DMHJ DSCT DCW Mixture Cleaner Falcon Safety Products, lnc. 25 lmclone Drive Branchburg, NJ US Phone: E T

Transcription

1 MATERIAL SAFETY DATA SHEET 1. Product and Company ldentification Product Name Synonym(s) cas # Product use Manufacturer LEGEND HMIS/NFPA Severe Serious Moderate Slight Minimal Dust-Off@ Monitor Wipes DMHJ DSCT DCW Mixture Cleaner Falcon Safety Products, lnc. 25 lmclone Drive Branchburg, NJ US Phone: Health Flarnmabrlity E T ø u Personal Protection 0 B Hazards ldentification Emergency overview Potential short term health effects Routes of exposure Eyes Skin Target organs Chronic effects Signs and symptoms CAUTION Combustible liquid. Keep away from heat and flame. Eye and skin irritant. Eye, Skin contact,,. Excessive intentional inhalation may cause respiratory tract irritation and central nervous system effects (headache, dizziness). Not a normal route of exposure. May cause stomach distress, nausea or vomiting. Eyes. Skin. Prolonged or repeated exposure can cause drying, defatting and dermatitis. Symptoms may include redness, edema, drying, defatting and cracking of the skin. Symptoms of overexposure may be headache, dizziness, tiredness, nausea and vomiting. 3. Gompos t on / lnformation on lngredients lngredient(s) cas # Percent 2-Propanol, 1-butoxy First Aid Measures First aid procedures Eye contact Skin contact Hold eye open and rinse slowly and gently with water Íor minutes. Remove contact lenses, if present, after the first 5 minutes, then continue rinsing eye. Call a poison control center or doctor for treatment advice. Flush with cool water. Wash with soap and water. Obtain medical attention if irritation persists. lf symptoms develop move victim to fresh air. lf symptoms persist, obtain medical attention. Do not induce vomiting, Never give anything by mouth if victim is unconscious, or is convulsing. Obtain medical attention. #20859 Page 1 of 5 lssue date 14-Sep-201 0

2 General advice Flammable properties Keep away from sources of ignition. No smoking, lf you feel unwell, seek medical advice (show the label where possible). Ensure that medical personnel are aware of the material(s) involved, and take precautions to protect themselves. Show this safety data sheet to the doctor in attendance. Avoid contact with eyes and skin. Keep out of reach of children. 5. Fire Fighting Measures Combustible by WHMIS/OSHA criteria. Extinguishing media Suitable extinguishing media Dry chemical. Alcohol foam. Carbon dioxide. Unsuitable extinguishing media Protection of firefighters Specific hazards arising from the chemical Protective equipment for Firefighters should wear full protective clothing including self contained breathing apparatus. firefighters Hazardous combustion products May include and are not limited to: Oxides of carbon. Explosion data Sensitivity to mechanical impact Sensitivity to static discharge Personal precautions Methods for containment Methods for cleaning up Handling Storage Exposure limits lngredient(s) 2-Propanol, l-butoxy- Engineering controls Personal protective equipment Eye / face protection Hand protection 6. Accidental Release Measures Wear appropriate protective equipment and clothing during clean-up Prevent entry into waterways, sewers, basements or confined areas. Remove sources of ignition. Pick up and discard towel. 7. Handling and Storage Use according to package label instructions. Keep out of reach of children. Keep away from heat, open flames or other sources of ignition. Store in a closed container away from incompatible materials. 8. Exposure Controls / Personal Protection Exposure Limits ACGIH-TLV Not established OSHA.PEL Not established General ventilation normally adequate. Safety glasses if eye contact is possible. Skin and body protect on As required by employer code. Respiratory protection lf there is constant skin contact, rubber gloves are recommended. Where exposure guideline levels may be exceeded, use an approved NIOSH respirator. General hygiene considerations Handle in accordance with good industrial hygiene and safety practice. When using do not eat or drink. Wash hands before breaks and immediately after handling the product. 9. Physical and Ghemical Properties Appearance Color Form Odor Liquid saturated on wipe Colorless to light yellow liquid on a wipe Pre-moistened towelette. Slight solvent #20859 Page 2 of 5 lssue date I 4-Sep-20 I 0

3 Odor threshold Physical state ph Melting point Freezing point Boiling point Pour point Evaporation rate Flash point Auto-ignition tem pereture Flammability limits in air, lower, 7o by volume Flammability limits in air, upper, % by volume Vapor pressure Vapor density Specific gravity Octanol/water coefficient Solubility (H2O) Percent volatile Chemical stability Solid (liquid) > 'F (> 87'C) (liquid) Not applicable Not applicable (liquid) Pad is not soluble in water Stability and Reactivity Stable under recommended storage conditions. Conditions to avoid Source of ignition. Do not mix with other chemicals. lncompatible materials Oxidizers. Hazardous decomposition products May include and are not limited to: Oxides of carbon Possibility of hazardous reactions Hazardous polymerization does not occur. I l. Toxicological Information Component analysis - LC50 lngredient(s) 2-Propanol, 1-butoxy- Component analysis - Oral LD50 Ingredient(s) 2-Propanol, 1-butoxy- Effects of acute exposure Eye Skin Sensitization Chronic effects Carcinogenicity Mutagenicity Reproductive effects Teratogenicity Synergistic Materials LC50 LDSO 3300 mg/kg rat Excessive intentional inhalation may cause respiratory tract irritation and central nervous system effects (headache, dizzi ness). Not a normal route of exposure. May cause stomach distress, nausea or vomiting. I 2. Ecological lnformation Ecotoxicity Environmental effects #20859 Page 3 of 5 lssue date 14-Setr2o10

4 Aquatic toxicity Persistence / degradabil ity Bioaccum ulation / accumulation Partition coefficient Mobility in environmental media Chemical fate information Other adverse effects Waste codes Disposal instructions Waste from residues / unused products Contaminated packaging 1 3. Disposal Gonsiderations Dispose in accordance with all applicable regulations Transport lnformat on U.S. Department of Transportation (DOT) Transportation of Dangerous Goods (TDG - Canada) IATA/ICAO (Air) IMDG (Marine Transport) Ganadian federal regulations US Federal regulations Occupational Safety and Health Administration (OSHA) 29 CFR hazardous Yes chemical CERCLA (Superfund) reportable quantity None I 5. Regulatory lnformation Superfund Amendments and Reauthorization Act of 1986 (SARA) Hazard cetegories Section 302 extremely hazardous substance This product has been classified in accordance with the hazard criteria of the Controlled Products Regulations and the MSDS contains all the information required by the Controlled Products Regulations. This product is a "Hazardous Chemical" as defined by the OSHA Hazard Communication Standard, 29 CFR CERCLA/SARA Hazardous Substances - Not applicable. lmmediate Hazard - Yes Delayed Hazard - No Fire Hazard - Yes Pressure Hazard - No Reactivity Hazard - No No Section 311 hazardous chemical Yes Clean Air Act (GAA) Clean Water Act (CWA) WHMIS status Controlled WHMIS classification Class B - Division 3 - Combustible Liquid, Class D - Division 28 WHMIS labeling #20859 Page 4 of 5 lssue date 1 4-Sep-201 0

5 State regulations This product does not contain a chemical known to the State of California to cause cancer, birth defects or other reproductive harm. lnventory name Country(s) or region lnventory name On inventory (yes/no)* Canada Domestic Substances List (DSL) Yes Canada Non-Domestic Substances List (NDSL) No United States & Puerto Rico Toxic Substances Control Act (TSCA) lnventory Yes A "Yes" indicates that all components of this product comply with the inventory requirements administered by the governing country(s) 16. Other lnformation Disclaimer lssue date Effective date Expiry date Prepared by Other information lnformation contained herein was obtained from sources considered technically accurate and reliable. While every effort has been made to ensure full disclosure of product hazards, in some cases data is not available and is so stated. Since conditions of actual product use are beyond control of the supplier, it is assumed that users of this material have been fully trained according to the requirements of all applicable legislation and regulatory instruments. No warranty, expressed or implied, is made and supplier will not be liable for any losses, injuries or consequential damages which may result from the use of or reliance on any information contained in this document. 14-Sep Sep Sep Dell Tech Laboratories Ltd. (519) For an updated MSDS, please contact the supplier/manufacturer listed on the first page of the document. #20859 Page 5 of 5 lssue date 14-Sep-201 0