SAFETY DATA SHEET. Eye Irrit. 2: H319; Skin Irrit. 2: H315 Causes skin irritation. Causes serious eye irritation.

Transcription

1 Page: 1 Compilation date: 25/11/2014 Revision date: 04/02/2016 Revision No: 7 Section 1: Identification of the substance/mixture and of the company/undertaking 1.1. Product identifier Product name: 1.2. Relevant identified uses of the substance or mixture and uses advised against Use of substance / mixture: Water miscible metalworking fluid 1.3. Details of the supplier of the safety data sheet Company name: ROCOL ROCOL House Swillington Leeds West Yorkshire LS26 8BS ENGLAND Tel: +44 (0) Fax: +44 (0) customer-service@rocol.com 1.4. Emergency telephone number Emergency tel: +44 (0) Section 2: Hazards identification 2.1. Classification of the substance or mixture Classification under CLP: Most important adverse effects: Eye Irrit. 2: H319; Skin Irrit. 2: H315 Causes skin irritation. Causes serious eye irritation Label elements Label elements: Hazard statements: Hazard pictograms: H315: Causes skin irritation. H319: Causes serious eye irritation. GHS07: Exclamation mark Signal words: Precautionary statements: Warning P264: Wash hands thoroughly after handling. P280: Wear protective gloves/protective clothing/eye protection/face protection.

2 P : IF ON SKIN: Wash with plenty of water/. P : IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing. P321: Specific treatment (see instructions on this label). P : If skin irritation occurs: Get medical advice/attention. Page: Other hazards PBT: This product is not identified as a PBT/vPvB substance. Section 3: Composition/information on ingredients 3.2. Mixtures MINERAL OIL (NOTE L <3% DMSO EXTRACTABLE COMPONENTS) EINECS CAS PBT / WEL CLP Classification Percent Substance with a Community workplace exposure limit. FATTY ACID ALKANOLAMIDE % Skin Irrit. 2: H315; Eye Irrit. 2: H % ALCOHOLS C16-C18, C18-UNSATURATED, ETHOXYLATED (<2,5 EO) Skin Irrit. 2: H315; Aquatic Chronic 3: H % BORIC ACID COMPOUND WITH 2,2'-IMINODIETHANOL Skin Irrit. 2: H315; Eye Irrit. 2: H % Section 4: First aid measures 4.1. Description of first aid measures Skin contact: Eye contact: Ingestion: Inhalation: Wash immediately with plenty of soap and water. Bathe the eye with running water for 15 minutes. Consult a doctor. Wash out mouth with water. Remove casualty from exposure ensuring one's own safety whilst doing so Most important symptoms and effects, both acute and delayed Skin contact: Eye contact: Ingestion: Inhalation: There may be mild irritation at the site of contact. There may be irritation and redness. There may be irritation of the throat. There may be coughing and a sore throat Indication of any immediate medical attention and special treatment needed

3 Page: 3 Section 5: Fire-fighting measures 5.1. Extinguishing media Extinguishing media: Use water spray to cool containers. Suitable extinguishing media for the surrounding fire should be used Special hazards arising from the substance or mixture Exposure hazards: In combustion emits toxic fumes of carbon dioxide / carbon monoxide Advice for fire-fighters Advice for fire-fighters: Wear self-contained breathing apparatus. Wear protective clothing to prevent contact with skin and eyes. Section 6: Accidental release measures 6.1. Personal precautions, protective equipment and emergency procedures Personal precautions: Refer to section 8 of SDS for personal protection details Environmental precautions Environmental precautions: Do not discharge into drains or rivers Methods and material for containment and cleaning up Clean-up procedures: Transfer to a closable, labelled salvage container for disposal by an appropriate method Reference to other sections Section 7: Handling and storage 7.1. Precautions for safe handling Handling requirements: Avoid direct contact with the substance Conditions for safe storage, including any incompatibilities Storage conditions: Suitable packaging: Store in a cool, well ventilated area. Must only be kept in original packaging Specific end use(s) Section 8: Exposure controls/personal protection 8.1. Control parameters

4 Page: 4 MINERAL OIL (NOTE L <3% DMSO EXTRACTABLE COMPONENTS) Workplace exposure limits: Respirable dust State 8 hour TWA 15 min. STEL 8 hour TWA 15 min. STEL UK 5mg/m3 10mg/m3 - - DNEL/PNEC Values DNEL / PNEC No data available Exposure controls Engineering measures: Respiratory protection: Hand protection: Eye protection: Skin protection: Environmental: Ensure there is sufficient ventilation of the area. Respiratory protection not normally required. Gloves (oil-resistant). Nitrile gloves. Safety glasses with side-shields. Protective clothing. No special requirement. Section 9: Physical and chemical properties 9.1. Information on basic physical and chemical properties State: Liquid Colour: Yellow-brown Odour: Characteristic odour Evaporation rate: Negligible Oxidising: Non-oxidising (by EC criteria) Solubility in water: Soluble Viscosity: Viscous Boiling point/range C: 100 Flash point C: > 100 Autoflammability C: > 200 Relative density: Other information Other information: No data available. Section 10: Stability and reactivity Reactivity Reactivity: Stable under recommended transport or storage conditions Chemical stability Chemical stability: Stable under normal conditions Possibility of hazardous reactions Hazardous reactions: Hazardous reactions will not occur under normal transport or storage conditions.

5 Page: Conditions to avoid Conditions to avoid: Heat Incompatible materials Materials to avoid: Strong oxidising agents. Strong reducing agents Hazardous decomposition products Haz. decomp. products: In combustion emits toxic fumes of carbon dioxide / carbon monoxide. Section 11: Toxicological information Information on toxicological effects MINERAL OIL (NOTE L <3% DMSO EXTRACTABLE COMPONENTS) DERMAL RBT LD50 >5000 mg/kg ORAL RAT LD50 >5000 mg/kg FATTY ACID ALKANOLAMIDE DERMAL RBT LD50 > 2000 mg/kg ORAL RAT LD50 > 2000 mg/kg ALCOHOLS C16-C18, C18-UNSATURATED, ETHOXYLATED (<2,5 EO) ORAL RAT LD50 > 2000 mg/kg Relevant hazards for product: Hazard Route Basis Skin corrosion/irritation DRM Hazardous: calculated Serious eye damage/irritation OPT Hazardous: calculated Symptoms / routes of exposure Skin contact: Eye contact: Ingestion: Inhalation: There may be mild irritation at the site of contact. There may be irritation and redness. There may be irritation of the throat. There may be coughing and a sore throat. Section 12: Ecological information Toxicity

6 Page: 6 ALCOHOLS C16-C18, C18-UNSATURATED, ETHOXYLATED (<2,5 EO) FISH 96H LC mg/l Persistence and degradability Persistence and degradability: Only slightly biodegradable Bioaccumulative potential Bioaccumulative potential: No bioaccumulation potential Mobility in soil Mobility: Non-volatile. Absorbed only slowly into soil Results of PBT and vpvb assessment PBT identification: This product is not identified as a PBT/vPvB substance Other adverse effects Section 13: Disposal considerations Waste treatment methods Disposal of packaging: NB: Dispose of in a regulated landfill site or other method for hazardous or toxic wastes. The user's attention is drawn to the possible existence of regional or national regulations regarding disposal. Section 14: Transport information Transport class: This product does not require a classification for transport. Section 15: Regulatory information Safety, health and environmental regulations/legislation specific for the substance or mixture Chemical Safety Assessment Section 16: Other information Other information Other information: Phrases used in s.2 and s.3: Legal disclaimer: This safety data sheet is prepared in accordance with Commission Regulation (EU) No 2015/830. H315: Causes skin irritation. H319: Causes serious eye irritation. H412: Harmful to aquatic life with long lasting effects. The above information is believed to be correct but does not purport to be all inclusive and shall be used only as a guide. This company shall not be held liable for any damage resulting from handling or from contact with the above product. [final page]

7