Safety Data Sheet ACIDE LACTIQUE

Transcription

1 Safety Data Sheet dated 21/10/2015, version 1 SECTION 1: Identification of the substance/mixture and of the company/undertaking 1.1. Product identifier Identification of the substance: Trade name: CAS number: EC number: REACH number: XXXX 1.2. Relevant identified uses of the substance or mixture and uses advised against Recommended use: Enological product 1.3. Details of the supplier of the safety data sheet Company: SOFRALAB 79 AV. A.A. Thévenet - CS MAGENTA - FRANCE Tel: 0033 (0) Fax: 0033 (0) Competent person responsible for the safety data sheet: lcq@sofralab.com 1.4. Emergency telephone number Emergency telephone number of the company and/or of an authorised advisory centre: ORFILA 0033 (0) SECTION 2: Hazards identification 2.1. Classification of the substance or mixture EC regulation criteria 1272/2008 (CLP) Warning, Skin Irrit. 2, Causes skin irritation. Danger, Eye Dam. 1, Causes serious eye damage. Adverse physicochemical, human health and environmental effects: No other hazards 2.2. Label elements Symbols: Danger Hazard statements: H315 Causes skin irritation. H318 Causes serious eye damage. Precautionary statements: P280 Wear protective gloves/protective clothing/eye protection/face protection. P302+P352 IF ON SKIN: Wash with plenty of water/... P305+P351+P338 IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing. P310 Immediately call a POISON CENTER/doctor/... Page n. 1 of 8

2 P362+P364 Take off contaminated clothing and wash it before reuse. Special Provisions: Contents LACTIC ACID Special provisions according to Annex XVII of REACH and subsequent amendments: 2.3. Other hazards vpvb Substances: - PBT Substances: Other Hazards: No other hazards SECTION 3: Composition/information on ingredients 3.1. Substances Identification of the substance: Chemical characterization: LACTIC ACID CAS number: EC number: REACH number: XXXX Qty Name Ident. Number Classification >= 90% LACTIC ACID CAS: /2 Skin Irrit. 2 H315 EC: REACH No.: /1 Eye Dam. 1 H XXXX 3.2. Mixtures SECTION 4: First aid measures 4.1. Description of first aid measures In case of skin contact: Immediately take off all contaminated clothing. OBTAIN IMMEDIATE MEDICAL ATTENTION. Remove contaminated clothing immediatley and dispose off safely. After contact with skin, wash immediately with soap and plenty of water. In case of eyes contact: After contact with the eyes, rinse with water with the eyelids open for a sufficient length of time, then consult an opthalmologist immediately. Protect uninjured eye. In case of Ingestion: Do not under any circumstances induce vomiting. OBTAIN A MEDICAL EXAMINATION IMMEDIATELY. In case of Inhalation: Remove casualty to fresh air and keep warm and at rest Most important symptoms and effects, both acute and delayed 4.3. Indication of any immediate medical attention and special treatment needed In case of accident or unwellness, seek medical advice immediately (show directions for use or safety data sheet if possible). Treatment: Page n. 2 of 8

3 SECTION 5: Firefighting measures 5.1. Extinguishing media Suitable extinguishing media: Water. Carbon dioxide (CO2). Extinguishing media which must not be used for safety reasons: in particular Special hazards arising from the substance or mixture Do not inhale explosion and combustion gases. Burning produces heavy smoke Advice for firefighters Use suitable breathing apparatus. Collect contaminated fire extinguishing water separately. This must not be discharged into drains. Move undamaged containers from immediate hazard area if it can be done safely. SECTION 6: Accidental release measures 6.1. Personal precautions, protective equipment and emergency procedures Wear personal protection equipment. Remove all sources of ignition. Remove persons to safety. See protective measures under point 7 and Environmental precautions Do not allow to enter into soil/subsoil. Do not allow to enter into surface water or drains. Retain contaminated washing water and dispose it. In case of gas escape or of entry into waterways, soil or drains, inform the responsible authorities. Suitable material for taking up: absorbing material, organic, sand 6.3. Methods and material for containment and cleaning up Wash with plenty of water Reference to other sections See also section 8 and 13 SECTION 7: Handling and storage 7.1. Precautions for safe handling Avoid contact with skin and eyes, inhaltion of vapours and mists. Don't use empty container before they have been cleaned. Before making transfer operations, assure that there aren't any incompatible material residuals in the containers. Contamined clothing should be changed before entering eating areas. Do not eat or drink while working. See also section 8 for recommended protective equipment Conditions for safe storage, including any incompatibilities Keep away from food, drink and feed. Incompatible materials: in particular. Instructions as regards storage premises: Adequately ventilated premises Specific end use(s) in particular SECTION 8: Exposure controls/personal protection 8.1. Control parameters No occupational exposure limit available Page n. 3 of 8

4 DNEL Exposure Limit Values PNEC Exposure Limit Values 8.2. Exposure controls Eye protection: Eye glasses with side protection. Protection for skin: Overall. Protection for hands: Gloves of full protection Respiratory protection: Not needed for normal use. Thermal Hazards: Environmental exposure controls: Appropriate engineering controls: SECTION 9: Physical and chemical properties 9.1. Information on basic physical and chemical properties Properties Value Method: Notes Appearance and colour: Liquid Odour: Characteristic Odour threshold: ph: Melting point / freezing point: Initial boiling point and 125 C boiling range: Flash point: >112 C Evaporation rate: Solid/gas flammability: Upper/lower flammability or explosive limits: Vapour pressure: mn/m Vapour density: Relative density: 1.2 g/cm Solubility in water: 100% Solubility in oil: Partition coefficient log Pow = (n-octanol/water): Auto-ignition temperature: Decomposition >200 C temperature: Viscosity: Explosive properties: Oxidizing properties: Other information Page n. 4 of 8

5 Properties Value Method: Notes Miscibility: Fat Solubility: Conductivity: SECTION 10: Stability and reactivity Reactivity Stable under normal conditions Chemical stability Stable under normal conditions Possibility of hazardous reactions Conditions to avoid Hight temperatures Incompatible materials Oxydants Hazardous decomposition products. SECTION 11: Toxicological information Information on toxicological effects Toxicological information of the substance: LACTIC ACID - CAS: a) acute toxicity: Test: LD50 - Route: Skin - Species: Rabbit > 2000 mg/kg Test: LC50 - Route: Inhalation - Species: Rat = 7.94 mg/l - Duration: 4h Test: LD50 - Route: Oral - Species: Rat = 4875 mg/kg Test: LD50 - Route: Oral - Species: Rat = 3730 mg/kg b) skin corrosion/irritation: Test: Skin Irritant - Route: Skin Positive If not differently specified, the information required in Regulation (EU)2015/830 listed below must be considered as : a) acute toxicity; b) skin corrosion/irritation; c) serious eye damage/irritation; d) respiratory or skin sensitisation; e) germ cell mutagenicity; f) carcinogenicity; g) reproductive toxicity; h) STOT-single exposure; i) STOT-repeated exposure; j) aspiration hazard. SECTION 12: Ecological information Toxicity Adopt good working practices, so that the product is not released into the environment. LACTIC ACID - CAS: a) Aquatic acute toxicity: Endpoint: EC50 Daphnia = 240 mg/l - Duration h: 48 Endpoint: LC50 Fish = 320 mg/l - Duration h: 48 Endpoint: EC50 Algae = 3500 mg/l Page n. 5 of 8

6 12.2. Persistence and degradability Bioaccumulative potential Mobility in soil Results of PBT and vpvb assessment vpvb Substances: - PBT Substances: Other adverse effects SECTION 13: Disposal considerations Waste treatment methods Recover, if possible. Send to authorised disposal plants or for incineration under controlled conditions. In so doing, comply with the local and national regulations currently in force. SECTION 14: Transport information UN number Not classified as dangerous in the meaning of transport regulations UN proper shipping name Transport hazard class(es) Packing group Environmental hazards ADR-Enviromental Pollutant: No IMDG-Marine pollutant: No Special precautions for user Transport in bulk according to Annex II of Marpol and the IBC Code SECTION 15: Regulatory information Safety, health and environmental regulations/legislation specific for the substance or mixture Dir. 98/24/EC (Risks related to chemical agents at work) Dir. 2000/39/EC (Occupational exposure limit values) Regulation (EC) n. 1907/2006 (REACH) Regulation (EC) n. 1272/2008 (CLP) Regulation (EC) n. 790/2009 (ATP 1 CLP) and (EU) n. 758/2013 Regulation (EU) 2015/830 Regulation (EU) n. 286/2011 (ATP 2 CLP) Regulation (EU) n. 618/2012 (ATP 3 CLP) Regulation (EU) n. 487/2013 (ATP 4 CLP) Regulation (EU) n. 944/2013 (ATP 5 CLP) Regulation (EU) n. 605/2014 (ATP 6 CLP) Restrictions related to the product or the substances contained according to Annex XVII Regulation (EC) 1907/2006 (REACH) and subsequent modifications: Restrictions related to the product: Restriction 3 Restrictions related to the substances contained: No restriction. Where applicable, refer to the following regulatory provisions : Page n. 6 of 8

7 Directive 2003/105/CE ('Activities linked to risks of serious accidents') and subsequent amendments. Regulation (EC) nr 648/2004 (detergents). 1999/13/EC (VOC directive) Provisions related to directives 82/501/EC(Seveso), 96/82/EC(Seveso II): Chemical safety assessment No SECTION 16: Other information Full text of phrases referred to in Section 3: H315 Causes skin irritation. H318 Causes serious eye damage. This document was prepared by a competent person who has received appropriate training. Main bibliographic sources: ECDIN - Environmental Chemicals Data and Information Network - Joint Research Centre, Commission of the European Communities SAX's DANGEROUS PROPERTIES OF INDUSTRIAL MATERIALS - Eight Edition - Van Nostrand Reinold CCNL - Appendix 1 The information contained herein is based on our state of knowledge at the above-specified date. It refers solely to the product indicated and constitutes no guarantee of particular quality. It is the duty of the user to ensure that this information is appropriate and complete with respect to the specific use intended. This MSDS cancels and replaces any preceding release. ADR: CAS: CLP: DNEL: EINECS: GefStoffVO: GHS: IATA: IATA-DGR: ICAO: ICAO-TI: IMDG: INCI: KSt: LC50: LD50: LTE: PNEC: RID: STE: STEL: STOT: European Agreement concerning the International Carriage of Dangerous Goods by Road. Chemical Abstracts Service (division of the American Chemical Society). Classification, Labeling, Packaging. Derived No Effect Level. European Inventory of Existing Commercial Chemical Substances. Ordinance on Hazardous Substances, Germany. Globally Harmonized System of Classification and Labeling of Chemicals. International Air Transport Association. Dangerous Goods Regulation by the "International Air Transport Association" (IATA). International Civil Aviation Organization. Technical Instructions by the "International Civil Aviation Organization" (ICAO). International Maritime Code for Dangerous Goods. International Nomenclature of Cosmetic Ingredients. Explosion coefficient. Lethal concentration, for 50 percent of test population. Lethal dose, for 50 percent of test population. Long-term exposure. Predicted No Effect Concentration. Regulation Concerning the International Transport of Dangerous Goods by Rail. Short-term exposure. Short Term Exposure limit. Specific Target Organ Toxicity. Page n. 7 of 8

8 TLV: TWATLV: WGK: Threshold Limiting Value. Threshold Limit Value for the Time Weighted Average 8 hour day. (ACGIH Standard). German Water Hazard Class. Page n. 8 of 8