THE SPECIALIST FOR NO DIG REHABILITATION

Size: px
Start display at page:

Download "THE SPECIALIST FOR NO DIG REHABILITATION"

Transcription

1 THE SPECIALIST FOR NO DIG REHABILITATION DN 50 to DN 250 Private and public drainage Housing management Industry

2 HIGH DEMAND FOR PIPE REHABILITATION The total length of drainage systems on private and industrial properties is far greater than the public sewer system. Studies in various regions recorded a leakage of 50 to 70 percent. One fifth of the tested pipes should be rehabilitated in the short to medium term to avoid more serious damage in the future. There is so much to do let s go for it. The Problems Exfiltration: Through defective pipes wastewater can enter into the ground. The discharge of pollutants into the ground is illegal and contamination of soil and groundwater must be avoided. Infiltration: If clean groundwater and rainwater enters faulty sewage pipes, it must be cleaned at the treatment plant and this leads to a significant increase in sewage charges. Value of the property Leaking pipes can cause a wet basement, a blockage or even a collapse of the pipes during heavy rainfall. If the damage is detected in time, it can be easily removed and expensive consequential damage can be avoided. With the proven BRAWOLINER system, the rehabilitation measures can be carried out quickly, permanently and cost-effectively. Even small leaks can cause major damage over time. A camera inspection can detect the damage at an early stage, so it can be eliminated cost-effectively Longitudinal crack Roots Displacement

3 THE BRAWOLINER METHOD 1 easy, fast and reliable The BRAWOLINER method is a no dig sewer rehabilitation system for repairing damaged drains and sewers without the need to carry out disruptive excavations. This not only saves time but also money. During the renovation process, the flexible BRAWOLINER is soaked in resin and then inserted into the defective pipe using pressurised air or water. The BRAWOLINER completely lines the inside of the pipe and eliminates any existing or potential damage. Mixing of resin and hardener 2 Curing creates a completely new, watertight pipe within the old one. Impregnation of the liner 4 Result after curing: a new pipe in the old pipe 3 Inversion with a pressure drum

4 BRAWOLINER -Rehabilitation during production ADVANTAGES OF THE BRAWOLINER -REHABILITATION The BRAWOLINER -process was developed specifically for the rehabilitation of pipes in diameters from dn 50 to dn 250 and offers many advantages compared to traditional remediation: Rapid rehabilitation without excavation, dirt and noise Up to 50% cheaper than open construction Suitable for almost all demage and all pipe materials Durability of over 50 years Complicated pipe runs? No problem with BRAWOLINER The rehabilitation solution for pipes from DN 50 to DN 250 Multiple bends of up to 90 Two changes in pipe diameter are possible Fast, easy and affordable renovation of pipe unions!

5 THE COMPLETE SYSTEM FOR YOUR SUCCESS BRAWOLINER For small diameter sewer rehabilitation Completely seamless liner From DN 50 to DN 250 Optimum adaptation to the pipe Bends of up to 90 Up to two dimensional changes BRAWOLINER connection collars Flexible BRAWOLINER material Optimum adaptation to the pipe run Dimensional change is possible BRAWO resin The resins for lasting quality Epoxy resins with different curing times Excellent static properties High abrasion resistance High chemical resistance Certified environmental performance Cold-and hot-curing BRAWOLINER expert information For details, see the BRAWOLINER product data sheets and

6 Individual rehabilitation vehicles: From the standard solution to an individual trailer with resin mixing unit BRAWOLINER -EQUIPMENT As system supplier, we offer a complete and first class range of products. Alongside our own liners and epoxy resin, we can also supply the appropriate installation, leak testing and monitoring equipment. BRAWOLINER offers a one-stop shop for everything you need including professional advice and training, Make use of our expertise. BRAWO installation equipment Resin Mixing Unit Impregnation plant Inversion drum HotBox Inspection Camera Cutting tools BRAWO test equipment BRAWO DocuBox Installation documentation and seal testing Seal test set for air and water testing BRAWO Pipe connection rehabilitation Inflatable satellite bladder BRAWO Pipe connection rehabilitation Set BRAWO SteamBox for steam rehabilitation of pipe connection

7 BRAWOLINER STANDS FOR QUALITY 2 x IKT Test winner Exactly like our proven BRAWOLINER the new BRAWOLINER XT liner also won the IKT product test in standard and in extreme situations. During the extensive functional check both BRAWOLINER products received the best results in all assessment criteria s (effectiveness, density and load-carrying capacity of the structure). Consulting and Training Trained installers ensure the success of a rehabilitation. For this reason BRAWOLINER regularly offers product training and provides advices on matters of rehabilitation. Please feel free to contact us for a training session. In-house vehicle and special machinery shop BRAWOLINER offers individual rehabilitation vehicles, from the trailer to the truck, including a resin mixing plant and steam generator in the proven BRAWOLINER quality and at fair prices. DIBt and Thames Water approved BRAWOLINER was the first lining system to be awarded with DIBT approval for the rehabilitation of small dimension sewerage systems in The certification demonstrates the suitability for rehabilitation and regular checks ensure consistently high quality. Furthermore it passed the Thames Water Infiltration Test. BRAWOLINER Your competent partner Do you require any further information s about our product range, a live demo here in Wolfstein or an individual quotation? Please contact us: Phone: info@brawoliner.de We will be pleased to consult you and we are available to support you with help and advise

8 BRAWOLINER competence in more than 30 countries BRAWOLINER is a leading systems supplier in no dig rehabilitation. Besides as liners and resin, we also offer the complete installation equipment. Specializing in small diameter pipes from DN 50 to DN 250, we offer a reliable rehabilitation solution for sewerage systems with 90 bends, changes in diameters and for defective pipe connections. Outstanding service, fast delivery, expert advice and support for projects, as well as an unique quality at fair prices is what we stand for in over 30 countries. BRAWOLINER Karl Otto Braun GmbH & Co. KG Lauterstr Wolfstein/Germany Tel.: Fax: info@brawoliner.de

EVALUATION SUBJECT: HAMMERHEAD CURED-IN- PLACE PIPE (CIPP) LINING SYSTEM DIVISION: PLUMBING SECTION: SANITARY WASTE AND VENT PIPING

EVALUATION SUBJECT: HAMMERHEAD CURED-IN- PLACE PIPE (CIPP) LINING SYSTEM DIVISION: PLUMBING SECTION: SANITARY WASTE AND VENT PIPING ICC-ES Report PMG-1273 Reissued 01/2018 This report is subject to renewal 01/2019 EVALUATION SUBJECT: HAMMERHEAD CURED-IN- PLACE PIPE (CIPP) LINING SYSTEM DIVISION: 22 00 00 PLUMBING SECTION: 22 13 16

More information

CIPP Cured-in-Place Pipeline CIPP. cured-in-place pipe. trenchless pipe rehabilitation

CIPP Cured-in-Place Pipeline CIPP. cured-in-place pipe. trenchless pipe rehabilitation CIPP Cured-in-Place Pipeline CIPP cured-in-place pipe trenchless pipe rehabilitation MPC ToughTube cured-in-place pipe lives up to its name. The lining process is accomplished by either inverting or pulling

More information

Mokapu CIPP Case Study & Innovations in Trenchless Technologies for Wastewater System Rehabilitation

Mokapu CIPP Case Study & Innovations in Trenchless Technologies for Wastewater System Rehabilitation Mokapu CIPP Case Study & Innovations in Trenchless Technologies for Wastewater System Rehabilitation Presented by Mike York, Insituform Technologies, Inc. Trenchless v. Dig and Replace What is CIPP? Developed

More information

EVALUATION SUBJECT: PERMA-LATERAL PULLED- IN-PLACE CURED-IN-PLACE PIPE LINING SYSTEM

EVALUATION SUBJECT: PERMA-LATERAL PULLED- IN-PLACE CURED-IN-PLACE PIPE LINING SYSTEM ICC-ES Report PMG-1074 Reissued 11/2017 This report is subject to renewal 11/2018 EVALUATION SUBJECT: PERMA-LATERAL PULLED- IN-PLACE CURED-IN-PLACE PIPE LINING SYSTEM DIVISION: 22 00 00 PLUMBING SECTION:

More information

PIPE in PIPE instead of replacing existing pipes!

PIPE in PIPE instead of replacing existing pipes! InsaTech.US PIPE in PIPE instead of replacing existing pipes! THE NEW INNOVATIVE Rehabilitation Technology CLEAN PIPES are environmental friendliness YOUR PARTNER FOR Rehabilitation Technology The InsaTech

More information

BKP Berolina Polyester GmbH & Co. KG. Berolina-Liner System Lightspeed in gravity pipe rehabilitation!

BKP Berolina Polyester GmbH & Co. KG. Berolina-Liner System Lightspeed in gravity pipe rehabilitation! BKP Berolina Polyester GmbH & Co. KG Berolina-Liner System Lightspeed in gravity pipe rehabilitation! Berolina-Liner System The Berolina-Liner System sets new standards in pipe rehabilitation. With the

More information

Improved Inflow & Infiltration (I&I) Monitoring Program

Improved Inflow & Infiltration (I&I) Monitoring Program City of Abbotsford Improved Inflow & Infiltration (I&I) Monitoring Program Submission For 2009 UBCM Community Excellence Awards Best Practices City of Abbotsford Improved Inflow & Infiltration (I&I) Monitoring

More information

DRAIN, SEWER AND INDUSTRIAL PIPELINE

DRAIN, SEWER AND INDUSTRIAL PIPELINE Postal PO Box 16594, Dowerglen, 1612 Address No. 6 Ingwe Road, Sebenza, 1609 DRAIN, SEWER AND INDUSTRIAL PIPELINE From pipe From surveying pipe surveying to industrial to industrial vacuum vacuum units,

More information

ARE TREE ROOTS DAMAGING YOUR PIPES & DRAINS?

ARE TREE ROOTS DAMAGING YOUR PIPES & DRAINS? ARE TREE ROOTS DAMAGING YOUR PIPES & DRAINS? THE WORLD S FINEST PATENTED SYSTEM FOR LINING DRAINS & PIPES Winner of the Gold Medal at Geneva Switzerland for engineering technique product Drains & Pipelines

More information

Michelle D. Beason, PE National Plant Services, Inc.

Michelle D. Beason, PE National Plant Services, Inc. 8th Biennial HWEA Collection System Conference Michelle D. Beason, PE National Plant Services, Inc. Honolulu, HI December 4, 2015 CLEANING INSPECTION REPAIR LARGE AND SMALL DIAMETER PIPE CLEANING ROOT

More information

r.tec GmbH The technology provider of the Rabmer Group

r.tec GmbH The technology provider of the Rabmer Group r.tec GmbH The technology provider of the Rabmer Group Know How Technology Quality - Innovation What do we offer? We have developed a technology portfolio from the perspective of a contractor we serve

More information

PERFECT PIPE THE SANITARY SEWER PIPE SYSTEM THAT STANDS THE TEST OF TIME. Technology for people

PERFECT PIPE THE SANITARY SEWER PIPE SYSTEM THAT STANDS THE TEST OF TIME. Technology for people PERFECT PIPE THE SANITARY SEWER PIPE SYSTEM THAT STANDS THE TEST OF TIME Technology for people PERFECT PIPE SEWER PIPES IN THE EXCAVATION METHOD AND PIPE JACKING 02 A revolution in pipe construction for

More information

TRELLEBORG PIPE SEALS. The MtH- Story. Trelleborg Pipe Seals Establishes MtH System Internationally

TRELLEBORG PIPE SEALS. The MtH- Story. Trelleborg Pipe Seals Establishes MtH System Internationally TRELLEBORG PIPE SEALS The MtH- Story Trelleborg Pipe Seals Establishes MtH System Internationally epros DrainMtH Products and systems for the efficient rehabilitation and sustainable maintenance of wastewater

More information

Lessons Learned from a 60 CIPP Storm Sewer Liner Installation. Robert Stolt, PE Christopher Beranek, PE

Lessons Learned from a 60 CIPP Storm Sewer Liner Installation. Robert Stolt, PE Christopher Beranek, PE Lessons Learned from a 60 CIPP Storm Sewer Liner Installation Robert Stolt, PE Christopher Beranek, PE Presentation Outline 1. CIPP Project Scope 2. CIPP Liner Installation 3. Defects Identified 4. Warranty

More information

MWRD Infiltration and Inflow Control Program Compliance Update. Committee of the Whole Meeting April 3, 2018

MWRD Infiltration and Inflow Control Program Compliance Update. Committee of the Whole Meeting April 3, 2018 MWRD Infiltration and Inflow Control Program Compliance Update Committee of the Whole Meeting April 3, 2018 Presentation Outline Background on MWRD s Watershed Management Ordinance Wastewater, Infiltration

More information

Service Lateral Rehabilitation Using Cured-In-Place-Pipe (CIPP)

Service Lateral Rehabilitation Using Cured-In-Place-Pipe (CIPP) THE TOTAL SOURCE Service Lateral Rehabilitation Using Cured-In-Place-Pipe (CIPP) Brendan Doyle BLD Services, LLC Introduction Intent, to provide information on: Lateral preparation Lateral CCTV Inspection

More information

Cured-in-Place Pipe (CIPP) for Pressure Pipe. Presented by: Mike Moore

Cured-in-Place Pipe (CIPP) for Pressure Pipe. Presented by: Mike Moore Cured-in-Place Pipe (CIPP) for Pressure Pipe Presented by: Mike Moore CIPP Proven Technology Introduced over 45 years ago Most used trenchless technology for the rehabilitation of gravity flow pipeline

More information

Lateral Connection Repair

Lateral Connection Repair TRELLEBORG PIPE SEALS Lateral Connection Repair OF UNDERGROUND HOUSE SEWERS AND DOWNPIPES IN BUILDINGS epros DrainLCR-B Introducing Trelleborg Pipe Seals Part of the wider Trelleborg Industrial Solutions

More information

Infiltration and Inflow. Michael Sassaman Phone

Infiltration and Inflow. Michael Sassaman Phone Infiltration and Inflow Michael Sassaman msassaman@entecheng.com Phone 610-373-3345 Inflow and Infiltration PA DEP Learning Objectives Do you have Excessive I/I? Sources of Inflow and Infiltration I/I

More information

Method One: Liner/Bladder Assembly-Inversion Method.

Method One: Liner/Bladder Assembly-Inversion Method. CIPP Sectional/Point Repairs Critical Factors Finally Explained By: Shaun M. Flanery Abstract A 1999 report from the American Society of Civil Engineers indicated at that time that the nation s 500,000

More information

BEHIND EVERY GREAT CITY IS GREAT INFRASTUCTURE PRODUCT RANGE MAIN PIPES. Aarsleff Pipe Technologies

BEHIND EVERY GREAT CITY IS GREAT INFRASTUCTURE PRODUCT RANGE MAIN PIPES. Aarsleff Pipe Technologies BEHIND EVERY GREAT CITY IS GREAT INFRASTUCTURE PRODUCT RANGE MAIN PIPES Aarsleff Pipe Technologies 2 CONTENTS INTRODUCTION Page 3 RENEWAL OF MAIN PIPES OVERVIEW Page 4 OMEGA-LINER FOLDED PIPE Page 6 FELT

More information

State of Michigan Laws, Rules and Programs that relate to the Rehabilitation of Sanitary Sewer Collection System. By Thomas McDowell, P.E.

State of Michigan Laws, Rules and Programs that relate to the Rehabilitation of Sanitary Sewer Collection System. By Thomas McDowell, P.E. State of Michigan Laws, Rules and Programs that relate to the Rehabilitation of Sanitary Sewer Collection System By Thomas McDowell, P.E. Laws, Rules and Programs Part 41, Sewerage Systems, of the Natural

More information

Lateral Thinking The Key To Meeting Sewer Infiltration Reduction Targets & Lowering Operating Costs

Lateral Thinking The Key To Meeting Sewer Infiltration Reduction Targets & Lowering Operating Costs Lateral Thinking The Key To Meeting Sewer Infiltration Reduction Targets & Lowering Operating Costs John Monro Interflow Pty Limited Keywords: house service line, lateral, infiltration reduction, rehabilitation,

More information

SECTION IRRIGATION PIPELINE LINING (CURED-IN-PLACE PIPE)

SECTION IRRIGATION PIPELINE LINING (CURED-IN-PLACE PIPE) SECTION 02518 IRRIGATION PIPELINE LINING (CURED-IN-PLACE PIPE) PART 1 GENERAL 1.01 SECTION INCLUDES A. Irrigation pipeline lining, as herein specified, consists of installing pipe liner by trenchless methods

More information

CHAPTER 12: SANITARY SEWER SYSTEM

CHAPTER 12: SANITARY SEWER SYSTEM CHAPTER 12: SANITARY SEWER SYSTEM Chapter 12 includes the following information: 1. System Overview 2. On Site Sewage Treatment 3. Inter Community Services 4. Future Demand Forecast 5. Infiltration and

More information

CHAPTER 12: SANITARY SEWER SYSTEM

CHAPTER 12: SANITARY SEWER SYSTEM CHAPTER 12: SANITARY SEWER SYSTEM Chapter 12 includes the following information: 1. System Overview 2. On-Site Sewage Treatment 3. Inter-Community Services 4. Future Demand Forecast 5. Infiltration and

More information

TECHNICAL SPECIFICATION FOR CURED-IN-PLACE MANHOLE REHABILITATION LINER SYSTEM

TECHNICAL SPECIFICATION FOR CURED-IN-PLACE MANHOLE REHABILITATION LINER SYSTEM TECHNICAL SPECIFICATION FOR CURED-IN-PLACE SYSTEM PART 1 GENERAL 1.01 SCOPE OF WORK Furnish all materials, labor, equipment, tools and required incidentals for providing and installing a resin impregnated

More information

DOLOMITE RISK MANAGEMENT PROCEDURE FOR IRENE GLEN HOMEOWNERS ASSOCIATION

DOLOMITE RISK MANAGEMENT PROCEDURE FOR IRENE GLEN HOMEOWNERS ASSOCIATION DOLOMITE RISK MANAGEMENT PROCEDURE FOR IRENE GLEN HOMEOWNERS ASSOCIATION INDEX 1. INTRODUCTION 1 2. INFRASTRUCTURE MANAGEMENT PLAN 1 3. RESIDENCE MANAGEMENT PLAN 3 4. EMERGENCY REACTION PLAN 6 5. MONITORING

More information

I N S DR A L T D. Specialist Drainage & Plumbing Services. Tel: Unit 1 Abbey Industrial Park Bumbles Green Nazeing Essex EN9 2SD

I N S DR A L T D. Specialist Drainage & Plumbing Services. Tel: Unit 1 Abbey Industrial Park Bumbles Green Nazeing Essex EN9 2SD A B B E Y L T D DR A I N S Specialist Drainage & Plumbing Services Unit 1 Abbey Industrial Park Bumbles Green Nazeing Essex EN9 2SD Tel: 01992 892 772 Looking after your environment www.abbeydrains.co.uk

More information

Rehabilitating drains and sewers

Rehabilitating drains and sewers Rehabilitating drains and sewers Time-saving mortars for drain & sewer rehabilitation Wastewater systems have been constructed in Germany since the middle of the 19th century. Many now need rehabilitating

More information

Installation Practice InnerSeal

Installation Practice InnerSeal Installation Practice InnerSeal Rehabilitation of a Full-Length Sewer Service Lateral using One-Piece Main and Lateral Cured-In-Place Liner Assembly Installed By Means Of Air Inversion 1. Intent This instruction

More information

Current Status of Sewer Network Renovation in Europe and the Activities of CEN

Current Status of Sewer Network Renovation in Europe and the Activities of CEN Global Standardization - How will it Contribute to Sewage Works in Japan? Current Status of Sewer Network Renovation in Europe and the Activities of CEN Dr John Gumbel Convenor ISO TC138 WG12 Global Standardization

More information

NEW CONTRACT STRUCTURE LEADS TO OPTIMUM SEWER REHABILITATION PROGRAM

NEW CONTRACT STRUCTURE LEADS TO OPTIMUM SEWER REHABILITATION PROGRAM John Monro Interflow Pty Limited Abstract: NEW CONTRACT STRUCTURE LEADS TO OPTIMUM SEWER REHABILITATION PROGRAM Being the region s largest Water Corporation, Sydney Water maintains an extensive program

More information

The Rehabilitation of Existing Building Drains and Building Sewers by the

The Rehabilitation of Existing Building Drains and Building Sewers by the Inversion or Pulled-in-Place Method and Curing of Resin-impregnated Tube Page 1 of 7 www.icc-es.org/pmg (800) 423-6587 (562) 699-0543 A Subsidiary of the International Code Council PROPOSED PMG LISTING

More information

Lateral connection seals for Würzburg

Lateral connection seals for Würzburg 1 Lateral connection seals for Würzburg Successful trial for Trelleborg epros small-diameter lateral connection repair system Trenchless repairs of lateral connections are rather tricky jobs to do. Many

More information

International Aramoon Corp. Pipe Inspection and Rehabilitation By: Faiz Al-Elweet. SAWEA Al-Khobar KSA February 24, 2010

International Aramoon Corp. Pipe Inspection and Rehabilitation By: Faiz Al-Elweet. SAWEA Al-Khobar KSA February 24, 2010 International Aramoon Corp. 1 Pipe Inspection and Rehabilitation By: Faiz Al-Elweet SAWEA Al-Khobar KSA February 24, 2010 International Aramoon Corp. 2 Nobody would like to wait until the problem appears

More information

INLINER LAY_InLiner Brochure_FA_ indd 1

INLINER LAY_InLiner Brochure_FA_ indd 1 INLINER LAY_InLiner Brochure_FA_010913.indd 1 Layne Inliner, LLC is the second largest cured-in-place pipe (CIPP) lining company in the United States. We began as the first U.S. licensee of the Inliner

More information

With over 40 years experience, SDI-unistride

With over 40 years experience, SDI-unistride sdi-unistride Company Profile With over 40 years experience, SDI-unistride is an award winning drainage solution provider. Our teams having many different skills ranging from: Camera surveys and investigations

More information

SECTION XXXXX CHEMICAL GROUTING

SECTION XXXXX CHEMICAL GROUTING SECTION XXXXX CHEMICAL GROUTING PART 1 -- GENERAL 1.01 SCOPE OF WORK A. Provide all labor, materials, accessories, equipment, and tools required for the rehabilitation, infiltration reduction, and root

More information

Pipeline Rehabilitation

Pipeline Rehabilitation Pipeline Rehabilitation Profile The Velosi Group was formed in 1982 and has grown to become one of the world s most trusted specialists in Asset Integrity and HSE Solutions providing a comprehensive range

More information

SPECIFICATIONS FOR PREMIER-PIPE USA CURED-IN-PLACE TECH LINER

SPECIFICATIONS FOR PREMIER-PIPE USA CURED-IN-PLACE TECH LINER SPECIFICATIONS FOR PREMIER-PIPE USA CURED-IN-PLACE TECH LINER 1. General Statement: This specification is for the Cured in Place Pipe process (CIPP) of pipe rehabilitation using a glass fiber reinforced

More information

Pipeline renovation with Omega-Liner close-fit lining

Pipeline renovation with Omega-Liner close-fit lining Pipeline renovation with Omega-Liner close-fit lining Omega-Liner close fit lining fast and reliable solution for sewer renovation In the Omega-Liner close-fit lining the old sewer pipeline is replaced

More information

Overview of Lateral and Main/Lateral Connection Lining and Sealing Technologies

Overview of Lateral and Main/Lateral Connection Lining and Sealing Technologies Overview of Lateral and Main/Lateral Connection Lining and Sealing Technologies Prepared by the NASSCO Lateral Committee 11/14/12 0 P a g e TABLE OF CONTENTS 1.0 INTRODUCTION PAGE 3 2.0 REHABILITATION

More information

Overview of Lateral and Main/Lateral Connection Lining and Sealing Technologies

Overview of Lateral and Main/Lateral Connection Lining and Sealing Technologies Overview of Lateral and Main/Lateral Connection Lining and Sealing Technologies Prepared by the NASSCO Lateral Committee 08/12/14 0 P a g e TABLE OF CONTENTS 1.0 INTRODUCTION PAGE 3 2.0 REHABILITATION

More information

Infrastructure Point Repair System Technical Specifications

Infrastructure Point Repair System Technical Specifications 4301 A 34 t h Street North St. Petersburg, FL 33714 PH: 877-327-4216 Fax: 727-327- 4118 Web: www.irsi.net Infrastructure Point Repair System 1. Scope: This specification defines the approved methodology

More information

SS 207 Junction Sealing for Circular Non Man Entry Sewer Pipe

SS 207 Junction Sealing for Circular Non Man Entry Sewer Pipe Standard Specification SS 207 Junction Sealing for Circular Non Man Entry Sewer Pipe Version 1 1 General 1.1 Intent The intent of this specification is to define the requirements for rehabilitating and

More information

Lateral liner wanted: fitted, no crease and tight

Lateral liner wanted: fitted, no crease and tight IKT-Product-Test Lateral liner wanted: fitted, no crease and tight Fitting accuracy, flat surface and leaktightness: the latest IKT-Product-Test Liners for Laterals shows which liners fulfil the requirements

More information

You can help protect our water from pharmaceuticals and personal care products! Tel. 1-800-666-0206 Fax. 1-703-684-2492 www.wef.org a Printed on 100% recycled paper. HS1802 6/2008 You can help protect

More information

ACRYLATE INJECTION KEEPS PICTURESQUE CERNE ABBAS OPEN FOR BUSINESS

ACRYLATE INJECTION KEEPS PICTURESQUE CERNE ABBAS OPEN FOR BUSINESS ACRYLATE INJECTION KEEPS PICTURESQUE CERNE ABBAS OPEN FOR BUSINESS Cerne Abbas is an ancient settlement with a recorded history going back over 1,000 years. The village nestles in the Dorset countryside

More information

Service Lateral Rehabilitation

Service Lateral Rehabilitation THE TOTAL SOURCE Service Lateral Rehabilitation Jacob Trapani BLD Services, LLC Introduction Intent, to provide information on: Lateral rehabilitation Sealing options Studies have shown that 40% to 70%

More information

FUTURE ORIENTATED AND POWERFUL. REHAU U-LINER PRESENTATION

FUTURE ORIENTATED AND POWERFUL. REHAU U-LINER PRESENTATION FUTURE ORIENTATED AND POWERFUL. PRESENTATION BY TOBIAS DEMEL BUSINESS DEVELOPMENT V1 11.201 www.rehau.com Construction Automotive Industry REHAU, UNLIMITED POLYMER SOLUTIONS WHO IS REHAU? REHAU, UNLIMITED

More information

SECTION 809 CURED-IN-PLACE PIPE (CIPP) LATERALS

SECTION 809 CURED-IN-PLACE PIPE (CIPP) LATERALS SECTION 809 CURED-IN-PLACE PIPE (CIPP) LATERALS 809-1 DESCRIPTION: This Work consists of installing a cured-in-place pipe (CIPP) liner to stabilize structural defects and construction inadequacies in sanitary

More information

TESTING TOP HAT LINERS AND ROBOTIC SYSTEMS FOR REPAIR OF LATERAL CONNECTIONS. Dr.-Ing. Bert Bosseler, Dipl.-Ing. Gunter Kaltenhäuser

TESTING TOP HAT LINERS AND ROBOTIC SYSTEMS FOR REPAIR OF LATERAL CONNECTIONS. Dr.-Ing. Bert Bosseler, Dipl.-Ing. Gunter Kaltenhäuser TESTING TOP HAT LINERS AND ROBOTIC SYSTEMS FOR REPAIR OF LATERAL CONNECTIONS Dr.-Ing. Bert Bosseler, Dipl.-Ing. Gunter Kaltenhäuser IKT - Institute for Underground Infrastructure, Exterbruch 1, 45886 Gelsenkirchen,

More information

Specification Guidelines for Testing and Sealing Lateral Connections and Lateral Service Lines in Sanitary Sewer Systems

Specification Guidelines for Testing and Sealing Lateral Connections and Lateral Service Lines in Sanitary Sewer Systems Specification The information contained in the document is property of Avanti International. Avanti offers the following verbiage as a technical reference to assist in the creation of specifications for

More information

Application Engineering Services. Solutions for all Surface Engineering Needs

Application Engineering Services. Solutions for all Surface Engineering Needs Application Engineering Services Solutions for all Surface Engineering Needs Henkel Your Partner for Maintenance & Repair Solutions With years of experience in the industrial maintenance market, Henkel

More information

SEWER TELEVISING & REPAIRS. Adam Tierney Business Development Manager Northern Pipe, Inc.

SEWER TELEVISING & REPAIRS. Adam Tierney Business Development Manager Northern Pipe, Inc. SEWER TELEVISING & REPAIRS Adam Tierney Business Development Manager Northern Pipe, Inc. AGENDA Purpose of CCTV Inspections Equipment NASSCO (National Association of Sewer Service Companies) Inspection

More information

Sure-Grip System. A System with Benefits. Concrete Protection

Sure-Grip System. A System with Benefits. Concrete Protection Concrete Protection Concrete Protection The Sure-Grip concrete protective liner system, developed and patented by Agru, is a high-quality innovative solution for the long-term protection of concrete structures.

More information

C) Poly-Triplex Liner System-4400: Custom fabricated liner composed of 20- ounce non-porous inner membrane with two (2) 12-ounce layers of structural

C) Poly-Triplex Liner System-4400: Custom fabricated liner composed of 20- ounce non-porous inner membrane with two (2) 12-ounce layers of structural The PolyTriplex Liner System was developed to permanently stop infiltration and halt further deterioration in manholes and sewage pump-stations. Successful installations have taken place for over ten years.

More information

17/03/2017 CONTENTS. Real Cases Studies in the Region for Pipelines Inspection & Rehabilitation. Introduction CONTENTS. Introduction / Cont.

17/03/2017 CONTENTS. Real Cases Studies in the Region for Pipelines Inspection & Rehabilitation. Introduction CONTENTS. Introduction / Cont. E M I R A T E S Real Cases Studies in the Region for Pipelines Inspection & Rehabilitation i) Introduction Dubia, UAE 14 March 2017 Trenchless Middle East Faiz Alelweet & Eng. Hamza Ali Maintenance Manager

More information

Sectional repair of Pipes and Sewers

Sectional repair of Pipes and Sewers TRELLEBORG PIPE SEALS Sectional repair of Pipes and Sewers epros DrainPacker Introducing Trelleborg Pipe Seals Part of the wider Trelleborg Industrial Solutions Business Area of Trelleborg Group, Trelleborg

More information

INTERFIT LATERAL SEALING SYSTEM INSTALLATION GUIDELINE SPECIFICATION

INTERFIT LATERAL SEALING SYSTEM INSTALLATION GUIDELINE SPECIFICATION INTERFIT LATERAL SEALING SYSTEM INSTALLATION GUIDELINE SPECIFICATION INTERFIT LATERAL SEALING SYSTEM SECTION 1: GENERAL 1.1 INTENT 1.2 SCOPE 1.3 REFERENCE DOCUMENTS AND STANDARDS 1.4 SUBMITTALS SECTION

More information

Press Release. Rehabilitation of oil pipelines with flexible high pressure pipes

Press Release. Rehabilitation of oil pipelines with flexible high pressure pipes Press Release July 31, 2013 Rehabilitation of oil pipelines with flexible high pressure pipes Network operators all over the world are confronted with increasingly aging pipeline infrastructure. Since

More information

CIPMH (Cured-in-Place Manhole) Lining System

CIPMH (Cured-in-Place Manhole) Lining System Product Submittal Document Information CIPMH (Cured-in-Place Manhole) Lining System CIPMH FULL DEPTH-PA For Structural Rehabilitation Updated 9/25/14 Product Submittal Review ITEM 1. Manufacturer Company

More information

Private Side Sewer Inspections for Sources of Inflow & Infiltration Frequently Asked Questions

Private Side Sewer Inspections for Sources of Inflow & Infiltration Frequently Asked Questions Private Side Sewer Inspections for Sources of Inflow & Infiltration Frequently Asked Questions As of Oct. 1, 2010, Tacoma property owners are required to have a certified inspection of their private side

More information

Eastern Drainage Services Ltd Drainage investigations for surveyors, engineers and loss adjusters

Eastern Drainage Services Ltd Drainage investigations for surveyors, engineers and loss adjusters Eastern Drainage Services Ltd Drainage investigations for surveyors, engineers and loss adjusters Specialists in all drainage renovation techniques including in-situ repairs and sewer connections 6 Drymere,

More information

Time-saving mortars for drains & sewers

Time-saving mortars for drains & sewers Time-saving mortars for drains & sewers Ideas Concepts Solutions for the construction and renovation of sewers, pipes, reservoirs, roads, industrial flooring and anchors. Save time with Time-saving mortars

More information

Rigid and Flexible Pipe Design, Installation and Whole of Life Cost

Rigid and Flexible Pipe Design, Installation and Whole of Life Cost Rigid and Flexible Pipe Design, Installation and Whole of Life Cost Rigid and Flexible Pipe Design, Installation and Whole of Life Cost Executive Summary Pipes are typically identified as either flexible

More information

Building over or close to a public sewer

Building over or close to a public sewer Building over or close to a public sewer Place holder image thameswater.co.uk/developerservices Building over or close to a public sewer Did you know Thames Water is legally responsible for more than 100,000

More information

REPORTER INSPECTION NEWS & VIEWS FROM THE AMERICAN SOCIETY OF HOME INSPECTORS, INC.

REPORTER INSPECTION NEWS & VIEWS FROM THE AMERICAN SOCIETY OF HOME INSPECTORS, INC. ASHI 10.18 REPORTER INSPECTION NEWS & VIEWS FROM THE AMERICAN SOCIETY OF HOME INSPECTORS, INC. THE UNKNOWN UNDERGROUND The Zero Dig Solution to Failing Sewer Laterals By Morgan Trouard PG16 TECHNICAL FOCUS

More information

Lining Solutions for a future Life

Lining Solutions for a future Life Lining Solutions for a future Life www.saertex-multicom.com EN SAERTEX multicom LP Huntersville, NC USA SAERTEX multicom GmbH Headquarter, Saerbeck Germany Your system supplier for trenchless pipe rehabilitation.

More information

SKSC Civils (pty) LTD. Brilliance Technology Quality - Innovation

SKSC Civils (pty) LTD. Brilliance Technology Quality - Innovation SKSC Civils (pty) LTD Brilliance Technology Quality - Innovation About us SKSC Civils was inspired by numerous individuals in South Africa, ranging from the civil to the construction industry, to truly

More information

This policy will generally explain the following in regards to the City sewerage collection systems:

This policy will generally explain the following in regards to the City sewerage collection systems: CITY OF SACO POLICY ON SEWER AND STORMWATER BACK-UPS PURPOSE The purpose of this policy is to explain how and why sewer or stromwater backups occur, what to do in the event a homeowner has a backup, and

More information

Lateral Connection Repair

Lateral Connection Repair TRELLEBORG PIPE SEALS Lateral Connection Repair IN MAIN SEWER PIPES epros DrainLCR-S Introducing Trelleborg Pipe Seals Part of the wider Trelleborg Industrial Solutions Business Area of Trelleborg Group,

More information

TECHNICAL SPECIFICATIONS FIBERGLASS/ULTRAVIOLET LIGHT CURED-IN-PLACE PIPE (CIPP) FOR MAINLINE RENEWAL

TECHNICAL SPECIFICATIONS FIBERGLASS/ULTRAVIOLET LIGHT CURED-IN-PLACE PIPE (CIPP) FOR MAINLINE RENEWAL TECHNICAL SPECIFICATIONS FIBERGLASS/ULTRAVIOLET LIGHT CURED-IN-PLACE PIPE (CIPP) FOR MAINLINE RENEWAL PART 1 - PRODUCTS 1.1 GENERAL It is the intent of this specification to provide for the reconstruction

More information

Top Performance Pipes for Toughest Conditions

Top Performance Pipes for Toughest Conditions h Top Performance Pipes for Toughest Conditions 2 Corrosion, Abrasion, Impacts: Customized Solutions for the Most Challenging Applications h Top Performance Pipe Systems When aggressive materials are transported

More information

San Antonio Water System Standard Specifications for Construction ITEM NO SANITARY SEWER LATERAL STUB OUTS OR RECONNECTIONS

San Antonio Water System Standard Specifications for Construction ITEM NO SANITARY SEWER LATERAL STUB OUTS OR RECONNECTIONS 1109.1 DESCRIPTION: ITEM NO. 1109 SANITARY SEWER LATERAL STUB OUTS OR RECONNECTIONS 1. Installation of sanitary sewer lateral stub outs in sanitary sewer mains serving areas where service did not previously

More information

Infiltration & Inflow

Infiltration & Inflow Infiltration & Inflow Understanding How Stormwater & Groundwater Increase Sewer Treatment Costs Presented by Southeast Pipe Survey, Inc. Infiltration & Inflow Defined Infiltration groundwater that enters

More information

Product Information. Polyester Felt Cured-In-Place Pipe (CIPP) Lining Tube

Product Information. Polyester Felt Cured-In-Place Pipe (CIPP) Lining Tube 1468 West Hospital Road Paoli, Indiana 47454 Phone: (812) 723-0244 Fax: (812) 723-0405 Polyester Felt Cured-In-Place Pipe (CIPP) Lining Tube Revised November 16, 2016 Company Profile Product Types Resins

More information

Preparing Your Agency for an Electro Scan Water CIPP Certification Field Demonstration

Preparing Your Agency for an Electro Scan Water CIPP Certification Field Demonstration Preparing Your Agency for an Electro Scan Water CIPP Certification Field Demonstration January 2016 Water Lining Defects Are Typically Missed by CCTV. Electro Scan Is Now Being Recommended For CIPP Lining

More information

Specifying Trenchless Sewer Rehabilitation Projects. Presented by: Todd Stelmacher Visu-Sewer, Inc.

Specifying Trenchless Sewer Rehabilitation Projects. Presented by: Todd Stelmacher Visu-Sewer, Inc. Specifying Trenchless Sewer Rehabilitation Projects Presented by: Todd Stelmacher Visu-Sewer, Inc. Todd Stelmacher Bio Visu-Sewer Sales Engineer MN, ND, SD, WI 30+ years public utilities experience Municipal

More information

Iran (

Iran ( An Investigation of Structural Design Effect on Sewer System Defects Using Sewer Inspection Robot N. Mehrdadi 1, S. M. Tafazoli 2, S. M. Ghaneeizad 3 1 Faculty of Environment, University of Tehran, Tehran,

More information

Chapter 8 Addressing I/I Issues and High Flows

Chapter 8 Addressing I/I Issues and High Flows Chapter Outline Chapter 8 Addressing I/I Issues and High Flows This chapter is organized into the following sections: Introduction Background Estimation of Infiltration Volume Conveyance Costs Effect of

More information

Optimize the flow. Spandau Pumpen, Your reliable partner for coolant pumps

Optimize the flow. Spandau Pumpen, Your reliable partner for coolant pumps 1-6334-EN Optimize the flow Spandau Pumpen, Your reliable partner for coolant pumps Build on experience and expertise Your machines and systems produce a variety of components every day, process metal,

More information

Superior GRP pipes for today s sewer challenges

Superior GRP pipes for today s sewer challenges SEWER Pipe Superior GRP pipes for today s sewer challenges Managing sewage and stormwater in a sustainable way Amiblu Pipe Engineered Engineered for the for next the 150 next 150 years years 1 SEWER pipe

More information

North American Society for Trenchless Technology (NASTT) No-Dig Show Nashville, TN March 11-15, Paper B-3-02

North American Society for Trenchless Technology (NASTT) No-Dig Show Nashville, TN March 11-15, Paper B-3-02 North American Society for Trenchless Technology (NASTT) No-Dig Show 2012 Nashville, TN March 11-15, 2012 Paper B-3-02 Kristina Kiest 1, and John Vose 2 Gasket Sealing Technology: A Solution to Sealing

More information

UNIFIED FACILITIES GUIDE SPECIFICATIONS

UNIFIED FACILITIES GUIDE SPECIFICATIONS USACE / NAVFAC / AFCEC / NASA UFGS-22 05 83.63 (November 2016) -------------------------------- Preparing Activity: NASA UFGS-22 05 83.63 (November 2013) UNIFIED FACILITIES GUIDE SPECIFICATIONS References

More information

A pipe restoration system for pressure pipes

A pipe restoration system for pressure pipes A pipe restoration system for pressure pipes NUFLOWTECH.COM.AU 1800 NUFLOW #NUFLOW Redline is a simple but highly effective cured-in-place pipe restoration system that completely coats the inside of copper

More information

Structural Lining of Water Mains. City of St. John s, Water and Wastewater Division

Structural Lining of Water Mains. City of St. John s, Water and Wastewater Division Structural Lining of Water Mains Overview Applications Pre-lining process Installation (Aqua-Pipe Product) Post-lining process Challenges Applications Alternative to water main reconstruction. Limited

More information

Sika Injection Systems for Concrete Structures. Concrete Structures

Sika Injection Systems for Concrete Structures. Concrete Structures Sika Injection Systems for Concrete Structures Sika is a globally active company in the speciality and construction chemicals business. It has subsidiary manufacturing, sales and technical support facilities

More information

Trenchless Technology

Trenchless Technology Trenchless Technology UNIVERSAL NEED FOR REHABILITATION Rising Community Expectations Rising Environmental Expectations Diminishing Financial Resources Aging Infrastructure Rising Risk Management & External

More information

Design, Specification and Selection of Concrete Jacking Pipes Who Decides? What Really Matters?

Design, Specification and Selection of Concrete Jacking Pipes Who Decides? What Really Matters? Design, Specification and Selection of Concrete Jacking Pipes Who Decides? What Really Matters? Author: John C. Bower, Principal, Independent Civil Solutions Pty. Ltd. Keywords: Jacking pipes, microtunnelling,

More information

Chemical Grouting to Maintain and Sustain Municipal Sewers By: Marc A Anctil Logiball Inc.

Chemical Grouting to Maintain and Sustain Municipal Sewers By: Marc A Anctil Logiball Inc. Chemical Grouting to Maintain and Sustain Municipal Sewers By: Marc A Anctil Logiball Inc. TRENCHLESS TECHNOLOGY ROADSHOW May 28-29, 2014 Scotiabank Convention Centre, Niagara Falls, ON There could

More information

CITY OF TAMPA ADDENDUM NO. 1. DATE: September 15, Contract 11-C-00001; Wastewater Sewer Rehabilitation by Cured-in-Place Pipe (C.I.P.P.

CITY OF TAMPA ADDENDUM NO. 1. DATE: September 15, Contract 11-C-00001; Wastewater Sewer Rehabilitation by Cured-in-Place Pipe (C.I.P.P. CITY OF TAMPA Pam Iorio, Mayor CONTRACT ADMINISTRATION DEPARTMENT David L. Vaughn, AIA, Director ADDENDUM NO. 1 DATE: September 15, 2010 Contract 11-C-00001; Wastewater Sewer Rehabilitation by Cured-in-Place

More information

Colombo sewerage rehabilitation project

Colombo sewerage rehabilitation project Loughborough University Institutional Repository Colombo sewerage rehabilitation project This item was submitted to Loughborough University's Institutional Repository by the/an author. Citation: ANDERSEN,

More information

Primus Line Technology

Primus Line Technology Primus Line Technology Field of application Primus Line is a new technology in the field of the trenchless reconstruction of public pipelines under pressure. Its application is very advantageous for all

More information

Drainage and Grease Management for the Commercial Kitchen

Drainage and Grease Management for the Commercial Kitchen Drainage and Grease Management for the Commercial Kitchen ACO. The future of drainage. The ACO system chain provides drainage solutions to meet the needs of tomorrow s food service facilities. Hostile

More information

SPECIAL SPECIFICATION 5256 Cured-In-Place Pipe (Sanitary Sewer)

SPECIAL SPECIFICATION 5256 Cured-In-Place Pipe (Sanitary Sewer) 2004 Specifications CSJ 0912-71-657 SPECIAL SPECIFICATION 5256 Cured-In-Place Pipe (Sanitary Sewer) 1. Description. Furnish and install cured-in-place pipe. A. Resin-impregnated flexible tubes inserted

More information

CIPP REFERENCE SPECIFICATION

CIPP REFERENCE SPECIFICATION CIPP REFERENCE SPECIFICATION This CIPP Reference Specification serves as only a guideline and is not intended to encompass the requirements of every municipality or industrial application. However, the

More information

Reliable GRP pipe systems for potable water supply

Reliable GRP pipe systems for potable water supply PIPE Systems Reliable GRP pipe systems for potable water supply A clever way to safely transport drinking water Amiblu Pipe Systems PIPE SYSTEMS Amiblu GRP pipe systems Hobas and Flowtite glassfiber reinforced

More information