PARTS CATALOG TJ035E TJ035E-AS50 2-STROKE ENGINE PRODUCT CODE BRUSH-CUTTER P/N

Transcription

1 TJ035E- S50-01 TITLE PRTS CTLOG 2-STROKE ENGINE TJ035E PRODUCT CODE TJ035E-S50 NOTE BRUSH-CUTTER P/N

2 TJ035E- S50-03 PRTS LIST INFOMTION PRTS CTLOG INTRODUCTION This parts catalog lists parts and sub-assemblies provided as service parts. When it becomes necessary to replace parts, always use KWSKI GENUINE PRTS which have passed strict inspection which guarantees quality and performance. 1. HOW TO ORDER PRTS 1) When ordering the parts, be sure to use the parts catalog corresponding to the product code. Check the product revision codes on the product and the catalog. 2) Specify the part code (all digits) exactly as listed in this catalog on your parts order. 3) The parts not shown in the illustrations of this catalog are not sold separately; only the complete units or next higher assemblies illustrated are supplied as the service parts. 2. EXPLNTION OF PRTS CTLOG FORMT 1) Product Code This code describes the product code covered by this catalog. The product revision code, which is a part of the product code, is omitted. 2) Part Group Title This title is the representative name for the group of parts illustrated on the page. 3) Reference Number The reference numbers are shown on the illustration and the list as the link between them. 4) Part Number This is the key of your parts ordering. Three kinds of part number are used in this catalog. a. Structure 1 b. Structure 2 c. Standard Hardware Number (for bolts, nuts, washer, or the like) 5) and dditional Information The part name, the location, the size, and the serial number as additional information, etc. are described here. Use them to find out and check the part required. When a part number is changed without change of the product revision code and the changed parts are not interchangeable, the serial number of the product is noted as follows; ( F ) : ffected units are from beginning of the product of the product code up to and including this serial number. (F ) : ffected units are from this serial number and above. (F F ) : ffected units are in this serial number range. 6) The figure shows quantity of the part required at the indicated position on the illustration and for the specified product revision code. The asterisk (*) on this column means the part can be used as the substitute on the product and is supplied until the stock is exhausted. Note:Some small parts will be supplied by units. Example: If six (6) bolts are ordered and the minimum quantity per unit is five (5), two (2), units of the bolt will be delivered. 7) Product Revision Code This Code indicates an important change which affects the service parts interchangeability. 3. BBREVITIONS #...Number &...nd (+)...Plus ( )...Minus 2ND...Second 3RD...Third 4TH... Fourth...mpere R...s Required SSY...ssembly CNT... Center COMP... Complete FR...Front G...Gram HEX...Hexagonal ID=...Inside Diameter IN...Inch L=...Length LH...Left Hand LWR...Lower MM...Millimeter O/S...Over Size OD=...Outside Diameter REF...Reference RH...Right Hand RPM...Revolutions Per Minute RR...Rear STD...Standard T...Teeth T=...Thickness U/S...Under Size UPP... Upper V...Volt W...Watt

3 TJ035E- S50 B-01 PICTORIL INDEX B-03 CYLINDER/CRNKCSE B-04 PISTON/CRNKSHFT B-05 COOLING-EQUIPMENT B-06 ELECTRIC-EQUIPMENT B-07 CRBURETOR B-08 IR-FILTER/MUFFLER

4 TJ035E- S50 B-02 PICTORIL INDEX B-09 FUEL-TNK/FUEL-VLVE B-10 STRTER B-11 P.T.O-EQUIPMENT

5 TJ035E- S50 C-01 PICTORIL INDEX C-03 LBEL

6 TJ035E- S50 B-03 CYLINDER/CRNKCSE Part CYLINDER-ENGINE GSKET CP PLTE CRNKCSE CRNKCSE STND PIN BERING-BLL,6201C SEL-OIL,ISCD12X22X SEL-OIL,ISCD 12X22X4.5F CB0520 BOLT-SOCKET,5X SCREW-PN+-,4X SCREW-CSK-CROSS,4X SCREW-PN-WSP-CROS,5X OCT.14,2008 E

7 TJ035E- S50 B-04 PISTON/CRNKSHFT Part PISTON-ENGINE PIN-PISTON RING-SET-PISTON BERING-SMLL END BERING-SMLL END * CRNKSHFT-SSY SPCER,9X15X RING-SNP 2 2 OCT.14,2008 E B

8 TJ035E- S50 B-05 COOLING-EQUIPMENT Part PD,SHROUD SHROUD-ENGINE HOUSING-FN SCREW,4X SCREW-PN-WP+-,5X OCT.14,2008 E

9 TJ035E- S50 B-06 ELECTRIC-EQUIPMENT Part INSULTOR FLYWHEEL CP-SPRK PLUG * CP-SPRK PLUG TERMINL COIL-SSY-IGNITION WIRE-LED WIRE-LED,L= PLUG-SPRK,BPMR7(NGK),SOLID BOLT,4X CLMP TUBE,6X6.6X NUT,M KEY-WOODRUFF 1 4 OCT.14,2008 E0160-B209B

10 TJ035E- S50 B-07 CRBURETOR Part BRCKET GSKET GSKET GSKET,CRBURETOR/INSULTOR B GSKET,CYLINDER/INSULTOR VLVE-SSY-REED VLVE-REED FILTER COVER,PRIMER PUMP CRBURETOR-SSY VLVE-FLOT LEVER BODY BODY RM STOPPER DIPHRGM DIPHRGM PCKING PUMP-PRIMING SCREW,5X SCREW B SCREW C SCREW D SCREW NUT RING-SNP PIN RING-O JET-MIN,# SPRING SCREW,3X WSHER SCREW-PN-WSP+-,5X OCT.14,2008 E

11 TJ035E- S50 B-08 IR-FILTER/MUFFLER Part CSE-IR FILTER ELEMENT-IR FILTER GSKET,MUFFLER CP BFFLE RRESTER-SPRK MUFFLER-SSY SCREW BOLT CB0516 BOLT-SOCKET,5X SCREW-PN-WSP+-,5X OCT.14,2008 E0190-B026

12 TJ035E- S50 B-09 FUEL-TNK/FUEL-VLVE Part BRETHER FILTER-FUEL TNK-COMP-FUEL CP-SSY-TNK SCREW,5X GROMMET,FUEL TNK CLMP TUBE,3X5X TUBE,3X6X CP-TNK & BRETHER,SSY 1 7 OCT.14,2008 E

13 TJ035E- S50 B-10 STRTER Part PWL PLTE,RECOIL STRTER CSE,STRTER-RECOIL GRIP,STRTER-RECOIL CM,STRTER-RECOIL PULLEY-STRTING STRTER-RECOIL REEL,STRTER-RECOIL ROPE,3.5X RING-SNP SPRING SPRING SPRING SCREW,4X SCREW 1 8 OCT.14,2008 E

14 TJ035E- S50 B-11 P.T.O-EQUIPMENT Part CLUTCH-SSY CLUTCH-SSY * SHOE-CLUTCH SHOE-CLUTCH * WSHER PIN,CLUTCH SPRING SPRING * WSHER,SPRING,10.5X14.5X OCT.14,2008 E

15 TJ035E- S50 C-03 LBEL Part LBEL-PRODUCT LBEL-WRNING LBEL-BRND 1 10 OCT.14,2008 F0290-B399

16 TJ035E- S50 H-09 PRT NME INDEX IR-FILTER/MUFFLER...B-08 CRBURETOR...B-07 COOLING-EQUIPMENT...B-05 CYLINDER/CRNKCSE...B-03 ELECTRIC-EQUIPMENT...B-06 FUEL-TNK/FUEL-VLVE... B-09 LBEL...C-03 P.T.O-EQUIPMENT... B-11 PISTON/CRNKSHFT...B-04 STRTER...B-10

17 TJ035E- S50 H-10 NUMERICL PRTS INDEX Part Grid Part Grid Part Grid Part Grid Part Grid B B B B B B B B B B B B B B CB B CB B B B B B B B B B B B B B B B B B B B B B B B B B B B B B B B B B B B B B B B B B B B B B B B B B B B B B B B B B B B C C C B B B B B B B B B B B B B B B B B B B B B B B B B B B B B B B B B B B B B B B B B B B B B B B-09