Section 1. Identification of the substance/mixture and of the company/undertaking Rogers Action Cleaning Gel. No information available

Transcription

1 SAFETY DATA SHEET Issuing Date 14-Apr-2014 Revision Number 0 Section 1. Identification of the substance/mixture and of the company/undertaking 1.1. Product identifier Product Code(s) Product Name Contains Triethanolamine Rogers Action Cleaning Gel 1.2. Relevant identified uses of the substance or mixture and uses advised against Recommended Use Gun Cleaning Uses advised against 1.3. Details of the supplier of the safety data sheet Company Manufactured by: Radiator Specialty Company 600 Radiator Road Indian Trail, NC TEL: For further information, please contact Address 1.4. Emergency telephone number Emergency Telephone RMPDC: Number Europe Classification of the substance or mixture Section 2. Hazards identification REGULATION (EC) No 1272/2008 Skin Corrosion/Irritation Category 2 Serious Eye Damage/Eye Irritation Category 2 Physical Hazards None Supplier The Safariland Group Attn: Tim Sparks International Parkway Jacksonville, FL TEL: FAX: Classification according to EU Directives 67/548/EEC or 1999/45/EC For the full text of the R-phrases mentioned in this Section, see Section 16 The preparation is classified as dangerous in accordance with Directive 1999/45/EC. Symbol(s) R-code(s) Xi - Irritant Xi;R36/ Label Elements Page 1 / 8

2 Signal Word Warning Hazard Statements H315 - Causes skin irritation H319 - Causes serious eye irritation EUH210 - Safety data sheet available on request Precautionary Statements P302 + P352 - IF ON SKIN: Wash with plenty of soap and water P332 + P313 - If skin irritation occurs: Get medical advice/ attention P362 - Take off contaminated clothing and wash before reuse P264 - Wash face, hands and any exposed skin thoroughly after handling P280 - Wear protective gloves/ protective clothing/ eye protection/ face protection P305 + P351 + P338 - IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing P337 + P313 - If eye irritation persists: Get medical advice/ attention 2.3. Other information 3.1. Substances Not applicable 3.2. Mixtures Section 3. Composition/information on ingredients Chemical Name EC-No CAS-No Weight % Classification EU - GHS REACH No. Substance Classification Diethylene glycol Xi; R36 Eye Irrit. 2 (H319) monobutyl ether -XXXX For the full text of the R-phrases mentioned in this Section, see Section 16 For the full text of the H-Statements mentioned in this Section, see Section of first-aid measures Section 4. First aid measures Eye Contact Skin Contact Ingestion Inhalation Protection of First-aiders Rinse immediately with plenty of water, also under the eyelids, for at least 15 minutes. Get medical attention if irritation persists. Wash off immediately with soap and plenty of water. Get medical attention if irritation persists. Clean mouth with water and afterwards drink plenty of water. Move to fresh air. Use personal protective equipment. Avoid contact with skin, eyes and clothing Most important symptoms and effects, both acute and delayed Most Important Symptoms/Effects Irritation Indication of immediate medical attention and special treatment needed Page 2 / 8

3 Notes to Physician Treat symptomatically Extinguishing media Section 5. Fire-fighting measures Suitable Extinguishing Media Use extinguishing measures that are appropriate to local circumstances and the surrounding environment. Extinguishing media which must not be used for safety reasons None 5.2. Special hazards arising from the substance or mixture Special exposure hazards arising from the substance or preparation itself, combustion products, resulting gases None in particular Advice for firefighters Special protective equipment for fire-fighters As in any fire, wear self-contained breathing apparatus and full protective gear. Section 6. Accidental release measures 6.1. Personal precautions, protective equipment and emergency procedures Use personal protective equipment. Avoid contact with the skin and the eyes. Wash thoroughly after handling Environmental precautions Prevent entry into waterways, sewers, basements or confined areas. Do not flush into surface water or sanitary sewer system Methods and materials for containment and cleaning up Dike far ahead of liquid spill for later disposal. Soak up with inert absorbent material (e.g. sand, silica gel, acid binder, universal binder, sawdust). Sweep up and shovel into suitable containers for disposal Reference to other sections See Section 12 for additional information. Section 7. Handling and storage 7.1. Precautions for Safe Handling Handling Ensure adequate ventilation. Wear personal protective equipment. Avoid contact with skin, eyes and clothing. Wash thoroughly after handling. Hygiene Measures When using, do not eat, drink or smoke. Provide regular cleaning of equipment, work area and clothing Conditions for safe storage, including any incompatibilities Keep containers tightly closed in a cool, well-ventilated place. Keep out of the reach of children. Keep in properly labeled containers Specific end use(s) Exposure Scenario Page 3 / 8

4 Other Guidelines 8.1. Control parameters Exposure Limits Section 8. Exposure controls/personal protection Chemical Name Diethylene glycol monobutyl ether EU The United Kingdom France Spain Germany STEL: 15 ppm STEL: 15 ppm STEL: mg/m 3 TWA: 67.5 mg/m 3 STEL: mg/m 3 STEL: 15 ppm TWA: 67.5 mg/m 3 STEL: mg/m 3 TWA: 67.5 mg/m 3 TWA 10 ppm TWA 67.5 mg/m 3 STEL 15 ppm STEL mg/m 3 TWA: 67 mg/m 3 Ceiling / Peak: 15 ppm Ceiling / Peak: mg/m 3 Chemical Name Diethylene glycol monobutyl ether Italy TWA: 67.5 mg/m 3 STEL: 15 ppm STEL: mg/m 3 Chemical Name Austria Switzerland Diethylene glycol monobutyl ether STEL 15 ppm STEL mg/m 3 TWA: 67.5 mg/m 3 Portugal STEL: 15 ppm STEL: mg/m 3 TWA: 67 mg/m 3 The Netherlands Skin STEL: 100 mg/m 3 TWA: 50 mg/m 3 Poland STEL: 100 mg/m 3 TWA: 67 mg/m 3 Finland TWA: 68 mg/m 3 Norway TWA: 68 mg/m 3 STEL: 20 ppm STEL: 102 mg/m 3 Denmark TWA: 68 mg/m 3 Ireland TWA: 67.5 mg/m 3 STEL: 15 ppm STEL: mg/m 3 Derived No Effect Level Predicted No Effect Concentration (PNEC) 8.2. Exposure controls Engineering Measures Personal protective equipment Eye Protection Skin and Body Protection Hand Protection Respiratory Protection Environmental Exposure Controls Ensure adequate ventilation, especially in confined areas. Tightly fitting safety goggles. Wear protective gloves/clothing Protective gloves. When workers are facing concentrations above the exposure limit they must use appropriate certified respirators. Do not allow material to contaminate ground water system Information on basic physical and chemical properties Section 9. Physical and chemical properties Physical State Odor Liquid. Ether. Appearance Colorless Property Values ph Melting Point/Range Not applicable Boiling Point/Boiling Range 100 C / 212 F Flash Point 94 C / F Evaporation rate Flammability (solid, gas) Remarks/ - Method Page 4 / 8

5 Vapor Pressure Vapor Density Relative Density 0.96 Water Solubility Completely soluble Solubility in other solvents Partition coefficient: n-octanol/water Autoignition Temperature Decomposition Temperature Viscosity Explosive Properties Oxidizing Properties 9.2. Other information VOC Content (%) 36 Flammability Limits in Air Reactivity Chemical stability Stable under normal conditions Possibility of hazardous reactions None under normal processing Conditions to avoid High temperatures Incompatible materials Strong oxidizing agents. Acids. Bases Hazardous decomposition products Carbon oxides. Nitrogen oxides (NOx) Section 10. Stability and reactivity Section 11. Toxicological information Acute Toxicity Product Information Inhalation Eye Contact Skin Contact Ingestion Product does not present an acute toxicity hazard based on known or supplied information. None under normal use condtions Causes serious eye irritation. Causes skin irritation. None under normal use conditions. Component Information Chemical Name LD50 Oral LD50 Dermal LC50 Inhalation Triethanolamine = 4190 mg/kg ( Rat ) > 2000 mg/kg ( Rabbit ) > 16 ml/kg - ( Rat ) Diethylene glycol monobutyl ether = 3384 mg/kg ( Rat ) = 2700 mg/kg ( Rabbit ) Morpholine = 1050 mg/kg ( Rat ) = 310 mg/kg ( Rabbit ) Sensitization Mutagenic Effects Carcinogenic Effects Contains no ingredients above reportable quantities listed as a carcinogen. Page 5 / 8

6 Reproductive Toxicity Developmental Toxicity STOT - single exposure STOT - repeated exposure Target Organ Effects Aspiration Hazard Eyes. Skin. Section 12. Ecological information Toxicity Ecotoxicity Effects The environmental impact of this product has not been fully investigated. Chemical Name Diethylene glycol monobutyl ether Toxicity to Algae Toxicity to Fish Toxicity to Microorganisms EC50 96 h: > 100 mg/l (Desmodesmus subspicatus) LC50 96 h: = 1300 mg/l static (Lepomis macrochirus) Daphnia Magna (Water Flea) EC50 24 h: = 2850 mg/l (Daphnia magna) EC50 48 h: > 100 mg/l (Daphnia magna) Persistence and degradability Bioaccumulative potential Mobility in soil Adsorbs on soil Results of PBT and vpvb assessment Other adverse effects This product does not contain any known or suspected endocrine disruptors Waste treatment methods Section 13. Disposal considerations Waste from Residues / Unused Products Contaminated Packaging Other Information Dispose of in accordance with local regulations. Empty containers should be taken to an approved waste handling site for recycling or disposal. According to the European Waste Catalogue, Waste Codes are not product specific, but application specific. Waste codes should be assigned by the user based on the application for which the product was used. Page 6 / 8

7 Section 14. Transport information IMDG/IMO UN-Number Proper Shipping Name Hazard Class Packing Group Marine Pollutant Special Provisions Transport in bulk according to Annex II of MARPOL 73/78 and the IBC Code None. None. RID UN-Number Proper Shipping Name Hazard Class Packing Group Environmental hazard None Special Provisions None. ADR UN-Number Proper Shipping Name Hazard Class Packing Group Environmental hazard None Special Provisions None. ICAO UN-Number Proper shipping name Hazard Class Packing Group Environmental hazard None Special Provisions None. IATA UN-Number Proper Shipping Name Hazard Class Packing Group Environmental hazard None Special Provisions None. Section 15. Regulatory information Safety, health and environmental regulations/legislation specific for the substance or mixture International Inventories Page 7 / 8

8 TSCA EINECS/ELINCS DSL/NDSL PICCS ENCS IECSC AICS KECL Not determined Legend TSCA - United States Toxic Substances Control Act Section 8(b) Inventory EINECS/ELINCS - European Inventory of Existing Commercial Chemical Substances/EU List of Notified Chemical Substances DSL/NDSL - Canadian Domestic Substances List/Non-Domestic Substances List PICCS - Philippines Inventory of Chemicals and Chemical Substances ENCS - Japan Existing and New Chemical Substances IECSC - China Inventory of Existing Chemical Substances AICS - Australian Inventory of Chemical Substances KECL - Korean Existing and Evaluated Chemical Substances Chemical Safety Assessment Full text of R-phrases referred to under Sections 2 and 3 R36 - Irritating to eyes Key literature references and sources for data Section 16. Other information R20/21/22 - Harmful by inhalation, in contact with skin and if swallowed R36/38 - Irritating to eyes and skin Full text of H-Statements referred to under sections 2 and 3 H319 - Causes serious eye irritation Issuing Date Revision Date Revision Note 14-Apr Apr-2014 Initial Release. This safety data sheet complies with the requirements of Commission Regulation (EU) No 453/2010 of 20 May 2010 amending Regulation (EC) No. 1907/2006 General Disclaimer The information provided on this SDS is correct to the best of our knowledge, information and belief at the date of its publication. The information given is designed only as a guide for safe handling, use, processing, storage, transportation, disposal and release and is not to be considered as a warranty or quality specification. The information relates only to the specific material designated and may not be valid for such material used in combination with any other material or in any process, unless specified in the text. End of Safety Data Sheet Page 8 / 8