MATERIAL SAFETY DATA SHEET. 1. Product and Company Identification

Transcription

1 MATERIAL SAFETY DATA SHEET 1 Product and Company Identification Product Name Synonym(s) CAS # Product use Manufacturer LEGEND HMIS/NFPA Severe Serious 4 3 Moderate 2 Slight Minimal 1 0 Dust Off Whiteboard Wipes DWBT Mixture Cleaner Falcon Safety Products, Inc 25 Imclone Drive Branchburg, NJ US Phone: Health / 1 Flammability 2 Physical Hazard 0 Personal Protection B Hazards Identification Emergency overview Potential short term health effects Routes of exposure Eyes Skin Target organs Chronic effects Signs and symptoms CAUTION Combustible liquid Keep away from heat and flame Eye and skin irritant Eye, Skin contact,, May cause irritation May cause irritation Excessive intentional inhalation may cause respiratory tract irritation and central nervous system effects (headache, dizziness) Not a normal route of exposure May cause stomach distress, nausea or vomiting Eyes Skin Prolonged or repeated exposure can cause drying, defatting and dermatitis Symptoms may include redness, edema, drying, defatting and cracking of the skin Symptoms of overexposure may be headache, dizziness, tiredness, nausea and vomiting 3 Composition / Information on Ingredients CAS # Percent 2-Propanol, 1-butoxy First aid procedures Eye contact Skin contact 4 First Aid Measures Hold eye open and rinse slowly and gently with water for minutes Remove contact lenses, if present, after the first 5 minutes, then continue rinsing eye Call a poison control center or doctor for treatment advice Flush with cool water Wash with soap and water Obtain medical attention if irritation persists If symptoms develop move victim to fresh air If symptoms persist, obtain medical attention Do not induce vomiting Never give anything by mouth if victim is unconscious, or is convulsing Obtain medical attention #20859 Page 1 of 5 Issue date 14-Sep-2010

2 General advice Keep away from sources of ignition No smoking If you feel unwell, seek medical advice (show the label where possible) Ensure that medical personnel are aware of the material(s) involved, and take precautions to protect themselves Show this safety data sheet to the doctor in attendance Avoid contact with eyes and skin Keep out of reach of children 5 Fire Fighting Measures Flammable properties Extinguishing media Suitable extinguishing media Unsuitable extinguishing media Protection of firefighters Specific hazards arising from the chemical Protective equipment for firefighters Hazardous combustion products Explosion data Sensitivity to mechanical impact Sensitivity to static discharge Combustible by WHMIS/OSHA criteria Dry chemical Alcohol foam Carbon dioxide Firefighters should wear full protective clothing including self contained breathing apparatus May include and are not limited to: Oxides of carbon 6 Accidental Release Measures Personal precautions Methods for containment Methods for cleaning up Handling Storage Exposure limits Wear appropriate protective equipment and clothing during clean-up Prevent entry into waterways, sewers, basements or confined areas Remove sources of ignition Pick up and discard towel 7 Handling and Storage Use according to package label instructions Keep out of reach of children Keep away from heat, open flames or other sources of ignition Store in a closed container away from incompatible materials 8 Exposure Controls / Personal Protection Exposure Limits 2-Propanol, 1-butoxy- Engineering controls Personal protective equipment Eye / face protection ACGIH-TLV Not established OSHA-PEL Not established General ventilation normally adequate Safety glasses if eye contact is possible Hand protection If there is constant skin contact, rubber gloves are recommended Skin and body protection As required by employer code Respiratory protection Where exposure guideline levels may be exceeded, use an approved NIOSH respirator General hygiene considerations Handle in accordance with good industrial hygiene and safety practice When using do not eat or drink Wash hands before breaks and immediately after handling the product 9 Physical and Chemical Properties Appearance Color Form Odor Liquid saturated on wipe Colorless to light yellow liquid on a wipe Pre-moistened towelette Slight solvent #20859 Page 2 of 5 Issue date 14-Sep-2010

3 Odor threshold Physical state ph Melting point Freezing point Boiling point Pour point Evaporation rate Flash point Auto-ignition temperature Flammability limits in air, lower, % by volume Flammability limits in air, upper, % by volume Vapor pressure Vapor density Specific gravity Octanol/water coefficient Solid (liquid) > F (> 87 C) (liquid) Not applicable Not applicable (liquid) Solubility (H2O) Pad is not soluble in water Percent volatile Stability and Reactivity Chemical stability Conditions to avoid Stable under recommended storage conditions Source of ignition Do not mix with other chemicals Incompatible materials Oxidizers Hazardous decomposition products May include and are not limited to: Oxides of carbon Possibility of hazardous reactions Hazardous polymerization does not occur 11 Toxicological Information Component analysis - LC50 2-Propanol, 1-butoxy Component analysis - Oral LD50 2-Propanol, 1-butoxy Effects of acute exposure Eye Skin Sensitization Chronic effects Carcinogenicity Mutagenicity Reproductive effects Teratogenicity Synergistic Materials Ecotoxicity Environmental effects May cause irritation May cause irritation LC50 LD mg/kg rat Excessive intentional inhalation may cause respiratory tract irritation and central nervous system effects (headache, dizziness) Not a normal route of exposure May cause stomach distress, nausea or vomiting Non-hazardous by WHMIS/OSHA criteria Non-hazardous by WHMIS/OSHA criteria Non-hazardous by WHMIS/OSHA criteria Non-hazardous by WHMIS/OSHA criteria Non-hazardous by WHMIS/OSHA criteria Non-hazardous by WHMIS/OSHA criteria 12 Ecological Information #20859 Page 3 of 5 Issue date 14-Sep-2010

4 Aquatic toxicity Persistence / degradability Bioaccumulation / accumulation Partition coefficient Mobility in environmental media Chemical fate information Other adverse effects Waste codes Disposal instructions Waste from residues / unused products Contaminated packaging 13 Disposal Considerations Dispose in accordance with all applicable regulations 14 Transport Information US Department of Transportation (DOT) Not regulated as dangerous goods Transportation of Dangerous Goods (TDG - Canada) Not regulated as dangerous goods IATA/ICAO (Air) Not regulated as dangerous goods IMDG (Marine Transport) Not regulated as dangerous goods 15 Regulatory Information Canadian federal regulations US Federal regulations Occupational Safety and Health Administration (OSHA) 29 CFR hazardous Yes chemical CERCLA (Superfund) reportable quantity None Superfund Amendments and Reauthorization Act of 1986 (SARA) Hazard categories Immediate Hazard - Yes Delayed Hazard - No Fire Hazard - Yes Pressure Hazard - No Reactivity Hazard - No Section 302 extremely hazardous substance This product has been classified in accordance with the hazard criteria of the Controlled Products Regulations and the MSDS contains all the information required by the Controlled Products Regulations This product is a "Hazardous Chemical" as defined by the OSHA Hazard Communication Standard, 29 CFR CERCLA/SARA Hazardous Substances - Not applicable No Section 311 hazardous chemical Yes Clean Air Act (CAA) Clean Water Act (CWA) WHMIS status WHMIS classification WHMIS labeling Controlled Class B - Division 3 - Combustible Liquid, Class D - Division 2B #20859 Page 4 of 5 Issue date 14-Sep-2010

5 State regulations This product does not contain a chemical known to the State of California to cause cancer, birth defects or other reproductive harm Inventory name Country(s) or region Inventory name On inventory (yes/no)* Canada Domestic Substances List (DSL) Yes Canada United States & Puerto Rico Non-Domestic Substances List (NDSL) Toxic Substances Control Act (TSCA) Inventory No Yes A "Yes" indicates that all components of this product comply with the inventory requirements administered by the governing country(s) Disclaimer Issue date Effective date 16 Other Information Information contained herein was obtained from sources considered technically accurate and reliable While every effort has been made to ensure full disclosure of product hazards, in some cases data is not available and is so stated Since conditions of actual product use are beyond control of the supplier, it is assumed that users of this material have been fully trained according to the requirements of all applicable legislation and regulatory instruments No warranty, expressed or implied, is made and supplier will not be liable for any losses, injuries or consequential damages which may result from the use of or reliance on any information contained in this document 14-Sep Sep-2010 Expiry date 15-Sep-2013 Prepared by Dell Tech Laboratories Ltd (519) Other information For an updated MSDS, please contact the supplier/manufacturer listed on the first page of the document #20859 Page 5 of 5 Issue date 14-Sep-2010