CHAIN SAW MODEL(s) MAC CAT TYPE 1

Transcription

1 NO. /0/0 0 MAC CAT 0 --/9/0 TYPE 0 9 All repairs, adjustments and maintenance not described in the Operator s Manual must be performed by qualified service personnel Assy.--- Isolator. 000 Strap--- Limiter. 000 Spring--- Isolator. 00 Washer. 000 Screw. 00 Screw. 00 Sleeve--- AV Spring. 00 Handle--- Front Screw Screw. 00 Bar Chain. 00 it--- Assy Spike(incl.). 000 Screw. 00 Plate--- Bar Mounting. 00 Screw Chain Catcher. 00 Screw Check Valve Plug--- Bronze Vent. 000 Assy---Oil Cap. 00 Spring--- Starter Dog Screw. 009 Screw. 00 Housing--- Fan. 009 it--- Rope. 000 Handle--- Starter. 00 Spring--- Recoil Pulley--- Starter Screw. 00 Nut--- Flywheel. 00 Washer--- Flywheel Assy--- Flywheel. 00 Bolt--- Bar. 009 Assy---Fuel Cap. 009 Nut--- U ---Type. 00 Fitting---fuel line. 009 it--- Fuel line (large) Grommet--- Cable Cable--- Throttle. 00 Cover--- Rear Handle Screw. 00 Screw Lockout--- Throttle Trigger--- Throttle. 000 Spring. 009 it--- Switch. 00 Handle --- Rear Screw Assy. Isolator --- lower. 00 it--- Isolator (Upper). 00 Screw. 000 nob--- Choke Grommet--- nob. 009 Assy--- Chassis (incl. 9---,---). 009 it---oil Pump (Incls.,,0). 000 Gear--- Worm Spring. 009 Elbow---Oil Pickup Screw Seal Block. 00 Assy---Oil Pickup (Incl. ---). 00 Pick--- up Oiler. 00 Filter--- Oil Plug---Oil Filter Washer--- Thrust. 000 Assy.--- Clutch Drum w/bearing. 00 Washer--- Clutch Assy. Clutch Assy--- Chain Brake Nut--- Bar Mounting. 00 Pin--- Retainer. 009 Retainer. 009 it--- Bar Adjust

2 0 NO. /0/ MAC CAT 0 --/9/ TYPE 0 9 All repairs, adjustments and maintenance not described in the Operator s Manual must be performed by qualified service personnel it--oil Check Valve Assy.--- Isolator. 000 Strap--- Limiter. 000 Spring--- Isolator. 00 Washer. 000 Screw. 00 Screw. 00 Sleeve--- AV Spring. 00 Handle--- Front Screw Screw. 009 Bar Chain. 00 it--- Assy Spike(incl.). 000 Screw. 00 Plate--- Bar Mounting. 00 Screw Chain Catcher. 00 Screw Assy---Oil Cap it--- Oil Check Valve. 00 Spring--- Starter Dog Screw Screw. 00 Housing--- Fan. 009 it--- Rope. 000 Handle--- Starter. 00 Spring--- Recoil Pulley--- Starter Screw. 00 Nut--- Flywheel. 00 Washer--- Flywheel Assy--- Flywheel. 00 Bolt--- Bar. 009 Assy---Fuel Cap. 009 Nut--- U ---Type. 00 Fitting---fuel line. 009 it--- Fuel line (large) Grommet--- Cable Cable--- Throttle. 00 Cover--- Rear Handle Screw. 00 Screw Lockout--- Throttle Trigger--- Throttle. 000 Spring. 009 it--- Switch. 00 Handle --- Rear Screw Assy. Isolator --- lower. 00 it--- Isolator (Upper). 00 Screw. 000 nob--- Choke Grommet--- nob. 009 Assy--- Chassis. 009 it---oil Pump (Incls.,,0). 000 Gear--- Worm Spring. 009 Elbow---Oil Pickup Screw Seal Block. 00 Assy---Oil Pickup (Incl. ---). 00 Pick--- up Oiler. 00 Filter--- Oil Plug---Oil Filter Washer--- Thrust. 000 Assy.--- Clutch Drum w/bearing. 00 Washer--- Clutch Assy. Clutch Assy--- Chain Brake Nut--- Bar Mounting. 00 Pin--- Retainer. 009 Retainer. 009 it--- Bar Adjust (incl. & )

3 NO. /0/0 0 MAC CAT 0 --/9/0 9 0 Type All repairs, adjustments and maintenance not described in the Operator s Manual must be performed by qualified service personnel it -Oil Vent Assy. -Isolator. 000 Limiter Strap. 009 Spring -Isolator. 00 Washer. 000 Screw. 00 Screw. 000 Front Handle Screw Screw Bar -. Chain it -Spike (Incl. ). 009 Screw. 00 Screw. 00 Plate -Bar Mount.. 00 Screw Chain Catcher. 00 Bolt -Bar Assy -Oil Cap it -Oil Vent. 00 Nut -Flywheel Screw. 00 Starter Pulley. 00 Baffle -Air. 009 Screw. 009 Housing -Fan. 009 it - Rope. 000 Handle -Starter Spring -Recoil Screw. 00 Washer -Flywheel. 009 Assy -Flywheel. 009 Assy -Fuel Cap. 00 Fitting -fuel line. 009 it -Fuel line (large). 009 Spring -Switch. 00 Screw. 00 Cover -Rear Handle Screw Screw Throttle Lockout Trigger -Throttle. 00 Handle - Rear. LLLLL Screw. LLLLL Assy Isolator -lower. 009 it -Isolator (Upper). 00 Screw. 009 Spring -Isolator Lever -Switch Lever -Choke Grommet -nob. 009 Nut - U -Type. 00 Assy -Chassis fuel lines and caps ) Washer -Thrust. 000 Assy. -Clutch Drum w/bearing. 00 Washer -Clutch Assy. Clutch. 009 it - Oil Pump (incl. 9,0,) Gear -Worm Spring Elbow -Oil Pickup. 000 Screw Seal Block. 00 Assy -Oil Pick -up (Incl.,). 00 Pick -up Oiler. 00 Filter -Oil. 009 Assy -Chain Brake Adjuster (Incl. knob)

4 NO. /0/0 0 MAC CAT 0 --/9/0 TYPE All repairs, adjustments and maintenance not described in the Operator s Manual must be performed by qualified service personnel Engine Gasket it Housing -Air Filter. 000 Nut. 009 Air Filter - Foam Wrench -Bar it -Engine Gasket (incl.,0,). 00 Screw. 000 Shield -Cylinder. 00 Assy -Air Purge. 000 Screw. 009 Assy -Fuel Pick -up. 009 it -Line Purge/Carb. (Small Dia). 009 it -Line Purge/Tank (large line). 009 Grommet -Carb Adjust Seal -Carb Adapter Spark Plug (RCJ -Y). 00 Clip -High Tension Lead. 009 Assy -Wire Harness (includes switch). 00 Screw. 009 Module -Ignition. 00 Strap -Ground. 00 Insulator -Heat Back Plate -Muffler. 00 Screw Screen -Spark Diffuser -Muffler Gasket -Muffler (kit). 000 Assy -Muffler (Incl. -). 000 Assy -Crankshaft. 009 Cap -Crankcase. 00 Assy -Seal & Bearing Ring -Piston. 009 Retainer - Piston Pin it -Piston - (incl. -) it -Cylinder Gasket -Carb. Adapter (kit). 00 Screw Carb. Adapter. 00 Screw Carb. Gasket (kit) it -Carburetor 009 (WT -9) Not Shown 00 Manual - (Scan) 000 Manual - (Euro I) 00 Manual - (Euro II) 00 Decal -Warning 00 Cap -limiter low(tan) 009 Cap -limiter high(brn)

5 NO. /0/0 All repairs, adjustments and maintenance not described in the Operator s Manual must be performed by qualified service personnel. 0 MAC CAT 0 --/9/0 TYPE Engine Gasket it Housing -Air Filter. 000 Nut. 009 Air Filter - Foam Wrench -Bar it -Engine Gasket (incl.,0,). 00 Screw. 009 Shield -Cylinder. 00 Assy -Air Purge. 000 Screw. 009 Assy -Fuel Pick -up. 009 it -Line Purge/Carb. (Small Dia). 009 it -Line Purge/Tank (large line). 009 Grommet -Carb Adjust Seal -Carb Adapter Spark Plug (RCJ -Y). 00 Clip -High Tension Lead. 009 Assy -Wire Harness (includes switch). 00 Screw. 009 Module -Ignition. 00 Strap -Ground. 00 Insulator -Heat Back Plate -Muffler. 00 Screw Screen -Spark Diffuser -Muffler Gasket -Muffler (kit). 000 Assy -Muffler (Incl. -). 000 Assy -Crankshaft. 009 Cap -Crankcase. 00 Assy -Seal & Bearing. 009 Ring -Piston. 009 Retainer - Piston Pin. 000 it -Piston - (incl. -) Cylinder Gasket -Carb. Adapter (kit). 00 Screw Carb. Adapter. 00 Screw Carb. Gasket (kit) it -Carburetor 009 (WT -9) Not Shown 0 Manual - (Scan) 0 Manual - (Euro I) 0 Manual - (Euro II) 00 Decal -Warning 00 Cap -limiter low(tan) 009 Cap -limiter high(brn)

6 NO. /0/0 0 MAC CAT 0 --/9/0 Type All repairs, adjustments and maintenance not described in the Operator s Manual must be performed by qualified service personnel. 0 Engine Gasket it Screw. 00 Assy--- Cylinder Shield (includes # ). 009 it--- Fuel Line (Small). 00 it--- Purge Bulb(incl.#). 000 Screw. 009 Assy--- Fuel Pick--- up. 00 Strap--- Ground Ignition Module Screw Assy--- Wire Harness. 009 Foam--- Air Filter. 000 Nut. 000 Assy--- Air Box. 00 Grommet--- Carb Adjust. 00 Seal--- Carb Adapter. 009 Reflector--- Heat Spark Plug (RCJ--- Y). 00 Clip--- High Tension Lead Cylinder Backplate--- Muffler Gasket--- Muffler(kit). 00 Diffuser--- Muffler. 000 Screen--- Spark. 00 Bolt--- Muffler. 00 Grommet--- Throttle Cable it --- Carburetor n 0 Walbro (WT--- 9) (Incl. Grommet) Gasket--- Carb. (kit). 00 Screw Carb. Adapter Screw Gasket--- Adaptor(kit). 009 Ring--- Piston. 009 Retainer--- Piston Pin. 000 it--- Piston (Incl. & ) it--- Engine Gasket (Incl., & ). 00 Scrench. 00 Assy--- Seal & Bearing. 009 Cap--- Crankcase Assy--- Crankshaft Assy--- Muffler (Incl. 0---) Not Shown Manuals (Scan) (Euro I) (Euro IV) (Euro V) (Turkish) (Russian) Decal--- Warning (Euro)

7 NO. /0/0 0 MAC CAT 0 --/9/0 Carburetor Assembly --- WT #009 D D Gasket/ Dia. it Carb. Repair it D D Ref. Part No. Description. 009 Limiter Cap--- High. 00 Limiter Cap--- Low. 009 Carburetor Repair it ( = Indicates Contents) & Includes Limiter Caps. 009 Gasket/Diaphragm it ( D = Indicates Contents) it - Carburetor Assembly No WT - it - Carburetor Assembly No W-0 it - Carburetor Assembly No WT - Note: No Repair kits are available for these carburetors

8 NO. /0/0 0 MAC CAT 0 --/9/0 LLLLL Service Reference LLLLL Note: Due to product improvements, your unit may have been built with or without the spring and screw shown below. If your unit does not have this spring and screw, no action is required. If your unit does have the spring and screw, please order the part numbers listed below. 00 Screw 00 Assy--Isolator Spring