BZ7918 ZEP ORNG HAND CLN ZU /48OZ

Transcription

1 SECTION 1. PRODUCT AND COMPANY IDENTIFICATION Material name : Material number : Manufacturer or supplier's details Company : Zep Inc. Address : 1310 Seaboard Industrial Blvd., NW Atlanta, GA Telephone : Emergency telephone numbers For SDS Information : Compliance Services For a Medical Emergency : Toll Free - All Calls Recorded For a Transportation Emergency : CHEMTREC: All Calls Recorded. In the District of Columbia SECTION 2. HAZARDS IDENTIFICATION Emergency Overview Appearance Colour Odour viscous orange pleasant, characteristic GHS Classification Not a hazardous substance or mixture. GHS Label element Not a hazardous substance or mixture. Precautionary statements : Prevention: P264 Wash hands thoroughly after handling. Potential Health Effects Carcinogenicity: IARC ACGIH OSHA NTP No component of this product present at levels greater than or equal to 0.1% is identified as probable, possible or confirmed human carcinogen by IARC. No component of this product present at levels greater than or equal to 0.1% is identified as a carcinogen or potential carcinogen by ACGIH. No component of this product present at levels greater than or equal to 0.1% is identified as a carcinogen or potential carcinogen by OSHA. No component of this product present at levels greater than or equal to 0.1% is identified as a known or anticipated carcinogen 1 / 9

2 by NTP. SECTION 3. COMPOSITION/INFORMATION ON INGREDIENTS Substance / Mixture : Mixture Hazardous components Chemical Name CAS-No. Concentration [%] Alcohols, C12-16, ethoxylated >= 1 - < 5 Citrus, ext >= < 1 SECTION 4. FIRST AID MEASURES General advice If inhaled In case of skin contact In case of eye contact If swallowed : Move out of dangerous area. Show this safety data sheet to the doctor in attendance. Do not leave the victim unattended. : If unconscious place in recovery position and seek medical advice. If symptoms persist, call a physician. : This product is formulated for use on skin but should always be immediately washed off with plenty of water. Discontinue use if irritation and redness develop. If conditions persist for more than 72 hours, condult a physician. : Remove contact lenses. Protect unharmed eye. Keep eye wide open while rinsing. If eye irritation persists, consult a specialist. Rinse immediately with plenty of water for at least 15 minutes. : Keep respiratory tract clear. Never give anything by mouth to an unconscious person. If symptoms persist, call a physician. DO NOT induce vomiting unless directed to do so by a physician or poison control center. Take victim immediately to hospital. SECTION 5. FIREFIGHTING MEASURES Suitable extinguishing media Unsuitable extinguishing media Specific hazards during firefighting : Water spray jet Alcohol-resistant foam Carbon dioxide (CO2) Dry chemical : High volume water jet : Do not allow run-off from fire fighting to enter drains or water courses. 2 / 9

3 Hazardous combustion products Specific extinguishing methods Further information Special protective equipment for firefighters : Carbon dioxide (CO2) Carbon monoxide Smoke : Use extinguishing measures that are appropriate to local circumstances and the surrounding environment. : Collect contaminated fire extinguishing water separately. This must not be discharged into drains. Fire residues and contaminated fire extinguishing water must be disposed of in accordance with local regulations. : Wear self-contained breathing apparatus for firefighting if necessary. SECTION 6. ACCIDENTAL RELEASE MEASURES Personal precautions, protective equipment and emergency procedures Environmental precautions Methods and materials for containment and cleaning up : Material can create slippery conditions. Use non-slip safety shoes in areas where spills or leaks can occur. Refer to protective measures listed in sections 7 and 8. : Prevent product from entering drains. Prevent further leakage or spillage if safe to do so. If the product contaminates rivers and lakes or drains inform respective authorities. : Soak up with inert absorbent material (e.g. sand, silica gel, acid binder, universal binder, sawdust). Keep in suitable, closed containers for disposal. SECTION 7. HANDLING AND STORAGE Advice on safe handling Conditions for safe storage Materials to avoid : Avoid contact with eyes. For personal protection see section 8. Smoking, eating and drinking should be prohibited in the application area. Dispose of rinse water in accordance with local and national regulations. : Keep container tightly closed in a dry and well-ventilated place. Containers which are opened must be carefully resealed and kept upright to prevent leakage. : Oxidizing agents SECTION 8. EXPOSURE CONTROLS/PERSONAL PROTECTION Components with workplace control parameters Contains no substances with occupational exposure limit values. 3 / 9

4 Personal protective equipment Respiratory protection : In case of insufficient ventilation, wear suitable respiratory equipment. Hand protection Remarks Eye protection Skin and body protection Hygiene measures : No special protection is required. : Eye protection is not required while washing with this product. In the workplace, the use of safety glasses is recommended to avoid eye exposure during the handling of containers or during spill clean-up. : No special protection is required. : When using do not eat or drink. When using do not smoke. Wash hands before breaks and at the end of workday. SECTION 9. PHYSICAL AND CHEMICAL PROPERTIES Appearance : viscous Colour Odour Odour Threshold : orange : pleasant, characteristic : ph : Melting point/freezing point Boiling point Flash point : Evaporation rate Upper explosion limit Lower explosion limit Vapour pressure Relative vapour density Density Solubility(ies) Water solubility Partition coefficient: n- octanol/water Auto-ignition temperature Thermal decomposition Viscosity : : not applicable : : not applicable : not applicable : : : 1.02 g/cm3 : emulsifiable : : not determined : 4 / 9

5 Viscosity, kinematic : SECTION 10. STABILITY AND REACTIVITY Reactivity Chemical stability Possibility of hazardous reactions Conditions to avoid Incompatible materials Hazardous decomposition products : Stable : Stable under normal conditions. : No decomposition if stored and applied as directed. : : Oxidizing agents : Carbon oxides SECTION 11. TOXICOLOGICAL INFORMATION Acute toxicity Acute oral toxicity : Acute toxicity estimate : > 5,000 mg/kg Method: Calculation method Skin corrosion/irritation Result: No skin irritation Serious eye damage/eye irritation Result: No eye irritation Respiratory or skin sensitisation Germ cell mutagenicity Carcinogenicity Reproductive toxicity Alcohols, C12-16, ethoxylated: Citrus, ext.: STOT - single exposure 5 / 9

6 STOT - repeated exposure Aspiration toxicity Further information Remarks: SECTION 12. ECOLOGICAL INFORMATION Ecotoxicity Persistence and degradability Bioaccumulative potential Partition coefficient: n- octanol/water Mobility in soil Other adverse effects Regulation Remarks Additional ecological information : Remarks: 40 CFR Protection of Environment; Part 82 Protection of Stratospheric Ozone - CAA Section 602 Class I Substances This product neither contains, nor was manufactured with a Class I or Class II ODS as defined by the U.S. Clean Air Act Section 602 (40 CFR 82, Subpt. A, App.A + B). : An environmental hazard cannot be excluded in the event of unprofessional handling or disposal., Harmful to aquatic life. SECTION 13. DISPOSAL CONSIDERATIONS Disposal methods 6 / 9

7 Waste from residues Contaminated packaging : The product should not be allowed to enter drains, water courses or the soil. Do not contaminate ponds, waterways or ditches with chemical or used container. Dispose of in accordance with local regulations. : Empty remaining contents. Dispose of as unused product. Do not re-use empty containers. SECTION 14. TRANSPORT INFORMATION Transportation Regulation: 49 CFR (USA): Transportation Regulation: IMDG (Vessel): Transportation Regulation: IATA (Cargo Air): Transportation Regulation: IATA (Passenger Air): Transportation Regulation: TDG (Canada): SECTION 15. REGULATORY INFORMATION EPCRA - Emergency Planning and Community Right-to-Know Act CERCLA Reportable Quantity This material does not contain any components with a CERCLA RQ. SARA 304 Extremely Hazardous Substances Reportable Quantity This material does not contain any components with a section 304 EHS RQ. SARA 311/312 Hazards : Acute Health Hazard SARA 302 : SARA 302: No chemicals in this material are subject to the reporting requirements of SARA Title III, Section / 9

8 Health Instability SAFETY DATA SHEET SARA 313 : SARA 313: This material does not contain any chemical components with known CAS numbers that exceed the threshold (De Minimis) reporting levels established by SARA Title III, Section 313. California Prop 65 This product does not contain any chemicals known to State of California to cause cancer, birth defects, or any other reproductive harm. The components of this product are reported in the following inventories: TSCA DSL AICS NZIoC PICCS IECSC On TSCA Inventory This product contains one or several components that are not on the Canadian DSL nor NDSL. Not in compliance with the inventory Not in compliance with the inventory Not in compliance with the inventory Not in compliance with the inventory Inventory Acronym and Validity Area Legend: AICS (Australia), DSL (Canada), IECSC (China), REACH (European Union), ENCS (Japan), ISHL (Japan), KECI (Korea), NZIoC (New Zealand), PICCS (Philippines), TSCA (USA) SECTION 16. OTHER INFORMATION Further information NFPA: Flammability HMIS III: HEALTH FLAMMABILITY 1 0 PHYSICAL HAZARD 0 Special hazard. 0 = not significant, 1 =Slight, 2 = Moderate, 3 = High 4 = Extreme, * = Chronic OSHA GHS Label Information: Not a hazardous substance or mixture. Precautionary statements : Prevention: Wash hands thoroughly after handling. 8 / 9

9 We believe the statements, technical information and recommendations contained herein are reliable, but they are given without warranty or guarantee of any kind. The information in this document applies to this specific material as supplied. It may not be valid for this material if it is used in combination with any other materials. Users should make their own investigations to determine the suitability and applicability of the information for their particular purposes. This SDS has been prepared by the Compliance Services organization supporting this manufacturer, supplier or distributor. Zep Inc. markets products under well recognized and established brand names such as Zep, Zep Commercial,Zep Professional, Enforcer, National Chemical, Selig, Mis ty, Next Dimension, Petro, i-chem, TimeMist, TimeWick, MicrobeMax, Country Vet, Konk, Original Bike Spirits, Blue Coral, Black Magic, Rain-X, Niagara National, FC Forward Chemicals,Rexodan, Mykal, and a number of private labeled brands. 9 / 9