription

1 SAFETY DATA SHEET Issuing Date 01-Aug-2014 Revision Number 0 1. IDENTIFICATION OF THE SUBSTANCE/PREPARATION AND THE COMPANY/UNDERTAKING GHS product identifier Product Name Aeon Plate Finisher / Preserver Other means of identification Product Code(s) Synonyms 1A10251, 1A and 1A10253 ne Recommended use of the chemical and restrictions on use Recommended Use Uses advised against Thermal CtP Developer for Industrial Use information available Supplier's details Supplier Address Presstek LLC 55 Executive Drive Hudson, NH Phone: (603) Emergency telephone number Emergency Telephone Number Classification Chemtrec HAZARDS IDENTIFICATION This chemical is not considered hazardous according to the OSHA Hazard Communication Standard 2012 (29 CFR ). GHS Label elements, including precautionary statements Emergency Overview Signal Word ne The product contains no substances which at their given concentration are considered to be hazardous to health Appearance Yellowish tint Physical State Liquid. Odor Slight Precautionary Statements Prevention ne Page 1 / 7

2 General Advice ne Storage ne Disposal ne Hazard t Otherwise Classified (HNOC) t applicable Other information % of the mixture consists of ingredient(s) of unknown toxicity. 3. COMPOSITION/INFORMATION ON INGREDIENTS Chemical Name CAS- Weight % Trade secret Citric acid * *The exact percentage (concentration) of composition has been withheld as a trade secret. 4. FIRST AID MEASURES Description of necessary first-aid measures Eye Contact Rinse thoroughly with plenty of water, also under the eyelids. If symptoms persist, call a physician. Skin Contact Inhalation Ingestion Wash skin with soap and water. Remove and wash contaminated clothing before re-use. If skin irritation persists, call a physician. Move to fresh air. If symptoms persist, call a physician. Drink plenty of water. Do NOT induce vomiting. Never give anything by mouth to an unconscious person. Consult a physician if necessary Most important symptoms/effects, acute and delayed Most Important Symptoms/Effects Indication of immediate medical attention and special treatment needed, if necessary tes to Physician Treat symptomatically. Suitable Extinguishing Media Water fog. Foam. Dry chemical. Carbon dioxide (CO 2 ). 5. FIRE-FIGHTING MEASURES Unsuitable Extinguishing Media CAUTION: Use of water spray when fighting fire may be inefficient. Specific Hazards Arising from the Chemical Explosion Data Sensitivity to Mechanical Impact Sensitivity to Static Discharge ne. ne. Page 2 / 7

3 Protective Equipment and Precautions for Firefighters As in any fire, wear self-contained breathing apparatus pressure-demand, MSHA/NIOSH (approved or equivalent) and full protective gear. 6. ACCIDENTAL RELEASE MEASURES Personal precautions, protective equipment and emergency procedures Personal Precautions Use personal protective equipment. Environmental Precautions Environmental Precautions See Section 12 for additional Ecological Information. Prevent product from entering drains. Do not flush into surface water or sanitary sewer system. Methods and materials for containment and cleaning up Methods for Containment Methods for Cleaning Up Prevent further leakage or spillage if safe to do so. Dam up. Soak up with inert absorbent material. Pick up and transfer to properly labeled containers. 7. HANDLING AND STORAGE Precautions for safe handling Handling Handle in accordance with good industrial hygiene and safety practice. Avoid contact with skin, eyes and clothing. Wear personal protective equipment. Avoid breathing vapors or mists. Conditions for safe storage, including any incompatibilities Storage Incompatible Products Keep containers tightly closed in a dry, cool and well-ventilated place. Keep container closed when not in use. Keep at temperatures between 5 and 30 C (41 and 81 F). ne known based on information supplied. 8. EXPOSURE CONTROLS / PERSONAL PROTECTION Control parameters Exposure Guidelines This product does not contain any hazardous materials with occupational exposure limits established by the region specific regulatory bodies. Appropriate engineering controls Engineering Measures Showers Eyewash stations Ventilation systems Individual protection measures, such as personal protective equipment Eye/Face Protection Skin and Body Protection Respiratory Protection Hygiene Measures Safety glasses with side-shields. Goggles. Impervious clothing. Impervious gloves. protective equipment is needed under normal use conditions. If exposure limits are exceeded or irritation is experienced, NIOSH/MSHA approved respiratory protection should be worn. Handle in accordance with good industrial hygiene and safety practice. Page 3 / 7

4 Information on basic physical and chemical properties 9. PHYSICAL AND CHEMICAL PROPERTIES Physical State Liquid Appearance Yellowish tint Odor Slight Odor Threshold information available Property Values Remarks/ - Method ph ne known Melting Point/Range t applicable ne known Boiling Point/Boiling Range t applicable ne known Flash Point t applicable. ne known Evaporation rate data available ne known Flammability (solid, gas) data available ne known Flammability Limits in Air upper flammability limit data available lower flammability limit data available Vapor Pressure data available ne known Vapor Density data available ne known Specific Gravity 1.1 g/cm 3 ne known Water Solubility Easily soluble ne known Solubility in other solvents data available ne known Partition coefficient: n-octanol/water data available ne known Autoignition Temperature data available ne known Decomposition Temperature data available ne known Viscosity data available ne known Flammable Properties Explosive Properties Oxidizing Properties t flammable data available data available Other information VOC Content (%) data available 10. STABILITY AND REACTIVITY Reactivity data available. Chemical stability Stable under recommended storage conditions. Possibility of hazardous reactions ne under normal processing. Hazardous Polymerization Hazardous polymerization does not occur. Conditions to avoid ne known based on information supplied. Incompatible materials Page 4 / 7

5 ne known based on information supplied. Hazardous decomposition products Carbon oxides. Smoke Information on likely routes of exposure 11. TOXICOLOGICAL INFORMATION Product Information Inhalation Eye Contact Skin Contact Ingestion Chemical Name LD50 Oral LD50 Dermal LC50 Inhalation Citric acid 3000 mg/kg ( Rat ) - - Symptoms related to the physical, chemical and toxicological characteristics Symptoms Delayed and immediate effects and also chronic effects from short and long term exposure Sensitization Mutagenic Effects Carcinogenicity Reproductive Toxicity STOT - single exposure STOT - repeated exposure Aspiration Hazard Contains no ingredients above reportable quantities listed as a carcinogen. Numerical measures of toxicity - Product Acute Toxicity % of the mixture consists of ingredient(s) of unknown toxicity. The following values are calculated based on chapter 3.1 of the GHS document: LD50 Oral mg/kg; Acute toxicity estimate 12. ECOLOGICAL INFORMATION Ecotoxicity The environmental impact of this product has not been fully investigated. Chemical Name Toxicity to Algae Toxicity to Fish Toxicity to Microorganisms Citric acid LC50 96 h: = 1516 mg/l static (Lepomis macrochirus) Persistence and Degradability Daphnia Magna (Water Flea) EC50 72 h: = 120 mg/l (Daphnia magna) Bioaccumulation Chemical Name Log Pow Citric acid Other Adverse Effects 13. DISPOSAL CONSIDERATIONS Waste Disposal Methods Dispose of in accordance with federal, state, and local regulations Page 5 / 7

6 Contaminated Packaging Do not re-use empty containers. 14. TRANSPORT INFORMATION DOT t regulated International Inventories TSCA 15. REGULATORY INFORMATION Complies Legend TSCA - United States Toxic Substances Control Act Section 8(b) Inventory DSL/NDSL - Canadian Domestic Substances List/n-Domestic Substances List U.S. Federal Regulations Section 313 of Title III of the Superfund Amendments and Reauthorization Act of 1986 (SARA). This product does not contain any chemicals which are subject to the reporting requirements of the Act and Title 40 of the Code of Federal Regulations, Part 372. SARA 311/312 Hazard Categories Acute Health Hazard Chronic Health Hazard Fire Hazard Sudden Release of Pressure Hazard Reactive Hazard Clean Water Act This product does not contain any substances regulated as pollutants pursuant to the Clean Water Act (40 CFR and 40 CFR ). CERCLA This material, as supplied, contains one or more substances regulated as a hazardous substance under the Comprehensive Environmental Response Compensation and Liability Act (CERCLA) (40 CFR 302): Chemical Name Hazardous Substances RQs Extremely Hazardous Substances RQ RQs Citric acid - - RQ Section number U.S. State Regulations California Proposition 65 This product does not contain any Proposition 65 chemicals. U.S. State Right-to-Know Regulations "X" designates that the ingredients are listed on the state right to know list. Chemical Name New Jersey Massachusetts Pennsylvania Illinois Rhode Island Sodium hexametaphosphate X X Page 6 / 7

7 U.S. EPA Label Information EPA Pesticide Registration Number t applicable 16. OTHER INFORMATION NFPA Health Hazard 1 Flammability 0 Instability 0 Physical and Chemical Hazards - HMIS Health Hazard 1 Flammability 0 Physical Hazard 0 Personal Protection X Prepared By Issuing Date Revision Date Revision te Product Stewardship 23 British American Blvd. Latham, NY Aug Aug-2014 Initial Release. General Disclaimer The information provided on this SDS is correct to the best of our knowledge, information and belief at the date of its publication. The information given is designed only as a guide for safe handling, use, processing, storage, transportation, disposal and release and is not to be considered as a warranty or quality specification. The information relates only to the specific material designated and may not be valid for such material used in combination with any other material or in any process, unless specified in the text. End of Safety Data Sheet Page 7 / 7