SAFETY DATA SHEET SILVER POWER. Section: 1. PRODUCT AND COMPANY IDENTIFICATION. Product name : SILVER POWER

Transcription

1 Section: 1. PRODUCT AND COMPANY IDENTIFICATION Product name : Other means of identification : Not applicable. Recommended use : Presoak Restrictions on use : Reserved for industrial and professional use. Product dilution information :.15 % -.5 % Company : Ecolab Co. 515 Tomken Road Mississauga, Ontario Canada L4W 2X Emergency health information : (US/Canada), (outside US) Issuing date : 3/17/216 Section: 2. HAZARDS IDENTIFICATION GHS Classification Skin irritation : Category 2 Eye irritation : Category 2A Not a hazardous substance or mixture. GHS Label element Hazard pictograms : Signal Word Hazard Statements Precautionary Statements Precautionary Statements : Warning : Causes skin irritation. Causes serious eye irritation. : Prevention: Wash skin thoroughly after handling. Wear protective gloves/ eye protection/ face protection. Response: IF ON SKIN: Wash with plenty of water. IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing. If skin irritation occurs: Get medical advice/attention. If eye irritation persists: Get medical advice/ attention. Take off contaminated clothing and wash it before reuse. : Prevention: / 1

2 Wash hands thoroughly after handling. Response: Get medical advice/ attention if you feel unwell. Storage: Store in accordance with local regulations. Other hazards : None known. Section: 3. COMPOSITION/INFORMATION ON INGREDIENTS Pure substance/mixture : Mixture Chemical Name CAS-No. Concentration: (%) Sodium Carbonate(soda) alcohols, c12-16, ethoxylated sodium isononanoate sodium hydroxide ethylenediamine tetraacetate No hazardous ingredients Section: 4. FIRST AID MEASURES In case of eye contact In case of skin contact If swallowed If inhaled Protection of first-aiders Notes to physician Most important symptoms and effects, both acute and delayed In case of eye contact In case of skin contact If swallowed If inhaled : Rinse immediately with plenty of water, also under the eyelids, for at least 15 minutes. Remove contact lenses, if present and easy to do. Continue rinsing. Get medical attention. : Wash off immediately with plenty of water for at least 15 minutes. Use a mild soap if available. Get medical attention if irritation develops and persists. : Rinse mouth. Get medical attention if symptoms occur. : Get medical attention if symptoms occur. : If potential for exposure exists refer to Section 8 for specific personal protective equipment. : Treat symptomatically. : See Section 11 for more detailed information on health effects and symptoms. : Rinse with plenty of water. : Rinse with plenty of water. : Rinse mouth. Get medical attention if symptoms occur. : Get medical attention if symptoms occur / 1

3 Section: 5. FIREFIGHTING MEASURES Suitable extinguishing media Unsuitable extinguishing media Specific hazards during firefighting Hazardous combustion products Special protective equipment for firefighters Specific extinguishing methods Risk of explosion. : Use extinguishing measures that are appropriate to local circumstances and the surrounding environment. : None known. : Not flammable or combustible. : Decomposition products may include the following materials: Carbon oxides nitrogen oxides (NOx) Sulphur oxides Oxides of phosphorus : Use personal protective equipment. : Fire residues and contaminated fire extinguishing water must be disposed of in accordance with local regulations. In the event of fire and/or explosion do not breathe fumes. : Not available. Section: 6. ACCIDENTAL RELEASE MEASURES Personal precautions, protective equipment and emergency procedures Environmental precautions Methods and materials for containment and cleaning up Personal precautions, protective equipment and emergency procedures Environmental precautions Methods and materials for containment and cleaning up : Ensure clean-up is conducted by trained personnel only. Refer to protective measures listed in sections 7 and 8. : Do not allow contact with soil, surface or ground water. : Sweep up and shovel into suitable containers for disposal. : Refer to protective measures listed in sections 7 and 8. : No special environmental precautions required. : Stop leak if safe to do so. Contain spillage, and then collect with noncombustible absorbent material, (e.g. sand, earth, diatomaceous earth, vermiculite) and place in container for disposal according to local / national regulations (see section 13). Flush away traces with water. For large spills, dike spilled material or otherwise contain material to ensure runoff does not reach a waterway. Section: 7. HANDLING AND STORAGE Advice on safe handling : Avoid contact with skin and eyes. Wash hands thoroughly after handling / 1

4 Conditions for safe storage : Keep out of reach of children. Store in suitable labeled containers. Storage temperature : C to 4 C Advice on safe handling : Wash hands after handling. For personal protection see section 8. Conditions for safe storage : Keep out of reach of children. Store in suitable labeled containers. Section: 8. EXPOSURE CONTROLS/PERSONAL PROTECTION Components with workplace control parameters Components CAS-No. Form of exposure Permissible concentration Basis sodium hydroxide (c) 2 mg/m3 CAD AB OEL C 2 mg/m3 CAD BC OEL C 2 mg/m3 OEL (QUE) sodium hydroxide Ceiling 2 mg/m3 ACGIH Ceiling 2 mg/m3 NIOSH REL TWA 2 mg/m3 OSHA Z1 Engineering measures : Good general ventilation should be sufficient to control worker exposure to airborne contaminants. Personal protective equipment Eye protection Hand protection Skin protection Respiratory protection Hygiene measures Engineering measures : Due to the form and packaging of the product, no protective equipment is needed under normal use conditions. : Due to the form and packaging of the product, no protective equipment is needed under normal use conditions. : No special protective equipment required. : No personal respiratory protective equipment normally required. : Handle in accordance with good industrial hygiene and safety practice. Wash face, hands and any exposed skin thoroughly after handling. : Good general ventilation should be sufficient to control worker exposure to airborne contaminants. Personal protective equipment Eye protection Hand protection Skin protection Respiratory protection : No special protective equipment required. : No special protective equipment required. : No special protective equipment required. : No personal respiratory protective equipment normally required / 1

5 Section: 9. PHYSICAL AND CHEMICAL PROPERTIES Appearance : Cast Solid liquid Colour : opaque, dark blue light blue Odour : citrus citrus ph : , 1 % Flash point Odour Threshold Melting point/freezing point Initial boiling point and boiling range Evaporation rate Flammability (solid, gas) Upper explosion limit Lower explosion limit Vapour pressure Relative vapour density Relative density : 1.3 Water solubility Solubility in other solvents Partition coefficient: n- octanol/water Auto-ignition temperature Thermal decomposition Viscosity, kinematic Explosive properties Oxidizing properties Molecular weight VOC : Not applicable., Does not sustain combustion. : soluble Section: 1. STABILITY AND REACTIVITY Chemical stability Possibility of hazardous reactions Conditions to avoid Incompatible materials Hazardous decomposition products : Stable under normal conditions. : No dangerous reaction known under conditions of normal use. : None known. : Acids : Decomposition products may include the following materials: Carbon oxides nitrogen oxides (NOx) / 1

6 Sulphur oxides Oxides of phosphorus Section: 11. TOXICOLOGICAL INFORMATION Information on likely routes of exposure : Eye contact, Skin contact Potential Health Effects Eyes Skin Ingestion Inhalation Chronic Exposure Eyes Skin Ingestion Inhalation Chronic Exposure : Causes serious eye irritation. : Causes skin irritation. Experience with human exposure Eye contact Skin contact Ingestion Inhalation Eye contact Skin contact Ingestion Inhalation : Redness, Pain, Irritation : Redness, Irritation Toxicity Product Acute oral toxicity Acute inhalation toxicity : Acute toxicity estimate : 4,225 mg/kg / 1

7 Acute dermal toxicity Skin corrosion/irritation Serious eye damage/eye irritation Respiratory or skin sensitization Carcinogenicity Reproductive effects Germ cell mutagenicity Teratogenicity STOT - single exposure STOT - repeated exposure Aspiration toxicity : Acute toxicity estimate : > 5, mg/kg Section: 12. ECOLOGICAL INFORMATION Ecotoxicity Environmental Effects Product Toxicity to fish Toxicity to daphnia and other aquatic invertebrates Toxicity to algae Components Toxicity to daphnia and other aquatic invertebrates : Harmful to aquatic life. : 96 h LC5: 41 mg/l : Sodium Carbonate(soda) 48 h EC5 Ceriodaphnia (water flea): mg/l sodium hydroxide 48 h EC5: 4 mg/l ethylenediamine tetraacetate 48 h EC5 Daphnia: > 5 mg/l Persistence and degradability no data available Bioaccumulative potential no data available Mobility in soil no data available Other adverse effects no data available Section: 13. DISPOSAL CONSIDERATIONS / 1

8 Disposal methods Disposal considerations Disposal methods Disposal considerations : Do not contaminate ponds, waterways or ditches with chemical or used container. Where possible recycling is preferred to disposal or incineration. If recycling is not practicable, dispose of in compliance with local regulations. Dispose of wastes in an approved waste disposal facility. : Dispose of as unused product. Empty containers should be taken to an approved waste handling site for recycling or disposal. Do not reuse empty containers. Dispose of in accordance with local, state, and federal regulations. : Do not contaminate ponds, waterways or ditches with chemical or used container. Where possible recycling is preferred to disposal or incineration. If recycling is not practicable, dispose of in compliance with local regulations. Dispose of wastes in an approved waste disposal facility. : Dispose of as unused product. Empty containers should be taken to an approved waste handling site for recycling or disposal. Do not reuse empty containers. Dispose of in accordance with local, state, and federal regulations. Section: 14. TRANSPORT INFORMATION The shipper/consignor/sender is responsible to ensure that the packaging, labeling, and markings are in compliance with the selected mode of transport. Land transport (TDG) Not dangerous goods Sea transport (IMDG/IMO) Not dangerous goods Section: 15. REGULATORY INFORMATION This product has been classified according to the hazard criteria of the HPR and the SDS contains all of the information required by the HPR. NPRI Components : Pigment / Colorant Nitrilotriaceticacid[NTA] Salt The components of this product are reported in the following inventories: United States TSCA Inventory : On TSCA Inventory Canadian Domestic Substances List (DSL) : This product contains one or several components listed in the Canadian NDSL. Australia. Industrial Chemical (Notification and Assessment) Act : New Zealand. Inventory of Chemicals (NZIoC), as published by ERMA New Zealand : / 1

9 Health Health Instability Instability SAFETY DATA SHEET Japan. ENCS - Existing and New Chemical Substances Inventory : On the inventory, or in compliance with the inventory Japan. ISHL - Inventory of Chemical Substances (METI) : Korea. Korean Existing Chemicals Inventory (KECI) : Philippines Inventory of Chemicals and Chemical Substances (PICCS) : China Inventory of Existing Chemical Substances : Section: 16. OTHER INFORMATION NFPA: Flammability HMIS III: HEALTH 2 2 FLAMMABILITY PHYSICAL HAZARD Special hazard. = not significant, 1 =Slight, 2 = Moderate, 3 = High 4 = Extreme, * = Chronic NFPA: Flammability HMIS III: HEALTH FLAMMABILITY PHYSICAL HAZARD Special hazard. = not significant, 1 =Slight, 2 = Moderate, 3 = High 4 = Extreme, * = Chronic Issuing date : 3/17/216 version : 1.1 Prepared by : Regulatory Affairs / 1

10 REVISED INFORMATION: Significant changes to regulatory or health information for this revision is indicated by a bar in the left-hand margin of the SDS. The information provided in this Safety Data Sheet is correct to the best of our knowledge, information and belief at the date of its publication. The information given is designed only as a guidance for safe handling, use, processing, storage, transportation, disposal and release and is not to be considered a warranty or quality specification. The information relates only to the specific material designated and may not be valid for such material used in combination with any other materials or in any process, unless specified in the text / 1