MATERIAL SAFETY DATA SHEET

Transcription

1 , R NAME OF PRODUCT: GLYCINE SOLUTION 10% Reviewed on: 11 JUN 10 SECTION 1: PRODUCT AND COMPANY IDENTIFICATION PRODUCT NAME: Glycine Solution 10% SYNONYMS: PRODUCT CODES: MANUFACTURER: Orbeco-Hellige, Inc. DIVISION: USA ADDRESS: 6456 Parkland Dr. Sarasota, FL PHONE: FAX PHONE: EMERGENCY PHONE: OTHER CALLS: Chemtrec: (International), (Toll Free) CHEMICAL NAME: Not applicable (N/A) CHEMICAL FAMILY: N/A CHEMICAL FORMULA: N/A PRODUCT USE: PREPARED BY: Orbeco-Hellige, Inc. SECTION 1 NOTES: SECTION 2: COMPOSITION/INFORMATION ON INGREDIENTS INGREDIENT: CAS NO. % WT % VOL SARA 313 REPORTABLE Glycine % Deionized Water % OSHA PEL-TWA: OSHA PEL STEL: OSHA PEL CEILING: ACGIH TLV-TWA: ACGIH TLV STEL: ACGIH TLV CEILING: SECTION 2 NOTES: ppm mg/m3 SECTION 3: HAZARDS IDENTIFICATION EMERGENCY OVERVIEW: Clear, colorless & odorless liquid ROUTES OF ENTRY: POTENTIAL HEALTH EFFECTS EYES: No effects anticipated SKIN: No effects anticipated INGESTION: No effects anticipated Page 1 OF 6

2 INHALATION: No effects anticipated ACUTE HEALTH HAZARDS: None reported CHRONIC HEALTH HAZARDS: None reported MEDICAL CONDITIONS GENERALLY AGGRAVATED BY EXPOSURE: CARCINOGENICITY OSHA: ACGIH: NTP: IAR OTHER: SECTION 3 NOTES: This product does NOT contain any OSHA carcinogens and IARC, NTP listed chemicals SECTION 4: FIRST AID MEASURES EYES: Flush eyes with water. Call physician if irritation develops SKIN: Wash skin with plenty of water INGESTION: Give large quantities of water. Call physician immediately INHALATION: None r equired NOTES TO PHYSICIANS OR FIRST AID PROVIDERS: N/A SECTION 4 NOTES: SECTION 5: FIRE-FIGHTING MEASURES FLAMMABLE LIMITS IN AIR, UPPER: N/A (% BY VOLUME) LOWER: N/A FLASH POINT: N/A N/A METHOD USED: N/A AUTOIGNITION TEMPERATURE: N/A N/A NFPA HAZARD CLASSIFICATION HEALTH: 0 FLAMMABILITY: 0 REACTIVITY: 0 OTHER: HMIS HAZARD CLASSIFICATION HEALTH: 0 FLAMMABILITY: 0 REACTIVITY: 0 PROTECTION: EXTINGUISHING MEDIA: Use media appropriate to surrounding fire conditions SPECIAL FIRE FIGHTING PROCEDURES: N/A UNUSUAL FIRE AND EXPLOSION HAZARDS: N/A PAGE 2 OF 6

3 HAZARDOUS DECOMPOSITION PRODUCTS: This material will not burn SECTION 5 NOTES: SECTION 6: ACCIDENTAL RELEASE MEASURES ACCIDENTAL RELEASE MEASURES: Spill Response: Only persons properly qualified to respond to an emergency involving hazardous substances may respond to a spill according to federal regulations (OSHA 29 SFR (a) (v)) and per your company s emergency response plan and guidelines/procedures. See Section 12, Special instruction for disposal assistance Containment Technique: Stop spilled material frombeing released into the environment. Clean-up Technique: Absorb spilled liquid with non-reactive sorbent material. Sweep up material. Place material in plastic bag. Mark bag Non hazardous trash, and dispose of as normal refuse. Decontaminate the area of the spill with a soap solution. Evacuation Procdedure: Evacuate as needed to perform spill clean-up. If conditions warrant, increase the size of the evacuation. Special Instructions (for accidental release): N/A 304 EHS RQ (40 CFR 355): N/A D.O.T. Emergency Response Guide Number: None SECTION 6 NOTES: SECTION 7: HANDLING AND STORAGE HANDLING AND STORAGE: Wash thoroughly after handling. Maintain general industrial hygiene practices when using this product. Storage: Protect from freezing and heat OTHER PRECAUTIONS: SECTION 7 NOTES: SECTION 8: EXPOSURE CONTROLS/PERSONAL PROTECTION ENGINEERING CONTROLS: None reported VENTILATION: Maintain adequate ventilation RESPIRATORY PROTECTION: Adequate ventilation EYE PROTECTION: Sfety glasses with top and side shields SKIN PROTECTION: Disposable latex gloves OTHER PROTECTIVE CLOTHING OR EQUIPMENT: WORK HYGIENIC PRACTICES: Maintain general industrial hygiene practices when using this product EXPOSURE GUIDELINES: Protect from freezing and heat. Wash thoroughly after handling. SECTION 8 NOTES: PAGE 3 OF 6

4 SECTION 9: PHYSICAL AND CHEMICAL PROPERTIES APPEARANCE: Clear, colorless ODOR: Odorless PHYSICAL STATE: Liquid ph AS SUPPLIED: 6.25 ph (Other): BOILING POINT: N/A MELTING POINT: N/A FREEZING POINT: VAPOR PRESSURE (mmhg): N/A VAPOR DENSITY (AIR = 1): N/A SPECIFIC GRAVITY (H2O = 1): N/A EVAPORATION RATE: N/A BASIS (=1): N/A SOLUBILITY IN WATER: Soluble PERCENT SOLIDS BY WEIGHT: PERCENT VOLATILE: BY WT/ BY VOL VOLATILE ORGANIC COMPOUNDS (VOC): WITH WATER: WITHOUT WATER: LBS/GAL LBS/GAL MOLECULAR WEIGHT: VISCOSITY: SECTION 9 NOTES: PAGE 4 OF 6

5 SECTION 10: STABILITY AND REACTIVITY STABLE UNSTABLE STABILITY: Yes CONDITIONS TO AVOID (STABILITY): Extreme temperatures INCOMPATIBILITY (MATERIAL TO AVOID): None reported HAZARDOUS DECOMPOSITION OR BY-PRODUCTS: No hazardous decomposition products known HAZARDOUS POLYMERIZATION: Will not occur CONDITIONS TO AVOID (POLYMERIZATION): SECTION 10 NOTES: SECTION 11: TOXICOLOGICAL INFORMATION TOXICOLOGICAL INFORMATION: LD50: None reported LC50: None reported Dermal Toxicity Data: None reported Skin and Eye Irritation Data: None reported Mutation Data: Glycine ister chromatid exchange human lymphocytes 100 mg/l Reproductive Effects Data: None reported Ingredient Toxicological Data: Glycine oral rate LD50=7930 mg/kg SECTION 11 NOTES: SECTION 12: ECOLOGICAL INFORMATION ECOLOGICAL INFORMATION: No product ecological information available SECTION 12 NOTES: SECTION 13: DISPOSAL CONSIDERATIONS WASTE DISPOSAL METHOD: Open cold water tap completely, slowly our the material into the drain. Allow cold water to run for 5 minutes to completely flush the system. Empty Containers: Rinse three (3) times with an appropriate solvent. Dispose of empty container as normal trash. RCRA HAZARD CLASS: SECTION 13 NOTES: These disposal guidelines are based on federal regulations and may be superseded by more stringent state and local requirements. Please consult your local environmental regulators for more information. PAGE 5 OF 6

6 SECTION 14: TRANSPORT INFORMATION U.S. DEPARTMENT OF TRANSPORTATION PROPER SHIPPING NAME: Not currently regulated HAZARD CLASS: ID NUMBER: PACKING GROUP: LABEL STATEMENT: WATER TRANSPORTATION PROPER SHIPPING NAME: Not currently regulated HAZARD CLASS: ID NUMBER: PACKING GROUP: LABEL STATEMENTS: AIR TRANSPORTATION PROPER SHIPPING NAME: Not currently regulated HAZARD CLASS: ID NUMBER: PACKING GROUP: LABEL STATEMENTS: OTHER AGENCIES: SECTION 14 NOTES: SECTION 15: REGULATORY INFORMATION U.S. FEDERAL REGULATIONS TSCA (TOXIC SUBSTANCE CONTROL ACT): Not Applicable CERCLA (COMPREHENSIVE RESPONSE COMPENSATION, AND LIABILITY ACT): SARA TITLE III (SUPERFUND AMENDMENTS AND REAUTHORIZATION ACT): This product does NOT hazardous under 29 CFR and therefore is not covered by Title III under SARA. 311/312 HAZARD CATEGORIES: This product does NOT hazardous under 29 CFR and therefore is not covered by Title III under SARA. 313 REPORTABLE INGREDIENTS: This product does NOT hazardous under 29 CFR and therefore is not covered by Title III under SARA. STATE REGULATIONS: INTERNATIONAL REGULATIONS: SECTION 15 NOTES: SECTION 16: OTHER INFORMATION OTHER INFORMATION: PREPARATION INFORMATION: Orbeco-Hellige, Inc. DISCLAIMER: Orbeco-Hellige, Inc provides this information with best intention, the purpose of which is meant as a guideline and no guarantee is provided regarding the completeness or accuracy of this document. End user accepts responsibility associated with use of this material in accordance with established guidelines and individual judgment. ORBECO-HELLIGE, INC WILL NOT BE HELD RESPONSIBLE FOR DAMAGE RESULTING FROM USE OR RELIANCE UPON THIS INFORMATION PAGE 6 OF 6