Material Safety Data Sheet

Transcription

1 Material Safety Data Sheet Revision Number: Issue date: 12/15/ PRODUCT AND COMPANY IDENTIFICATION Product type: Lubricant Item number: Region: United States Company address: Contact information: Henkel Corporation Telephone: One Henkel Way Emergency telephone: Rocky Hill, Connecticut Internet: 2. HAZARDS IDENTIFICATION EMERGENCY OVERVIEW HMIS: Physical state: paste HEALTH: 1 Color: black FLAMMABILITY: 1 Odor: mild PHYSICAL HAZARD: 0 Personal Protection: See MSDS Section 8 CAUTION: CAUSES EYE, SKIN AND RESPIRATORY TRACT IRRITATION. Relevant routes of exposure: Skin, Inhalation, Eyes Potential Health Effects Inhalation: Skin contact: Eye contact: Ingestion: Existing conditions aggravated by exposure: Shortness of breath. Coughing. Moderate respiratory tract irritation. Moderate skin irritation. Moderate eye irritation. Redness. Excess tearing. Principal hazard of ingestion is aspiration into the lungs and subsequent pneumonitis. Not expected to be harmful by ingestion. Eye, skin, and respiratory disorders. This material is considered hazardous by the OSHA Hazard Communication Standard (29 CFR ). See Section 11 for additional toxicological information. 3. COMPOSITION / INFORMATION ON INGREDIENTS Hazardous components CAS NUMBER % Petroleum Based grease Unknown Calcium oxide Graphite Mineral oil light naphthenic hydrotreat. <3% DMSO Distillates (petroleum), hydrotreated heavy naphthenic Calcium distearate Boron nitride FIRST AID MEASURES Inhalation: Skin contact: Move to fresh air. If symptoms develop and persist, get medical attention. Immediately flush skin with plenty of water (using soap, if available). Remove contaminated clothing and footwear. If symptoms develop and persist, get medical attention. Wash clothing before reuse. Page 1 of 5

2 Eye contact: Ingestion: Get medical attention. Immediately flush eyes with plenty of water for at least 15 minutes. Get medical attention. Keep individual calm. Do not induce vomiting: contains petroleum distillates and/or aromatic solvents. 5. FIRE FIGHTING MEASURES Flash point: Autoignition temperature: Flammable/Explosive limits - lower: Flammable/Explosive limits - upper: Extinguishing media: Special firefighting procedures: Unusual fire or explosion hazards: Hazardous combustion products: Not applicable Water spray (fog), foam, dry chemical or carbon dioxide. Wear a self-contained breathing apparatus with a full face piece operated in pressure-demand or other positive pressure mode. Oxides of nitrogen. Oxides of carbon. 6. ACCIDENTAL RELEASE MEASURES Use personal protection recommended in Section 8, isolate the hazard area and deny entry to unnecessary and unprotected personnel. Environmental precautions: Clean-up methods: Do not allow product to enter sewer or waterways. Scrape up as much material as possible. Clean residue with soap and water. Store in a partly filled, closed container until disposal. 7. HANDLING AND STORAGE Handling: Storage: Prevent contact with eyes, skin and clothing. Do not breathe vapor and mist. Wash thoroughly after handling. Keep container closed. Keep in a cool, well ventilated area. For information on product shelf life contact Henkel Customer Service at (800) EXPOSURE CONTROLS / PERSONAL PROTECTION Employers should complete an assessment of all workplaces to determine the need for, and selection of, proper exposure controls and protective equipment for each task performed. Page 2 of 5

3 Hazardous components ACGIH TLV OSHA PEL AIHA WEEL OTHER Petroleum Based grease mist mist Calcium oxide 2 mg/m3 TWA 2 mg/m3 TWA Graphite 1 Total dust. 15 MPPCF TWA Mineral oil light naphthenic hydrotreat. <3% DMSO Distillates (petroleum), hydrotreated heavy naphthenic Calcium distearate Inhalable fraction. mist 10 mg/m3 STEL mist Inhalable fraction. 10 mg/m3 TWA 3 mg/m3 TWA 500 ppm (2,000 mg/m3) TWA Mist. mist 500 ppm (2,000 mg/m3) TWA Mist. Boron nitride Engineering controls: Respiratory protection: Eye/face protection: Skin protection: Use local ventilation if general ventilation is insufficient to maintain vapor concentration below established exposure limits. Observe OSHA regulations for respiratory use (29 CFR ). Use NIOSH approved respirator if there is potential to exceed exposure limit(s). Safety goggles or safety glasses with side shields. Use impermeable gloves and protective clothing as necessary to prevent skin contact. 9. PHYSICAL AND CHEMICAL PROPERTIES Physical state: paste Color: black Odor: mild Odor threshold: ph: Vapor pressure: Boiling point/range: Melting point/ range: Specific gravity: Vapor density: Flash point: Not applicable Flammable/Explosive limits - lower: Flammable/Explosive limits - upper: Autoignition temperature: Evaporation rate: Solubility in water: Insoluble Partition coefficient (n-octanol/water): VOC content: 3 %; 38.4 g/l EPA Method 24 Page 3 of 5

4 10. STABILITY AND REACTIVITY Stability: Hazardous reactions: Hazardous decomposition products: Incompatible materials: Conditions to avoid: Stable Will not occur. reasonably foreseeable. Strong acids and strong bases. Strong oxidizing agents. Strong reducing agents. known 11. TOXICOLOGICAL INFORMATION Hazardous components NTP Carcinogen IARC Carcinogen OSHA Carcinogen (Specifically Regulated) Petroleum Based grease No No No Calcium oxide No No No Graphite No No No Mineral oil light naphthenic hydrotreat. <3% DMSO No No No Distillates (petroleum), hydrotreated heavy naphthenic No No No Calcium distearate No No No Boron nitride No No No Hazardous components Petroleum Based grease Calcium oxide Graphite Mineral oil light naphthenic hydrotreat. <3% DMSO Distillates (petroleum), hydrotreated heavy naphthenic Calcium distearate Boron nitride Health Effects/Target Organs No Data Irritant, Corrosive, Eyes Lung Irritant Irritant No Target Organs Irritant, Corrosive 12. ECOLOGICAL INFORMATION Ecological information: 13. DISPOSAL CONSIDERATIONS Information provided is for unused product only. Recommended method of disposal: Hazardous waste number: Follow all local, state, federal and provincial regulations for disposal. Not a RCRA hazardous waste. U.S. Department of Transportation Ground (49 CFR) International Air Transportation (ICAO/IATA) 14. TRANSPORT INFORMATION Page 4 of 5

5 Water Transportation (IMO/IMDG) 15. REGULATORY INFORMATION United States Regulatory Information TSCA 8 (b) Inventory Status: TSCA 12(b) Export Notification: CERCLA/SARA Section 302 EHS: CERCLA/SARA Section 311/312: CERCLA/SARA 313: California Proposition 65: All components are listed or are exempt from listing on the Toxic Substances Control Act Inventory. above reporting de minimus above reporting de minimus Immediate Health above reporting de minimus No California Proposition 65 listed chemicals are known to be present. Canada Regulatory Information CEPA DSL/NDSL Status: WHMIS hazard class: All components are listed on or are exempt from listing on the Canadian Domestic Substances List. E, D.2.B 16. OTHER INFORMATION This material safety data sheet contains changes from the previous version in sections: New Material Safety Data Sheet format. Prepared by: Lou Fabrizio, Regulatory Affairs Specialist DISCLAIMER: The data contained herein are furnished for information only and are believed to be reliable. However, Henkel Corporation and its affiliates ( Henkel ) does not assume responsibility for any results obtained by persons over whose methods Henkel has no control. It is the user s responsibility to determine the suitability of Henkel s products or any production methods mentioned herein for a particular purpose, and to adopt such precautions as may be advisable for the protection of property and persons against any hazards that may be involved in the handling and use of any Henkel s products. In light of the foregoing, Henkel specifically disclaims all warranties, express or implied, including warranties of merchantability and fitness for a particular purpose, arising from sale or use of Henkel s products. Henkel further disclaims any liability for consequential or incidental damages of any kind, including lost profits. Page 5 of 5