TECHNICAL MANUAL DIRECT SUPPORT MAINTENANCE REPAIR PARTS AND SPECIAL TOOLS LISTS FOR RADIO SET AN/ARC-164(V)12

Transcription

1 TM P TECHNICAL MANUAL DIRECT SUPPORT MAINTENANCE REPAIR PARTS AND SPECIAL TOOLS LISTS FOR RADIO SET AN/ARC-6(V) (NSN ) AND RADIO SET AN/ARC-6(V)6 (NSN ) HDQUARTERS, DEPARTMENT OF THE ARMY May 98

2

3 *TM P TECHNICAL MANUAL HDQUARTERS DEPARTMENT OF THE ARMY NO P WASHINGTON, DC, May 98 DIRECT SUPPORT MAINTENANCE REPAIR PARTS AND SPECIAL TOOLS LISTS FOR RADIO SET AN/ARC-6(V) (NSN ) AND RADIO SET AN/ARC-6(V)6 (NSN ) Current as of 0 February 98 REPORTING ERRORS AND RECOMMENDING IMPROVEMENTS You can help improve this manual. If you find any mistakes or if you know of a way to improve the procedures, please let us know. Mail your letter, DA Form 08 (Recommended Changes to Publications and Blank Forms), or DA Form 08- located in the back of this manual direct to: Comman der, US Army Communications-Electronics Command and Fort Monmouth, ATTN: DR- SEL-ME-MP, Fort Monmouth, New Jersey In either case, a reply will be furnished direct to you SECTION I Table of Contents Page Introduction Illus Figure GROUP II Repair Parts List Radio set AN/ARC-6(V) and Radio set AN/ARC-6(V) Radio set control C-057/ARC-6(V) Switching Unit (A) MNOS Memory(AA) (No parts authorized) 00 Control Adapter (A) (No parts authorized) 003 Wiring Harneas (W) (No parts authorized) Receiver-Transmitter RT-88/ARC-6(V) and RT-88A/ARC-6(V)6 (Unit ) Signal Data Converter (A) Converter Circuit Card Assembly (AA) (No parts authorized) 00 Synthesizer (A) This manual superseades TM P, 7 March 98. i

4 TM P GROUP Table of Contents Continued Illus Page Figure Digital Circuit Card Assembly (AA) (No parts authorized) 000 Analog Circuit Card Assembly (AA) (No parts authorized) 0003 D/A Converter Circuit Card Assembly (AA3) (No parts authorized) 003 Guard Receiver (A3) (No parts authorized) 00 Main Receiver (A) (No parts authorized) 005 FM/FSK Modulator (A5) (No parts authorized) 006 Transmitter (A6) Modulator Circuit Card Assembly (A6A) (No parts authorized) 007 Power Supply (A7) DC to DC Converter (A7A) (No parts authorized) 0070 Power Supply Circuit Card Assembly (A7A) (No parts authorized) 008 Cable Assembly (W6) (No parts authorized) 03 Mount MT-607/ARC-6(V) (Unit 3) SECTION III. Special Tools List (Not applicable) IV. National Stock Number and Part Number Index ii

5 TM P SECTION I INTRODUCTION. Scope This manual lists spares and repair parts; special tools; special test, measurement, and diagnostic equipment (TMDE), and other special support equipment required for performance of direct support maintenance of the AN/ARC-6(V) and AN/ ARC-6(V) 6. It authorizes the requisitioning and issue of spares and repair parts as indicated by the source and maintenance codes.. General This Repair Parts and Special Tools List is divided into the following sections: a Section II. Repair Parts List A list of spares and repair parts authorized for use in the performance of maintenance. The list also includes parts which must be removed for replacement of the authorized parts. Parts lists are composed of functional groups in numeric sequence, with the parts in each group listed in figure and item number sequence. b. Section III. Special Tools List. Not applicable. c. Section IV National Stock Number and Part Number Index. A list, in National item identification number (NIIN) sequence, of all National stock numbers (NSN) appearing in the listing followed by a list, in alphameric sequence, of all part numbers appearing in the listings. National stock numbers and part numbers are cross-referenced to each illustration figure and item number appearance. 3. Explanation of Columns a Illustration This column is divided as follows: () Figure number. Indicates the figure number of the illustration on which the item is shown. () Item number. The number used to identify item called out in the illustration. b. Source, Maintenance, and Recoverability (SMR) codes. () Source code. Source codes indicate the manner of acquiring support items for maintenance, re pair, or overhaul of end items. Source codes are entered in the first and second positions of the Uniform SMR Code format as follows: code Definition PA Item procured and stocked for anticipated or known usage. Code Definition PB Item procured and stocked for insurance purpose because essentiality dictates that a minimum quantity be available in the supply system. PC Item procured and stocked and which otherwise would be coded PA except that it is deteriorative in nature. PD Support item, excluding support equipment, procured for initial issue or outfitting and stocked only for subsequent or additional initial issues or outfittings. Not subject to automatic replenishment. PE Support equipment procured and stocked for initial issue and outfitting to specified maintenance repair activities. PF Support equipment which will not be stocked but which will be centrally procured on de mand. PG Item procured and stock to provide for sustained support for the life of the equipment. It is applied to an item peculiar to the equipment which, because of probable discontinuance or shutdown of production facilities, would prove uneconomical to reproduce at a later time. KD An item of a depot overhaul/repair and not purchased separately. Depot kit defined as a kit that provides items required at the time of overhaul or repair. KF An item of a maintenance kit and not purchased separately. Maintenance kit defined as a kit that provides an item that can be replaced at organizational or intermediate levels of maintenance. KB Item included in both a depot overhaul/repair kit and a maintenance kit. MO Item to be manufactured or fabricated at the organizational level. MF Item to be manufactured or fabricated at the direct support maintenance level. MH Item to be manufactured or fabricated at the general support maintenance level. MD Item to be manufactured or fabricated at the depot maintenance level. AO Item to be assembled at organization level.

6 TM P code Definition AF Item to be assembled at direct support maintenance level. AH Item to be assembled at general support maintenance level. AD Item to be assembled at depot maintenance level. XA Item is not procured or stocked because the requirements for the item will result in the replacement of the next higher assembly. XB Item is not procured or stocked. If not available through salvage, requisition. XC Installation drawing, diagram, instruction sheet, field service drawing, that is identified by manufacturer s part number. XD A support item that is not stocked. When required, item will be procured through normal supply channels. NOTE Cannibalization or salvage may be used as a source of supply for any items source coded above except those coded XA and aircraft support items as restricted by AR () Maintenance code. Maintenance codes are assigned to indicate the levels of maintenance authorized to USE and REPAIR support items. The maintenance codes are entered in the third and fourth positions of the Uniform SMR Code format as follows: (a) The maintenance code entered in the third position will indicate the lowest maintenance level authorized to remove, replace, and use the support item. The maintenance code entered in the third position will indicate one of the following levels of maintenance: Code Application/Explunation C Crew or operator maintenance performed within organizational maintenance. O Support item is removed, replaced, used at the organizational level. F Support item is removed, replaced, used at the direct support level. H Support item is removed, replaced, used at the general support level. D Support items that are removed, replaced, used at depot, mobile depot, specialized repair activity only. (b) The maintenance code entered in the fourth positions indicates whether the item is to be repaired and identifies the lowest maintenance level with the capability to perform complete repair (i.e., all authorized maintenance functions). This position will contain one of the following maintenance codes: code Application/Explandon O The lowest maintenance level capable of complete repair of the support item is the organizational level. F The lowest maintenance level capable of complete repair of the support item is the direct support level. H The lowest maintenance level capable of complete repair of the support item is the general support level. D The lowest maintenance level capable of complete repair of the support item is the depot level. L- Repair restricted to designated specialized repair activity. Z Nonreparable. No repair is authorized. B No repair is authorized. The item may be reconditioned by adjusting, lubricating, etc., at the user level. No parts or special tools are procured for the maintenance of this item. (3) Recoverability code. Recoverability codes are assigned to support items to indicate the disposition action on unserviceable items. The recoverability code is entered in the fifth position of the Uniform SMR Code format as follows: Recoverability codes Definition Z Nonreparable item. When unserviceable, condemn and dispose at the level indicated in position 3. O Reparable item. When uneconomically reparable, condemn and dispose at organizational level. F Reparable item. When uneconomically reparable, condemn and dispose at the direct support level. H Reparable item. When uneconomically reparable, condemn and dispose at the general SUPport level. D Reparable item. When beyond lower level repair capability, return to depot. Condemnation and disposal not authorized below depot level. L- Reparable item. Repair, condemnation, and disposal not authorized below depot/specialized repair activity level. A Item requires special handling or condemnation procedures because of specific reasons (i.e., precious metal content, high dollar value, critical material or hazardous material). Refer to appropriate manuals/directives for specific instructions. c. National Stock Number. Indicates the National stock number assigned to the item and will be used for requistioning purposes.

7 TM P d. Federal Supply Code for Manufacturer (FSCM). The FSCM is a 5-digit numeric code listed in SB 708-/ which is used to identify the manufacturer, distributor, or Government agency, etc. e. Part Number. Indicates the primary number used by the manufacturer (individual, company, firm, corporation, or Government activity), which controls the design and characteristics of the item by means of its engineering drawings, specifications, standards, and inspection requirements to identify an item or range of items. NOTE When a stock numbered item is requisitioned, the repair parts received may have a different part number than the part being replaced. f. Description. Indicates the Federal item name and, if required, a minimum description to identify the item. g. Unit of Measure (U/M). Indicates the standard of the basic quantity of the listed item as used in performing the actual maintenance function. This measure is expressed by a two character alphabetical abbreviation (e.g., ea, in, pr, etc). When the unit of measure differs from the unit of issue, the lowest unit of issue that will satisfy the required units of measure will be requisitioned. h. Quantity Incorporated in Unit Indicates the quantity of the item used in the breakout shown on the illustration figure, which is prepared for a functional group, subfunctional group, or an assembly.. Special Information a. Usable on codes are shown in the description column. Uncoded items are applicable to all models. Identification of the usuable on codes used in this publication are: Code Used on EJM AN/ARC-6(V) FFK AN/ARC-6(V)6 b. Detailed manufacturing instructions for items source coded to be manufactured or fabricated are found in TM c. Detailed assembly instructions for items source coded to be assembled are found in TM Assembly components are listed immediately following the item to be assembled. d. The following publications pertain to the AN/ ARC-6(V) and AN/ARC- 6(V)6 and its components: TM , Radio Set AN/ARC-6(V) and AN/ARC- 6(V)6 TM P, Radio Set AN/ARC- 6(V) and AN/ARC- 6(V)6 TM , Radio Set AN/ARC-6(V) and AN/ARC- 6(V)6 e. National stock numbers (NSN S) that are missing from P source coded items have been applied for and will be added to this TM by future change/ revised when they are entered in the Army Master Data File (AMDF). Until the NSN S are established and published, submit exception requisitions to: Commander, US Army Communications Electronics Command and Fort Monmouth, ATTN: DRSEL-MM, Fort Monmouth, New Jersey for the part required to support your equipment. 5. How to Locate Repair Parts a. When National stock number or part number is unknown. () First. Using the table of contents, determine the functional group within which the item belongs. This is necessary since illustrations are prepared for functional groups and listings are divided into the same groups. () Second. Find the illustration covering the functional group to which the item belongs. (3) Third. Identify the item on the illustration and note the illustration figure and item number of the item. () Fourth. Using the Repair Parts Listing, find the figure and item number noted on the illustration. b. When National stock number or part number is known. () First. Using the index of National Stock Numbers and Part Numbers, find the pertinent National stock number or part number. This index is in NIIN sequence followed by a list of part numbers in alphameric sequence, cross-referenced to the illustration figure number and item number. () Second. After finding number, locate the figure and repair parts list. 6. Abbreviations Not applicable. the figure and item item number in the (Next printed page is ) 3

8 TM P Figure. Radio Set AN/ARC- 6(V) and AN/ARC-6(V) 6.

9 () ILLUSTRATION (a) FIG NO. (b) ITEM NO. () SMR CODE SECTION II (3) NATIONAL STOCK NUMBER () FSCM (5) PART NUMBER (6) DESCRIPTION TM P USABLE ON CODE (7) (8) U/M QTY INC IN UNIT GROUP 00 RADIO SET AN/ARC-6(V) AND AN/ARC-6(V)6 3 PAODD PAODD PAODD PAODD C-057/ARC-6( V) RT-88/ARC-6( V) RT-88A/ARC-6 (V)6 MT-607/ARC-6( V) CONTROL,RADIO SET RECEIVER-TRANSMITTE EJM RECEIVER TRANSMITTE FFK MOUNTING, ELECT

10 TM P 6 Figure. Control C-057/ARC-6(v).

11 SECTION II () () (3) () ILLUSTRATION (a) FIG NO. (b) ITEM N0. SMR CODE NATIONAL STOCK NUMBER FSCM (5) PART NUMBER (6) DESCRIPTION TM P USABLE ON CODE (7) U/M (8) QTY INC IN UNIT GROUP 0 RADIO SET CONTROL C-057/ARC-6(V) PAFDD SA-5/ARC-6( V) SWITCHIN UNIT,FREQ PAFDD PAFFF MX-9708/ARC-6( V) CX-980/ARC-6 (V) HOUSING-POWER SUPPL CABLE ASSEMBLY,SPEC PAFZZ FMD-5VA FUSE, CARTRIDGE /(8 BLANK)

12

13 TM P Figure 3. Switching Unit (A) (Sheet of ). 9

14 TM P 0 Figure 3. Switching Unit (A) (Sheet of ).

15 () ILLUSTRATION (a) FIG NO. (b) ITEM NO. SECTION II () SMR CODE (3) NATIONAL STOCK NUMBER () FSCM (5) PART NUMBER TM P (6) (7) (8) DESCRIPTION USABLE ON CODE U/M QTY INC IN UNIT GROUP 00 SWITCHING UNIT (A) PAFDD PAOZZ PAOZZ PAOZZ PAOZZ ELECTRONIC COMPONEN KNOB KNOB KNOB KNOB

16 TM P Figure. Receiver- Tranmitter RT-88/ARC-6(V) and RT-88A/ARC-6(V) (Unit ).

17 () SECTION II () (3) () (6) TM P (7) (8) ILLUSTRATION (8) FIG NO. (b) ITEM NO. SMR CODE NATIONAL STOCK NUMBER FSCM PART NUMBER DESCRIPTION USABLE ON CODE U/M QTY INC IN UNIT GROUP 0 RECEIVER-TRANSMITTER RT-88/ARC-6(V) AND RT-88A/ARC-6(V)6 (UNIT ) PAFDD CV-3556/ARC-6( V) CONVERTER,SIGNAL DA PDFDD O-705/ARC-6(V ) SYNTHESIZER,ELECTRI PAFDD R-976/ARC-6(V ) RECEIVER SUBASSEMBL PAFDD R-36/ARC-6(V ) RECEIVER,RADIO PAFDD R36A/ARC-6(V ) RECEIVER,RADIO FFK 5 PAFDD MD-056/ARC-6( V) CIRCUIT CARD ASSEMB PAFDD T 5/ARC-6(V) TRANSMITTER,RADIO EJM 6 PAFDD T-5/ARC-6(V ) TRANSMITT ER,RADIO FFK 7 PAFDD PP-758/ARC-6( V) POWER SUPPLY PAFZZ CX-309/ARC-6 (V) CABLE ASSEMBLY,SPEC EJM 8 PAFZZ CX-309A/ARC-6 (V) CABLE ASSEMBLY,SPEC FFK 9 PAFZZ CABLE ASSEMBLY,RADl PAFZZ CABLE ASSEMBLY,RADI PAFZZ /806 CABLE ASSEMBLY,RADI PAFZZ /80 CABLE ASSEMBLY,RADI PAFZZ CABLE ASSEMBLY,RADI PAFZZ CABLE ASSEMBLY,RADI XDFZZ MX-0037/ARC-6 (V) COVER, ACCESS /( BLANK)

18

19 TM P Figure 5. Signal Data Converter (A) (Sheet of ). 5

20 TM P Figure 5. Signal Data Converter (A) (Sheet of ). 6

21 () ILLUSTRATION (a) FIG NO. (b) ITEM NO. SECTION II () SMR CODE (3) NATIONAL STOCK NUMBER () FSCM (5) PART NUMBER (6) DESCRIPTION TM P USABLE ON CODE (7) U/M (8) QTY INC IN UNIT GROUP 00 SIGNAL DATA CONVERTER (A) 5 PAFDD CIRCUIT CARD ASSEMB PAOZZ FOA50VA FUSE,CARTRIDGE PAFZZ FHN0G FUSEHOLDER,EXTRACTO

22 TM P Figure 6. Synthesizer (A). 8

23 SECTION II TM P () () (3) () (5) (6) (7) (8) ILLUSTRATION DESCRIPTION QTY (a) (b) NATIONAL FIG ITEM SMR INC STOCK PART NO. NO. CODE NUMBER IN FSCM NUMBER USABLE ON CODE U/M UNIT GROUP 00 SYNTHESIZER (A) 6 6 PAFDD PAFDD CIRCUIT CARD ASSEMB CIRCUIT CARD ASSEMB PAFDD CIRCUIT CARD ASSEMB

24 TM P Figure 7. Transmitter (A6). 0

25 () ILLUSTRATION (a) FIG NO. (b) ITEM NO. SECTION II () SMR CODE (3) () NATIONAL STOCK NUMBER FSCM (5) PART NUMBER (6) DESCRIPTION TM P USABLE ON CODE (7) U/M (8) QTY INC IN UNIT GROUP 006 TRANSMITTER (A6) 7 PAFDD ClRCUIT CARD ASSEMB EJM 7 PAFDD ClRCUIT CARD ASSEMB FFK

26 TM P Figure 8. Power Supply (A7).

27 SECTION II () () (3) () (5) (6) (7) ILLUSTRATION (a) FIG NO. (b) ITEM NO. SMR CODE NATIONAL STOCK NUMBER FSCM PART NUMBER DESCRIPTION TM P USABLE ON CODE U/M (8) QTY INC IN UNTY GROUP 007 POWER SUPPLY (A7) 8 8 PAFDD POWER SUPPLY PAFDD POWER SUPPLY SUBASS /( BLANK)

28

29 TM P Figure 9. Mount Mt-607/ARC-6(V) (Unit 3) (Sheet of ). 5

30 TM P 6 Figure 9. Mount MT-607/ARC-6(V) (Unit 3) (Sheet of ).

31 () lllustratlon (a) FIG NO. (b) ITEM NO. SECTION II () SMR CODE (3) NATIONAL STOCK NUMBER () FSCM (5) PART NUMBER (6) DESCRIPTION TM P USABLE ON CODE (7) U/M (8) QTY INC IN UNIT GROUP 03 MOUNT MT-607/ARC-6(V) (UNIT 3) 9 PAOZZ F0A50VAS FUSE,CARTRIDGE PAOZZ FHN0G FUSEHOLDER,EXTRACTO PAOZZ F0A3V5AS FUSE,CARTRIDGE XDOZZ CB-0 MOUNT,RESILIENT PAFZZ MS70-6 RELAY,ELECTROMAGNET XDFZZ 088 LP9A605K CAPACITOR,FIXED,PLA PAFZZ FAN,TUBXIAL

32 SECTION IV NATIONAL STOCK NUMBER AND PART NUMBER INDEX NOTE: LATEST NATIONAL STOCK NUMBER AND PART NUMBER ASSIGNMENTS. FIGURE ITEM STOCK NUMBER NO. NO. STOCK NUMBER TM P FIGURE NO ltem NO FSCM PART NUMBER FIGURE ITEM NO. NO. FSCM PART NUMBER FIGURE ITEM NO. NO B-CB-0 C-057/ARC-6(V) CV-3556/ARC-6(V) CX 980/ARC-6(V) CX-309/ARC-6(V) CX-309A/ARC-6(V) FHN0G FHN0G FM0-5VA F0A50VA F0A50VAS F0A3V5AS LP9AB05K MD-056/ARC-6(V) MS70-6 MT-607/ARC-6(V) MX-0037/ARC-6(V) MX-9708/ARC-6(V) O-705/ARC-6(V) PP-758/ARC-6(V) R-976/ARC-6(V) R-36/ARC-6(V) RT-88/ARC-6(V) RT-88A/ARC-6(V) R36A/ARC-6(V) SA-5/ARC-6(V) T-399/ARC-6(V) T-5/ARC-6(V) / / LATEST NATIONAL STOCK NUMBER ASSIGNMENTS FIGURE ITEM STOCK NUMBER NO. NO LATEST PART NUMBER ASSIGNMENTS FSCM PART NUMBER CX-309A/ARC-6(V)6 RT 88A/ARC 6(V)6 T-399/ARC-6(V) FIGURE NO. ITEM NO

33

34

35

36

37

38

39

40

41 TM P By Order of the Secretary of the Army: Official: ROBERT M. JOYCE Major General, United States Army The Adjutant General JOHN A. WICKMAN JR. General United States Army Chief of Staff DISTRIBUTION: To be distributed in accordance with DA Form -36B requirements for AN/ARC-6. *U.S. GOVERNMENT PRINTING OFFICE: /6393

42

43

44 PIN: