Safety Data Sheet acc. to GHS HPR

Transcription

1 Page 1/6 * 1 Identification of the substance/mixture and of the company/undertaking Creation date: Product identifier Stopaq Outerwrap HTPP Article category AC13 Plastic articles Application of the substance / the mixture Coating Uses advised against - Details of the supplier of the safety data sheet Manufacturer/Supplier: Seal For Life Industries - Stopaq Contact details Seal For Life Industries - Stopaq B.V. Gasselterstraat 20, 9503JB Stadskanaal, the Netherlands Tel , Fax , info@sealforlife.com Information department: Occupational product safety department of Seal For Life Industries Emergency telephone number: For worldwide emergency assistance call CHEMTREC (24 hours): Within USA/Canada ; Outside USA/Canada (collect calls accepted) 2 Hazard(s) identification Classification of the substance or mixture The product is not classified according to the Globally Harmonized System (GHS). Label elements GHS label elements Hazard pictograms Signal word Hazard statements Other hazards Results of PBT and vpvb assessment PBT: Not available. vpvb: Not available. * 3 Composition/information on ingredients Chemical characterization: Mixtures Description: Mixture of the substances listed below with nonhazardous additions. Dangerous components: * 4 First-aid measures Description of first aid measures General information: No special measures required. After inhalation: Supply fresh air; consult doctor in case of complaints. After skin contact: Generally the product does not irritate the skin. After eye contact: Rinse opened eye for several minutes under running water. If symptoms persist, consult a doctor. After swallowing: If symptoms persist consult doctor. (Contd. on page 2)

2 Page 2/6 Information for doctor: Most important symptoms and effects, both acute and delayed No further relevant information available. Indication of any immediate medical attention and special treatment needed No further relevant information available. (Contd. of page 1) * 5 Fire-fighting measures Extinguishing media Suitable extinguishing agents: CO2, extinguishing powder or water spray. Fight larger fires with water spray or alcohol resistant foam. Special hazards arising from the substance or mixture Formation of toxic gases is possible during heating or in case of fire. In case of fire, the following can be released: Carbon monoxide (CO) Advice for firefighters Protective equipment: Wear self-contained respiratory protective device. Wear fully protective suit. * 6 Accidental release measures Personal precautions, protective equipment and emergency procedures Not required. Environmental precautions: Do not allow to enter sewers/ surface or ground water. Methods and material for containment and cleaning up: Pick up mechanically. Reference to other sections See Section 7 for information on safe handling. See Section 8 for information on personal protection equipment. See Section 13 for disposal information. * 7 Handling and storage Handling: Precautions for safe handling No special measures required. Information about protection against explosions and fires: No special measures required. Specific engineering controls to be used Not applicable Conditions for safe storage, including any incompatibilities Storage: Requirements to be met by storerooms and receptacles: No special requirements. Information about storage in one common storage facility: Not required. Further information about storage conditions: None. Specific end use(s) No further relevant information available. * 8 Exposure controls/personal protection Additional information about design of technical systems: No further data; see item 7. Control parameters Components with limit values that require monitoring at the workplace: The product does not contain any relevant quantities of materials with critical values that have to be monitored at the workplace. Additional information: The lists that were valid during the creation were used as basis. (Contd. on page 3)

3 Page 3/6 Exposure controls Personal protective equipment: General protective and hygienic measures: The usual precautionary measures for handling chemicals should be followed. Breathing equipment: Not required. Protection of hands: Not required. Eye protection: Not required. (Contd. of page 2) * 9 Physical and chemical properties Information on basic physical and chemical properties General Information Appearance: Form: Web Color: According to product specification Odor: Odorless Odor threshold: ph-value: Change in condition Boiling point/boiling range: Flash point: Flammability (solid, gaseous): Ignition temperature: Decomposition temperature: Auto igniting: Danger of explosion: Explosion limits: Lower: Upper: Vapor pressure: Density: Relative density Vapor density Evaporation rate Solubility in / Miscibility with Water: Undetermined. Product is not selfigniting. Product does not present an explosion hazard. Insoluble. Segregation coefficient (n-octanol/water): Viscosity: Dynamic: Kinematic: Solvent content: Organic solvents: 0.0 % VOC: 0.0 g/l / 0.00 lb/gl Solids content: % Other information No further relevant information available. (Contd. on page 4)

4 Page 4/6 (Contd. of page 3) * 10 Stability and reactivity Reactivity No further relevant information available. Chemical stability Thermal decomposition / conditions to be avoided: No decomposition if used according to specifications. Possibility of hazardous reactions No dangerous reactions known. Conditions to avoid No further relevant information available. Incompatible materials: No further relevant information available. Hazardous decomposition products: No dangerous decomposition products known. * 11 Toxicological information Information on toxicological effects Acute toxicity: LD/LC50 values that are relevant for classification: No futher relevant information available Primary irritant effect: on the skin: No irritant effect. on the eye: No irritating effect. Sensitization: No sensitizing effects known. Additional toxicological information: The product is not subject to classification according to internally approved calculation methods for preparations: When used and handled according to specifications, the product does not have any harmful effects according to our experience and the information provided to us. Carcinogenic categories IARC (International Agency for Research on Cancer) Polyethylene 3 NTP (National Toxicology Program) OSHA-Ca (Occupational Safety & Health Administration) * 12 Ecological information Toxicity Aquatic toxicity: No further relevant information available. Persistence and degradability Based on previous experience, this product is inert and non-degradable. Behavior in environmental systems: Bioaccumulative potential No further relevant information available. Mobility in soil No further relevant information available. Additional ecological information: General notes: Generally not hazardous for water Results of PBT and vpvb assessment PBT: Not available. vpvb: Not available. Other adverse effects No further relevant information available. (Contd. on page 5)

5 Page 5/6 (Contd. of page 4) * 13 Disposal considerations Waste treatment methods Recommendation: Smaller quantities can be disposed of with household waste. Uncleaned packagings: Recommendation: Disposal must be made according to official regulations. * 14 Transport information UN-Number DOT, TDG, ADN, IMDG, IATA UN proper shipping name DOT, TDG, ADN, IMDG, IATA Transport hazard class(es) DOT, TDG, ADN, IMDG, IATA Class Packing group DOT, TDG, IMDG, IATA Environmental hazards: Special precautions for user Transport in bulk according to Annex II of MARPOL73/78 and the IBC Code UN "Model Regulation": * 15 Regulatory information Safety, health and environmental regulations/legislation specific for the substance or mixture Sara Section 355 (extremely hazardous substances): Section 313 (Specific toxic chemical listings): TS (Toxic Substances Control Act): All ingredients of this product are included, or are exempted from inclusion in the EPA Toxic Substances Control Act (TS) Chemical Substance Inventory Proposition 65 Chemicals known to cause cancer: Chemicals known to cause reproductive toxicity for females: Chemicals known to cause reproductive toxicity for males: Chemicals known to cause developmental toxicity: (Contd. on page 6)

6 Page 6/6 Carcinogenic categories EPA (Environmental Protection Agency) TLV (Threshold Limit Value established by ACGIH) NIOSH-Ca (National Institute for Occupational Safety and Health) Canadian substance listings: Canadian Domestic Substances List (DSL) All ingredients are listed. Canadian Ingredient Disclosure list (limit 0.1%) Canadian Ingredient Disclosure list (limit 1%) GHS label elements Hazard pictograms Signal word Hazard statements Chemical safety assessment: A Chemical Safety Assessment has not been carried out. (Contd. of page 5) 16 Other information This information is based on our present knowledge. However, this shall not constitute a guarantee for any specific product features and shall not establish a legally valid contractual relationship. Department issuing MSDS: Occupational product safety department of Seal For Life Industries Contact: Seal For Life Industries Gasselterstraat 20, 9503JB Stadskanaal, the Netherlands Tel: ; Fax ; info@sealforlife.com Date of preparation / last revision 01/15/2016 / 5 Abbreviations and acronyms: IMDG: International Maritime Code for Dangerous Goods DOT: US Department of Transportation IATA: International Air Transport Association ACGIH: American Conference of Governmental Industrial Hygienists EINECS: European Inventory of Existing Commercial Chemical Substances ELINCS: European List of Notified Chemical Substances S: Chemical Abstracts Service (division of the American Chemical Society) VOC: Volatile Organic Compounds (USA, EU) LC50: Lethal concentration, 50 percent LD50: Lethal dose, 50 percent vpvb: very Persistent and very Bioaccumulative NIOSH: National Institute for Occupational Safety OSHA: Occupational Safety & Health * Data compared to the previous version altered.