1. Identification of the substance/mixture and of the company/undertaking

Transcription

1 according to 1907/2006/EC, Article 31, amended by Regulation (EU) No. 453/2010 SQUALANE Date: 22/08/ Identification of the substance/mixture and of the company/undertaking 1.1 Product Identifier Trade Name: Squalane INCI: Squalane Biological Definition: Squalane derived from the unsaponifiable fraction of Olive oil. Reach Registration Number: - FEMA No.: FDA No.: CoE No.: - CAS-No.: EC No.: - EINECS No.: Relevant identified uses of the substance or mixture and uses advised against Identified Uses: No additional data available. 1.3 Details of the supplier of the safety data sheet Aromantic Ltd 17 Tytler Street Forres Moray IV36 1EL Tel: Fax: info@aromantic.co.uk 1.4 Emergency telephone number Health and Safety Executive (HSE) Chemicals Regulation Directorate 5S.1 Redgrave Court, Merton Road, Bootle, Merseyside. L20 7HS Telephone: biocidesenquiries@hse.gsi.gov.uk REACH and CLP UK CA Help Desk, Health and Safety Executive 1

2 2.3 Redgrave Court, Merton Road, L20 7HS Bootle, Merseyside 2. Hazards Identification 2.1 Classification of the substance or mixture Classification (1999/45): Not dangerous according to REACH Regulation 1907/2006. Classification (EC 1272/2008): The product does not belong to any list of substances supposedly hazardous to human or animal health according to EU Regulation 1272/2008 and further amendments, nor to those having recognised exposition limits. Care should be taken when handling hot oil as it may constitute a burn hazard. Spills constitute a slippage hazard. 2.2 Label elements Label Elements in accordance with (EC) No 1272/2008: None. 2.3 Other hazards Signal Word: None. Contains: No hazardous substances. Hazard Statements: None. Precautionary Statements: None. Supplementary Precautionary Statements: None. PBT or vpvb according to Annex XIII: No. Adverse physio-chemical properties: None. Adverse effects on human health: None. 3. Composition/Information on ingredients 3.1 Substances Substances: N/A 3.2 Mixtures Mixtures: N/A 4. First Aid Measures 4.1 Description of first aid measures General Advice: Remove contaminated soaked clothing immediately. Inhalation: Move affected person to fresh air. Get medical attention if any discomfort continues. Ingestion: No special measures required. If necessary get medical attention. Skin Contact: After contact with skin, wash immediately with plenty of soap and water while removing soaked clothes. Eye Contact: Rinse immediately with plenty of water. Remove any contact lenses and open eyelids, continue to rinse for at least 15 minutes. Get medical attention if any discomfort continues. 2

3 4.2 Most important symptoms and effects, both acute and delayed Symptoms and effects: N/A 4.3 Indication of any immediate medical attention and special treatment needed Special requirements: N/A 5. Fire Fighting Measures 5.1 Extinguishing media Suitable extinguishing Media: Foam, Carbon dioxide or dry chemical powder or appropriate foam. Unsuitable extinguishing Media-DO NOT USE: No additional data available. 5.2 Special hazards arising from the substance or mixture Specific hazards: Emits toxic fumes under fire conditions. 5.3 Advice for firefighters Special firefighting procedures/ protective actions: High temperatures can lead to high pressures inside closed containers. Avoid inhalation of vapours that are created. Use appropriate respiratory protection. Do not allow spillage of extinguish fire will be poured into drains or watercourses. 6. Accidental Release Measures 6.1 Personal precautions, protective equipment and emergency procedures Personal precautions: Eliminate sources of ignition and ventilate the area. Avoid inhalation of vapours; use an appropriate respirator. 6.2 Environmental precautions Environmental Precautions: Keep spills out of municipal sewers and open bodies of water. 6.3 Methods and material for containment and cleaning up Spill Clean Up Methods: Contain and absorb spill with inert inorganic non-combustible, material, such as sand or earth, and remove it to a container for disposal according to local regulations. Clean the surface thoroughly to remove residual contamination. Avoid open flames or sources of ignition (e.g. pilot lights on gas hot water heater). Ventilate area and wash spill site after material pickup is complete. Dispose of in accordance with current laws and regulations. 6.4 Reference to other sections Reference to other sections: Section 8 Exposure controls/ personal protection for further information on personal precautions. Section 13 Disposal considerations for further information on waste treatment. 7. Handling and Storage 7.1 Precautions for safe handling 3

4 Usage precautions: The usual precautions for handling chemicals should be observed. 7.2 Conditions for safe storage, including any incompatibilities Storage Precautions: Keep material away from sources of ignition (e.g. hot surfaces, sparks, flame and static discharges. Store in hermetic recipients, preferably full, in a cool, dry, ventilated area away from sources of heat and direct sunlight. Keep away from the sources of ignition. Keep away from incompatible materials (see section 10). Prevent access to unauthorized persons. Suitable Packaging: No additional data available. 7.3 Specific end use(s) End Uses: No additional data available. 8. Exposure Controls/Personal Protection 8.1 Control parameters Protective Equipment: Components with workplace control parameters: Declaration of substances is not required. 8.2 Exposure controls Engineering Measures: In the case of brief exposure, use a device filter. Respiratory Equipment: In case of insufficient ventilation, use suitable respiratory equipment. Hand Protection: Compatible Chemical-resistant, gloves are recommended. Wash contaminated gloves before re-use. Eye Protection: Chemical safety goggles are recommended. Wash contaminated goggles before reuse. Wear eye shields and protective clothing. Other Protection: No additional data available. Hygiene Measures: No specific hygiene procedures recommended but good personal hygiene practices should always be observed when working with chemical products. Personal protection: No additional data available. Skin protection: No additional data available. Environmental exposure controls: No additional data available. 9. Physical and Chemical Properties 9.1 Information on basic physical and chemical properties Appearance: Clear Oil. Colour: Colourless. Odour: Odourless. Relative Density: gr/cm3 at 20 C Flash Point ( C): >200 Refractive Index: Melting Point ( C): No additional data available. 4

5 Boiling Point ( C): >150 Vapour Pressure: No additional data available. Solubility in C: Insoluble. Auto-ignition temperature ( C): No additional data available. 9.2 Other information ph: Stability and Reactivity 10.1 Reactivity Reactivity: Stable under the recommended handling and storage conditions Unstable at high temperatures Chemical stability Stability: Chemically stable under the recommended handling and storage conditions. Unstable at high temperatures Possibility of hazardous reactions Possible hazardous reactions: At high temperatures, acrolein may be produced Conditions to avoid Conditions to Avoid: Avoid excessive heat, flames and other sources of ignition, high temperatures and strong oxidising agents Incompatible materials Incompatible materials: Strong oxidising agents Hazardous decomposition products Hazardous Decomposition Products: During combustion carbon monoxide and unidentified organic compounds may be formed. 11. Toxicological Information 11.1 Information on toxicological effects Acute Toxicity: No additional data available. Skin corrosion / irritation: No additional data available. Serious eye damage / irritation: No additional data available. Respiratory or skin sensitisation: No additional data available. Ingestion: No additional data available. Germ Cell Mutagenicity: No additional data available. Carcinogenicity: No additional data available. Reproductive toxicity: No additional data available. STOT-single exposure: No additional data available. STOT-repeated exposure: No additional data available. Aspiration hazard: No additional data available. Photo-toxicity: No additional data available. Other Information: No additional data available. 5

6 12. Ecological Information 12.1 Toxicity Ecotoxicity: No additional data available Persistence and degradability Persistence & degradability: Biodegradable Bioaccumulative potential Bioaccumulative Potential: No additional data available Mobility in soil Mobility: No additional data available Results of PBT and vpvb assessment PBT Assessment Results: No additional data available Other adverse effects Precautions: Do not allow to get into waste water or waterways. 13. Disposal Considerations 13.1 Waste treatment methods Disposal Methods: When possible recover spilled product. When product must be discarded, do so into an authorised dump or recycling service station. Act in accordance with local and national regulations. 14. Transport Information Warning Icon: Road (ADR), Rail (RID), Sea (IMDG) and Air (ICAO) transport not restricted in drums or food tanks UN number UN No Road ADR/RID: None. UN No Sea- IMDG: None. UN No Air IATA: None UN proper shipping name Road ADR/RID: None. Sea- IMDG: None. Air IATA: None Transport hazard class(es) Road ADR/RID: None. Sea- IMDG: None. Air- IATA: None Packing group Road ADR/RID: None. Sea- IMDG: None. Air IATA: None. 6

7 14.5 Environmental hazards Environmentally hazardous substance/ marine pollutant: No additional data available Special precautions for user Precautions: None Transport in bulk according to Annex II of MARPOL73/78 and the IBC Code Hazchem code: None. 15. Regulatory Information 15.1 Safety, health and environmental regulations/legislation specific for the substance or mixture EU Directives: Commission Regulation (EU) No 453/2010 of 20 May 2010 amending Regulation (EC) No 1907/2006 of the European Parliament and of the Council of 18th Dec 2006 Concerning the Registration, Evaluation, Authorisation and Restriction of Chemicals (REACH), establishing a European Chemicals Agency, amending Directive 199/45/EC and repealing Council Regulation Council Regulation (EEC) No793/93 and Commission Regulation (EC) No1488/94 as well as Council Directive 76/769/EEC and Commission Directives 91/155/EEC, 93/67/EEC, and 93/105/EEC and 2000/21/EC including amendments. Statutory Instruments: The Chemicals (Hazard Information and Packaging for Supply Regulations 2009 (S.I No 716). Approved Code of Practice: Classification and Labelling of Substances and Preparations Dangerous for Supply. s for Substances and Preparations Guidance Notes: Workplace Exposure Limits EH40. CHIP for everyone HSG Chemical safety assessment Assessment information: An assessment has not been executed as this is not a hazardous material according to article 31 of REACH 1907/ Other Information Risk Phrases in Full: None. Hazard Statements in Full: None. Other Information: None. This information is based on our present knowledge. However, this shall not constitute a guarantee for any specific product features and shall not establish a legally valid contractual relationship. The information contained in this SDS is accurate to the best of our knowledge and has been obtained from a variety of sources. No liability can be accepted arising out of the use, application or processing of this product. It is the users responsibility to determine the safe conditions for the use of this product. Revision Date: Version: 4 7