Safety Data Sheet Clear gloss polyester topcoat for vertical hang

Transcription

1 Safety Data Sheet dated 2/28/2013, version 1 1. IDENTIFICATION Product identifier Mixture identification: Trade name: Other means of identification: Trade code: 6FL2700S02EST Recommended use of the chemical and restrictions on use Recommended use: Surface coating Restrictions on use: Name, address, and telephone number of the chemical manufacturer, importer, or other responsible party Company: SIRCA S.p.A. Viale Roma, S.Dono di Massanzago (PD) - ITALY Tel Competent person responsible for the safety data sheet: safety@sirca.it Emergency phone number SIRCA S.p.A.- Phone n HAZARD(S) IDENTIFICATION Classification of the chemical Danger, Flam. Liq. 2, Highly flammable liquid and vapour. Warning, Skin Irrit. 2, Causes skin irritation. Warning, Eye Irrit. 2A, Causes serious eye irritation. Danger, STOT SE 1, Causes damage to organs. Label elements Symbols: Danger Hazard statements: H225 Highly flammable liquid and vapour. Page n. 1 of 11

2 H315 Causes skin irritation. H319 Causes serious eye irritation. H370 Causes damage to organs. Precautionary statements: P210 Keep away from heat/sparks/open flames/hot surfaces. - No smoking. P233 Keep container tightly closed. P240 Ground/bond container and receiving equipment. P241 Use explosion-proof electrical/ventilating/lighting/equipment. P242 Use only non-sparking tools. P243 Take precautionary measures against static discharge. P260 Do not breathe dust/fume/gas/mist/vapours/spray. P270 Do no eat, drink or smoke when using this product. P280 Wear protective gloves/protective clothing/eye protection/face protection. P302+P352 IF ON SKIN: Wash with plenty of water and soap. P303+P361+P353 IF ON SKIN (or hair): Take off immediately all contaminated clothing. Rinse skin with water/shower. P305+P351+P338 IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing. P308+P311 IF exposed or concerned: Call a POISON CENTER/doctor/... P332+P313 If skin irritation occurs: Get medical advice/attention. P337+P313 If eye irritation persists: Get medical advice/attention. P363 Wash contaminated clothing before reuse. P370+P378 In case of fire: use CO2, Foam, Chemical powders to extinguish. P403+P235 Store in a well-ventilated place. Keep cool. P405 Store locked up. P501 Dispose of contents/container in accordance with applicable regulations. Special Provisions: Hazards not otherwise classified identified during the classification process: Ingredient(s) with unknown acute toxicity: Additional classification information NFPA rating: HMIS rating: Page n. 2 of 11

3 3. COMPOSITION/INFORMATION ON INGREDIENTS Substances Mixtures Hazardous components within the meaning of 29 CFR and related classification: 25% - 48% styrene REACH No.: xxxx, Index number: , CAS: , EC: B.6/3 Flam. Liq. 3 H226 A.3/2A Eye Irrit. 2A H319 A.2/2 Skin Irrit. 2 H315 A.1/4/Inhal Acute Tox. 4 H332 2% - 2.5% methanol REACH No.: xxxx, Index number: X, CAS: , EC: B.6/2 Flam. Liq. 2 H225 A.8/1 STOT SE 1 H370 A.1/3/Oral Acute Tox. 3 H301 A.1/3/Dermal Acute Tox. 3 H311 A.1/3/Inhal Acute Tox. 3 H331 1% - 2% ethyl acetate REACH No.: xxxx, Index number: , CAS: , EC: B.6/2 Flam. Liq. 2 H225 Page n. 3 of 11

4 A.3/2A Eye Irrit. 2A H319 A.8/3 STOT SE 3 H % - 0.2% 2-butoxyethanol REACH No.: xxxx, Index number: , CAS: , EC: A.3/2A Eye Irrit. 2A H319 A.2/2 Skin Irrit. 2 H315 A.1/4/Oral Acute Tox. 4 H302 A.1/4/Dermal Acute Tox. 4 H312 A.1/4/Inhal Acute Tox. 4 H FIRST-AID MEASURES Description of necessary measures In case of skin contact: Immediately take off all contaminated clothing. Areas of the body that have - or are only even suspected of having - come into contact with the product must be rinsed immediately with plenty of running water and possibly with soap. Wash thoroughly the body (shower or bath). Remove contaminated clothing immediatley and dispose off safely. After contact with skin, wash immediately with soap and plenty of water. In case of eyes contact: After contact with the eyes, rinse with water with the eyelids open for a sufficient length of time, then consult an opthalmologist immediately. Protect uninjured eye. In case of contact with eyes, rinse immediately with plenty of water and seek medical advice. In case of ingestion: Give nothing to eat or drink. Do not under any circumstances induce vomiting. OBTAIN A MEDICAL EXAMINATION IMMEDIATELY. In case of inhalation: If breathing is irregular or stopped, administer artificial respiration. In case of inhalation, consult a doctor immediately and show him packing or label. Most important symptoms/effects, acute and delayed Indication of immediate medical attention and special treatment needed In case of accident or unwellness, seek medical advice immediately (show directions for use or safety data sheet if possible). 5. FIRE-FIGHTING MEASURES Page n. 4 of 11

5 Suitable extinguishing media: In case of fire, use CO2, Foam, Chemical powders Unsuitable extinguishing media: in particular. Specific hazards arising from the chemical Do not inhale explosion and combustion gases. Burning produces heavy smoke. Hazardous combustion products: Explosive properties: Oxidizing properties: Special protective equipment and precautions for fire-fighters Use suitable breathing apparatus. Collect contaminated fire extinguishing water separately. This must not be discharged into drains. Move undamaged containers from immediate hazard area if it can be done safely. 6. ACCIDENTAL RELEASE MEASURES Personal precautions, protective equipment, and emergency procedures Wear personal protection equipment. Remove all sources of ignition. Wear breathing apparatus if exposed to vapours/dusts/aerosols. Provide adequate ventilation. Remove persons to safety. Use appropriate respiratory protection. See protective measures under point 7 and 8. Methods and materials for containment and cleaning up Wash with plenty of water. 7. HANDLING AND STORAGE Precautions for safe handling Avoid contact with skin and eyes, inhalation of vapours and mists. Use localized ventilation system. Don't use empty container before they have been cleaned. Before making transfer operations, assure that there aren't any incompatible material residuals in the containers. Contaminated clothing should be changed before entering eating areas. Do not eat or drink while working. See also section 8 for recommended protective equipment. Conditions for safe storage, including any incompatibilities Always keep the containers tightly closed. Always keep in a well ventilated place. Keep away from unguarded flame, sparks, and heat sources. Avoid direct exposure to sunlight. Avoid accumulating electrostatic charge. Place recipients on the ground whilst decanting, and wear anti-static clothing and shoes. Keep away from food, drink and feed. Incompatible materials: Page n. 5 of 11

6 Page n. 6 of 11 in particular. Instructions as regards storage premises: Cool and adequately ventilated. Safety electric system. Storage temperature: Store at ambient temperature. 8. EXPOSURE CONTROLS/PERSONAL PROTECTION Control parameters styrene - CAS: TLV TWA - 20 ppm, A4-85,2 mg/m3, A4 TLV STEL - 40 ppm, A4-170,4 mg/m3, A4 methanol - CAS: OEL (IT) - LTE(8h): 260 mg/m3, 200 ppm - Behaviour: Binding - Notes: Skin EU - LTE(8h): 260 mg/m3, 200 ppm - Notes: Skin ACGIH - LTE: mg/m3, 200 ppm - STE: mg/m3, 250 ppm - Notes: Skin ethyl acetate - CAS: OEL (IT), 400 ppm TLV TWA ppm ,31 mg/m3 2-butoxyethanol - CAS: OEL (IT) - LTE(8h): 98 mg/m3, 20 ppm - STE: 246 mg/m3, 50 ppm - Behaviour: Binding - Notes: skin EU - LTE(8h): 98 mg/m3, 20 ppm - STE: 246 mg/m3, 50 ppm - Notes: Skin ACGIH - LTE: mg/m3, 20 ppm - Notes: A3 DNEL Exposure Limit Values PNEC Exposure Limit Values Appropriate engineering controls: Individual protection measures Eye protection: Use close fitting safety goggles, don't use eye lens. Protection for skin: Use clothing that provides comprehensive protection to the skin, e.g. cotton, rubber, PVC or viton. Protection for hands: Use protective gloves that provides comprehensive protection, e.g. P.V.C., neoprene or rubber. Respiratory protection: Use adequate protective respiratory equipment. Thermal Hazards: 9. PHYSICAL AND CHEMICAL PROPERTIES Appearance and colour: liquid Odour: characteristic Odour threshold:

7 ph: Melting point / freezing point: < 1 C Initial boiling point and boiling range: > 55 C Solid/gas flammability: Upper/lower flammability or explosive limits: Vapour density: Flash point: < 21 C Evaporation rate: Vapour pressure: Relative density: Kg/l at 20 C Solubility in water: Solubility in oil: Partition coefficient (n-octanol/water): Auto-ignition temperature: > 250 C Decomposition temperature: Viscosity: 45 " Din cup 4 (Typical value) Miscibility: Fat Solubility: Conductivity: Substance Groups relevant properties 10. STABILITY AND REACTIVITY Reactivity Stable under normal conditions Chemical stability Stable under normal conditions Possibility of hazardous reactions No dangerous reaction if stored and used appropriately. Conditions to avoid Avoid accumulating electrostatic charge. Vapours can form explosive mixtures with air. Incompatible materials Avoid contact with combustible materials. The product could catch fire. Hazardous decomposition products. 11. TOXICOLOGICAL INFORMATION Information on toxicological effects Toxicological information of the mixture: Toxicological information of the main substances found in the mixture: ethyl acetate - CAS: a) acute toxicity: Test: LD50 - Route: Skin - Species: Rabbit = mg/kg Test: LD50 - Route: Oral - Species: Rat = 5620 mg/kg Test: LC50 - Route: Inhalation - Species: Rat > 29.3 mg/l - Duration: 4h b) skin corrosion/irritation: Test: Skin Irritant - Route: Skin - Species: Rabbit Negative Page n. 7 of 11

8 Page n. 8 of 11 e) germ cell mutagenicity: Test: Genotoxicity Negative methanol - CAS: LD50 (RAT) ORAL SINGLE DOSE: 5628 MG/KG LD50 (RABBIT) SKIN SINGLE DOSE: MG/KG Substance(s) listed on the NTP report on Carcinogens: Styrene Substance(s) listed on the IARC Monographs: Styrene Group 2B 2-butoxyethanol Group 3 Substance(s) listed as OSHA Carcinogen(s): Substance(s) listed as NIOSH Carcinogen(s): 12. ECOLOGICAL INFORMATION Ecotoxicity Adopt good working practices, so that the product is not released into the environment. ethyl acetate - CAS: a) Aquatic acute toxicity: Endpoint: LC50 - Species: Fish = mg/l - Duration h: 96 Endpoint: EC50 - Species: Daphnia = 154 mg/l - Duration h: 48 Endpoint: EC50 - Species: Algae = 3300 mg/l - Duration h: 48 Persistence and degradability Bioaccumulative potential Mobility in soil Other adverse effects 13. DISPOSAL CONSIDERATIONS Waste treatment and disposal methods Recover, if possible. Send to authorised disposal plants or for incineration under controlled conditions. In so doing, comply with the local and national regulations currently in force. 14. TRANSPORT INFORMATION UN number ADR-UN Number: 1263 DOT-UN Number: 1263 IATA-UN Number: 1263 IMDG-UN Number: 1263 UN proper shipping name ADR-Shipping Name: DOT-Shipping Name: IATA-Shipping Name: Paint Related material Paint Related material Paint Related material

9 IMDG-Shipping Name: Paint Related material Transport hazard class(es) ADR-Class: 3 DOT-Class: 3 IATA-Class: 3 IMDG-Class: 3 Packing group ADR-Packing Group: II DOT-Packing Group: II IATA-Packing group: II IMDG-Packing group: II Environmental hazards ADR-Enviromental Pollutant: No IMDG-Marine pollutant: No Transport in bulk (according to Annex II of MARPOL 73/78 and the IBC Code) No Special precautions ADR-Tunnel Restriction Code: D/E DOT-Special provisions: 149, B52, IB2, T4, TP1, TP8, TP28 IATA-Passenger Aircraft: 353 IATA-Cargo Aircraft: 364 IATA-S.P.: A72 IATA-ERG: 8L IMDG-EmS: F-E, S-E IMDG-Storage category: B IMDG-Storage notes: 15. REGULATORY INFORMATION TSCA - Toxic Substances Control Act TSCA inventory: all the components are listed on the TSCA inventory TSCA listed substances: Styrene is listed in TSCA Section 8A CAIR SARA - Superfund Amendments and Reauthorization Act Section 302 Extremely Hazardous Substances: no substances listed Section 304 Hazardous substances: no substances listed Section 313 Toxic chemical list: Methanol, Styrene CERCLA - Comprehensive Environmental Response, Compensation, and Liability Act Substance(s) listed under CERCLA: Styrene Reportable quantity: 1000 pounds Methanol Reportable quantity: 5000 pounds Ethyl acetate Reportable quantity: 5000 pounds CAA - Clean Air Act CAA listed substances: Styrene is listed in CAA Section 111, Section 112(b) HAP, Section 112(b) HON Methanol is listed in CAA Section 111, Section 112(b) HAP, Section 112(b) HON Ethyl acetate is listed in CAA Section 111 Page n. 9 of 11

10 2-butoxyethanol is listed in CAA Section 111, Section 112(b) HON CWA - Clean Water Act CWA listed substances: Methanol is listed in CWA Section 304 Styrene is listed in CWA Section 311 Ethyl acetate is listed in CWA Section 304 USA - State specific regulations California Proposition 65 Substance(s) listed under California Proposition 65: Methanol Listed as reproductive toxicant Massachusetts Right to know Substance(s) listed under Massachusetts Right to know: Styrene Methanol Ethyl acetate 2-butoxyethanol New Jersey Right to know Substance(s) listed under New Jersey Right to know: Styrene Methanol Ethyl acetate 2-butoxyethanol Pennsylvania Right to know Substance(s) listed under Pennsylvania Right to know: Styrene Methanol Ethyl acetate 2-butoxyethanol 16. OTHER INFORMATION Text of phrases referred to under heading 3: H226 Flammable liquid and vapour. H319 Causes serious eye irritation. H315 Causes skin irritation. H332 Harmful if inhaled. H225 Highly flammable liquid and vapour. H370 Causes damage to organs. H301 Toxic if swallowed. H311 Toxic in contact with skin. H331 Toxic if inhaled. H336 May cause drowsiness or dizziness. H302 Harmful if swallowed. H312 Harmful in contact with skin. Safety Data Sheet dated 2/28/2013, version 1 Disclaimer: Page n. 10 of 11

11 The information contained herein is based on our state of knowledge at the above-specified date. It refers solely to the product indicated and constitutes no guarantee of particular quality. The information relates only to the specific material and may not be valid for such material used in combination with any other material or in any process. This Safety Data Sheet cancels and replaces any preceding release. ADR: CAS: CLP: DNEL: EINECS: GHS: HMIS: IARC: IATA: IATA-DGR: ICAO: ICAO-TI: IMDG: INCI: KSt: LC50: LD50: LTE: NFPA: NIOSH: NTP: OSHA: PNEC: RID: STE: STEL: STOT: TLV: TWATLV: European Agreement concerning the International Carriage of Dangerous Goods by Road. Chemical Abstracts Service (division of the American Chemical Society). Classification, Labeling, Packaging. Derived No Effect Level. European Inventory of Existing Commercial Chemical Substances. Globally Harmonized System of Classification and Labeling of Chemicals. Hazardous Materials Identification System International Agency for Research on Cancer International Air Transport Association. Dangerous Goods Regulation by the "International Air Transport Association" (IATA). International Civil Aviation Organization. Technical Instructions by the "International Civil Aviation Organization" (ICAO). International Maritime Code for Dangerous Goods. International Nomenclature of Cosmetic Ingredients. Explosion coefficient. Lethal concentration, for 50 percent of test population. Lethal dose, for 50 percent of test population. Long-term exposure. National Fire Protection Association National Institute for Occupational Safety and Health National Toxicology Program Occupational Safety and Health Administration Predicted No Effect Concentration. Regulation Concerning the International Transport of Dangerous Goods by Rail. Short-term exposure. Short Term Exposure limit. Specific Target Organ Toxicity. Threshold Limiting Value. Threshold Limit Value for the Time Weighted Average 8 hour day. (ACGIH Standard). Page n. 11 of 11