MATERIAL SAFETY DATA SHEET FOR BOSS FOAM CLEANING SPRAY

Transcription

1 MATERIAL SAFETY DATA SHEET FOR BOSS FOAM CLEANING SPRAY IDENTIFICATION OF THE SUBSTANCE/PREPARATION AND COMPANY Product type: Intended Use: Trade Name: Supplier of product: Foam Cleaner Cleaning of hard surfaces. Removed oil/grease/general soiling BOSS Foam Cleaning Spray The BSS Group Ltd Registered Office: Travis Perkins PLC, Lodge Way House, Lodge Way, Harlestone Road, Northampton NN5 7UG. Telephone/Fax Numbers: / Address: Web site Address: 2. HAZARD IDENTIFICATION reception@bssgroup.com CLASSIFICATION OF THE SUBSTANCE OR MIXTURE Directive 67/548/EEC & Directive 1999/45/EC: Label elements: Product Name: Hazard Symbol: F+; Extremely flammable. According to Directive 67/548/EEC & Directive 1999/45/EC Anti-Static Foam Cleaner Risk Phrases: Safety Phrases: Additional Information: Other hazards: Additional Information: F+ R12: Extremely flammable. S2: Keep out of the reach of children. S16: Keep away from sources of ignition - No smoking. S23: Do not breathe vapour/spray. S43: In case of fire, use: Extinguish preferably with dry chemical, sand or carbon dioxide S51: Use only in well-ventilated areas. Pressurized container. Protect from sunlight and do not expose to temperatures exceeding 50 C. Do not pierce or burn, even after use. Do not spray on a naked flame or any incandescent material May cause eye irritation. None BOSS MSDS 024 REVIEWED: 04/03/2013 Page: 1 of 7

2 3. COMPOSITION/INFORMATION ON INGREDIENTS. Product as supplied: Aerosol 3.1 Mixtures EC Classification No. 67/548/EEC Hazardous ingredient(s) 2- Butoxyethanol %W/W CAS No. EC No. REACH Registration No None assigned EC Classification and Risk Phrases Xn; R20/21/22, Xi; R36/38 Butane None assigned F+; R12 4. FIRST AID MEASURES Description of first aid measures Inhalation: Skin Contact: Eye Contact: Move person to fresh air. If symptoms persist, obtain medical attention. Wash skin with soap and water. If symptoms persist, obtain medical attention. Hold eyelids apart and flush eyes with plenty of water for at least 15 minutes. If symptoms persist, obtain medical attention. Ingestion: Most important symptoms and effects, both acute and delayed: Indication of any immediate medical attention and special treatment needed: Unlikely route of exposure. Unlikely to be required but if necessary treat symptomatically. No special requirements. 5. FIRE FIGHTING MEASURES Extinguishing Media: Suitable Extinguishing Media: Unsuitable Extinguishing Media: Special hazards arising from the substance or mixture: Advice for fire-fighters: Extinguish preferably with dry chemical, sand or carbon dioxide. None known Heating may cause pressure rise with risk of bursting. Fire fighters should wear complete protective clothing including self-contained breathing apparatus. If it is safe to do so, containers should be removed from fire area because they are likely to rupture under fire conditions. Keep containers cool by spraying with water if exposed to fire. BOSS MSDS 024 REVIEWED: 04/03/2013 Page: 2 of 7

3 6. ACCIDENTAL RELEASE MEASURES Personal precautions, protective equipment and emergency procedures: Environmental precautions: Methods and material for containment and cleaning up: Reference to other sections: See Also Section 7, 8, HANDLING AND STORAGE: Precautions for safe handling: Eliminate sources of ignition. Caution - spillages may be slippery. Stop leak if safe to do so. Do not allow to enter drains, sewers or watercourses. Place leaking cans in a bucket or pail to minimise product contamination of surfaces. Leaked product will render floors very slippery. Absorb spillages onto sand. Ensure adequate ventilation. Keep away from heat/sparks/open flames/hot surfaces. No smoking. Do not pierce or burn, even after use. Do not spray on a naked flame or any incandescent material. Do not breathe vapour/spray. Wash hands thoroughly after handling. Protect from sunlight. Store in a dry place. Keep in a well ventilated place. Conditions for safe storage, including any incompatibilities: Storage Temperature: Do not expose to temperatures exceeding 50 C/ 122 F Storage Life: Incompatible materials: Specific end use(s): Strong oxidising agents, Strongly alkaline, Strongly acidic. Cleaning of hard surfaces Removed oil/grease/general soiling 8. EXPOSURE CONTROLS/PERSONAL PROTECTION Control parameters Occupational Exposure Limits SUBSTANCE CAS No. LTEL (8 hr TWA ppm) LTEL (8 hr TWA mg/m³) STEL (ppm) STEL (mg/m³) 2-Butoxyethanol WEL (Sk) Butane WEL Note WEL: Workplace Exposure Limit (UK HSE EH40) Sk - Can be absorbed through skin. Biological limit value PNECs and DNELs Not established. Not established. BOSS MSDS 024 REVIEWED: 04/03/2013 Page: 3 of 7

4 8. EXPOSURE CONTROLS/PERSONAL PROTECTION (cont) Exposure controls Eye/face protection: Not normally required. Wear eye protection with side protection (EN166). Thermal hazards: Skin protection (Hand protection/other): Respiratory protection: Environmental Exposure Controls: Not normally required. Wear suitable gloves if prolonged skin contact is likely. Wear a suitable respirator if the ventilation is not sufficient to keep the solvent vapour concentration below the occupational limit values. Not applicable Do not allow to enter drains, sewers or watercourses. 9. PHYSICAL AND CHEMICAL PROPERTIES Information on basic physical and chemical properties Appearance: Aerosol. Colour: Clear, Colourless. Odour: Solvent. Odour Threshold: Not applicable. ph: Melting Point/Freezing Point: Initial boiling point and boiling range: Flash point: -40 C Evaporation rate: Flammability (solid, gas): Extremely flammable. Upper/lower flammability or explosive % limits: Vapour pressure: 2.41 bar Vapour density: Relative density: Not applicable. Solubility(ies): Soluble in water. Partition coefficient: n-octanol/water: Auto-ignition temperature: Decomposition Temperature: Viscosity: Not applicable. Explosive properties: Contains gas under pressure; may explode if heated. Oxidising properties: Not oxidising. Other Information: None BOSS MSDS 024 REVIEWED: 04/03/2013 Page: 4 of 7

5 10. STABILITY AND REACTIVITY Reactivity: Chemical stability: Possibility of hazardous reactions: Conditions to avoid: Incompatible materials: Hazardous Decomposition Product(s): Keep away from heat/sparks/open flames/hot surfaces. No smoking. Strong oxidising agents, Strongly alkaline, Strongly acidic. None known. 11. TOXICOLOGICAL INFORMATION Information on toxicological effects Mixtures Acute toxicity: Low acute toxicity. Irritation: May cause eye irritation. Corrosivity: Not classified. Sensitisation: It is not a skin sensitiser. Repeated dose toxicity: None anticipated. Carcinogenicity: No evidence of carcinogenicity. Mutagenicity: There is no evidence of mutagenic potential. Toxicity for reproduction: None anticipated. Other information: None. 12. ECOLOGICAL INFORMATION Toxicity: Persistence and degradability: Bioaccumulative potential: Mobility in soil: Results of PBT and vpvb assessment: Other adverse effects: Low toxicity to aquatic organisms. The product is biodegradable. No information available. Soluble in water. The product is predicted to have high mobility in soil. Not classified as PBT or vpvb. None. 13. DISPOSAL CONSIDERATIONS Waste treatment methods: Additional Information: Recycle only completely emptied packaging. Containers must not be punctured or destroyed by burning, even when empty. Non-emptied aerosol: Dispose of wastes in an approved waste disposal facility. Disposal should be in accordance with local, state or national legislation. BOSS MSDS 024 REVIEWED: 04/03/2013 Page: 5 of 7

6 14. TRANSPORT INFORMATION UN number: UN 1950 (EEC tariff No ) UN proper shipping name ADR/RID/ADN/IMDG: AEROSOLS. ICAO/IATA: AEROSOLS, FLAMMABLE. Transport hazard class(es): 2 Packing Group: None. Environmental hazards: Not classified as a Marine Pollutant. Special precautions for user: None. Transport in bulk according Not applicable. to Annex II of MARPOL73/78 and the IBC Code: Additional Information: 2 ADR Hazard label(s): 2201 ADR/RID Marginal: EmS: F-D, S-U IMDG Code: Limited Quantity provisions apply. Limited Quantity (LQ): REGULATORY INFORMATION Safety, health and environmental regulations/legislation specific for the substance or mixture EU regulations Authorisations and/or restrictions on use Candidate List of Substances of Very High Concern for All chemicals are not listed. Authorisation: REACH: ANNEX XIV LIST OF SUBSTANCES All chemicals are not listed. SUBJECT TO AUTHORISATION: REACH: ANNEX XVII RESTRICTIONS ON THE All chemicals are not listed. MANUFACTURE, PLACING ON THE MARKET AND USE OF CERTAIN DANGEROUS SUBSTANCES, PREPARATIONS AND ARTICLES: Community Rolling Action Plan (CoRAP); Draft All chemicals are not listed. 29/02/2012: Other EU regulations: COSHH - Control of Substances Hazardous to Health CHIP - Chemicals (Hazard Information and Packaging) Regulations Rivers (Prevention of Pollution) Act 1961 Control of Pollution (Special Waste Regulations) 1980 National regulations: None known Chemical Safety Assessment: Not available BOSS MSDS 024 REVIEWED: 04/03/2013 Page: 6 of 7

7 16. OTHER INFORMATION The following sections contain revisions or new statements: LEGEND LTEL Long Term Exposure Limit STEL Short Term Exposure Limit DNEL Derived No Effect Level PNEC Predicted No Effect Concentration PBT Persistent, Bioaccumulative and Toxic vpvb very Persistent and very Bioaccumulative F+ Extremely flammable Xi Irritant Xn Harmful Risk Phrases R12 Extremely flammable. R20/21/22 Harmful by inhalation, in contact with skin and if swallowed. R36/38 Irritating to eyes and skin. DISCLAIMER This information relates only to the specific material designated and may not be valid for such material used in combination with any other material or in any process. Such information is, to the best of the company s knowledge and belief, accurate and reliable as of the date indicated. However, the user s responsibility to satisfy himself as to the suitability of such information for his own particular use. BOSS MSDS 024 REVIEWED: 04/03/2013 Page: 7 of 7