LOCTITE CORPORATION 07/07/02 ROCKY HILL, CONNECTICUT EMERGENCY PHONE: (860) MATERIAL SAFETY DATA SHEET Page 01 of 05

Transcription

1 Page 1 of CHEMICAL PRODUCT AND COMPANY IDENTIFICATION MATERIAL SAFETY DATA SHEET Page 01 of 05 Part No.: Product Type: Industrial Waterless Handcleaner 2. COMPOSITION, INFORMATION ON INGREDIENTS Ingredients CAS No. % STODDARD SOLVENT Water Fatty acid soap Fatty acid soap Poly(oxy-1,2-ethanediyl), a-un decyl-w-hydroxy, Mineral oil Ingredients which have exposure limits Exposure Limits (TWA) ACGIH OSHA OTHER Ingredients (TLV) (PEL) STODDARD SOLVENT 100 ppm 100 ppm None 525 mg/m3 525 mg/m3 Mineral oil 5mg/m3 TWA mist 5mg/m3 TWA mist None Exposure Limits (STEL) ACGIH OSHA Ingredients (TLV) (PEL) Mineral oil 10 mg/m3 mist None 3. HAZARDS IDENTIFICATION Toxicity: Primary Routes of Entry: Signs and Symptoms of Exposure: Eye irritant. May irritate respiratory system upon frequent or prolonged use. High concentrations may irritate eyes and respiratory system. Material vomited after ingestion and aspirated into the lungs may cause broncopneumonia or pulmonary edema, which may be fatal. Oral LD50 more than 5000 mg/kg Skin contact, ingestion, and inhalation. None under normal conditions of use. Overexposure may cause eye or respiratory system irritation; headache, nausea, dizziness, weakness, fatigue, unconsciousness; vomiting

2 Page 2 of 5 MATERIAL SAFETY DATA SHEET Page 02 of HAZARDS IDENTIFICATION (continued) Existing Conditions Aggravated by Exposure: diarrhea; eye redness, tearing, blurred vision. None known Literature Referenced Carcinogen Ingredients Target Organ and Other Health Effects NTP IARC OSHA STODDARD SOLVENT CNS IRR NO NO NO Water NTO NO NO NO Fatty acid soap NTO NO NO NO Fatty acid soap No Data NO NO NO Poly(oxy-1,2-ethanediyl), a-un decyl-w-hydroxy, No Data NO NO NO Mineral oil NTO NO NO NO Abbreviations CNS Central nervous system NTO No Target Organs IRR Irritant 4. FIRST AID MEASURES Ingestion: Inhalation: Skin Contact: Eye Contact: Do not induce vomiting. Call physician immediately. Remove to fresh air. If symptoms persist, obtain medical attention. Flush with water. Flush at least 15 minutes with water. Call physician immediately. 5. FIRE FIGHTING MEASURES Flash Point: 124 F Method: Pensky-Martens Closed Cup Per ASTM D 4359 this product is a solid. Recommended Extinguishing Agents: Carbon Dioxide, Chemical powder Special Firefighting Procedures: Hazardous Products formed by Fire or Thermal Decomp Irritating organic vapors Unusual Fire or Explosion Hazards: None Explosive Limits: (% by volume in air)lower (% by volume in air)upper

3 Page 3 of 5 MATERIAL SAFETY DATA SHEET Page 03 of ACCIDENTAL RELEASE MEASURES Steps to be taken in case of spill or leak: Rinse away with water or wipe up with a towel. 7. HANDLING AND STORAGE Safe Storage: Hand cleaner should be stored between 40 F and 100 F (Contact Loctite Customer Service for shelf life information) Handling: Follow all general safety precautions. Keep away from children. 8. EXPOSURE CONTROLS, PERSONAL PROTECTION Eyes: Skin: Ventilation: Respiratory Not normally needed, but safety glasses offer increased protection. None normally needed. Sufficient to maintain vapor concentration below TLV. 9. PHYSICAL AND CHEMICAL PROPERTIES See Section 2 for Exposure Limits. Appearance: White Cream Odor: Pleasant smelling Boiling Point: Not Available ph: 8.8 Solubility in Water: Soluble Specific Gravity Volatile Organic Compound (EPA Method 24) 37.9% 322 grams per liter of base material (Calc.) Vapor Pressure: Vapor Density: Evaporation Rate (Ether = 1) 10. STABILITY AND REACTIVITY Stability: Stable Hazardous Polymerization: Will not occur Incompatibility: None Conditions to Avoid: Hazardous Decomposition Products (non-thermal): None MATERIAL SAFETY DATA SHEET Page 04 of 05

4 Page 4 of TOXICOLOGICAL INFORMATION 12. ECOLOGICAL INFORMATION 13. DISPOSAL CONSIDERATIONS See Section 3. No data available Recommended methods of disposal: EPA Hazardous Waste Number Incinerate following EPA and local regulations. NH - Not a RCRA Hazardous Waste Material 14. TRANSPORTATION INFORMATION DOT (49 CFR 172) Domestic Ground Transport Proper Shipping Name: Unrestricted Hazard Class or Division: Unrestricted Identification Number: None Marine Pollutant: None IATA Proper Shipping Name: Unrestricted Class or Division: Unrestricted UN or ID Number: None 15. REGULATORY INFORMATION CA Proposition 65: No California Prop 65 chemicals are known to be present at or above the No Significant Risk level 16. OTHER INFORMATION Estimated NFPA(R) Code: Health Hazard: 1 Fire Hazard: 2 Reactivity Hazard: 0 Specific Hazard: Does not apply Estimated HMIS(R) Code: Health Hazard: 1 Flammability Hazard: 2 Reactivity Hazards: 0 Personal Protection: See Section 8. NFPA is a registered trademark of the National Fire Protection Assn.

5 Page 5 of 5 7/11/ OTHER INFORMATION (continued) HMIS is a registered trademark of the National Paint and Coatings Assn. Prepared By: Title: Company: C.J. Michaels Safety,Health & Regulatory Affairs Loctite Corporation 1001 Trout Brook Crossing, Rocky Hill, CT (24hr.) Phone: (860) Revision Date: January 27, 1999 Revision: 0001