SAFETY DATA SHEET Simply Anti-Friction Additive

Transcription

1 Date: December 4, 2013 Version: 1.0 SECTION 1. IDENTIFICATION OF PRODUCT & COMPANY 1.1 Intended Use: AF1 1.2 Intended Use: Motor Oil 1.3 Company Identification: JRP Distribution Ltd., 11 & 12 (Units 1 & 2) Peter Road, Lancing Business Park, Lancing West Sussex BN15 8TH 1.4 Emergency Telephone +44(0) (Business hours) SECTION 2. HAZARDS IDENTIFICATION 2.1 Classification: Preparation non-hazardous Not hazardous by Annex I (Note L) of R. D. 363/ R-Phrases: This product is not classified in any of the categories of risk described in the European or State legislation. They do not require classification as carcinogenic if it can be shown that the substance contains less than 3% DMSO extract as measured by IP 346. This note applies only to certain complex coal-derived substances and oil - applies in Annex I. SECTION 3. COMPOSITION/INFORMATION ON INGREDIENTS 2.1 Classification: Mixture of substances listed below with non-hazardous addition. 2.2 Hazardous Components: CAS No. EINEC No. Classification Content (%) Lubricating oil hydrotreated C20-C50 Alkyl aryl sulfonate Magnesium > < 5 Zinc alkyl dithiophosphate Xi; Irritant; R36/38 < 5 Amide organomolybdenum R52/53; S61 < 2 The concentrations of the components in this formulation do not exceed the limits set in Directives 1999/45/EC or 67/548/ECC, so no hazardous characteristics give the final product. SECTION 4. GENERAL FIRST AID MEASURES Symptoms: Instructions: 4.1 Ingestion: Gastrointestinal discomfort may occur. Go to the doctor. Do not induce vomiting.

2 4.2 Eye Contact: May cause temporary irritation. Wash thoroughly and repeatedly with clean water. If irritation persists, seek medical attention. 4.3 Skin Contact: Repeated or prolonged skin contact. May cause skin conditions such as existence of small wounds or abrasions. Wash affected areas with soap and water. Take off shoes and dirty/contaminated garments. Do not use solvents. 4.4 Inhalation: Under normal conditions of handling no risk of this type. Breathe clean air for a few minutes. SECTION 5. FIRE FIGHTING MEASURE The product has a flash point of more than 200 C. 5.1 Extinguishing Agents: Foam, dry powder, CO2 or water spray. 5.2 Unsuitable Extinguishing Agents: Direct water jet. 5.3 Decomposition Products: Mainly carbon oxides, water vapour, oxides of zinc, magnesium oxides, molybdenum oxides and nitrogen oxides. 5.3 Protective Equipment: Do not enter enclosed or confined area where fire occurs without proper protective equipment including self-contained breathing apparatus. Use appropriate masks. SECTION 6. ACCIDENTAL RELEASE MEASURES 6.1 Person-Related Safety Precautions: 6.2 Information About Protection Against Explosion & Fires: Avoid contact with skin and eyes. Do not empty into drains and sewage systems. Avoid contamination of soil and water (both surface and groundwater). 6.3 Measures for Cleaning: Soak up with absorbent and fireproof material (eg, silica gel, binder). Collect waste in suitable, labelled and sealed containers and manage through authorized manager. If there is a significant spill notify the local authority. The product is non-emulsifiable in water. SECTION 7. HANDLING AND STORAGE 7.1 Handling: Avoid prolonged or repeated contact with skin and eyes. If oil mist is formed there must be an adequate ventilation system. 7.2 Storage: Store in a place protected from extremes of temperature and humidity, avoiding the proximity of sources of ignition and flammable products, and strong oxidizing chemicals. In the event that the combustion product is started, avoid breathing fumes generated. Store containers so that accidental spills of the product are prevented or potential spills will be contained. SECTION 8. EXPOSURE CONTROLS AND PERSONAL PROTECTION 8.1 Exposure Limits: Substance: Percentage Contained in Preparation: Environmental Limit: Daily Exposure: Short-Term Exposure: Ppm Mg/m 3 Ppm Mg/m 3

3 Lubricant: > Exposure Control / Personal Protection: Respiratory Protection: Not required in normal conditions of use and handling. Use respiratory protection if ventilation is inadequate Hand Protection: It is advisable to use rubber gloves Eye Protection: Not required in normal conditions. If splashes are produced or product is hot, use appropriate glasses Skin protection: Minimise contact with skin using appropriate equipment (gloves, clean clothes, shoes, etc..) Environment: Avoid spillage on the ground or in water. SECTION 9. PHYSICAL AND CHEMICAL PROPERTIES 9.1 Appearance: Bright and clear liquid 9.2 Odour: Characteristic 9.3 ph: N/A 9.4 Minimum Boiling Point: 300ºC 9.5 Self-Igniting: N/A 9.6 Explosive Properties: N/A 9.7 Oxidising Properties: N/A 9.8 Vapour Pressure at 20ºC: <0.1hPa 9.9 Density: At 20ºC to g/cm Solubility: Soluble in petroleum solvents 9.11 Water Solubility: Insoluble 9.12 Viscosity at 100ºC 12.5 to Evaporation Rate: N/A 9.14 Solidification Point Max: -35ºC 9.15 Explosion Limits: Below 0.6 / Above 7.0 SECTION 10. STABILITY AND REACTIVITY The product is stable under normal storage conditions Conditions to be avoided: Violent reactions may occur under the following conditions: High temperatures Presence of strong oxidizers (chlorates, nitrates, peroxides, etc) 10.2 Dangerous products of decomposition: May form carbon monoxide (CO) in case of combustion. SECTION 11. TOXICOLOGICAL INFORMATION 11.1 Oral Toxicity: The oral LD50 in rats is usually doses above 2,000 mgr / kg based on similar

4 products Dermal Toxicity: The lethal dose LD50 in rabbits is greater than 2,000 estimated mgr / kg based on similar materials Inhalation Toxicity: No data available to indicate product or components may cause hazard upon inhalation. In cases of high temperatures or high vapour, headaches may occur Chronic Toxicity: No data available to indicate product or components present chronic health hazard at concentrations greater than 1% Eye Irritation: May cause irritation or redness Skin Irritation: Is not believed to be a primary skin irritant. Prolonged or repeated skin contact with this product with wet clothes can cause dermatitis. The symptoms may include redness, oedema, drying and cracking of the skin Respiratory Irritation: If the product is in the form of mist or vapours generated by heating, exposure may cause irritation of the mucous membranes and upper respiratory tract. If working conditions are good, respiratory irritation should not be a problem Dermal Sensitivity: No data available to indicate product or components may be a skin sensitizer CRM: No data available to indicate product or components may be carcinogenic, mutagenic or toxic to reproduction. SECTION 12. ECOLOGICAL INFORMATION 12.1 Ecotoxicity: The product is considered harmful to aquatic organisms and may cause adverse effects in the aquatic environment in the medium / long term Mobility: Spillages may penetrate the soil causing ground water contamination Persistence and Degradability: The product is not readily biodegradable, thus the need to prevent soil and water pollution Bioaccumulation Potential: Some of the components have the potential to bioaccumulate, thus the need to prevent its release to the environment Further Ecological Information: Spills may form a film on the surface of the water, preventing the transfer of oxygen, causing physical damage to aquatic organisms. SECTION 13: DISPOSAL CONSIDERATION 13.1 Waste Management: - Use appropriate storage of waste management containers to avoid any environmental contamination. - Removal of product and packaging must be in accordance with European, state and local legislation. - Avoid release of the product into the environment. SECTION 14: TRANSPORT INFORMATION 14.1 ADR (Road): Not Classified 14.2 RID (Rail): Not Classified 14.3 IMDG (Sea): Not Classified 14.4 ICAO/IATA (Air): Not Classified

5 SECTION 15: REGULATORY INFORMATION SAFETY DATA SHEET 15.1 Labelling: Pictograms: Not Required R Phrases: S Phrases: Not Required - S26: In case of contact with eyes, rinse immediately with plenty of water and seek medical advice. - S41: In case of fire and/or explosion do not breathe fumes. - S61: Avoid release to the environment Storing Chemicals: Royal Decree 379/2001, on storage of hazardous substances. SECTION 16: OTHER INFORMATION 16.1 Full text of R-phrases specified in paragraph 3: R36/38 Irritating to eyes and skin R52/53 Harmful to aquatic organisms, may cause long-term adverse effects in the aquatic environment. - Annex I (Note L) of RD 363/1995: No need to apply the classification as carcinogenic if it can be shown that the substance contains less than 3% DMSO extract as measured by IP 346. This note applies only to certain complex coal-derived substances and oil - applies in Annex I Further Information: - It is recommended to provide training on risks and preventive measures for persons on handling such substances. - Distribution of the SDS: This document contains important information on the use, handling and storage of this product, so it should be accessible to the person responsible for security. - The information in this Safety Data Sheet corresponds to our current knowledge regarding the product. It is referenced in no way be taken as a guarantee of its properties and characteristics. - Data from sources outside our company are assumed to be accurate but we cannot guarantee that they are complete and correct.