SECTION 1 ALL SITES - CAWLEY RD, YARRAVILLE & CNR FRANCIS ST & HARDIE RD, BROOKLYN

Size: px
Start display at page:

Download "SECTION 1 ALL SITES - CAWLEY RD, YARRAVILLE & CNR FRANCIS ST & HARDIE RD, BROOKLYN"

Transcription

1 In the interests of the safety of you and others, please read this leaflet. If you don t understand any part, please ask a Chalmers employee. Chalmers has one site with two distinct operational Depots: :: CORNER FRANCIS ST & HARDIE RD, BROOKLYN - Container Park :: CAWLEY RD, YARRAVILLE - Transport, Logistics & Head Office These Instructions apply to both Depots as specified. You must read SECTIONS 1, 4 & 5 regardless of which Depot you will visit. And either SECTION 2 or 3 depending on which Depot you will be visiting. SECTION 2 applies to Cnr Francis St & Hardie Rd Brooklyn and SECTION 3 applies to Cawley Rd Yarraville. Whilst this document is current at the time of writing, future changes in site layout, traffic flows and/or rules may occur. Please be aware of this and ask a Chalmers Manager, if there is any matter requiring further explanation. This Visitor Site Safety Induction is also available on our web site: SECTION 1 ALL SITES - CAWLEY RD, YARRAVILLE & CNR FRANCIS ST & HARDIE RD, BROOKLYN THE FOLLOWING INSTRUCTIONS APPLY TO ALL SITES. PLEASE ADHERE TO THEM. A safety vest or high visibility apparel (as per Australian Standards) must be worn at all times You are on a heavy industrial site be aware, at all times, of the high volume of industrial traffic. It is your responsibility to use care and caution whilst on site. Any person entering any Chalmers site does so at their own risk. When walking through the Depot, remain on the yellow walkways as far as practicable Give way to forklifts at all times. Please refer to and observe the respective Traffic Management Plan (attached) Note & obey all traffic management signs There is a strict 10 km per hour speed limit You are only authorised to enter or exit via designated areas Chalmers is a Drug and Alcohol free environment - no person is authorised on-site under any level of influence Visitors cannot smoke anywhere on site. Children under 16 years of age and animals must remain in the vehicle at all times You must have appropriate training, certificates or licenses for all tasks you carry out whilst working on site All incidents & near misses must be reported immediately to a Chalmers Manager For your security, keep your vehicles locked at all times when not attended FAILURE TO ADHERE TO ANY OF THE INSTRUCTIONS IN THIS DOCUMENT OR DIRECTIONS BY CHALMERS MANAGEMENT WHILST YOU ARE ON SITE, WILL RESULT IN YOU BEING ASKED TO LEAVE AND POSSIBLY BEING BANNED FROM FUTURE ACCESS. Page 1 of 6 - printed on 19/05/09.

2 SECTION 2 VISITOR ACCESS CNR FRANCIS ST & HARDIE RD, BROOKLYN - CONTAINER PARK Please read Section 1 above and then all relevant Instructions following. Visitors MUST first proceed to the Container Control Office at the front of the site (as seen from the Francis Street entrance) OR to the Workshop Office which is located further into the Container Park along the main inroad. Please refer to Brooklyn Traffic Management Plan. Visitors include drivers making deliveries on behalf of suppliers. Drivers making deliveries should park directly outside the Workshop Office. Visitors who are external container service/warehouse personnel with ongoing business within the operational areas of the Container Park, do not have to report on each visit. Nevertheless, all other aspects of this Induction leaflet continue to apply to them. These personnel MUST remain in or with their vehicle at all times as appropriate particularly when they are loading or unloading. Visitors, excluding external container service/warehouse personnel, cannot enter operational areas unless accompanied by a Chalmers employee. SECTION CAWLEY ROAD, YARRAVILLE -TRANSPORT, LOGISTICS & HEAD OFFICE (A) HEAD OFFICE ONLY If you are visiting Chalmers Head Office only, please park in the Visitors & Employees carpark the two-way Entrance/Exit to which is located south of the Head Office building. Alternatively, you may wish to park on Cawley Road itself in front of Head Office. All visitors MUST first proceed to the main reception area which is accessible at the front of Head Office directly from Cawley Road. You must: sign the Visitors Register get a copy of this Induction (if not previously provided) get a Visitor s Pass get a high visibility vest if you plan to visit the Yard Follow relevant Instructions in SECTION 1. Visitors MUST also return to the main reception area to hand back the Pass and vest & to sign out before departing. Signing in and out is important as it facilitates speedy evacuation of visitors, should an emergency arise. Please note that: Visitors MUST be accompanied by a Chalmers staff member on site. Where a visitor is performing a set task, they will be escorted to the agreed area and are not to leave this area without again being escorted by a Chalmers staff member. Chalmers expect to move their registered office and Head Office Administration to Cawley Road from 355 Francis St, Yarraville on 22 May If your visit concerns ANY OTHER AREA (apart from Head Office) of the Cawley Road Depot, then please follow the Instructions specific to the purpose(s) of your visit as detailed below. (B) LCL PICKUPS & COURIERS FOR LOGISTICS Page 2 of 6 - printed on 19/05/09.

3 Please refer to attached Cawley Rd Traffic Management Plan for your strict adherence. Please seek clarification from Chalmers staff should you require, prior to entering the Depot. Drivers can ONLY get out of their vehicles to process paperwork at the Logistics Office and to stand in the Driver Safe Zone to supervise their truck being loaded/unloaded. Strictly NO entry to warehouses other than the marked walkway at the Logistics Office. (C) AQIS & CUSTOMS AQIS & Customs officers must park in designated bays outside the Logistics Office. Report to the Logistics Office & sign in. (D) CARGO INSPECTIONS Persons inspecting their cargo are to report to the main reception area, and follow the Instructions for Visitor Access. (see (A) above. No unauthorised persons can enter the Yard without the supervision of a Chalmers Employee. Failure to do so may result in being banned from the site. Strictly NO entry to warehouses other than the marked walkway at the Logistics Office. (E) WORKSHOP DELIVERIES Workshop deliveries are to enter via Entry gate and proceed to the Workshop. Goods must be unloaded in the designated area. No entry is permitted into the Workshop. If Workshop is unattended, please exit in your vehicle via the Exit Gate and report to main reception area in the Head Office building. Strictly NO entry to warehouses. Page 3 of 6 - printed on 19/05/09.

4 (F) CONTRACTORS All contactors are to report to the main reception area & follow the Instructions for Visitor Access. (See (A) above) No unauthorised persons are to enter the Yard without the supervision of a Chalmers employee. If reception is unattended, please pick up phone and follow instructions. Strictly NO entry to warehouses. SECTION 4 SUPPLIER/ CONTRACTOR REQUIREMENTS Contractors shall indemnify and keep indemnified Chalmers Industries against all claims, legal matters or losses and expenses of any nature whatsoever, which Chalmers Industries may suffer or incur in connection with the loss of life, personal injury and/or damage to property from or out of the performance of the contract and caused or contributed to by the negligence of the contractor or any of the contractor s servants, agents or employees. The contractor shall have in place an insurance policy for $20,000,000 public liability. All debris must be removed by contractor and kept in a safe condition as far as practicable. Please ensure that you have familiarised yourself fully with the Standard Terms & Conditions for the Supply of Goods and Services to Chalmers. These are printed on the reverse side of our Orders and are also available on request. SECTION 5 YOU AGREE TO OBTAIN APPROVAL FROM CHALMERS MANAGEMENT PRIOR TO COMMENCING ANY WORKS INVOLVING: Working in an area subject to vehicle or pedestrian traffic Working in a confined space Operating equipment, which has the potential to generate noise levels greater than 85 dba. Working at a platform height greater than 2 meters Operation of any Chalmers plant or equipment Bringing dangerous goods on-site for the purpose of your contract. While on-site you must comply with Dangerous Goods Regulations 2000 (statutory Rule No. 127/2000). Page 4 of 6 - printed on 19/05/09.

5 BROOKLYN TRAFFIC MANAGEMENT PLAN Site: Cnr Francis Street & Hardie Road, Brooklyn. LINK LEGEND BUILDINGS A Container Control Office B Repair Control Office C Workshop Office D Compound Office BULK STORE 3 AREAS WEIGHBRIDGE CAR PARKS fc ENTRY/EXIT BUILDINGS wc REPAIR SHED MAIN ROADS BULK STORE 2 B C MAIN DOORS HARD SCORIA ROAD CONTAINER TRAFFIC FLOWS LINK BULK STORE 1 A D (Not to scale) Apr 2007 ENTRANC E HARDIE RD MAIN ENTRANCE Page 5 of 6 - printed on 19/05/09. FRANCIS ST

6 Page 6 of 6 - printed on 19/05/09.