Preventative Maintenance

Transcription

1 Florida Department of TRANSPORTATION Preventative Maintenance Appendix I Inspection Report Vendor Name: Enter Name Here Facility Serviced: Flagler NB Weigh Station Start & Completion Dates: 00/00/00 00/00/00 Work Order Number: Equipment Needs Immediate Attention? Yes (see section 000 below) or No (Circle) Page 1 of 9

2 SCALE 1 TRUCK SCALE REPORT Date: 00/00/00 WO #: SECTION TESTING 1ST LOAD SECTION 1 SECTION 2 SECTION 3 SECTION 4 SECTION 5 SECTION 6 SECTION 7 ARRIVAL SEALED 2ND LOAD SECTION 1 SECTION 2 SECTION 3 SECTION 4 SECTION 5 SECTION 6 SECTION 7 ARRIVAL SEALED LOAD TESTING TEST LOAD SCALE INDICATOR ARRIVAL PASS/FAIL SCALE INDICATOR DEPARTURE 0 LOAD MAX 0 LOAD STRAIN LOAD TESTING WEIGHT OF EMPTY TRUCK AMOUNT OF TEST WEIGHTS INDICATOR TRUCK AND WEIGHTS ERROR ON TEST WEIGHTS ONLY SECTION 1 SCALE 2 TRUCK SCALE REPORT Date: 00/00/00 WO #: SECTION TESTING 1ST LOAD SECTION 1 SECTION 2 SECTION 3 SECTION 4 SECTION 5 SECTION 6 SECTION 7 ARRIVAL SEALED 2ND LOAD SECTION 1 SECTION 2 SECTION 3 SECTION 4 SECTION 5 SECTION 6 SECTION 7 ARRIVAL SEALED LOAD TESTING TEST LOAD SCALE INDICATOR ARRIVAL PASS/FAIL SCALE INDICATOR DEPARTURE 0 LOAD MAX 0 LOAD STRAIN LOAD TESTING WEIGHT OF EMPTY TRUCK AMOUNT OF TEST WEIGHTS INDICATOR TRUCK AND WEIGHTS ERROR ON TEST WEIGHTS ONLY SECTION 1 Page 2 of 9

3 STATIC SCALE 1 LOAD CELL INSPECTION REPORT PLATFORM A POWERCELL PRE-WORK POST-WORK LOAD CELL 1 LOAD CELL 2 LOAD CELL 3 LOAD CELL 4 PLATFORM B POWERCELL PRE-WORK POST-WORK LOAD CELL 31 LOAD CELL 32 LOAD CELL 33 LOAD CELL 34 PLATFORM C POWERCELL PRE-WORK POST-WORK LOAD CELL 61 LOAD CELL 62 LOAD CELL 63 LOAD CELL 64 LOAD CELL 65 LOAD CELL 66 STATIC SCALE 2 LOAD CELL INSPECTION REPORT PLATFORM A POWERCELL PRE-WORK POST-WORK LOAD CELL 1 LOAD CELL 2 LOAD CELL 3 LOAD CELL 4 PLATFORM B POWERCELL PRE-WORK POST-WORK LOAD CELL 31 LOAD CELL 32 LOAD CELL 33 LOAD CELL 34 PLATFORM C POWERCELL PRE-WORK POST-WORK LOAD CELL 61 LOAD CELL 62 LOAD CELL 63 LOAD CELL 64 LOAD CELL 65 LOAD CELL 66 Page 3 of 9

4 WIM #1 INSPECTION REPORT SCALE 1 BEFORE CALIBRATION AFTER CALIBRATION ZERO COUNTS SPAN FACTOR SCALE 2 BEFORE CALIBRATION AFTER CALIBRATION ZERO COUNTS SPAN FACTOR WIM INSPECTION REPORT DECK 1 SIGNAL OHMS EXCITATION OHMS SHIELD TO GROUND LOAD CELL 1 LOAD CELL 2 LOAD CELL 3 LOAD CELL 4 SIGNAL MV EXCITATION VOLTS DECK 2 SIGNAL OHMS EXCITATION OHMS SHIELD TO GROUND LOAD CELL 1 LOAD CELL 2 LOAD CELL 3 LOAD CELL 4 SIGNAL MV EXCITATION VOLTS Page 4 of 9

5 WEIGH STATION EQUIPMENT/COMPONENT INSPECTIONS CAMERA STROBE INSPECTION REPORT YES/NO (CIRCLE) CHECKED MOUNT YES/NO (CIRCLE) CHECKED LENS COVERS YES/NO (CIRCLE) CHECKED STROBE BRIGHTNESS YES/NO (CIRCLE) CHECKED FOR SPIDER WEBS (REMOVED) COMPUTER INSPECTION REPORT YES/NO (CIRCLE) REBOOT STATIC PC YES/NO (CIRCLE) REBOOT WIM PC YES/NO (CIRCLE) REBOOT VDIM PC DIRECTIONAL LIGHT INSPECTION REPORT YES/NO (CIRCLE) SCALE BYPASS LIGHTS WORK YES/NO (CIRCLE) SCALE SORT LIGHTS WORK YES/NO (CIRCLE) BYPASS TRAFFIC LIGHTS WORK YES/NO (CIRCLE) SCALE 1 TRAFFIC LIGHT WORKS YES/NO (CIRCLE) SCALE 2 TRAFFIC LIGHT WORKS INTERCOM INSPECTION REPORT YES/NO (CIRCLE) CHECKED INTERCOM OPERATIONS Page 5 of 9

6 LIGHTNING PROTECTION INSPECTION REPORT YES/NO (CIRCLE) CHECKED CHEM-RODS AND FILLED WITH ELECTROLYTES YES/NO (CIRCLE) CHECKED MOW-PADS YES/NO (CIRCLE) CHECKED ARRAY (SPLINE BALLS, ANTENNAS, ETC.) LOOP INSPECTION REPORT YES/NO (CIRCLE) CHECKED LOOP SEALANT YES/NO (CIRCLE) CHECKED LOOP DETECTOR FOR PROPER OPERATIONS YES/NO (CIRCLE) CHECKED SYSTEM FOR PROPER OPERATIONS LPR CAMERA INSPECTION REPORT YES/NO (CIRCLE) CHECKED READS YES/NO (CIRCLE) CHECKED CAMERA MOUNTS YES/NO (CIRCLE) CHECKED LENS COVERS YES/NO (CIRCLE) CHECKED CAMERA WAS FOCUSED ON ROAD PROPERLY YES/NO (CIRCLE) CHECKED FOR SPIDER WEBS (REMOVED) OPEN/CLOSED SIGN INSPECTION REPORT YES/NO (CIRCLE) ALL LIGHT BULBS LIT YES/NO (CIRCLE) SIGN SWITCHES FROM OPEN TO CLOSED (VICA VERSA) YES/NO (CIRCLE) STRUCTURE STILL MEETS HIGHWAY STANDARDS Page 6 of 9

7 OVERVIEW CAMERA INSPECTION REPORT YES/NO (CIRCLE) CHECKED CAMERA VIEW (FOCUSED ON TRUCK PROPERLY) YES/NO (CIRCLE) CHECKED CAMERA MOUNTS YES/NO (CIRCLE) CHECKED LENS COVERS YES/NO (CIRCLE) CHECKED FOR SPIDER WEBS (REMOVED) PIT LIGHTING INSPECTION REPORT YES/NO (CIRCLE) ALL LIGHTS FUNCTION PROPERLY YES/NO (CIRCLE) CHECKED LIGHT WIRING YES/NO (CIRCLE) CHECKED TRUCK PANEL LIGHTING YES/NO (CIRCLE) LIGHTS REPLACED SIGN/SIGNAL CABINET INSPECTION REPORT YES/NO (CIRCLE) CHECKED UPS YES/NO (CIRCLE) CHECKED RELAYS YES/NO (CIRCLE) CHECKED LOOP DETECTORS FOR PROPER OPERATION SUMP PUMP INSPECTION REPORT YES/NO (CIRCLE) REMOVED/CLEANED SUMP PUMP YES/NO (CIRCLE) CHECKED CHECK VALVE YES/NO (CIRCLE) CHECKED SUMP PUMP WIRING YES/NO (CIRCLE) CLEANED SUMP YES/NO (CIRCLE) CLEANED DISCHARGE PIPE YES/NO (CIRCLE) CHECK PUMP FOR PROPER OPERATION Page 7 of 9

8 TRAFFIC LIGHT INSPECTION REPORT YES/NO (CIRCLE) CHECKED TRAFFIC LIGHT OPERATIONS US-DOT CAMERA INSPECTION REPORT YES/NO (CIRCLE) CHECKED READS YES/NO (CIRCLE) CHECKED CAMERA MOUNTS YES/NO (CIRCLE) CHECKED LENS COVERS YES/NO (CIRCLE) CHECKED CAMERA WAS FOCUSED ON TRUCK PROPERLY YES/NO (CIRCLE) CHECKED FOR SPIDER WEBS (REMOVED) 3D VIRTUAL DIMENSIONER (VDIM) YES/NO (CIRCLE) CHECKED READS YES/NO (CIRCLE) CHECKED MOUNTING SET SCREWS YES/NO (CIRCLE) CHECKED PELCO MOUNTING HARDWARE YES/NO (CIRCLE) CHECKED FAN OPERATIONS INSIDE EACH LASER YES/NO (CIRCLE) CHECKED CAMERA MOUNTS YES/NO (CIRCLE) CHECKED LENS COVERS (GLASS IN EACH LASER, IF NEEDED) YES/NO (CIRCLE) CHECKED VENTILATION VENTS YES/NO (CIRCLE) CHECKED SCANNERS CONNECTED YES/NO (CIRCLE) CHECKED AIR FILTERS YES/NO (CIRCLE) CHECKED FOR SPIDER WEBS (REMOVED) PING TEST: DRIVER SCANNER PING: (MS) TOP SCANNER PING: (MS) PASSENGER SCANNER PING: (MS) ROADWAY MEASUREMENT: DRIVER SCANNER: (FT.) (IN.) FROM ROAD SURFACE TOP SCANNER PING: (FT.) (IN.) FROM ROAD SURFACE PASSENGER SCANNER PING: (FT.) (IN.) FROM ROAD SURFACE CONTINUED BELOW Page 8 of 9

9 FIELD TEST: HEIGHT WIDTH LENGTH #1 COMPUTER (FT.) (IN.) (FT.) (IN.) (FT.) (IN.) MEASURED (FT.) (IN.) (FT.) (IN.) (FT.) (IN.) #2 COMPUTER (FT.) (IN.) (FT.) (IN.) (FT.) (IN.) MEASURED (FT.) (IN.) (FT.) (IN.) (FT.) (IN.) #3 COMPUTER (FT.) (IN.) (FT.) (IN.) (FT.) (IN.) MEASURED (FT.) (IN.) (FT.) (IN.) (FT.) (IN.) WIM CABINET INSPECTION REPORT YES/NO (CIRCLE) CHECKED UPS YES/NO (CIRCLE) CHECKED COOLING FANS YES/NO (CIRCLE) CHECKED LOOP DETECTORS FOR PROPER OPERATION YES/NO (CIRCLE) CHECKED AIR FILTERS WORK NOTES MISCELLANOUS OBSERVATIONS YES/NO (CIRCLE) EQUIPMENT NEEDS IMMEDIATE ATTENTION Page 9 of 9

10 FDOT MCSAW TRAINING MATRIX APPENDIX II Cameras Communications Technician License Plate Overview US DOT Cell Modem Cradle Ethernet Fiber T1 Reader Point Converter First, Last Name First, Last Name First, Last Name First, Last Name First, Last Name First, Last Name Indicators Lasers Lighting Loops/Sensors Technician IND780 IND9W JagXtreme LED Kistler Piezo Quartz First, Last Name First, Last Name First, Last Name First, Last Name First, Last Name First, Last Name Signage Strobes Vehicle Scales Technician Changeable Directional Dynamic Open & Variable Digital Emery Fairbanks Arrows Closed Winslow First, Last Name First, Last Name First, Last Name First, Last Name First, Last Name First, Last Name Vehicle Scales Weigh in Motion (WIM) Weigh Station System Technician Hydraulic Levertronics Toledo Digital Load Cell (PDX) Quartz Sensor First, Last Name First, Last Name First, Last Name First, Last Name First, Last Name First, Last Name

11 WIM Planning System Raw Data File Format Appendix IV The raw data file format will be a variable length, comma delimited ASCII file with each record terminated with a Carriage Return Line Feed character. The number of axles per record can be variable depending on how many axles the vehicle has. Filename Format: ssssssmmddyyyy.csv where: ssssss - 6 char Station ID padded with leading zeros mm - 2 digit month dd - 2 digit day yyyy 4 digit year Field Max Size Description Sequence No 5 WIM vehicle sequence number Date 10 Date stamp (MM/DD/YYYY) Time 10 Time stamp (HH:MM:SS:ffff) 10000th sec resolution DayOfWeek 1 see note 1 below StationID 6 Station Identification Dir of Travel 1 see note 2 below Lane 1 see note 3 below Class 2 FHWA Classification Speed 3 Vehicle Speed (mph) EASL 6 EASL value Violation 32 Violation Mask (see note 4 below) Gross 6 Vehicle Gross Weight (lbs) NumOfAxles 2 Total number of axles LeftWgt1 5 Axle1 Left Wheel Weight (lbs) RightWgt1 5 Axle1 Right Wheel Weight (lbs) AxleWgt1 5 Axle1 Total Weight (lbs) Spacing1 4 Axle Spacing 1-2 (tenths of feet) LeftWgt2 5 Axle1 Left Wheel Weight (lbs) RightWgt2 5 Axle2 Right Wheel Weight (lbs) AxleWgt2 5 Axle2 Total Weight (lbs) Spacing 2 4 Axle Spacing 2-3 (tenths of feet) * * * * * * * * * LeftWgt19 5 Axle19 Left Wheel Weight (lbs) RightWgt19 5 Axle19 Right Wheel Weight (lbs) Axle19Wgt 5 Axle 19 Total Weight (lbs) Note 1: The field DayOfWeek can have one of the following values: 1 Sunday 2 Monday 3 Tuesday 4 Wednesday 5 Thursday 6 Friday 7 Saturday

12 Note 2: The field DirOfTravel can have one of the following values: 1 North 2 Northeast 3 East 4 Southeast 5 South 6 Southwest 7 West 8 Northwest 9 North-South or Northeast-Southwest combined 0 East-West or Southeast-Northwest combines Note 3: The field Lane can have one of the following values: 1 Outside (rightmost) lane 2 Lane 2 3 Lane 3 4 Lane 4 5 Lane 5 6 Lane 6 7 Lane 7 8 Lane 8 9 Lane 9 0 Data with lanes combined