Issuing Date 01-Jun-2015 Revision Date 13-Mar-2017 Revision Number 1 1. IDENTIFICATION OF THE SUBSTANCE/PREPARATION AND THE COMPANY/UNDERTAKING

Transcription

1 SAFETY DATA SHEET Issuing Date 01-Jun-2015 Revision Number 1 1. IDENTIFICATION OF THE SUBSTANCE/PREPARATION AND THE COMPANY/UNDERTAKING GHS product identifier Product Name KILN GREASE HT Other means of identification Product Code(s) 751 Synonyms JET-LUBE KILN GREASE; ILEX KILN GREASE Recommended use of the chemical and restrictions on use Recommended Use Uses advised against Lubricants, Greases and Release Products, Sealant information available Supplier's details Manufacturer Address Jet-Lube, LLC 930 Whitmore Dr. Rockwall, Texas TEL: Toll Free: Emergency telephone number Emergency Telephone Number Classification CHEMTREC: (INTERNATIONAL) (NORTH AMERICA) 2. HAZARDS IDENTIFICATION This chemical is not considered hazardous according to the OSHA Hazard Communication Standard 2012 (29 CFR ). GHS Label elements, including precautionary statements Emergency Overview Signal Word ne The product contains no substances which at their given concentration are considered to be hazardous to health Appearance Green Physical State Semi-fluid (gel). Odor Slight Precautionary Statements Prevention ne Page 1 / 7

2 General Advice ne Storage ne Disposal ne Hazard t Otherwise Classified (HNOC) t applicable Other information 7.62% of the mixture consists of ingredient(s) of unknown toxicity. 3. COMPOSITION/INFORMATION ON INGREDIENTS Synonyms JET-LUBE KILN GREASE; ILEX KILN GREASE Chemical Name CAS- Weight % Trade secret Lubricating greases * A complex combination of hydrocarbons having carbon numbers predominantly in the range of C12 through C50. may contain organic salts of alkali metals, alkaline earth metals, etc. Calcium carbonate * *The exact percentage (concentration) of composition has been withheld as a trade secret. 4. FIRST AID MEASURES Description of necessary first-aid measures Eye Contact Rinse thoroughly with plenty of water, also under the eyelids. If symptoms persist, call a physician. Skin Contact Inhalation Ingestion Wash skin with soap and water. If skin irritation persists, call a physician. Move to fresh air. Do NOT induce vomiting. Drink plenty of water. Never give anything by mouth to an unconscious person. Consult a physician if necessary Most important symptoms/effects, acute and delayed Most Important Symptoms/Effects Indication of immediate medical attention and special treatment needed, if necessary tes to Physician Treat symptomatically. 5. FIRE-FIGHTING MEASURES Suitable Extinguishing Media Use extinguishing measures that are appropriate to local circumstances and the surrounding environment. Unsuitable Extinguishing Media Specific Hazards Arising from the Chemical Explosion Data Sensitivity to Mechanical Impact Sensitivity to Static Discharge Page 2 / 7 ne. ne.

3 Protective Equipment and Precautions for Firefighters As in any fire, wear self-contained breathing apparatus pressure-demand, MSHA/NIOSH (approved or equivalent) and full protective gear. 6. ACCIDENTAL RELEASE MEASURES Personal precautions, protective equipment and emergency procedures Personal Precautions Avoid contact with the skin and the eyes. Refer to Section 8 for personal protective equipment. Environmental Precautions Environmental Precautions Do not allow material to contaminate ground water system. See Section 12 for additional Ecological Information. Methods and materials for containment and cleaning up Methods for Containment Methods for Cleaning Up Prevent further leakage or spillage if safe to do so. Dam up. Soak up with inert absorbent material. Pick up and transfer to properly labeled containers. 7. HANDLING AND STORAGE Precautions for safe handling Handling Handle in accordance with good industrial hygiene and safety practice. Avoid contact with skin and eyes. Conditions for safe storage, including any incompatibilities Storage Incompatible Products Keep containers tightly closed in a dry, cool and well-ventilated place. Keep away from oxidizing materials. Strong oxidizing agents. Water. 8. EXPOSURE CONTROLS / PERSONAL PROTECTION Control parameters Exposure Guidelines Chemical Name ACGIH TLV OSHA PEL NIOSH IDLH Calcium carbonate TWA: 15 mg/m3 TWA: 5 mg/m3 (vacated) TWA: 15 mg/m3 (vacated) TWA: 5 mg/m3 TWA: 10 mg/m3 total dust TWA: 5 mg/m3 respirable dust Immediately Dangerous to Life or Health. OSHA PEL: Occupational Safety and Health Administration - Permissible Exposure Limits. NIOSH IDLH: Other Exposure Guidelines Vacated limits revoked by the Court of Appeals decision in AFL-CIO v. OSHA, 965 F.2d 962 (11th Cir., 1992). Appropriate engineering controls Engineering Measures Showers Eyewash stations Ventilation systems Individual protection measures, such as personal protective equipment Eye/Face Protection Skin and Body Protection If splashes are likely to occur, wear: Safety glasses with side-shields. Protective gloves. Page 3 / 7

4 Respiratory Protection Hygiene Measures protective equipment is needed under normal use conditions. If exposure limits are exceeded or irritation is experienced, NIOSH/MSHA approved respiratory protection should be worn. Handle in accordance with good industrial hygiene and safety practice. Information on basic physical and chemical properties 9. PHYSICAL AND CHEMICAL PROPERTIES Physical State Semi-fluid (gel) Appearance Green Odor Slight Odor Threshold information available Property Values Remarks/ - Method ph Neutral ne known Melting Point/Range 260 C / >374 F ne known Boiling Point/Boiling Range > 316 C / F ne known Flash Point > 315 C ne known Evaporation rate ne known Flammability (solid, gas) ne known Flammability Limits in Air upper flammability limit lower flammability limit Vapor Pressure ne known Vapor Density ne known Specific Gravity 0.95 ne known Water Solubility Insoluble in water. ne known Solubility in other solvents Largely. ne known Partition coefficient: n-octanol/water ne known Autoignition Temperature ne known Decomposition Temperature ne known Viscosity ne known Flammable Properties Explosive Properties Oxidizing Properties t flammable Other information VOC Content (%) STABILITY AND REACTIVITY Reactivity. Chemical stability Stable under recommended storage conditions. Possibility of hazardous reactions ne under normal processing. Hazardous Polymerization Hazardous polymerization does not occur. Conditions to avoid Incompatible products. Protect from moisture. Page 4 / 7

5 Incompatible materials Strong oxidizing agents. Water. Hazardous decomposition products ne known based on information supplied. Information on likely routes of exposure 11. TOXICOLOGICAL INFORMATION Product Information Inhalation Eye Contact Skin Contact Ingestion ne under normal use condtions Contact with eyes may cause irritation. Repeated exposure may cause skin dryness or cracking. May be harmful if swallowed. May cause gastrointestinal discomfort if consumed in large amounts. Chemical Name LD50 Oral LD50 Dermal LC50 Inhalation Lubricating greases = 2280 mg/kg ( Rat ) A complex combination of hydrocarbons having carbon numbers predominantly in the range of C12 through C50. may contain organic salts of alkali metals, alkaline earth metals, etc. Calcium carbonate = 6450 mg/kg ( Rat ) Symptoms related to the physical, chemical and toxicological characteristics Symptoms Delayed and immediate effects and also chronic effects from short and long term exposure Sensitization Mutagenic Effects Carcinogenicity Reproductive Toxicity STOT - single exposure STOT - repeated exposure Aspiration Hazard Contains no ingredients above reportable quantities listed as a carcinogen. Numerical measures of toxicity - Product Acute Toxicity 7.62% of the mixture consists of ingredient(s) of unknown toxicity. The following values are calculated based on chapter 3.1 of the GHS document: LD50 Oral 2469 mg/kg; Acute toxicity estimate 12. ECOLOGICAL INFORMATION Ecotoxicity Contains no substances known to be hazardous to the environment or that are not degradable in waste water treatment plants. Chemical Name Toxicity to Algae Toxicity to Fish Toxicity to Microorganisms complex combination >1001 mg/l LC50 96 h: > 2000 mg/l of hydrocarbons having carbon (Salmo gairdneri) numbers predominantly in the range of C12 through C50. may contain organic salts of alkali metals, alkaline earth metals, etc. Page 5 / 7 Daphnia Magna (Water Flea)

6 Persistence and Degradability Bioaccumulation Other Adverse Effects 13. DISPOSAL CONSIDERATIONS Waste Disposal Methods Contaminated Packaging Dispose of in accordance with federal, state, and local regulations Do not re-use empty containers. 14. TRANSPORT INFORMATION DOT t regulated 15. REGULATORY INFORMATION International Inventories Legend TSCA - United States Toxic Substances Control Act Section 8(b) Inventory DSL/NDSL - Canadian Domestic Substances List/n-Domestic Substances List U.S. Federal Regulations Section 313 of Title III of the Superfund Amendments and Reauthorization Act of 1986 (SARA). This product does not contain any chemicals which are subject to the reporting requirements of the Act and Title 40 of the Code of Federal Regulations, Part 372. SARA 311/312 Hazard Categories Acute Health Hazard Chronic Health Hazard Fire Hazard Sudden Release of Pressure Hazard Reactive Hazard Clean Water Act This product does not contain any substances regulated as pollutants pursuant to the Clean Water Act (40 CFR and 40 CFR ). CERCLA This material, as supplied, does not contain any substances regulated as hazardous substances under the Comprehensive Environmental Response Compensation and Liability Act (CERCLA) (40 CFR 302) or the Superfund Amendments and Reauthorization Act (SARA) (40 CFR 355). There may be specific reporting requirements at the local, regional, or state level pertaining to releases of this material. U.S. State Regulations California Proposition 65 This product does not contain any Proposition 65 chemicals. Page 6 / 7

7 U.S. State Right-to-Know Regulations "X" designates that the ingredients are listed on the state right to know list. Chemical Name New Jersey Massachusetts Pennsylvania Illinois Rhode Island Calcium carbonate X X X U.S. EPA Label Information EPA Pesticide Registration Number t applicable 16. OTHER INFORMATION NFPA Health Hazard 0 Flammability 1 Instability 0 Physical and Chemical Hazards - HMIS Health Hazard 0 Flammability 1 Physical Hazard 0 Personal Protection X Prepared By Issuing Date Revision Date Revision te Product Stewardship 23 British American Blvd. Latham, NY Jun Mar-2017 Updated company information. General Disclaimer The information provided on this SDS is correct to the best of our knowledge, information and belief at the date of its publication. The information given is designed only as a guide for safe handling, use, processing, storage, transportation, disposal and release and is not to be considered as a warranty or quality specification. The information relates only to the specific material designated and may not be valid for such material used in combination with any other material or in any process, unless specified in the text. End of Safety Data Sheet Page 7 / 7