Material Safety Data Sheet Attached

Transcription

1 CanadaColorsandChemicalsLimited 152KennedyRoadSouth Brampton,Ontario Canada L6W3G4 GeneralInquiryNumber:(905) MaterialSafetyDataSheet Attached

2 Thisproductisdistributedby CanadaColorsandChemicalsLimited GeneralInquiry:(416) (905) HourEmergency:(416) CCC:ProductCode: CCC:ProductName: MOPA Revision date : 2013/01/28 Page: 1/7 1. Product and Company Identification Company BASF Canada Inc. 100 Milverton Drive Mississauga, ON L5R 4H1, CANADA 24 Hour Emergency Response Information CANUTEC (reverse charges): (613) BASF HOTLINE: (800) 454-COPE (2673) Molecular formula: Chemical family: Synonyms: C(4)H(11)NO amine 3-Methoxy-1-propanamine 2. Hazards Identification Emergency overview FLAMMABLE. CORROSIVE. Corrosive to the skin, eyes and respiratory system. Causes burns. Harmful if swallowed. State of matter: liquid Colour: colourless to yellow Odour: amine-like Potential health effects Acute toxicity: Of moderate toxicity after single ingestion. The inhalation of a highly enriched/saturated vapor-air-mixture represents a potential acute hazard. Irritation / corrosion: Highly corrosive! Damages skin and eyes. May cause severe damage to the eyes. Assessment other acute effects: The available information is not sufficient for evaluation. Sensitization: Sensitization after skin contact possible. Chronic toxicity: Carcinogenicity: No data available concerning carcinogenic effects.

3 Revision date : 2013/01/28 Page: 2/7 Repeated dose toxicity: No known chronic effects. Teratogenicity: No data available concerning teratogenic effects. Genotoxicity: No mutagenic effect was found in various tests with bacteria and mammalian cell culture. The substance was not mutagenic in studies with mammals. Signs and symptoms of overexposure: The most important known symptoms and effects are described in the labelling (see section 2) and/or in section 11., Further symptoms are possible Potential environmental effects Aquatic toxicity: Acutely harmful for aquatic organisms. Inhibition of degradation activity in activated sludge is not to be anticipated during correct introduction of low concentrations. 3. Composition / Information on Ingredients CAS Number Content (W/W) Hazardous ingredients % 3-methoxypropylamine 4. First-Aid Measures General advice: Immediately remove contaminated clothing. If danger of loss of consciousness, place patient in recovery position and transport accordingly. Apply artificial respiration if necessary. First aid personnel should pay attention to their own safety. If inhaled: Keep patient calm, remove to fresh air. Assist in breathing if necessary. Consult a physician. If on skin: Wash affected areas thoroughly with soap and water. Remove contaminated clothing. If irritation develops, seek medical attention. If in eyes: In case of contact with the eyes, rinse immediately for at least 15 minutes with plenty of water. Immediate medical attention required. If swallowed: Rinse mouth and then drink plenty of water. Do not induce vomiting. Immediate medical attention required. Note to physician Treatment: Treat according to symptoms (decontamination, vital functions), no known specific antidote. Pulmonary odema prophylaxis. Medical monitoring for at least 24 hours. 5. Fire-Fighting Measures Flash point: 24 C (DIN 51755, closed cup) Autoignition: 295 C (DIN 51794) Lower explosion limit: For liquids not relevant for classification and labelling. The lower explosion point may be 5-15 C below the flash point.

4 Revision date : 2013/01/28 Page: 3/7 Upper explosion limit: Flammability: Self-ignition temperature: Flammable. Suitable extinguishing media: water spray, dry powder, foam, carbon dioxide For liquids not relevant for classification and labelling. not self-igniting Hazards during fire-fighting: nitrogen oxides, carbon oxides The substances/groups of substances mentioned can be released in case of fire. Under certain conditions in case of fire other hazardous combustion products may be generated. Protective equipment for fire-fighting: Wear self-contained breathing apparatus and chemical-protective clothing. Further information: Dispose of fire debris and contaminated extinguishing water in accordance with official regulations. 6. Accidental release measures Personal precautions: Avoid inhalation. Avoid contact with the skin, eyes and clothing. Environmental precautions: Do not discharge into drains/surface waters/groundwater. Cleanup: Clean contaminated floors and objects thoroughly with water and detergents, observing environmental regulations. Collect waste in suitable containers, which can be labeled and sealed. Incinerate or take to a special waste disposal site in accordance with local authority regulations. For small amounts: Pick up with absorbent material (e.g. sand, sawdust, general-purpose binder). For large amounts: Pick up with suitable appliance and dispose of. 7. Handling and Storage Handling General advice: Ensure thorough ventilation of stores and work areas. Protection against fire and explosion: Prevent electrostatic charge - sources of ignition should be kept well clear - fire extinguishers should be kept handy. Storage General advice: Containers should be stored tightly sealed in a dry place. Storage incompatibility: General advice: Segregate from acids and acid forming substances. Segregate from isocyanates. 8. Exposure Controls and Personal Protection

5 Revision date : 2013/01/28 Page: 4/7 Personal protective equipment Respiratory protection: Respiratory protection in case of vapour/aerosol release. Self-contained breathing apparatus. Hand protection: Chemical resistant protective gloves, Suitable materials, rubber, plastic Eye protection: Tightly fitting safety goggles (chemical goggles) and face shield. Body protection: Body protection must be chosen depending on activity and possible exposure, e.g. apron, protecting boots, chemical-protection suit (according to EN in case of splashes or EN ISO in case of dust). General safety and hygiene measures: Handle in accordance with good industrial hygiene and safety practice. Wearing of closed work clothing is required additionally to the stated personal protection equipment. Avoid contact with the skin, eyes and clothing. Do not breathe vapour/spray. Wash soiled clothing immediately. 9. Physical and Chemical Properties Form: liquid Odour: amine-like Odour threshold: No data available. Colour: colourless to yellow ph value: 11.5 ( 100 g/l, 20 C) Melting point: < -70 C Boiling point: 116 C ( 1,013 hpa) (other) Vapour pressure: 16 hpa ( 20 C) Density: g/cm3 ( 15 C) g/cm3 ( 55 C) Partitioning coefficient n ( 25 C) (calculated) octanol/water (log Pow): Viscosity, dynamic: 0.8 mpa.s ( 20 C) Particle size: The substance / product is marketed or used in a non solid or granular form. Solubility in water: ( 20 C) miscible Molar mass: g/mol 10. Stability and Reactivity Conditions to avoid: See MSDS section 7 - Handling and storage. Substances to avoid: acids halogenated compounds, isocyanates, strong acids, strong oxidizing agents Hazardous reactions: Reacts with oxidizing agents. Reacts with acids. Reacts with isocyanates. Reacts with halogenated compounds. The progress of reaction is exothermic. Decomposition products: Hazardous decomposition products: nitrogen oxides, carbon oxides Thermal decomposition: 2.0 K/min (DSC (DIN 51007)) No decomposition if used as directed. It is not a self-decompositionable substance. Oxidizing properties:

6 Revision date : 2013/01/28 Page: 5/7 Based on its structural properties the product is not classified as oxidizing. 11. Toxicological information Acute toxicity Oral: Type of value: LD50 Species: rat Value: 830-1,143 mg/kg (OECD Guideline 401) Literature data. Aspiration Hazard: No aspiration hazard expected. 12. Ecological Information Fish Acute: DIN Part 15 static Leuciscus idus/lc50 (96 h): mg/l After neutralization, it is no longer toxic. Nominal concentration. Aquatic invertebrates Acute: DIN EN ISO 6341 Daphnia magna/ec50 (48 h): 13.7 mg/l The details of the toxic effect relate to the nominal concentration. Aquatic plants Toxicity to aquatic plants: No data available concerning toxicity for algae. Microorganisms Toxicity to microorganisms: DIN Part 8 bacterium/ec10 (17 h): 12,900 mg/l Nominal concentration. Literature data. OECD Guideline 209 aquatic activated sludge, industrial/ec20 (0.5 h): > 1,995 mg/l Nominal concentration. Degradability / Persistence Biological / Abiological Degradation Test method: OECD 301C; ISO 9408; 92/69/EEC, C.4-F (aerobic), Inoculum conforming to MITI Method of analysis: BOD of the ThOD Degree of elimination: 3 % (28 d) Test method: OECD Guideline 302 B (aerobic), activated sludge, industrial Method of analysis: DOC reduction Degree of elimination: % (13 d) Evaluation: Poorly biodegradable. Easily eliminated from water. Bioaccumulation

7 Revision date : 2013/01/28 Page: 6/7 OECD Guideline 305 C carp (42 d) Bioconcentration factor Accumulation in organisms is not to be expected. Literature data. 13. Disposal considerations Waste disposal of substance: Incinerate in suitable incineration plant, observing local authority regulations. Container disposal: Contaminated packaging should be emptied as far as possible; then it can be passed on for recycling after being thoroughly cleaned. 14. Transport Information Land transport TDG Hazard class: 8 Packing group: I ID number: UN 2734 Hazard label: 8, 3 Proper shipping name: AMINES, LIQUID, CORROSIVE, FLAMMABLE, N.O.S. (contains 3- METHOXYPROPYLAMINE) Sea transport IMDG Hazard class: 8 Packing group: I ID number: UN 2734 Hazard label: 8, 3 Marine pollutant: NO Proper shipping name: AMINES, LIQUID, CORROSIVE, FLAMMABLE, N.O.S. (contains 3- METHOXYPROPYLAMINE) Air transport IATA/ICAO Hazard class: 8 Packing group: I ID number: UN 2734 Hazard label: 8, 3 Proper shipping name: AMINES, LIQUID, CORROSIVE, FLAMMABLE, N.O.S. (contains 3- METHOXYPROPYLAMINE) 15. Regulatory Information Federal Regulations Registration status: Chemical DSL, CA released / listed

8 Revision date : 2013/01/28 Page: 7/7 WHMIS classification: E: Corrosive material WHMIS classification B2: Flammable Liquid THIS PRODUCT HAS BEEN CLASSIFIED IN ACCORDANCE WITH THE HAZARD CRITERIA OF THE CPR AND THE MSDS CONTAINS ALL THE INFORMATION REQUIRED BY THE CPR. 16. Other Information We support worldwide Responsible Care initiatives. We value the health and safety of our employees, customers, suppliers and neighbors, and the protection of the environment. Our commitment to Responsible Care is integral to conducting our business and operating our facilities in a safe and environmentally responsible fashion, supporting our customers and suppliers in ensuring the safe and environmentally sound handling of our products, and minimizing the impact of our operations on society and the environment during production, storage, transport, use and disposal of our products. MSDS Prepared by: BASF NA Product Regulations msds@basf.com BASF HOTLINE (800) 454 COPE (2673) MSDS Prepared on: 2013/01/28 END OF DATA SHEET